Owners have filed 332 complaints
about the 2015 Hyundai Santa FE with NHTSA between 2015 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 19 of 26 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 42
Against the median year of the Hyundai Santa FE. 50 means typical for this
model; 100 means roughly double.
Severity — 59
11.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 47
28% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2015 compares with every other Hyundai Santa FE
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
32.4%
1,000 – 9,999 miles
118.9%
10,000 – 24,999 miles
1613.0%
25,000 – 49,999 miles
1310.6%
50,000 – 74,999 miles
2520.3%
75,000 – 99,999 miles
1613.0%
100,000 – 149,999 miles
2822.8%
150,000+ miles
118.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2015peak 12Jul 2026
NHTSA investigations into the 2015 Hyundai Santa FE
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543,...
DP22003Opened 12 Sep 2022Closed 12 Dec 2023ENGINE
Loss of Motive Power
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complain...
DP21003Opened 12 Nov 2021Closed 20 Jun 2023VEHICLE SPEED CONTROL:THROTTLE
Throttle control system vulnerabilities
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can b...
Recalls on the 2015 Hyundai Santa FE
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
23V651000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Risk: An engine compartment fire while parked or driving can increase the risk of injury.
17V358000
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
Hyundai Motor America (Hyundai) is recalling certain 2013-2017 Santa Fe and Santa Fe Sport vehicles. In the affected vehicles, the secondary hood latch actuating cable may corrode and bind, causing the secondary hood latch to remain in the unlatched position when the hood is closed.
Risk: If the hood is not securely closed or the primary latch is inadvertently released and the secondary latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024552824,695 units in Canada
Label
Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the compliance label for all new vehicles.
Recall 2024080353,849 units in Canada
Brakes
Issue: On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit. Note: This recall replaces recall R0246 (Transport Canada recall number 2023-527). For the Sonata model, only the Sonata Hybrid model is affected by this recall. Safety Risk: A short circuit could create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to replace the fuse for the ABS module. Hyundai recommends that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed.
Recall 2023527326,942 units in Canada
Brakes
This recall was replaced by Transport Canada Recall No. 2024-080. Issue: On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit. Safety Risk: A short circuit could create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to replace the fuse for the ABS module. Hyundai recommends that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed.
Recall 2023125404,543 units in Canada
Brakes
Issue: Hyundai is conducting a special service campaign that provides anti-corrosion treatment to certain underbody components. Over time, components under the vehicle, including brake lines could corrode. If this happens, a brake line could fail and leak. A brake fluid leak can result in reduced braking. Safety Risk: Reduced braking can cause an extended stopping distance and increase the risk of a crash. Corrective Actions: Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to inspect the underbody, including the brake lines. The dealer will apply an anti-corrosion treatment to certain parts, and replace the brake lines if necessary.
Recall 2017297128,865 units in Canada
Structure
On certain vehicles, the cable between the actuating lever for the secondary hood latch and the secondary latch may become corroded over time. This could cause the secondary hood latch to remain in the open position when the hood is closed. If the vehicle were to be driven with the primary hood latch disengaged, or primary hood latch is released while driving, the secondary hood latch may not hold the hood closed while the vehicle is in motion. If this were to occur, it could compromise the driver’s ability to see the road and its users, as well as cause damage to the windshield. These issues could result in a crash causing injury and/or property damage. Correction: Dealers will replace the secondary hood latch cable.
Reports where the owner recorded a crash, a fire, an injury or a death.
Salt Lake City, UTCrash
ENGINE
Time Belt problem. Check engine, yellow.
NHTSA complaint #11660125 — an unverified report by a vehicle owner.
S Floral Park, NYFire
ENGINE
While I was driving on the highway in the left lane, smoke came from the engine, then it started coming from underneath the car. The car turned off. I was forced to stop on the left lane of the highway and exit the vehicle and walk as far away as possible. I called 911, then I noticed fire coming from the engine. This was unsafe for myself as well as other riders on the highway. Firefighters came and put out the fire. Once they left, I was left by myself waiting for the tow truck to arrive. No police officers helped to keep myself safe while waiting on the left shoulder once the highway re-opened. When asked if I needed a police report, the police officer said no because it wasn't a crash. The vehicle was inspected by my insurance company and it was deemed a total loss. There were no warning signs or messages or symptoms prior to the failure at all.
NHTSA complaint #11592719 — an unverified report by a vehicle owner.
at 126,000 milesCovington, LAFire
SERVICE BRAKES, HYDRAULIC
The contact owns a 2015 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, he observed smoke emanating from the engine compartment, prompting him to pull to the shoulder of the roadway. After a visual inspection of the engine compartment, the contact observed flames originating near the firewall. The contact was able to extinguish the flames himself with a fire extinguisher. No warning lights were illuminated. A fire report was filed. A police report was not filed, and no injuries were reported. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V303000 (Service Brakes, Hydraulic), and the VIN was included. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 126,000.
NHTSA complaint #11576910 — an unverified report by a vehicle owner.
Glendora, CAFire
ENGINE
The engine caught fire and the vehicle is a total loss. Acceleration became inconsistent at time of the incident while driving on the freeway. Once that was noticed, and at a speed of 50mph, I immediately heard a loud clicking noise coming from the engine. ALL warning lights also immediately went off. I noticed white smoke and pulled over on the freeway. Once parked, black smoke was emerging from the engine. I exited the vehicle to safety and within 30 seconds, flames emerged from the vehicle. The vehicle maintenance was kept current during the 7 months of ownership. There were no prior warnings of any issues before the incident occurred.
NHTSA complaint #11563641 — an unverified report by a vehicle owner.
Port Orange, FLFire
ENGINE
Premature engine failure due to bearing. Car has oil consumption problem causing a ceased engine. Car stalled going 40 mph under a intersection, managed to pull over and car started fire and smoking. Fire Smothered itself.
NHTSA complaint #11479424 — an unverified report by a vehicle owner.
Southbridge, MAFire
UNKNOWN OR OTHER
Summer of 2020,my engine needed to be replaced for an unknown reason, that work was done at the Herb Chambers Hyundai service department. On 4/22/2022 my car hesitated to start, it did start, I traveled about 12 miles and my engine light came on. I traveled about 3 more miles and then my car stalled in the middle of the highway, I headed to the breakdown lane very quickly. As soon as I put the car in park, the car started to smoke, I ran down the highway on foot, called 911, I turned around and my car was engulfed in flames. This whole incident went awry very quickly, about 5 minutes. I am writing in as I was offered $16000.00 as a settlement for my vehicle and all losses from Hyundai. My insurance company is offering about $1500.00 more than Hyundai. Hyundai is not even performing an inspection which was not what they communicated initially. I was told an inspection needed to be done prior to any settlement decision. Their is a known recall, I understand, recall #205, which I had not yet been notified of. I want to reiterate that no inspection on Hyundai's part was done to confirm damage/recall issue. At this point I do not have a vehicle and not in a position to buy a new car.
NHTSA complaint #11462810 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Ocala, FL
ENGINE
Driving on highway no warning lights appeared the car made a loud pop noise and heavy smoke appeared from under the hood. Immediately pulled over and noticed all of the oil poured out and was nasty looking. The car was up to date on oil change. My car was towed home and bone dry no oil and no coolant the engine now had loud knocking and needs to be replaced for failure. The car was looked at by independent mechanic. Miles on the car are 152010. I had no warnings and up until the issues the car was serviced and cared for.
NHTSA complaint #11751822 — an unverified report by a vehicle owner.
Jacksboro, TX
ENGINE
I was driving down the road ( a busy Farm to market road) and my car lost power and died. Luckily i got off of the road. I tried to start the car again, but it kept dying. I had my son in law come help me move the car to a friends house so that I could get it to the dealership. It was after hours. I regularly get my oil changed and when my SIL checked the oil there was none on the dipstick. My SIL put oil in the car. My car was coming up on being due for a oil change. I am a single woman close to 50 yrs old and take my car in for maintenance. I then had my car towed to the local dealership to have an assessment done to find out what the issues is. The dealership reported that the timing was off and that bank 1 and 2 of the camshaft needs replaced. There is a known issue with the engine of this car doing the exact same thing my car did. There were no warning lights on to indicate a problem with the car. I inherited the car for my Mother In Law that passed away. She bought the car brand new and had it serviced regularly.
NHTSA complaint #11743719 — an unverified report by a vehicle owner.
Albany, CA
ENGINE
The engine failed due to complete and sudden oil loss. The vehicle is currently at Fremont Hyundai and available for inspection. Safety risk: the engine failed while driving on the highway with children in the vehicle. A check engine light appeared with no prior warning, the vehicle immediately lost power and stalled, requiring an emergency exit and tow. This is a direct collision risk at highway speed. The failure was confirmed by an independent mechanic who found zero oil in the engine and identified it as a known Hyundai defect. The vehicle was then towed to Fremont Hyundai, which is currently conducting diagnostics. The vehicle has been inspected by an independent mechanic and by Fremont Hyundai [XXX] ). No police or insurance involvement. There were NO warning lights, oil pressure alerts, or symptoms of any kind prior to failure. I purchased the vehicle in 2024 and maintained regular oil changes and checkups with receipts. The last oil change was performed a few months before the failure. No mechanic ever flagged low oil. The only warning was a check engine light that appeared seconds before the engine stalled. I have incurred $900 in towing costs as a direct result of this failure. Fremont Hyundai is now requiring me to pay $280 for a diagnostic, followed by $890 for a two-week oil consumption test. They have also stated that if the engine does not pass the initial diagnostic, they cannot help me at all. Given that the engine ran completely dry of oil, it is highly unlikely to pass. This means I am being asked to pay fees for a process the dealership already expects to fail, leaving me with no path to resolution and a car I cannot drive. The 2015 Hyundai Santa Fe is included in a class action lawsuit (Cho et al. v. Hyundai Motor Company) over this exact defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11738413 — an unverified report by a vehicle owner.
Chula Vista, CA
POWER TRAIN
2015 Hyundai Santa Fe Limited, 3.3L Lambda II GDI V6, ~102,000 miles. In December 2022, an authorized Hyundai dealer replaced three specific parts under a Hyundai recall/campaign (records requested). On Sunday [DATE] at approximately [TIME] PM, I was driving on [FREEWAY], [STATE], at 55–70 mph at night. With NO prior warning — no warning lights, no chimes, no loss of power buildup, no knocking, no engine protection mode — the engine suddenly and completely died. The failure was instantaneous. There was no limp-home mode and no opportunity to reach the shoulder under engine power. The vehicle lost forward momentum and rolled backward in a live highway travel lane, where it remained stranded until a tow truck recovered it. No injuries. The 12V battery and electrical system remained fully active throughout. The instrument cluster was operational and capable of displaying warnings before the failure. None were displayed. Dashboard warning lights illuminated only seconds AFTER the engine had already died — a post-failure consequence of engine shutdown, not a pre-failure warning. An independent mechanic diagnosed a seized engine due to loss of oil flow. No oil pressure or low-oil light had ever illuminated. The vehicle was then transported to the Hyundai dealer that performed the 2022 service; they promised a diagnostic call and have not provided one or any written diagnostic. This failure mode matches Hyundai TSB 24-EM-003H (15yr/150k extended warranty for 3.3L Lambda II engines in 2013–2019 Santa Fe), NHTSA Recall 21V-727 (acknowledging stall risk at highway speed), and the active class action Burns v. Hyundai Motor Company (C.D. Cal. 2025). Hyundai's KSDS is documented to trigger a blinking MIL, audible chime, and reduced-power Engine Protection Mode upon bearing wear. None of these protective behaviors occurred.
NHTSA complaint #11736814 — an unverified report by a vehicle owner.
Chula Vista, CA
ENGINE
2015 Hyundai Santa Fe Limited, 3.3L Lambda II GDI V6, ~102,000 miles. In December 2022, an authorized Hyundai dealer replaced three specific parts under a Hyundai recall/campaign (records requested). On Sunday [DATE] at approximately [TIME] PM, I was driving on [FREEWAY], [STATE], at 55–70 mph at night. With NO prior warning — no warning lights, no chimes, no loss of power buildup, no knocking, no engine protection mode — the engine suddenly and completely died. The failure was instantaneous. There was no limp-home mode and no opportunity to reach the shoulder under engine power. The vehicle lost forward momentum and rolled backward in a live highway travel lane, where it remained stranded until a tow truck recovered it. No injuries. The 12V battery and electrical system remained fully active throughout. The instrument cluster was operational and capable of displaying warnings before the failure. None were displayed. Dashboard warning lights illuminated only seconds AFTER the engine had already died — a post-failure consequence of engine shutdown, not a pre-failure warning. An independent mechanic diagnosed a seized engine due to loss of oil flow. No oil pressure or low-oil light had ever illuminated. The vehicle was then transported to the Hyundai dealer that performed the 2022 service; they promised a diagnostic call and have not provided one or any written diagnostic. This failure mode matches Hyundai TSB 24-EM-003H (15yr/150k extended warranty for 3.3L Lambda II engines in 2013–2019 Santa Fe), NHTSA Recall 21V-727 (acknowledging stall risk at highway speed), and the active class action Burns v. Hyundai Motor Company (C.D. Cal. 2025). Hyundai's KSDS is documented to trigger a blinking MIL, audible chime, and reduced-power Engine Protection Mode upon bearing wear. None of these protective behaviors occurred.
NHTSA complaint #11736814 — an unverified report by a vehicle owner.
Chula Vista, CA
SERVICE BRAKES
2015 Hyundai Santa Fe Limited, 3.3L Lambda II GDI V6, ~102,000 miles. In December 2022, an authorized Hyundai dealer replaced three specific parts under a Hyundai recall/campaign (records requested). On Sunday [DATE] at approximately [TIME] PM, I was driving on [FREEWAY], [STATE], at 55–70 mph at night. With NO prior warning — no warning lights, no chimes, no loss of power buildup, no knocking, no engine protection mode — the engine suddenly and completely died. The failure was instantaneous. There was no limp-home mode and no opportunity to reach the shoulder under engine power. The vehicle lost forward momentum and rolled backward in a live highway travel lane, where it remained stranded until a tow truck recovered it. No injuries. The 12V battery and electrical system remained fully active throughout. The instrument cluster was operational and capable of displaying warnings before the failure. None were displayed. Dashboard warning lights illuminated only seconds AFTER the engine had already died — a post-failure consequence of engine shutdown, not a pre-failure warning. An independent mechanic diagnosed a seized engine due to loss of oil flow. No oil pressure or low-oil light had ever illuminated. The vehicle was then transported to the Hyundai dealer that performed the 2022 service; they promised a diagnostic call and have not provided one or any written diagnostic. This failure mode matches Hyundai TSB 24-EM-003H (15yr/150k extended warranty for 3.3L Lambda II engines in 2013–2019 Santa Fe), NHTSA Recall 21V-727 (acknowledging stall risk at highway speed), and the active class action Burns v. Hyundai Motor Company (C.D. Cal. 2025). Hyundai's KSDS is documented to trigger a blinking MIL, audible chime, and reduced-power Engine Protection Mode upon bearing wear. None of these protective behaviors occurred.
NHTSA complaint #11736814 — an unverified report by a vehicle owner.
Neenah, WI
ENGINE
Vehicle engine started knocking heavily while driving down the road. Had vehicle inspected for issue and was told vehicle had burned all the oil down to one quart and the engine was destroyed. Vehicle recently serviced with oil change within roughly 3,000 miles.
NHTSA complaint #11733051 — an unverified report by a vehicle owner.
Prattville, AL
ENGINE
I purchased this vehicle one year ago from a used car dealership with 148,000 miles on it. Within a few months it was throwing crankshaft position, sensor codes, camshaft codes, and burning oil. I cannot bring my RPMs above two without my check engine light coming on and blinking. My car will go into limp mode. Hyundai does not have my car included in the engine recall they only have the sport Santa Fe included. They released an extended warranty for 150,000 miles but by the time that was put into place my car was at 151,000 miles so it was not eligible.
NHTSA complaint #11719329 — an unverified report by a vehicle owner.
Ladson, SC
AIR BAGS
Passenger airbag dash is cracked risking unpredictable deployment of air bag
NHTSA complaint #11718270 — an unverified report by a vehicle owner.
Alamogordo, NM
ENGINE
On 08/15/2025 I started the vehicle and heard a ticking noise that lasted for 3 seconds and stopped. The same noise happened when I would start the car in the mornings. It never lasted more than 3 seconds and I wasn't too sure what the noise was. There was no engine lights that came on so I wasnt too worried about it. On 8/21/2025 my husband went to the store and when he came back the car shut off while backing into the driveway. He said it made a weird noise and just shut off. We tested the battery but it was still charged. We brought it to our mechanic and he called us 15 mins later saying he found metal shavings on the oil filter and the engine had seized. He recommended going to the dealer, which is 90 miles away. Around the 15th we had received the warranty extension for 15 years/150,000 miles from Hyundai talking about a knocking sound that can lead to engine seizure. So I called the dealer and they said to bring it in. We got the car towed to the dealer on 8/26/2025. On 09/04/2025 they called to let us know that they ran the test on the engine but Hyundai was not going to help due to the car having 176,000 miles. They agreed the engine seized due to rod failure but wasn't going to offer Goodwill assistance, even with the service history we submitted from our carfax that showed regular scheduled maintenance recorda. We bought the car on 03/08/2025 when it was at 170,000 miles. I knew about the other open recalls and had them fixed on 06/12/2025 ( after being delayed from the dealer for 2 months because they couldn't get the parts for the auxiliary canister). Luckily the car died in the driveway and not in the middle of traffic. Hyundai has known about their Lambda engines having this issue and the KDSS recall was not available for this car which could have triggered a lifetime warranty on the engine. I barely had the car for 5 months.
NHTSA complaint #11698430 — an unverified report by a vehicle owner.
Tega Cay, SC
ENGINE
015 Santa Fe Ultimate. 134,000 miles. Original owner. All maintenance done per manual. Wife on hwy 2 hrs. Started loud engine knocking noise. No warning whatsiever.Pulled off closet exit. Stalled.Restarted.Pulled into gas station. Trusted mechanic inspected. Stated not to drive. He had identical vehicle at shop,identical problem.110,000 miles. Needs new engine.Noticed on fbook Forum,"Hyundai Engine Problems". Alot of similar complaints posted. Hyundai not warranting over 100,000 miles. This could have been much worse if it had been at night,in a rural area. Shocked has not been a recall!
NHTSA complaint #11675906 — an unverified report by a vehicle owner.
Salt Lake City, UTCrash
ENGINE
Time Belt problem. Check engine, yellow.
NHTSA complaint #11660125 — an unverified report by a vehicle owner.
Arroyo de Coco, FL
UNKNOWN OR OTHER
The driver's door is stuck, it cannot be opened.
NHTSA complaint #11633342 — an unverified report by a vehicle owner.
St Louis, MO
UNKNOWN OR OTHER
THE BRAKE LIGHT SWITCH IS MALFUNCTIONING AND CAUSING THE BRAKE LIGHT TO STAY ON CONTINIOUSLY. THIS IS DANGEROUS BECAUSE THE BRAKE LIGHT STAYS ON SO THERES NO INDICATION THAT I'M GETTING READY TO STOP BECAUSE THE LIGHT IS ALREADY ON, INCREASEING THE RISK OF A CRASH. THE CRUISE CONTROL IS ALSO AFECTECED WITH THIS ISSUE BECAUSE IT STOP WORKING AT THE SAME TIME. I LOOKED UP THE RECALL AND IT SAID THAT 2013 -2015 HYDUNDIA SANTA FEE SPORT VIHECLES WERE AFFECTED, BUT WHEN I CALL THE DEARLERSHIP THEY SAID MY VIN# WAS NOT INCLUDED IN THE RECALL!
NHTSA complaint #11631945 — an unverified report by a vehicle owner.
St Louis, MO
EXTERIOR LIGHTING
THE BRAKE LIGHT SWITCH IS MALFUNCTIONING AND CAUSING THE BRAKE LIGHT TO STAY ON CONTINIOUSLY. THIS IS DANGEROUS BECAUSE THE BRAKE LIGHT STAYS ON SO THERES NO INDICATION THAT I'M GETTING READY TO STOP BECAUSE THE LIGHT IS ALREADY ON, INCREASEING THE RISK OF A CRASH. THE CRUISE CONTROL IS ALSO AFECTECED WITH THIS ISSUE BECAUSE IT STOP WORKING AT THE SAME TIME. I LOOKED UP THE RECALL AND IT SAID THAT 2013 -2015 HYDUNDIA SANTA FEE SPORT VIHECLES WERE AFFECTED, BUT WHEN I CALL THE DEARLERSHIP THEY SAID MY VIN# WAS NOT INCLUDED IN THE RECALL!
NHTSA complaint #11631945 — an unverified report by a vehicle owner.
St Louis, MO
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
THE BRAKE LIGHT SWITCH IS MALFUNCTIONING AND CAUSING THE BRAKE LIGHT TO STAY ON CONTINIOUSLY. THIS IS DANGEROUS BECAUSE THE BRAKE LIGHT STAYS ON SO THERES NO INDICATION THAT I'M GETTING READY TO STOP BECAUSE THE LIGHT IS ALREADY ON, INCREASEING THE RISK OF A CRASH. THE CRUISE CONTROL IS ALSO AFECTECED WITH THIS ISSUE BECAUSE IT STOP WORKING AT THE SAME TIME. I LOOKED UP THE RECALL AND IT SAID THAT 2013 -2015 HYDUNDIA SANTA FEE SPORT VIHECLES WERE AFFECTED, BUT WHEN I CALL THE DEARLERSHIP THEY SAID MY VIN# WAS NOT INCLUDED IN THE RECALL!
NHTSA complaint #11631945 — an unverified report by a vehicle owner.
Indianapolis, IN
VEHICLE SPEED CONTROL
I was driving on the highway when, out of nowhere, my car started shaking whenever I went over 40 miles per hour. It was quite alarming and honestly a bit scary. So, I would like to request a recall on it. A week after I took it to Hyundai, they informed me that they sent it to you to see if it would be approved to cover the motor. I’ve had this car for just 2 years, and it's frustrating to deal with issues like this. I truly appreciate your attention to this matter, as I hope we can resolve it soon. Thank you for your understanding!
NHTSA complaint #11626687 — an unverified report by a vehicle owner.
Duluth, GA
ENGINE
At 110K miles my Sante Fe Sport began burning increasing amounts of oil. My mechanic says he does not know why it is burning oil. Today it has 134171K miles on it. It has been burning a quart or more of oil weekly. I drive about 200 miles per week.
NHTSA complaint #11622913 — an unverified report by a vehicle owner.
Gastonia, NC
ELECTRICAL SYSTEM
The engine has basically come apart. There is a timing chain issue, the engine is not recalled and it is getting where the car cannot drive. There is a constant smell of burning electrical wires. There’s also issues with the heating and air that is related to electrical.
NHTSA complaint #11622164 — an unverified report by a vehicle owner.
Gastonia, NC
ENGINE
The engine has basically come apart. There is a timing chain issue, the engine is not recalled and it is getting where the car cannot drive. There is a constant smell of burning electrical wires. There’s also issues with the heating and air that is related to electrical.
NHTSA complaint #11622164 — an unverified report by a vehicle owner.
Huntington Beach, CA
ENGINE
My car burns a lot of oil. The Hyundai dealership service center ran a controlled test and validated that my car burned a quart of oil in 1000 miles. This is not normal. It turns out that there are a lot of Hyundai owners with the exact same problem. It seems there are bad piston rings.
NHTSA complaint #11620707 — an unverified report by a vehicle owner.
Moorhead, MN
ENGINE
I am filing this complaint regarding my 2015 Hyundai Santa Fe Sport, which recently suffered engine failure due to an unresolved issue related to error code P1326. The check engine light began flashing, and despite multiple visits to my local Hyundai service center (Gateway Hyundai Nissan in Fargo, ND), the problem was not properly diagnosed or repaired, resulting in catastrophic engine damage. The vehicle has a branded title, but I have confirmed that, according to Hyundai's warranty policies, recalls and campaigns are still applicable to branded vehicles. Hyundai has issued a recall for engine defects associated with error code P1326, yet the service center has refused to replace the engine under this recall. Instead, they are insisting on an out-of-pocket repair cost of $9,300.56, even though the engine failure is a result of the defect addressed in the recall. This failure occurred while I'm driving with my wife and 9-month-old infant, which posed a significant safety risk. Had the service center properly addressed the issue during my earlier visits, this situation could have been prevented. I am filing this complaint to request that Hyundai be held accountable for the engine replacement as part of the recall and to prevent further safety risks for other drivers experiencing this defect. I respectfully ask the NHTSA to investigate Hyundai’s handling of this recall and ensure that customers with branded vehicles are not unfairly denied critical safety repairs. The manufacturer must ensure that engine replacements under the recall are carried out for all affected vehicles, regardless of their title status, to prevent dangerous road situations. Thank you for your attention to this matter.
NHTSA complaint #11615734 — an unverified report by a vehicle owner.
Aiken, SC
ENGINE
Car was burning lots of engine oil and lost power, dealer said nothing was wrong with it. months later when to limp mode, lacks of power in the highway, dealer said it lost compression on 2 cylinders and that I need a new engine. I ask them if the vehicle has a recall and they said no, all my research said that this type of engine has a recall for me they are looking for any loophole in order not to replace the engine
NHTSA complaint #11610743 — an unverified report by a vehicle owner.
Plymouth, MA
ENGINE
Sudden loss of engine power in traffic on highway in funeral procession. My safety was put at risk on the highway. The check engine light came on intermittently the previous week. I made six trips to the Hyundai dealer in Plymouth, MA. First told the oil was low when the dipstick was normal. Oil was changed. Check engine light came on as I left the lot. Two more trips computer reset two different ways. Engine does not have normal power going up hill. Another trip to dealer EVAP hose collapsed. Light back on and off. I paid for diagnostic fee $175, oil change then told it was CVV and timing issue with $2817.89 in parts because the tech "saw" the problem. >$3000 estimate for labor. Repair started now told CVV is not the problem metal shavings in oil OCV intake and exhaust valves and needs new engine. The car had $60,000 miles on it and was extremely well maintained. It does not have a warrantee. This is same issue as the Hyundai recall for metal debris left in oil passages of engine crankshaft during manufacture though my model is not covered by the recall. Hyundai declines to help. There is a huge personal safety and fire risk from this defective manufacturing process.
NHTSA complaint #11607075 — an unverified report by a vehicle owner.
Minnedosa, ND
FUEL/PROPULSION SYSTEM
Misfire code P0302 Injector failed open, flooded cylinder with fuel. Gas in the oil Possible cylinder failure Lack of compression
NHTSA complaint #11606012 — an unverified report by a vehicle owner.