409 of the
10,385 complaints filed about the Hyundai Santa FE
are about the steering —
4% of everything owners reported.
The worst model year for it is 2013.
Multiple occasions of the ADAS lane centering system operating unsafely. The worst one was on a gentle left-hand curve on a concrete surfaced bridge at night. The system allowed the vehicle to slowly drift to the outside of the lane. When it was fairly close to the white line, it jerked the wheel back to the left and then released the steering to my control while pointed hard into the oncoming lane. It will do similarly during the day when approaching a center turn lane on the highway. Sometimes it will decide that it should be in the turn lane, will make a rapid input, and then return control to me, now pointed at the oncoming lane. When the vehicle returns control to me, it indicates it by making the steering wheel and lines in the HUD grey, no chime, no warning icon, just green to grey and release the wheel in whatever direction it's pointing. It also sometimes slows drastically for vehicles that have exited the highway when on cruise control or applies hard braking for vehicles in the other lane while in a curve on a hill. There are no lights or malfunction warnings and the vehicle self-diagnostic says everything is operating correctly.
NHTSA complaint #11757711 — an unverified report by a vehicle owner.
Vehicle experiences severe, intermittent, un-commanded steering inputs from the Lane Keeping Assist (LKA) system at highway speeds (55-70 MPH). The steering wheel violently jerks toward adjacent traffic lanes/shoulders without operator input, lane drift, or warning, requiring immediate high-force manual intervention to overpower mechanical torque and prevent a collision or roadway departure. Chronology of manufacturer notice: - Oct 2024: Initial consumer dispute logs flagged steering safety concerns and unresolved campaign items. - Dec 2024: Opened Corporate Case 24164934, formally alerting consumer affairs to dangerous steering wheel jerking. - Jan 2025: Presented to an authorized dealer; an OTA software update was deployed, but intermittent tracking failures persisted, including failure to recognize lanes at night. - June 2026: Under Case 42680760, the system failed acutely on the interstate, jerking the vehicle out of painted lanes. The malfunction originates in the LKA steering control module and camera hardware, which are intact and available for inspection. Dealerships have not replicated the defect during brief diagnostic windows due to its intermittent nature. The manufacturer has deflected these notifications and refused a forensic diagnostic sweep or mechanical remediation. Instead, case managers attempted to close the file by offering partial financial goodwill for an unrelated cosmetic paint delamination defect on the same vehicle. No warning lamps or error messages precede these events; the system executes aggressive mechanical intervention with zero notice. This system error bypasses driver override thresholds, conflicting with vehicle crash avoidance frameworks. Because the computer fails to log diagnostic trouble codes (DTCs) during these steering drops, the manufacturer exploits this data vacuum to deny structural remediation, creating severe multi-vehicle side-impact and rollover risks.
NHTSA complaint #11743968 — an unverified report by a vehicle owner.
Driving at 70 mph on interstate, driver adjusted hands on steering wheel and accidently pulled both paddles, shifting car into neutral. Fortunately, there was little traffic, and the driver was able to move to the side of the interstate, out the car into park and shift back to drive. This was highly dangerous. Losing control of the vehicle while traveling at 70 miles an hour could have resulted in death. This feature is completely unnecessary in a family SUV and is going to cause an accident.
NHTSA complaint #11742217 — an unverified report by a vehicle owner.
The contact's girlfriend owns a 2024 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently swerved from side to side. The message “Consider Taking A Break” was displayed and the Driver Attention Warning (DAW) warning light was illuminated. Additionally, the Automatic Emergency Braking activated while driving near a vehicle or object, slamming the vehicle to a stop and causing the cruise control to deactivate. The message "Keep Hands On Steering Wheel" was displayed even though the contact's hands were on the steering wheel. The contact also stated that the front and rear driver's side doors were vertically bent from a manufacturing defect. The contact stated that his girlfriend feared for her safety while driving the vehicle. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case a filed. The failure mileage was approximately 10,000.
NHTSA complaint #11740318 — an unverified report by a vehicle owner.
The steering left side electrical components quit working at the same time without warning. This is all related to the Air Bag clock spring a serious safety defect that disables the airbag and possibly horn. I have taken the vehicle to a Hyundai dealership for diagnostics and this is what was found. "Needs immediate attention [Primary]: SSD : STEERING OR SUSPENSION DIAGNOSIS Air Bag - Clockspring Assembly / Spiral Cable: CLOCK SPRING HAS SHORTED OUT CAUSING ALL THE BUTTONS ON THE LEFT SIDE OF THE STEERING WHEEL NOT TO WORK This assembly consists of a clock spring, which is a coil that retracts and expands inside its housing as the steering wheel turns. Its function is to maintain electrical continuity for all the components on the drivers airbag.
NHTSA complaint #11733693 — an unverified report by a vehicle owner.
A brand new Santa Fe Hybrid AWD SEL(less than 2500 miles) makes squeaky noises when rotating the steering wheel to the counter clock wise. It is very annoying and frustrating. Due to the noise I can't fully concentrate to driving the car. Brought the vehicle to a local dealer and they would not do anything about it.
NHTSA complaint #11719196 — an unverified report by a vehicle owner.
-I had just exited from the highway and was driving into my town. While doing so, I had both hands on the steering wheel and suddenly the car started beeping and flashing warnings/ alerts indicating that my hands were not on the steering wheel, which they were. Within seconds the car began to deaccelerate and pull me off the road to my right hand side. I initially had no control over the vehicle. Then again- without explanation it began to register hands on the steering wheel and I was able to resume control of the vehicle. I believe the lane assist feature was on at the time. It all happened very quickly. Had I still been on the highway as I was moments before, there was enough traffic that I would have been pulled into another vehicle or caused an accident if people saw me suddenly rapidly deaccelerating/braking in front of them because they would have no warning and a very tiny amount of time to react. Then, in an other instance that followed shortly thereafter, my boyfriend was driving with one of the lane assist on. While driving, the weather changed and it began snowing and freezing rain that was freezing when it hit the windshield. The lane assist began to have trouble seeing the lines on the road since the snow and ice were obscuring them somewhat. It began to beep and gently correct the car- which was not appropriate in this case (we understand that the road conditions were beyond its abilities to safely discern things accurately). My boyfriend who had two hands on the wheel trying to carefully navigate this sudden burst of weather so at not to slide. He tried turning it off, but it wasn't turning off, and couldn't troubleshoot it without taking his hands off the wheel. He instructed me to turn it off through the settings menu in the infotainment system, which seemed to disable it. Prior to these dangerous problems, I had experienced some seemingly sensor- related malfunctions with the tire pressure monitoring system. I'm out of room to write more.
NHTSA complaint #11716466 — an unverified report by a vehicle owner.
While driving, the engine catastrophically failed without warning, causing an immediate loss of power-assisted braking and steering. The failure occurred while traveling downhill. I was unable to slow or control the vehicle properly and was forced to proceed through a school bus’s flashing lights to avoid a potentially catastrophic collision, resulting in a traffic citation. My son was in the vehicle at the time. A sudden loss of engine power, braking assist, and steering assist while driving presents a serious safety defect. Vehicle was towed to Fred Beans Hyundai in Doylestown where it has been confirmed engine failure. This failure happened immediately and without warning.
NHTSA complaint #11716098 — an unverified report by a vehicle owner.
internal mechanical failure of the piston rings and cylinder walls. Misfire on Cylinder #2. Further testing revealed that Cylinder #2 is at 80 PSI, which is significantly below the manufacturer's specification. A subsequent leak-down test showed a 90% loss of pressure with air escaping through the oil filler hole. The issue stated above can cause severe mechanical failure of piston rings and cylinder walls can absolutely lead to connecting rod bearing problems by creating excessive debris, poor lubrication, abnormal piston motion, and increased stress, causing premature wear, overheating, and eventual bearing failure, often resulting in catastrophic engine knocking and damage. Diagnostics completed by Hyundai dealer and stated an engine replacement. Vehicle became difficult to steer and then warning lamp came on. Vehicle was difficult to turn left and right and almost caused a collision.
NHTSA complaint #11711643 — an unverified report by a vehicle owner.
Vehicle will suddenly shutdown in the middle of the road. This could easily have caused a crash at any time. Several batteries have been replaced due to alternator not charging the battery. Then the battery has to be jumped for emergencies. I have taken the car in for repairs of the recall twice. I was told that the front end would come off and parts would have to be replaced because of the age of my vehicle they would not fit again. I need a solution to this problem.
NHTSA complaint #11711436 — an unverified report by a vehicle owner.
Consistently after 10-20 minutes of driving with steering assist or immediately upon driving on cold days (under 50F), the steering wheel generates loud squeaking noises with the steering wheel stiffening and becoming harder to turn, creating a potential safety issue. The change is gradual but required a full stop of the car, shutdown, and restart to remedy. This issue has persisted for months and other Hyundai owners have shared the issue on various forums with Hyundai’s solution to replace the full steering column in some instances. Many owners seem to not be able to get help as dealers are not able to easily replicate this issue without lengthy drives.
NHTSA complaint #11701815 — an unverified report by a vehicle owner.
Battery/Electrical: 3 separate occasions the battery drained completely overnight, requiring mechanical key to open and jumpstart services from AAA (covered under Hyundai services). Risk of leaving me stranded on isolated areas. Problem confirmed via 3 requests for AAA to jumpstart my vehicle. Hyundai service dept inspected vehicle, confirmed low battery levels, unable to reproduce issues overnight, reported no electrical or mechanical issues that would cause battery drain. No warning messages, lamps, or symptoms prior to each failure. Steering wheel column has friction squeak when using driver assist and adjusting direction. No issues at this time.
NHTSA complaint #11701696 — an unverified report by a vehicle owner.
I purchased my 2019 Hyundai Santa Fe on October 29, 2021. Since then, I’ve experienced a series of mechanical and electrical failures that I believe are far beyond normal for a vehicle of this age. - The remote start has never worked. - On October 20, 2023, the hatch latch failed. The only way to open it now is by climbing into the back and manually pulling the latch. - On October 27, 2023, the electric power steering failed. I had to replace the entire steering column at a cost of $4,000. - The paint began deteriorating prematurely and required a full repair. Hyundai covered this under warranty, but the cost was $8,000. - In early spring 2025, all coil packs had to be replaced due to misfires, costing approximately $500. - September 4, 2025, The car stalled while I was driving on a main road and I had to pull over. There were no warning lights and I started home. About a mile from home check engine light came on so contact mechanic. Ended up towing to a dealership and was told the engine must be replaced because the oil had burned off without any warning from the oil light indicator. The turbo also needs replacement. - The combined cost is $14,000. These failures have caused significant financial hardship and stress. I am currently $17,000 underwater on the loan, and the repair costs are overwhelming. The lack of warning before catastrophic engine damage is especially concerning. I believe these issues reflect systemic defects in the vehicle’s design and manufacturing. The repeated failure of critical components—especially the steering system and oil monitoring—make this the worst automotive experience I’ve ever had. I respectfully request that the NHTSA investigate these failures and determine whether Hyundai should be held accountable. Consumers deserve protection from vehicles with such extensive and costly problems.
NHTSA complaint #11695524 — an unverified report by a vehicle owner.
The contact owns a 2025 Hyundai Santa Fe. The contact stated that while stopped and making a left turn from a cross street, the accelerator pedal was depressed, and traffic allowed the contact to make the turn; however, the steering wheel jerked to the right, and the vehicle jumped over a median strip. The contact stated that there were no warning lights illuminated. The contact stated that the right front passenger’s side tire rolled over the median strip, and then the rear passenger’s side tire next. The contact depressed the brake pedal, and the vehicle stopped in a parking spot on the side of the street. The contact shifted the vehicle to park(P) and turned off the vehicle. The contact observed that the right front passenger’s side tire was flat. The contact called Roadside Assistance, and the technician informed the contact that there was a cut on the inside side wall of the front passenger’s tire. The contact had taken the vehicle to a local dealer, where it was diagnosed, and determined that the passenger’s side front suspension arms and other parts needed to be replaced. The vehicle was repaired; however, the vehicle was difficult to steer while the steering wheel was vibrating. The contact took the vehicle back to the same dealer, who removed the aftermarket parts and replaced the parts with OEM steering and suspension parts; however, there was still a vibration in the steering wheel. The contact stated that several times, while turning to the left, the vehicle would turn to the right instead. The manufacturer was not informed of the failure. The vehicle was not repaired. The failure mileage was approximately 11,000.
NHTSA complaint #11686422 — an unverified report by a vehicle owner.
At 118,000 miles Downhill brake, transmission and 4 wheel drive were damaged from the hyundai dealership not fullfilling warranty. They disconnected my tow hitch and my transmission was burning .. smelled like a bon fire. Took me 1 year to repair and have transmission changed through warranty but they didnt change the other components that were damaged due to negligence from the hyundai dealership. The dealership was very rude and didnt dedication their attention or care to truly finding what was wrong with my vehicle.
NHTSA complaint #11676848 — an unverified report by a vehicle owner.
I was driving on the freeway at 70MPH it was dusk. The traffic was light and I was exiting the freeway. Two lanes exit and then split each direction. There is a car next to me but is not coming into my lane and nobody in front of me. Suddenly a collision alarm starts going off the vehicle brakes and the emergency steering notification lights up on the dash and the vehicle swerves to the left almost hitting the median. After this occurred the transmission started having issues at speeds under 15mph with shifting. It would rev up to about 3500rpms then lunge.
NHTSA complaint #11673090 — an unverified report by a vehicle owner.
The vehicle is making a loud clunking noise in the steering column when driving down the road. It is veering all over the road and when I hit a bump it’s very bad. It’s difficult to keep in the lane. I brought it to my mechanic who said it was most likely the electronic steering motor assembly. He said he would not drive it in its current condition. Hyundai themselves said that it would be dangerous to operate. On the complaint website I was looking on there was around 50 complaints that have been reported to the NHTSA already and the website said it would also be very dangerous to drive.
NHTSA complaint #11652572 — an unverified report by a vehicle owner.
Engine oil disappear at 2,000 miles. Car dead stop while driving without any warning ⚠️ break fails at 95 degrees curves. Steering wheel loose and make noise. Hyundai dealer refused to fix the issue.
NHTSA complaint #11649290 — an unverified report by a vehicle owner.