2022 Nissan Leaf problems

ELECTRICAL SYSTEM

I have attempted to conduct the recall repairs (25V-655) on the LEAF battery. 2 different Nissan locations have cancelled my scheduled appointments stating "We don't have the software to complete these repairs".

NHTSA complaint #11758070 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

VIN [XXX] battery percentage drops drastically and instantly once it reaches 50–60%. is behavior aligns with the active lithium deposit defects found under open Recall R25C8. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11755107 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

After having the recall (Recall 25V655) remedy applied to my car, it will not restart after charging. I charged it once after receiving it back (the dealership had not fully charged it during the recall work - it was returned at 76%). And it immediately started throwing errors and will only be in neutral now. The Dealership service center maintains that this is not the result of the recall issue or the recall fix, which is quite unbelievable. I do not believe the recall remedy is actually a remedy.

NHTSA complaint #11748775 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

After having the recall (Recall 25V655) remedy applied to my car, it will not restart after charging. I charged it once after receiving it back (the dealership had not fully charged it during the recall work - it was returned at 76%). And it immediately started throwing errors and will only be in neutral now. The Dealership service center maintains that this is not the result of the recall issue or the recall fix, which is quite unbelievable. I do not believe the recall remedy is actually a remedy.

NHTSA complaint #11748775 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

In October of 2025 , while driving my nissan leaf. Suden4ly i got an error message on the dash showing battery issue force reduced, due to this the vehicle driven at 55miles approximately lower it self down to 30 mph, I was approximat3ly 35 miles from home or any nissan service departments, I was able to drive the vehicle to my closest dealership and they were able to look at the possible cause, they gave me the vehicle back a couple of days after withe codes del3t3d and a supposedly fix was recharged the 12w battery. ,less than a week pass by and same issue happen and I was able to come back to their service department.for further diagnostic. Aproximat3ly 45 days went by and I stop by there service dep and was told they didn't have the equipments special gloves to work on the high volt electrical battery so instead of me leaving it there for it to just sit there I took it home with is not far from it, for two months to allow them tkme.to.get the required equipment. I come back on December 27 since rh3n is still there with no diagnostic results or repairs just sitting there, getting more damage as I come back a few months after, I had my children car seat on it and they are all molded and no longer usable. I contacted nissan cuatomet affairs months ago and after many calls and emails to get some one to finally accept to help me get a resolution in March I was told by letter sent to my email that they agreed to buy back the unit. They asked for some documents on the letter, I got all the documents, sent them and , them asking for.more documents not listed and taking weeks to even answer and email , since then its been months and all I know they will buy but I have no value or update if they need any further docs or if what are they waiting for.

NHTSA complaint #11747868 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

"2022 Nissan Leaf 40 kWh (VIN: [XXX], ~41,570 miles) lost motive power at highway speed on [XXX]. Vehicle entered turtle mode and shifted into neutral while traveling on the freeway, requiring me to coast to an off-ramp (I was completely unable to use the accelerator nor move the car into Park). Vehicle was inoperable and required towing. This followed a similar incident on [XXX], where the vehicle entered turtle mode 7 miles from home despite showing 120 miles of indicated range. LeafSpy diagnostics confirm 8 weak battery cells with a 261 mV spread. Open recall NHTSA 25V-655 is unresolved. This is a safety defect, not normal degradation. I am attaching photos that show significant variance in mileage--at one point, I had 95 miles, and within 7 miles, it had gone to 0 miles and after another 8 miles, it entered turtle mode. 3 miles after that, the car essentially shut off and went into neutral. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11744732 — an unverified report by a vehicle owner.

ENGINE

"2022 Nissan Leaf 40 kWh (VIN: [XXX], ~41,570 miles) lost motive power at highway speed on [XXX]. Vehicle entered turtle mode and shifted into neutral while traveling on the freeway, requiring me to coast to an off-ramp (I was completely unable to use the accelerator nor move the car into Park). Vehicle was inoperable and required towing. This followed a similar incident on [XXX], where the vehicle entered turtle mode 7 miles from home despite showing 120 miles of indicated range. LeafSpy diagnostics confirm 8 weak battery cells with a 261 mV spread. Open recall NHTSA 25V-655 is unresolved. This is a safety defect, not normal degradation. I am attaching photos that show significant variance in mileage--at one point, I had 95 miles, and within 7 miles, it had gone to 0 miles and after another 8 miles, it entered turtle mode. 3 miles after that, the car essentially shut off and went into neutral. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11744732 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not available. The contact stated that a Level 3 charging error message was displayed, and the vehicle stalled. The vehicle was later towed to the local dealer, who performed an electrical software update, but the failure reoccurred. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 86,830.

NHTSA complaint #11743210 — an unverified report by a vehicle owner.

POWER TRAIN

I am reporting a critical safety hazard involving my 2021 Nissan Leaf S Plus (approx. 117,000 miles). Since January 2025, the vehicle has exhibited dangerous battery degradation and voltage sag during operation. On my 30-mile highway commute, while driving at normal highway speeds—especially on inclines—the vehicle would suddenly display a low-power warning, and the remaining battery percentage would instantly crash. This caused a sudden, dangerous loss of propulsion in high-speed traffic, creating severe crash risks. I primarily charged at home and rarely used DC fast charging. On May 22, 2026, while actively driving, the dashboard flashed: "Service EV system unable to restart after power off." I pulled over, and upon turning the car off, it completely bricked. The auxiliary electronics power up, but the vehicle permanently refuses to enter "READY" (Drive) mode due to a high-voltage safety lock. The vehicle was towed to an authorized Nissan dealer. The certified technician's diagnostic report confirmed that the high-voltage traction battery has completely failed and is internally damaged. Crucially, this vehicle is currently under an active, unremedied safety recall (NHTSA Recall 25V655 / Nissan R25C8) due to excessive lithium deposits that cause severe battery degradation, sudden power loss, and fire risks. The physical failure of my battery is a direct manifestation of this exact manufacturing defect. Nissan’s software-only "interim remedy" did not fix the hardware defect; it simply bricked my car after exposing my family to highway propulsion loss. Nissan must be held legally responsible for replacing these defective, recalled battery packs regardless of mileage, as they present a severe, systemic risk of catastrophic failure and traffic accidents.

NHTSA complaint #11742970 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I am reporting a critical safety hazard involving my 2021 Nissan Leaf S Plus (approx. 117,000 miles). Since January 2025, the vehicle has exhibited dangerous battery degradation and voltage sag during operation. On my 30-mile highway commute, while driving at normal highway speeds—especially on inclines—the vehicle would suddenly display a low-power warning, and the remaining battery percentage would instantly crash. This caused a sudden, dangerous loss of propulsion in high-speed traffic, creating severe crash risks. I primarily charged at home and rarely used DC fast charging. On May 22, 2026, while actively driving, the dashboard flashed: "Service EV system unable to restart after power off." I pulled over, and upon turning the car off, it completely bricked. The auxiliary electronics power up, but the vehicle permanently refuses to enter "READY" (Drive) mode due to a high-voltage safety lock. The vehicle was towed to an authorized Nissan dealer. The certified technician's diagnostic report confirmed that the high-voltage traction battery has completely failed and is internally damaged. Crucially, this vehicle is currently under an active, unremedied safety recall (NHTSA Recall 25V655 / Nissan R25C8) due to excessive lithium deposits that cause severe battery degradation, sudden power loss, and fire risks. The physical failure of my battery is a direct manifestation of this exact manufacturing defect. Nissan’s software-only "interim remedy" did not fix the hardware defect; it simply bricked my car after exposing my family to highway propulsion loss. Nissan must be held legally responsible for replacing these defective, recalled battery packs regardless of mileage, as they present a severe, systemic risk of catastrophic failure and traffic accidents.

NHTSA complaint #11742970 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I am reporting a critical safety hazard involving my 2021 Nissan Leaf S Plus (approx. 117,000 miles). Since January 2025, the vehicle has exhibited dangerous battery degradation and voltage sag during operation. On my 30-mile highway commute, while driving at normal highway speeds—especially on inclines—the vehicle would suddenly display a low-power warning, and the remaining battery percentage would instantly crash. This caused a sudden, dangerous loss of propulsion in high-speed traffic, creating severe crash risks. I primarily charged at home and rarely used DC fast charging. On May 22, 2026, while actively driving, the dashboard flashed: "Service EV system unable to restart after power off." I pulled over, and upon turning the car off, it completely bricked. The auxiliary electronics power up, but the vehicle permanently refuses to enter "READY" (Drive) mode due to a high-voltage safety lock. The vehicle was towed to an authorized Nissan dealer. The certified technician's diagnostic report confirmed that the high-voltage traction battery has completely failed and is internally damaged. Crucially, this vehicle is currently under an active, unremedied safety recall (NHTSA Recall 25V655 / Nissan R25C8) due to excessive lithium deposits that cause severe battery degradation, sudden power loss, and fire risks. The physical failure of my battery is a direct manifestation of this exact manufacturing defect. Nissan’s software-only "interim remedy" did not fix the hardware defect; it simply bricked my car after exposing my family to highway propulsion loss. Nissan must be held legally responsible for replacing these defective, recalled battery packs regardless of mileage, as they present a severe, systemic risk of catastrophic failure and traffic accidents.

NHTSA complaint #11742970 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Recall R25C8 has restricted my vehicle from Level 3 charging since October 2025. The manufacturer has left me with a vehicle that cannot perform basic long-distance transit for over half a year. This is our only vehicle and makes long distance traveling to visit family impossible without renting a car.

NHTSA complaint #11741317 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000(ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure listed in the recall and the vehicle did not fully charge and had stalled. The failure mileage was 17,000.

NHTSA complaint #11739434 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The high-voltage battery on my 2022 Nissan Leaf is subject to Recall 25V655. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. The issue is that the remedy described by Nissan is not an actual repair of the battery defect. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car may disable itself if the defect begins to appear. The recall materials also state there is no warning before overheating occurs. This creates multiple safety concerns: • The underlying battery defect remains uncorrected. • The vehicle can become immobilized (unable to restart or recharge) if the software detects the condition. • Loss of Level 3 charging capability affects the ability to travel safely or plan charging when needed. • A battery fire risk exists during Level 3 charging if the defect is not detected in time. Nissan’s documents state that the software is meant only to prevent the “progression” of a thermal incident, not to repair the defective battery. I am concerned that my vehicle contains a known hazardous defect that has not been physically repaired and that the software-only response is inadequate to ensure safety. I am filing this complaint so NHTSA is aware that the remedy being offered does not address the internal battery defect itself and may leave owners exposed to continued safety and reliability risks.

NHTSA complaint #11737228 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I feel like the manufacture has failed to remedy recall 25V-655 in a timely manner. Not being able to fast charge is not a workable solution for the function of the car.

NHTSA complaint #11733023 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Purchased 11/2022. Drove extensively out of town and charged with fast charger destroying the battery. Had towed into dealership 3 times they cleared the code 3 times (limp mode) Dealership refuses to change battery under warranty. Due to the fire hazard the car was put in non-op August 2024. Stuck with an unsafe car can’t drive it sell it or trade it in until the battery is replaced under warranty please help.

NHTSA complaint #11729738 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Dear National Highway Traffic Safety Administration (NHTSA), I am submitting a formal safety complaint regarding my 2022 Nissan Leaf due to repeated and sudden battery failure that has created unsafe driving conditions. Over the past several months, my vehicle has experienced severe and unpredictable battery drain. Even after a full charge (approximately 100 miles indicated), the battery rapidly depletes to 20–30 miles or less within a short distance. On multiple occasions, the vehicle has lost charge unexpectedly, leaving me stranded and requiring assistance to safely return home. This issue presents a serious safety concern, as the sudden loss of battery power can occur while driving, increasing the risk of being stranded in unsafe locations or traffic conditions. I took the vehicle to an authorized Nissan service center (Bommarito Nissan), where it remained for several days for diagnosis. During this time, I was informed that the issue was being evaluated and that replacement of several battery modules or possibly the entire battery pack might be required. However, after internal review, the issue was dismissed and attributed solely to “weather conditions,” and no repair or replacement was performed. This explanation is not acceptable, as the same issue has occurred in normal and mild weather conditions. The problem persists and continues to impact the safe operation of the vehicle. Despite multiple requests, I have not received a complete diagnostic report or a clear technical explanation from Nissan. The vehicle remains unreliable and unsafe to operate due to the risk of sudden battery depletion. I respectfully request that NHTSA review this matter as a potential safety defect related to battery performance and loss of propulsion in an electric vehicle. Thank you for your attention to this serious safety concern. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11729239 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Dear National Highway Traffic Safety Administration (NHTSA), I am submitting a formal safety complaint regarding my 2022 Nissan Leaf due to repeated and sudden battery failure that has created unsafe driving conditions. Over the past several months, my vehicle has experienced severe and unpredictable battery drain. Even after a full charge (approximately 100 miles indicated), the battery rapidly depletes to 20–30 miles or less within a short distance. On multiple occasions, the vehicle has lost charge unexpectedly, leaving me stranded and requiring assistance to safely return home. This issue presents a serious safety concern, as the sudden loss of battery power can occur while driving, increasing the risk of being stranded in unsafe locations or traffic conditions. I took the vehicle to an authorized Nissan service center (Bommarito Nissan), where it remained for several days for diagnosis. During this time, I was informed that the issue was being evaluated and that replacement of several battery modules or possibly the entire battery pack might be required. However, after internal review, the issue was dismissed and attributed solely to “weather conditions,” and no repair or replacement was performed. This explanation is not acceptable, as the same issue has occurred in normal and mild weather conditions. The problem persists and continues to impact the safe operation of the vehicle. Despite multiple requests, I have not received a complete diagnostic report or a clear technical explanation from Nissan. The vehicle remains unreliable and unsafe to operate due to the risk of sudden battery depletion. I respectfully request that NHTSA review this matter as a potential safety defect related to battery performance and loss of propulsion in an electric vehicle. Thank you for your attention to this serious safety concern. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11729239 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Nissan Leaf. The contact was notified of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that due to the recall, the ability to drive long distances was restricted. The contact had not experienced a failure.

NHTSA complaint #11728791 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Nissan Recall R25C8 (NHTSA ID: 25V655), Incomplete, remedy not available Primary Issue: High-voltage battery fire risk during Level 3 (DCFC) charging due to excessive lithium deposits. I have been told by Nissan not to use Level 3 fast charging. This has significantly impaired the utility of my vehicle due to: - Limited Range/Utility: Without fast charging, I can't use the car for trips beyond its immediate single-charge radius, basically turning a long-range EV into a local-only car. The proposed software may limit charging or prevent the vehicle from restarting if it detects a dangerous condition, rather than permanently fixing the defect. - Time Loss: I can't charge at home unless (only overnight & if weather permits) I run a cable out of my apartment window, across the grass & sidewalk for a trickle charge (Level 1). Otherwise I have to drive to a Level 2 charger & wait many hours to charge up. This is significantly longer, makes it impossible to quickly 'top off' as advertised. For comparison: L3 (DCFC) gets me at least 15% in about 15 minutes (60% per/hour); L2 only gets 11% per/hour. L1 only gets 2% per/hour. Without DCFC this car is almost useless. - Diminished Value: Nissan sold me a $38,000 car & I'm concerned that a software-only 'fix' that may throttle charging speeds or simply disable the car if it detects heat will permanently reduce the vehicle's market value. I actually expected to keep this car for the rest of my life, but the CHAdeMO system (which appears is becoming un-supported) that also lacks a cooling system, makes that very unlikely. - Impact to income due to part-time employment that requires travel, which the LEAF was capable of doing with DCFC stops. Now, I need to rent a vehicle for these events. Purchased Cherry Hill Nissan March 11, 2022 2/3/2026: Nissan Service appointment. They are still unable to fix the recall issue, whether via software or hardware. 3/18/2026: I received another safety recall notice. Still no solution.

NHTSA complaint #11727965 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Recall notice has been present for > 1 year and no remedy yet available for dangerous battery overheating.

NHTSA complaint #11728133 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Nissan Recall R25C8 (NHTSA ID: 25V655), Incomplete, remedy not available Primary Issue: High-voltage battery fire risk during Level 3 (DCFC) charging due to excessive lithium deposits. I have been told by Nissan not to use Level 3 fast charging. This has significantly impaired the utility of my vehicle due to: - Limited Range/Utility: Without fast charging, I can't use the car for trips beyond its immediate single-charge radius, basically turning a long-range EV into a local-only car. The proposed software may limit charging or prevent the vehicle from restarting if it detects a dangerous condition, rather than permanently fixing the defect. - Time Loss: I can't charge at home unless (only overnight & if weather permits) I run a cable out of my apartment window, across the grass & sidewalk for a trickle charge (Level 1). Otherwise I have to drive to a Level 2 charger & wait many hours to charge up. This is significantly longer, makes it impossible to quickly 'top off' as advertised. For comparison: L3 (DCFC) gets me at least 15% in about 15 minutes (60% per/hour); L2 only gets 11% per/hour. L1 only gets 2% per/hour. Without DCFC this car is almost useless. - Diminished Value: Nissan sold me a $38,000 car & I'm concerned that a software-only 'fix' that may throttle charging speeds or simply disable the car if it detects heat will permanently reduce the vehicle's market value. I actually expected to keep this car for the rest of my life, but the CHAdeMO system (which appears is becoming un-supported) that also lacks a cooling system, makes that very unlikely. - Impact to income due to part-time employment that requires travel, which the LEAF was capable of doing with DCFC stops. Now, I need to rent a vehicle for these events. Purchased Cherry Hill Nissan March 11, 2022 2/3/2026: Nissan Service appointment. They are still unable to fix the recall issue, whether via software or hardware. 3/18/2026: I received another safety recall notice. Still no solution.

NHTSA complaint #11727965 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

My Nissan Leaf is currently under NHTSA Recall Number 25V-655 since Oct 2025 and I cannot charge the car on a Level 3 fast charger. This has made the car unusable for my current needs. I have been forced to rent and borrow cars for necessary long distance trips. Nissan continues to delay their planned resolution for this problem and this situation is completely unacceptable.

NHTSA complaint #11727634 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

My Nissan Leaf is currently under NHTSA Recall Number 25V-655 since Oct 2025 and I cannot charge the car on a Level 3 fast charger. This has made the car unusable for my current needs. I have been forced to rent and borrow cars for necessary long distance trips. Nissan continues to delay their planned resolution for this problem and this situation is completely unacceptable.

NHTSA complaint #11727634 — an unverified report by a vehicle owner.