FaultScore report
Owners have filed 300 complaints about the 1992 Plymouth Grand Voyager with NHTSA between 1996 and 2018. The largest single group is the seat belts.
300
Complaints
13
Crashes reported
7
Fires reported
12
Injuries reported
1 complaint reports a death.
145,000 mi
Median mileage at failure
Half of reported failures happened before this
7%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
0 crashes, 4 fires
Median failure at 107,000 miles
Median failure at 85,350 miles
1 crashes, 0 fires · median 329,110 mi
Median failure at 118,000 miles
NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.
SAFETY BLT LATCH OPERATION
STEERING WHEEL SEPARATION
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING COLUMN SHAFT AND IS ATTACHED TO THE UNDERSIDE OF THE STEERING WHEEL ASSEMBLY BY 4 WELDS.IF CRACKS DEVELOP IN THE HEAT AFFECTED REGION OF THE WELDS AND PROPAGATE THROUGH THE STEERING WHEEL ARMATURE TO EACH OF THE WELDS, THE STEERING WHEEL CAN SEPARATE FROM THE HUB.THIS IS A SLOW PR...
ABS BRAKING SYSTEM FAILS
ABS BRAKING SYSTEM FAILS
LIFTGATE LATCHES
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT...
A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.
VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Risk: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
SEAT BELTS:FRONT:ANCHORAGE
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Risk: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
STEERING: STEERING WHEEL/HANDLE BAR
THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Risk: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Risk: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITH REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.
Risk: IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITHOUT REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.
Risk: IF THE LIFTGATE LATCH OPENS, OCCUPANTS CAN BE EJECTED RESULTING IN SIGNIFICANTLY INCREASED RISK OF INJURY OR DEATH.
Canada runs its own recall programme, and its campaigns do not always mirror the American ones.
Visual System
On certain vehicles, the left hand windshield wiper pivot drive arm was not mechanically staked to the pivot shaft. This may allow the drive arm to disengage from the shaft and lead to a loss of wiper function. Correction: The left windshield wiper pivot assembly will be replaced with one that incorporates an improved mechanical connection of the drive link to the pivot shaft.
Seats And Restraints
The first row rear seat outboard side seat belt anchor hook can become unattached from the body anchor position. Also, the covers on solid stalk mounted seat belt buckles may become dislodged. Should a cover become dislodged, the release button may stick inside the cover creating the potential for the buckle to become partially latched. In the event of a vehicle crash, either of these conditions could result in the occupant not being properly restrained. Correction: Anchor hook retaining clip will be replace with a revised profile clip and cover plate. Dealers will also install a cover retaining clip to the stalk mounted buckle cover to prevent dislocation of the buckle cover.
Structure
A combination of no bolt torque, high pressure in the strut and a severe duty cycle can create the potential for the liftgate strut attaching bolts to separate. This could result in injury to persons standing under the liftgate at the time of failure. Correction: Liftgate struts will be inspected for loose fasteners. If fasteners are loose, the strut (and integral bolts) will be replaced. If the bolt shows evidence of torque, the bolt will be removed, large washers will be installed and bolt will be torqued to specification.
Steering
The steering wheel armature stamping may crack and separate from the centre hub of the steering column. This could adversely affect steering control and result in a possible crash without prior warning. Correction: Steering wheels exhibiting cracks will be replaced. All other involved vehicles will have a anti-separation plate installed to prevent separation of the steering wheel from the steering column.
Brakes
Note: Vehicles equipped with Bendix-10 Antilock Brake System (ABS) Vehicles with ABS brakes may experience premature actuator piston seal wear in the ABS hydraulic control unit and/or actuator pump motor deterioration. If this occurs, the ABS function may be lost and reduced power assist may be experienced during vehicle braking. Correction: Vehicles with ABS malfunction will be repaired as necessary. Warranty on all ABS components will be extended to 10 years or 160,000 km (except for the brake actuator piston assembly and the pump-motor assembly which will have lifetime coverage).
Fuel System
IMPROPER STAMPING OF THE FUEL TANK FLANGES COULD RESULT IN DAMAGE TO THE FUEL TANK MOUNTING STRAPS AND/OR THE FUEL LINES WHICH IN TURN COULD RESULT IN FUEL TANK SEPARATION OR FUEL LEAKAGE. CORRECTION: VEHICLES WILL BE INSPECTED FOR PROPER FUEL TANK FLANGE BENDS AND IF NECESSARY THE FLANGE WILL BE BENT TO THE SPECIFIED ANGLE. DAMAGED MOUNTING STRAPS AND FUEL LINES WILL BE REPLACED AS REQUIRED.
Steering
A steering column coupling bolt may fracture due to hydrogen embrittlement, causing loss of clamping load on the steering column shaft coupling with resultant loss of steering control. Correction: Zinc plated steering column coupling bolts will be replaced with a phosphate coated bolt.
Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.
Reports where the owner recorded a crash, a fire, an injury or a death.
STEERING
1992 DODGE PLYMOUTH GRAND VOYAGER LE THE STEERING WHEEL BROKE UP UNDER THE VAN WHILE I WAS DRIVING,CAUSING ME TO CRASH INTO SOME ONE ELSE VEHICLE.
NHTSA complaint #10152602 — an unverified report by a vehicle owner.
STEERING:LINKAGES:TIE ROD ASSEMBLY
1992 DODGE PLYMOUTH GRAND VOYAGER LE THE STEERING WHEEL BROKE UP UNDER THE VAN WHILE I WAS DRIVING,CAUSING ME TO CRASH INTO SOME ONE ELSE VEHICLE.
NHTSA complaint #10152602 — an unverified report by a vehicle owner.
AIR BAGS:FRONTAL
AIR BAG FAILURE.
NHTSA complaint #10028556 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
UNDERHOOD WIRING HARNESS CAUGHT ON FIRE.
NHTSA complaint #8013470 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
VEHICLE WAS IN THE PARK GEAR AND IDLING WHEN IT ROLLED IN REVERSE WITH A CHILD RESTRAINED IN A CHILD SAFETY SEAT BEFORE CRASHING THROUGH A FENCE, AND BEING STOPPED BY A PILE OF WOOD. DEALERSHIP HAS NOT EXAMINED VEHICLE. *AK *SLC
NHTSA complaint #8000945 — an unverified report by a vehicle owner.
TIRES
DRIVER'S SIDE REAR TIRE FAILED, BLOW OUT OCCURRED, VAN ROLLED 4 TIMES. *AK (TIRESIZE: P205/70RI5)( DOT NUMBER: TIRE SIZE: P205/70RI5 )
NHTSA complaint #744599 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
SERVICE BRAKES
TL* THE CONTACT OWNS A 1992 PLYMOUTH GRAND VOYAGER. WHILE DRIVING VARIOUS SPEEDS, EXCESSIVE FORCE HAD TO BE APPLIED TO THE BRAKE PEDAL TO STOP THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. LODI CHRYSLER JEEP DODGE RAM (1255 BECKMAN RD, LODI, CA) DIAGNOSED THAT THE ABS PUMP MODULE ASSEMBLY AND BRAKE ACTUATOR ASSEMBLY FAILED. THE PARTS WERE INCLUDED IN A LIFETIME CHRYSLER CUSTOMER SATISFACTION CAMPAIGN NUMBER: 682; HOWEVER, THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO HONOR THE CAMPAIGN BECAUSE THEY NO LONGER MANUFACTURED THE PARTS FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 189,000.
NHTSA complaint #11120478 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
THIS VAN IS AFFECTED BY THE 96V099000 NHTSA RECALL, HOWEVER WHEN INQUIRING ABOUT GETTING THE ABS MOTOR REPLACED AT A LOCAL DEALERSHIP I WAS TOLD THAT THE PARTS ARE NO LONGER MADE TO FIX THIS ISSUE. I BELIEVE THAT CHRYSLER HAS A DUTY TO FIX THE BRAKES ON THIS VEHICLE AS DIRECTED BY THE NHTSA, PARTS OBSOLESCENCE DOES NOT ABSOLVE THEM FROM RESPONSIBILITY OR THE NHTSA. IF THE PARTS ARE NO LONGER AVAILABLE I REQUEST THAT CHRYSLER PURCHASE THE VAN BACK FROM ME AND HAVE IT DESTROYED, FIX THE BRAKES ACCORDING TO THE RECALL OR CONVERT THE BRAKES TO THE NON-ABS TYPE. I DO NOT UNDERSTAND HOW CHRYSLER AND THE NHTSA COULD ALLOW BENDIX (THE MANUFACTURER OF THIS RATHER PROBLEMATIC BRAKE SYSTEM) TO STOP MAKING A LIFETIME REPLACEMENT PART. THIS ISSUE CAUSES THE POWER ASSIST TO STOP WORKING, CREATES A HARD PEDAL WHICH MAKES IT IMPOSSIBLE TO DRIVE THE VEHICLE SAFELY. THIS CREATES A CONDITION WORSE THAN A VEHICLE WITH ALL MANUAL BRAKES THAT HAVE NO POWER / VACUUM ASSIST TO BEGIN WITH, WHEN TEST DRIVING THE VEHICLE IT TAKES BOTH FEET PLANTED FIRMLY ON THE PEDAL TO STOP IT. AS I HAVE NOT GOTTEN A SATISFACTORY SOLUTION THAT WAS MANDATED AND ENFORCED BY THE NHTSA, I LOOK FORWARD TO YOUR PROMPT REPLY IN THIS MATTER.
NHTSA complaint #10651805 — an unverified report by a vehicle owner.
SERVICE BRAKES
THIS VAN IS AFFECTED BY THE 96V099000 NHTSA RECALL, HOWEVER WHEN INQUIRING ABOUT GETTING THE ABS MOTOR REPLACED AT A LOCAL DEALERSHIP I WAS TOLD THAT THE PARTS ARE NO LONGER MADE TO FIX THIS ISSUE. I BELIEVE THAT CHRYSLER HAS A DUTY TO FIX THE BRAKES ON THIS VEHICLE AS DIRECTED BY THE NHTSA, PARTS OBSOLESCENCE DOES NOT ABSOLVE THEM FROM RESPONSIBILITY OR THE NHTSA. IF THE PARTS ARE NO LONGER AVAILABLE I REQUEST THAT CHRYSLER PURCHASE THE VAN BACK FROM ME AND HAVE IT DESTROYED, FIX THE BRAKES ACCORDING TO THE RECALL OR CONVERT THE BRAKES TO THE NON-ABS TYPE. I DO NOT UNDERSTAND HOW CHRYSLER AND THE NHTSA COULD ALLOW BENDIX (THE MANUFACTURER OF THIS RATHER PROBLEMATIC BRAKE SYSTEM) TO STOP MAKING A LIFETIME REPLACEMENT PART. THIS ISSUE CAUSES THE POWER ASSIST TO STOP WORKING, CREATES A HARD PEDAL WHICH MAKES IT IMPOSSIBLE TO DRIVE THE VEHICLE SAFELY. THIS CREATES A CONDITION WORSE THAN A VEHICLE WITH ALL MANUAL BRAKES THAT HAVE NO POWER / VACUUM ASSIST TO BEGIN WITH, WHEN TEST DRIVING THE VEHICLE IT TAKES BOTH FEET PLANTED FIRMLY ON THE PEDAL TO STOP IT. AS I HAVE NOT GOTTEN A SATISFACTORY SOLUTION THAT WAS MANDATED AND ENFORCED BY THE NHTSA, I LOOK FORWARD TO YOUR PROMPT REPLY IN THIS MATTER.
NHTSA complaint #10651805 — an unverified report by a vehicle owner.
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
WHILE DRIVING AT APPROXIMATELY 40 MPH, THE SPARE TIRE FELL FROM UNDER THE VAN.
NHTSA complaint #10521392 — an unverified report by a vehicle owner.
STRUCTURE
WHILE DRIVING AT APPROXIMATELY 40 MPH, THE SPARE TIRE FELL FROM UNDER THE VAN.
NHTSA complaint #10521392 — an unverified report by a vehicle owner.
SERVICE BRAKES
EXPERIENCED HARD BRAKE PEDAL (LOSE OF BRAKING) AND BRAKE / ABS LIGHTS ILLUMINATED ON THE DASH BOARD. THIS WAS THE SECOND FAILURE IN THE LAST TWO YEARS AFTER APPROXIMATELY 14,000 MILES OF OPERATION SINCE THE LAST REPAIR AND FOR AT LEAST THE FOURTH TIME SINCE WE HAVE OWNED THIS VEHICLE (BOUGHT NEW). PREVIOUS REPAIR INVOLVED REPLACEMENT OF BRAKE ACCUMULATOR, DUAL PRESSURE SWITCH, BRAKE ACTUATOR PISTON ASSEMBLY, AND THE PUMP MOTOR ASSEMBLY, THE LAST TWO OF WHICH ARE SUBJECT TO A LIFETIME RECALL. DEALER REFUSES TO REPAIR/REPLACE WARRANTED PARTS WITHOUT AGREEMENT THAT OTHER PARTS ARE REPLACED AT A COST OF APPROXIMATELY $900. GIVEN THAT IT IS LIKELY THAT WARRANTED PART FAILURES ARE LEADING TO THE FAILURE OF THE OTHER COMPONENTS AND THAT THE LAST REPAIR ONLY LASTED FOR 14,000 MILE WE REQUESTED THAT CHRYSLER COVER THE ENTIRE REPAIR. CHRYSLER REFUSED. IN ADDITION, IT HAS BEEN OUR EXPERIENCE THAT EACH TIME WE HAVE HAD THE BRAKE SYSTEM FAIL, IT HAS INCLUDED THE NEED TO REPLACE OTHER BRAKE SYSTEM COMPONENTS BEYOND THE PARTS SUBJECT TO THE LIFETIME RECALL. THUS IT WOULD APPEAR THAT THE LIFETIME RECALL SHOULD HAVE BEEN EXPANDED TO COVER ALL OF THE COMPONENTS IMPACTED BY THE FAILURE OF THE WARRANTED COMPONENTS.
NHTSA complaint #10483460 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1992 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS A LOUD NOISE COMING FROM THE VEHICLE. AFTER PULLING OVER SHE NOTICED THAT THE FUEL RAIL WAS FRACTURED AND PARTIALLY HANGING FROM THE VEHICLE. IN ADDITION, THE SLIDING PASSENGER SIDE DOOR WOULD SPORADICALLY COME OFF TRACK AND COULD NOT BE CLOSED PROPERLY. THE DOOR WAS CLOSED USING A CORD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THEY WOULD HAVE TO TAKE THE DOOR APART FOR REALIGNMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE, STATING THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
NHTSA complaint #10438709 — an unverified report by a vehicle owner.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1992 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS A LOUD NOISE COMING FROM THE VEHICLE. AFTER PULLING OVER SHE NOTICED THAT THE FUEL RAIL WAS FRACTURED AND PARTIALLY HANGING FROM THE VEHICLE. IN ADDITION, THE SLIDING PASSENGER SIDE DOOR WOULD SPORADICALLY COME OFF TRACK AND COULD NOT BE CLOSED PROPERLY. THE DOOR WAS CLOSED USING A CORD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HER THAT THEY WOULD HAVE TO TAKE THE DOOR APART FOR REALIGNMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE, STATING THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
NHTSA complaint #10438709 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
TL*THE CONTACT OWNS A 1992 PLYMOUTH GRAND VOYAGER. WHILE DRIVING AT 35 MPH, THE CONTACT ATTEMPTED TO USE THE BRAKES BUT THE VEHICLE DID NOT SLOW DOWN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP BUT NO REPAIRS WERE PERFORMED AT THE TIME OF THE COMPLAINT BECAUSE THE PARTS WERE NO LONGER AVAILABLE. THE CONTACT REFERENCED RECALL 96V099000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK) AS SHE FELT IT WAS RELATED TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 196,555.
NHTSA complaint #10330281 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
TWO WEEKS AGO THE ABS AND BRAKE LIGHTS CAME ON IN MY 1992 PLYMOUTH GRAND VOYAGER MINI-VAN. AT THAT MOMENT THERE WAS NO HYDRAULIC BRAKE PRESSURE AND IT WAS VERY DIFFICULT TO CONTROL THE VAN. THE VAN WAS TOWED TO MY REGULAR, INDEPENDENT REPAIR SHOP AND THEY CHECKED THE CONDITION AND THEIR DIAGNOSTIC COMPUTER ISSUED A CODED ERROR. I DISCOVERED THAT THIS ABS BRAKE WAS COVERED UNDER AN EXTENDED WARRANTY BY CHRYSLER. I TOOK THE VAN TO A NEARBY CHRYSLER DEALER AND THEY CHECKED. THE ABS LIGHT AND BRAKE LIGHT WERE OUT AT THIS TIME AND THE DEALER CHARGED FOR ONE HOUR, GAVE ME LIST OF PARTS THEY CONSIDERED MAY NEED TO BE REPLACED AND VERBALLY SAID IT MAY COST ABOUT $400 OR MORE TO FIX. THEY DID NOT ASSURE ME THAT A WARRANTY WOULD APPLY.
NHTSA complaint #10229272 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
MY ABS LIGHT CAME ON AND A FEW DAYS LATER MY MASTER CYLINDER FAILED RESULTING IN NO BREAKS. I WAS ABLE TO GET TO THE SIDE OF THE ROAD FOR A TOW. I HAVE PAID TO GET REPAIRS COMPLETED. CHRYSLER TELLS ME MY CAR IS NOT COVERED BY RECALL. I DISPUTE THIS. RECALL # 96V099000.
NHTSA complaint #10209354 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
MY ABS LIGHT CAME ON AND A FEW DAYS LATER MY MASTER CYLINDER FAILED RESULTING IN NO BREAKS. I WAS ABLE TO GET TO THE SIDE OF THE ROAD FOR A TOW. I HAVE PAID TO GET REPAIRS COMPLETED. CHRYSLER TELLS ME MY CAR IS NOT COVERED BY RECALL. I DISPUTE THIS. RECALL # 96V099000.
NHTSA complaint #10209354 — an unverified report by a vehicle owner.
POWER TRAIN:AUTOMATIC TRANSMISSION
TRANSMISSION IS LEAKING FROM FRONT PUMP SEAL AND FROM WHAT I HAVE BEEN TOLD ALL OF THE CARAVAN,VOYAGER AND TOWN & COUNTRY'S DO THIS BECAUSE THEY WERE NOT DESIGNED CORRECTLY.
NHTSA complaint #10199956 — an unverified report by a vehicle owner.
STEERING
1992 DODGE PLYMOUTH GRAND VOYAGER LE THE STEERING WHEEL BROKE UP UNDER THE VAN WHILE I WAS DRIVING,CAUSING ME TO CRASH INTO SOME ONE ELSE VEHICLE.
NHTSA complaint #10152602 — an unverified report by a vehicle owner.
STEERING:LINKAGES:TIE ROD ASSEMBLY
1992 DODGE PLYMOUTH GRAND VOYAGER LE THE STEERING WHEEL BROKE UP UNDER THE VAN WHILE I WAS DRIVING,CAUSING ME TO CRASH INTO SOME ONE ELSE VEHICLE.
NHTSA complaint #10152602 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
I HAVE A PLYMOUTH GRAND VOYAGER IN WHICH WAS INVOLVED IN AN EARLIER RE CALL FOR THE ABS BRAKES NOW THEY FAILED AGAIN
NHTSA complaint #10108415 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
I HAVE A PLYMOUTH GRAND VOYAGER IN WHICH WAS INVOLVED IN AN EARLIER RE CALL FOR THE ABS BRAKES NOW THEY FAILED AGAIN
NHTSA complaint #10108415 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
I HAVE A PLYMOUTH GRAND VOYAGER IN WHICH WAS INVOLVED IN AN EARLIER RE CALL FOR THE ABS BRAKES NOW THEY FAILED AGAIN
NHTSA complaint #10108415 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
THE BRAKES HAVE BEEN DEFECTIVE SINCE THE CONSUMER OWNED THE VEHICLE. THE BRAKES HAVE BEEN SERVICED EVERY YEAR. CONSUMER HAS TO PRESS ON THE BRAKES WITH BOTH FEET TO STOP THE VEHICLE. THE BRAKES REMAIN DEFECTIVE.
NHTSA complaint #10106639 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
TREAD SEPARATION IN TIRE. THE TIRE WAS A P205/17R15 WITH DOT U9M0 LBX2701 F01L. THE TIRE NAME WAS RESPONSE RST TOURING 2000. THE TIRE HAD 16000 MILES AND WAS ON THE VEHICLE 16 MAR 2002 TO 19 SEP 2004. THE TIRE WAS SOLD AND INSTALLED BY NTB, NATIONAL TIRE & BATTERY, STAFFORD, TX. OWNER DEDUCED THE SEPARATION AFTER THE DEFECTIVE TIRE WAS ROTATED TO THE REAR OF THE VEHICLE AND LATER NOTICED THE BUMP FROM THE TREAD SEPARATION. NTB STATED THAT THE REMAINING 3 TIRES WOULD ALSO FAIL BY TREAD SEPARATION. ALL FOUR TIRES WERE REPLACED. NONE OF THE TIRES WAS REPLACED FREE OF CHARGE.
NHTSA complaint #10091289 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
THE BRAKE PEDAL HAD BECAME HARD AND WOULDN'T GO DOWN WHEN DEPRESSED. THE CONSUMER COASTED THE VEHICLE INTO THE DRIVEWAY AND ENGAGED THE PARKING BRAKE TO STOP. THE VEHICLE WAS TOWED TO THE DEALER, AND THE MECHANIC PERFORMED A DIAGNOSTIC TEST THAT INDICATED THAT THE HYDRAULIC BRAKE PUMP MOTOR ASSEMBLY MALFUNCTIONED. ALSO, THERE WAS RECALL 96V099000 CONCERNING ANTI SKID BRAKE SYSTEM. HOWEVER, THE DEALERSHIP INDICATED THAT THIS RECALL HAD ALREADY BEEN PERFORMED. THE REMEDY FAILED, AND THE MANUFACTURER WAS NOT HONORING THE WARRANTY AS STATED IN THE RECALL, AND WERE NOT SENDING THE RECALL PART TO THE DEALERSHIP BECAUSE THE DEALERSHIP WAS UNABLE TO GET A DIAGNOSTIC TEST CODE INDICATING THAT THE RECALL PART FAILED, ALTHOUGH THE DEALERSHIP DUPLICATED THE PROBLEM , AND INDICATED THAT THE RECALL PART WAS CAUSING THE PROBLEM. *AK (THE SECOND CONSUMER: TARA BETH) *SC
NHTSA complaint #10083817 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
I HAD THIS VEHICLE FOR A VERY SHORT TIME WHEN I STARTED TO HAVE PROBLEMS WITH THE SLIDING DOOR NOT STAYING CLOSED. AFTER IT IS SHUT IT POPS OPEN IMMEDIATELY. I HAVE HAD THE BOLT ADJUSTED SEVERAL TIMES AND IT WOULD KEEP IT CLOSED, BUT NOT FOR LONG. AFTER IT HAD BEEN OPENED AND SHUT 2-5 TIMES IT WOULD AGAIN POP OPEN. THIS IS AN ON GOING PROBLEM. I HAVE PARKED THE VEHICLE AND WILL NOT DRIVE IT AND FEAR TO SELL IT DUE TO THIS MALFUNCTION OF THE SLIDING DOOR. SOMEONE SHOULD REPLACE THIS FOR FREE, BUT WHO? I AM A SINGLE MOTHER WITH 4 CHILDREN AND USED TO RELY ON A MINI-VAN.
NHTSA complaint #10081064 — an unverified report by a vehicle owner.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
I HAD THIS VEHICLE FOR A VERY SHORT TIME WHEN I STARTED TO HAVE PROBLEMS WITH THE SLIDING DOOR NOT STAYING CLOSED. AFTER IT IS SHUT IT POPS OPEN IMMEDIATELY. I HAVE HAD THE BOLT ADJUSTED SEVERAL TIMES AND IT WOULD KEEP IT CLOSED, BUT NOT FOR LONG. AFTER IT HAD BEEN OPENED AND SHUT 2-5 TIMES IT WOULD AGAIN POP OPEN. THIS IS AN ON GOING PROBLEM. I HAVE PARKED THE VEHICLE AND WILL NOT DRIVE IT AND FEAR TO SELL IT DUE TO THIS MALFUNCTION OF THE SLIDING DOOR. SOMEONE SHOULD REPLACE THIS FOR FREE, BUT WHO? I AM A SINGLE MOTHER WITH 4 CHILDREN AND USED TO RELY ON A MINI-VAN.
NHTSA complaint #10081064 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
WHILE APPLYING THE BRAKE THE PEDAL WENT TO THE FLOOR WHICH CAUSED A LOSS OF BRAKING POWER. THE DRIVER WAS ABLE TO CONTROL THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE DUAL FUNCTION PRESSURE SYSTEM, PERTAINING TO HYDRAULIC ASSEMBLY NEEDED TO BE REPLACED. *LA
NHTSA complaint #10071944 — an unverified report by a vehicle owner.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
I WOULD LIKE TO KNOW MORE ABOUT THE RECALLS FOR THE ABOVE VEHICLE AND WHAT EXACTLY THEY COVER AND DON'T COVER AND I GO ABOUT GETTING THEM FIXED. MY CAR IS NOW IN THE SHOP FOR FAILURE OF BRAKES. WHILE I WAS OUT DRIVING THE BRAKES SUDDENLY WENT ON ME
NHTSA complaint #10069362 — an unverified report by a vehicle owner.