FaultScore report
Owners have filed 366 complaints about the 1997 Plymouth Grand Voyager with NHTSA between 1996 and 2018. The largest single group is the engine & cooling. Across this model's run it ranks 2 of 8 worst.
FaultScore 57/100
Higher is worse. Measured against the other years of the Plymouth Grand Voyager.
How this is worked out366
Complaints
24
Crashes reported
24
Fires reported
18
Injuries reported
3 complaints report a death.
90,494 mi
Median mileage at failure
Half of reported failures happened before this
5%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Median failure at 103,500 miles
Median failure at 98,000 miles
Median failure at 198,650 miles
1 crashes, 0 fires
NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.
AIR BAG CLOCKSPRING
DC MINIVAN FUEL INJECTOR RAIL LEAK
POST COLLISION FUEL SYSTEM
POST-COLLISION FUEL SYSTEM INTEGRITY
INTEGRATED CHILD SEAT BELT LOCKUP
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
INTEGRATED CHILD SEAT BELT LOCKUP
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESS...
A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.
AIR BAGS:FRONTAL
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Risk: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
CHILD SEAT
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Risk: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
TIRES:BEAD
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Risk: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
SEAT BELTS:INTEGRATED CHILD SEAT
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH INTEGRAL CHILD SEATS. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. ON THE INTEGRAL CHILD SEAT, THE SHOULDER BELTS RESTRAINING THE CHILD RETRACT AND LOCK IN PLACE AFTER THE BELT BUCKLE IS CONNECTED TO THE LATCH PLATE. THE LATCH PLATE MOVEMENT LOCKS THE BELTS TO MAKE SURE THE CHILD IS RESTRAINED IN THE CASE OF A VEHICLE CRASH.
Risk: THE LATCH PLATE LOCATED IN THE SEAT CUSHION AREA MUST BE FREE TO MOVE BACK AGAINST ITS STOP AFTER THE BUCKLE IS REMOVED TO ALLOW THE SHOULDER BELTS TO BE PULLED OUT. ALWAYS BE SURE THE AREA AROUND THE LATCH PLATE IS FREE OF FOOD OR OTHER ITEMS THAT MIGHT PREVENT THE LATCH PLATE FROM MOVING BACK.
Canada runs its own recall programme, and its campaigns do not always mirror the American ones.
Airbag
On certain vehicles, the clockspring assembly may have been backwound during the vehicle assembly process. This could illuminate the air bag warning lamp and may eventually result in a driver's air bag open circuit. Correction: Dealers will replace the clockspring assembly on vehicles with less then 115 000 kms. Owners of vehicles with over 115 000 kms will be offered extended lifetime warranty on the clockspring.
Fuel System
On certain vehicles equipped with the 3.3L or 3.8L engine the Nitrile "O-ring" seals used in the fuel rail may degrade over time and extended exposure to elevated temperatures. This could result in fuel leakage, and, in the presence of an ignition source, an underhood fire could occur. Correction: External seals will be installed at both of the fuel rail crossover tube joints. If the crossover tube joints are leaking or red rust exists in the area, the fuel rail assembly must be replaced.
Seats And Restraints
NOTE: VEHICLES EQUIPPED WITH AN INTEGRATED CHILD SEAT. THE INTEGRATED CHILD SEAT SAFETY BELT LATCH MECHANISM MAY BECOME CONTAMINATED CAUSING THE SEAT BELT RELEASE MECHANISM TO STICK AND PREVENT THE RETRACTOR FROM RELEASING. THIS MAY RESULT IN DIFFICULTY REMOVING A CHILD FROM THE RESTRAINT. CORRECTION: CHILD SEAT LATCH PLATE MECHANISM WILL BE INSPECTED AND CLEANED. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR. NEW INSTRUCTION LABEL AND OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED FOR THE OPERATOR.
Suspension
NOTE: VEHICLES EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEELS. THERE IS THE POSSIBILITY THAT THE TIRE BEADS ON THESE VEHICLES WERE CUT DURING MOUNTING TO THE WHEEL. THIS WOULD CREATE THE POTENTIAL FOR THE TIRES TO EXPERIENCE A SUDDEN LOSS OF AIR WITHOUT WARNING. CORRECTION: TIRES WILL BE REPLACED WITH NEW ONES.
Brakes
NOTE: THIS RECALL HAS BEEN SUPERSEDED BY RECALL 97-107 (CHRYSLER-714). THE MASTER CYLINDER REAR SEAL BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY. THIS CAN ALLOW HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR. LOSS OF BRAKE FLUID WILL RESULT IN ILLUMINATION OF THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED MAY RESULT IN EXTENDED STOPPING DISTANCES. CORRECTION: AFFECTED VEHICLES WILL BE INSPECTED AND MASTER CYLINDER WILL BE REPLACED IF REQUIRED.
Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.
Reports where the owner recorded a crash, a fire, an injury or a death.
SEAT BELTS
IN 2005 WHILE ENTERING ONTO THE HIGHWAY GOING HOME FROM SOME PERSONAL APPOINTMENTS A SMALL CAR HIT OUR FULL SIZE VAN FROM BEHIND AND CAUSED US TO FLIP OVER AND ROLL OVER 8 TIMES AND SLIDE AT LEAST 2 CITY BLOCKS BEFORE IT STOPPED. WE WERE NOT EVEN DOING THE SPEED LIMIT WHEN WE WERE HIT. THE FRONT WINDOW SHATTERED AND GLASS WAS IN OUR EYES BUT OUR AIRBAGS DID NOT DEPLOY. WE WERE STUCK UPSIDE DOWN MY SEAT BELT WAS STUCK AND MY HUSBAND HAD TO PULL ME OUT OF THE DRIVER SIDE WINDOW. I HAD TO TREAT FOR TMJ PROBLEMS, STRESS AND TRAUMA IN MY NECK AND BACK FOR A FEW YEARS AND I STILL HAVE SOME ISSUES. DO WE HAVE A CLAIM AGAINST THE MANUFACTURER?
NHTSA complaint #11112744 — an unverified report by a vehicle owner.
AIR BAGS
IN 2005 WHILE ENTERING ONTO THE HIGHWAY GOING HOME FROM SOME PERSONAL APPOINTMENTS A SMALL CAR HIT OUR FULL SIZE VAN FROM BEHIND AND CAUSED US TO FLIP OVER AND ROLL OVER 8 TIMES AND SLIDE AT LEAST 2 CITY BLOCKS BEFORE IT STOPPED. WE WERE NOT EVEN DOING THE SPEED LIMIT WHEN WE WERE HIT. THE FRONT WINDOW SHATTERED AND GLASS WAS IN OUR EYES BUT OUR AIRBAGS DID NOT DEPLOY. WE WERE STUCK UPSIDE DOWN MY SEAT BELT WAS STUCK AND MY HUSBAND HAD TO PULL ME OUT OF THE DRIVER SIDE WINDOW. I HAD TO TREAT FOR TMJ PROBLEMS, STRESS AND TRAUMA IN MY NECK AND BACK FOR A FEW YEARS AND I STILL HAVE SOME ISSUES. DO WE HAVE A CLAIM AGAINST THE MANUFACTURER?
NHTSA complaint #11112744 — an unverified report by a vehicle owner.
STEERING
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM .
NHTSA complaint #10448357 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM .
NHTSA complaint #10448357 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM .
NHTSA complaint #10448357 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 1997 PLYMOUTH GRAND VOYAGER. THE VEHICLE HAD BEEN RUNNING FOR APPROXIMATELY TEN MINUTES WHEN THE CONTACT HEARD A LOUD NOISE. SOON AFTERWARDS, THE VEHICLE CAUGHT FIRE. THERE IS A RECALL FOR THIS FAILURE ON PLYMOUTHS WITH A DIFFERENT SIZE ENGINE. THE CURRENT MILEAGE, RECALL NUMBER, AND POWERTRAIN WERE UNKNOWN. THE FAILURE MILEAGE WAS 87,000.
NHTSA complaint #10212341 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
SEAT BELTS
IN 2005 WHILE ENTERING ONTO THE HIGHWAY GOING HOME FROM SOME PERSONAL APPOINTMENTS A SMALL CAR HIT OUR FULL SIZE VAN FROM BEHIND AND CAUSED US TO FLIP OVER AND ROLL OVER 8 TIMES AND SLIDE AT LEAST 2 CITY BLOCKS BEFORE IT STOPPED. WE WERE NOT EVEN DOING THE SPEED LIMIT WHEN WE WERE HIT. THE FRONT WINDOW SHATTERED AND GLASS WAS IN OUR EYES BUT OUR AIRBAGS DID NOT DEPLOY. WE WERE STUCK UPSIDE DOWN MY SEAT BELT WAS STUCK AND MY HUSBAND HAD TO PULL ME OUT OF THE DRIVER SIDE WINDOW. I HAD TO TREAT FOR TMJ PROBLEMS, STRESS AND TRAUMA IN MY NECK AND BACK FOR A FEW YEARS AND I STILL HAVE SOME ISSUES. DO WE HAVE A CLAIM AGAINST THE MANUFACTURER?
NHTSA complaint #11112744 — an unverified report by a vehicle owner.
AIR BAGS
IN 2005 WHILE ENTERING ONTO THE HIGHWAY GOING HOME FROM SOME PERSONAL APPOINTMENTS A SMALL CAR HIT OUR FULL SIZE VAN FROM BEHIND AND CAUSED US TO FLIP OVER AND ROLL OVER 8 TIMES AND SLIDE AT LEAST 2 CITY BLOCKS BEFORE IT STOPPED. WE WERE NOT EVEN DOING THE SPEED LIMIT WHEN WE WERE HIT. THE FRONT WINDOW SHATTERED AND GLASS WAS IN OUR EYES BUT OUR AIRBAGS DID NOT DEPLOY. WE WERE STUCK UPSIDE DOWN MY SEAT BELT WAS STUCK AND MY HUSBAND HAD TO PULL ME OUT OF THE DRIVER SIDE WINDOW. I HAD TO TREAT FOR TMJ PROBLEMS, STRESS AND TRAUMA IN MY NECK AND BACK FOR A FEW YEARS AND I STILL HAVE SOME ISSUES. DO WE HAVE A CLAIM AGAINST THE MANUFACTURER?
NHTSA complaint #11112744 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1997 PLYMOUTH GRAND VOYAGER. THE CONTACT NOTICED AN EXTENSIVE FUEL LEAK COMING FROM THE VEHICLE. THE CONTACT WAS NOT NOTIFIED OF NHTSA CAMPAIGN NUMBER: 00V268000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 196,559.
NHTSA complaint #10910054 — an unverified report by a vehicle owner.
AIR BAGS
I GOT IN THE VAN IN MY DRIVEWAY AND TURNED THE IGNITION SWITCH ON THEN I NOTICED THAT THE AIR BAG LIGHT WAS ON. SO I TURNED THE IGNITION SWITCH OFF WAITED A MINUTE THEN TURNED IT BACK ON AND THE LIGHT WAS STILL ON. I THOUGHT IT WAS A FUSE SO I PROCEEDED TO MY DESTINATION. AS I ARRIVED AT MY MOM'S HOUSE I TRIED TO BLOW THE HORN, THEN I FOUND OUT THAT MY HORN DID NOT WORK. SO I TURNED THE VAN OFF AND I CALLED A FRIEND WHO IS A MECHANIC AND HE ASKED ME IF THE AIR BAG LIGHT STAYED ON EVEN AFTER I TURNED THE VAN ON AND OFF I SAID YES THEN I EXPLAINED EVERYTHING TO HIM. HE TOLD ME THAT I NEEDED TO TRY MY CRUISE CONTROL. AND IF IT DID NOT WORK THEN MY CLOCKSPRING IS GONE. WELL CRUISE CONTROL DID NOT WORK. AND THE AIRBAG LIGHT IS STILL ON.
NHTSA complaint #10909497 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
I GOT IN THE VAN IN MY DRIVEWAY AND TURNED THE IGNITION SWITCH ON THEN I NOTICED THAT THE AIR BAG LIGHT WAS ON. SO I TURNED THE IGNITION SWITCH OFF WAITED A MINUTE THEN TURNED IT BACK ON AND THE LIGHT WAS STILL ON. I THOUGHT IT WAS A FUSE SO I PROCEEDED TO MY DESTINATION. AS I ARRIVED AT MY MOM'S HOUSE I TRIED TO BLOW THE HORN, THEN I FOUND OUT THAT MY HORN DID NOT WORK. SO I TURNED THE VAN OFF AND I CALLED A FRIEND WHO IS A MECHANIC AND HE ASKED ME IF THE AIR BAG LIGHT STAYED ON EVEN AFTER I TURNED THE VAN ON AND OFF I SAID YES THEN I EXPLAINED EVERYTHING TO HIM. HE TOLD ME THAT I NEEDED TO TRY MY CRUISE CONTROL. AND IF IT DID NOT WORK THEN MY CLOCKSPRING IS GONE. WELL CRUISE CONTROL DID NOT WORK. AND THE AIRBAG LIGHT IS STILL ON.
NHTSA complaint #10909497 — an unverified report by a vehicle owner.
SUSPENSION
THE DRIVERS SIDE STRUT TOWER IS RUSTING OUT, BUT NOT ON THE TOP LIKE MOST OF THEM DO. 3/4 OF THE SIDE OF THE TOWER IS RUSTED AND GONE. THE PASSENGER SIDE STILL LOOKS GOOD. I HAVE GONE TO SEVERAL SHOPS BUT NO ONE CAN HELP ME. THE VANS 3.3L ENGINE AND TRANS ARE STILL IN GOOD SHAPE SO I NEED TO FIND SOMEONE OR SOMETHING TO FIX THIS
NHTSA complaint #10863840 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE DRIVERS SIDE STRUT TOWER IS RUSTING OUT, BUT NOT ON THE TOP LIKE MOST OF THEM DO. 3/4 OF THE SIDE OF THE TOWER IS RUSTED AND GONE. THE PASSENGER SIDE STILL LOOKS GOOD. I HAVE GONE TO SEVERAL SHOPS BUT NO ONE CAN HELP ME. THE VANS 3.3L ENGINE AND TRANS ARE STILL IN GOOD SHAPE SO I NEED TO FIND SOMEONE OR SOMETHING TO FIX THIS
NHTSA complaint #10863840 — an unverified report by a vehicle owner.
POWER TRAIN
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
SUSPENSION
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
SERVICE BRAKES
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
VISIBILITY/WIPER
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE ILLUMINATED, BUT NOT WHEN BRAKE PETAL PUSHED,TRANSMISSION LEAKING BY CV AXEL,TURN SIGNALS AND PANELS INSIDE BY DASH NOT ALWAYS OPERATING,ONLY WHEN NEGATIVE TERMINAL IS READJUSTMENT,LIGHTS FLASHING AS IF PANIC MODE WAS ACTIVATED WHEN CAR IS NOT ON,RATTLING. SOUND FROM FRONT OF VAN POSSIBLE CV AXEL OR SUSPENSION.
NHTSA complaint #10816372 — an unverified report by a vehicle owner.
STEERING
I WAS IN MY WAY TO WORK WHEN IT WAS RAINING EVER TIME IT RAINS THE BELTS COMES OFF THIS IS VERY DANGEROUS. I HAD NO POWER STEERING AT ALL WHEN THIS HAPPEN WITH MUSCLE I MANAGED TO PULL OVER ONTO THE SHOULDER OF THE ROAD. ONCE WATER HITS THE TENSION WHEEL BELT IT KNOCKS IT OFF WHICH MAKES IT SLIDE OFF EVERY TIME.
NHTSA complaint #10760181 — an unverified report by a vehicle owner.
SUSPENSION
I WAS IN MY WAY TO WORK WHEN IT WAS RAINING EVER TIME IT RAINS THE BELTS COMES OFF THIS IS VERY DANGEROUS. I HAD NO POWER STEERING AT ALL WHEN THIS HAPPEN WITH MUSCLE I MANAGED TO PULL OVER ONTO THE SHOULDER OF THE ROAD. ONCE WATER HITS THE TENSION WHEEL BELT IT KNOCKS IT OFF WHICH MAKES IT SLIDE OFF EVERY TIME.
NHTSA complaint #10760181 — an unverified report by a vehicle owner.
EQUIPMENT ADAPTIVE/MOBILITY
I WAS IN MY WAY TO WORK WHEN IT WAS RAINING EVER TIME IT RAINS THE BELTS COMES OFF THIS IS VERY DANGEROUS. I HAD NO POWER STEERING AT ALL WHEN THIS HAPPEN WITH MUSCLE I MANAGED TO PULL OVER ONTO THE SHOULDER OF THE ROAD. ONCE WATER HITS THE TENSION WHEEL BELT IT KNOCKS IT OFF WHICH MAKES IT SLIDE OFF EVERY TIME.
NHTSA complaint #10760181 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
WHEN I TURN ON MY CAR AFTER 3 TO 5 SECOND IT WOULD TURN OFF AND WHEN I AM DRIVING WHEN IT REACHES ABOUT 15 TO 25 THE CHECK ENGINE LIGHT WILL TURN ON AND CAR TURNS OFF AND STEERING WHEEL DOS NOT WORK AND THE BRAKES DOS NOT WORK, BUT THE ELECTRICITY IS STILL WORKS , THE STEREO WOULD STILL BE ON.
NHTSA complaint #10525858 — an unverified report by a vehicle owner.
STRUCTURE:BODY
THE REAR DOOR WAS OPEN. I HEARD A LOUD NOISE AND I FOUND OUT THE PASSENGER SIDE BOLT BAD BROKEN ON THE LIFT SUPPORT. THE DOOR DID NOT FALL. I AM HAVING A VERY DIFFICULT TIME RAISING THE REAR DOOR WAIT ONE SUPPORT.
NHTSA complaint #10505077 — an unverified report by a vehicle owner.
STEERING
SINCE PURCHASING THIS VAN USED LAST YEAR 2011, MY VAN HAS A HIGH PITCHED SQUEALING NOISE. DEALERSHIP (3RD PARTY) STATED IT WAS ONLY A WET BELT AND WOULD STOP ONCE THE BELT DRIED. THIS NOISE NEVER STOPPED. MY TEEN DRIVER WAS ALONE WHEN THE BELT SNAPPED CAUSING HER TO LOOSE CONTROL OF THE STEERING. SEEING OTHER POST OF SIMILAR OR WORSE CASE SCENARIOS I AM LOOKING INTO FURTHER ACTION. NEITHER THE MECHANIC AT THE DEALERSHIP OR ANY OTHER MECHANIC EVER STATED TO ME THAT THIS ISSUE IS COMMON IN THIS VEHICLE.
NHTSA complaint #10472450 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
SO FAR THIS VEHICLE HAS BEEN A LEMON. I HAVE REPLACED EVERYTHING ON IT, FROM FUEL PUMP, SENSORS, STEERING COLUMN, BELT TENSIONER AND PULLEY, ALTERNATOR, WIPER SWITCH THAT SEEMS TO HAVE A MIND OF ITS OWN EVEN THO I REPLACED A NEW SWITCH. NOW MORE ELECTRICAL PROBLEMS. THE INSTRUMENT CLUSTER IS NOW MESSED UP. ABS LIGHT AND CHECK ENGINE LIGHT KEEP COMING ON ALL MY GAUGES GO FLAT. LIGHTS GO DIM. THEN SUDDENLY LIGHTS WILL FLASH AND THEY WILL ALL COME BACK ON. THEN GO OFF AGAIN. NOW, NOT ONLY DO THEY GO FLAT BUT NOW I HAVE A SHIFTING PROBLEM. THE VEHICLE WILL NOT SHIFT. IT SEEMS TO BE STUCK IN 2ND GEAR. I REPLACED THE WHOLE BRAKING SYSTEM. EGR VALVE, CAM SENSOR, CRUISE CONTROL, THE BODY. THE GAS PEDAL USE TO ACCELERATE ON ITS OWN. THAT WAS A LITTLE SCARY GOIN DOWN THE ROAD NOT KNOWING WHEN IT WAS GONNA DO THAT. EVERYONE WHO RIDES WITH ME KEEPS JOKING AS IF THE VEHICLE IS HAUNTED. LIGHTS GO WEAK, I'VE REPLACED ALL THE BULBS CLEANED THE HEADLIGHTS. NOTHING SEEMS TO WORK RIGHT ON THIS VEHICLE. I'VE ALREADY INVESTED THOUSANDS. WAY MORE THEN ITS WORTH. I'VE HAD PROBLEMS WHERE THE VEHICLE JUST REFUSES TO START. SOMETIMES NOT A PROBLEM. THEN USUALLY IN THE COLD IT WONT TURN OVER AT ALL. I HAVE REPLACED THE BATTERY NUMEROUS TIMES CHECKED FOR CODES. AIRBAG LIGHT WOULD COME ON. TRANSMISSION HESITATES. SOMETIMES VEHICLE SHUDDERS ACTS LIKE ITS GONNA QUIT.VEHICLE JUST HAS ON GOING PROBLEMS.
NHTSA complaint #10460401 — an unverified report by a vehicle owner.
STEERING
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM .
NHTSA complaint #10448357 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM .
NHTSA complaint #10448357 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM .
NHTSA complaint #10448357 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 1997 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THE ENTIRE INSTRUMENT PANEL INTERMITTENTLY FAILED AND ALL OF THE GAUGES DROPPED TO 0. THE VEHICLE ALSO INTERMITTENTLY STALLED. THE FAILURE OCCURRED WHILE AT A STOP SIGN AND WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS ADVISED TO REPLACE THE INSTRUMENT CLUSTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 162,000 AND THE CURRENT MILEAGE WAS 164,000.
NHTSA complaint #10399769 — an unverified report by a vehicle owner.