The contact owned a 2017 Ram Promaster 3500. The contact stated that an employee parked the vehicle in front of an apartment complex, went inside the building to finish working; when the employee returned outside the building, the vehicle was on fire. No warning lights illuminated prior to the fire. The employee saw smoke and flames coming from the engine compartment. The Fire Department was contacted, arrived on scene, and extinguished the fire. No injuries were sustained. A Police report was not filed. The vehicle was not repaired. The vehicle was destroyed. The vehicle was towed to an undisclosed location. The manufacturer was not notified of the failure. The failure mileage was 109,000.
NHTSA complaint #11750400 — an unverified report by a vehicle owner.
The contact owns a 2018 RAM 3500. The contact stated while attempting to start the vehicle, the contact noticed an abnormal cracking sound and smoke coming from the engine compartment. The contact inspected and used a fire extinguisher to slow the smoke and electrical sparks down. The contact did not notice any fire. The fire department arrived and disconnected the electrical cables to prevent further damage. The contact stated that the vehicle was inoperable. In addition, the contact stated that the failure occurred while the contact was traveling on vacation. The vehicle was towed to the dealer. The contact was informed that the failure was not diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The vehicle was later towed to an RV service center. The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.
NHTSA complaint #11748890 — an unverified report by a vehicle owner.
The contact owns a 2023 Ram 3500. The contact stated that while driving or while the vehicle was parked, the air bag warning light was intermittently illuminated. Additionally, the check engine warning light was illuminated, and the seat belt warning light was intermittently illuminated while the seat belt was securely buckled. The messages "Service ESC” and “Service Trailer Brake System” were displayed on the instrument panel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 65,000.
NHTSA complaint #11746488 — an unverified report by a vehicle owner.
The contact owns a 2021 Ram 3500 . The contact received notification of NHTSA Campaign Numbers: 25V720000 (Engine and Engine Cooling) and 25V552000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available and were on backordered. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
NHTSA complaint #11741292 — an unverified report by a vehicle owner.
The contact owns a 2016 RAM 3500. The contact stated that while her husband was driving on several occasions at various speeds, the vehicle lost power and did not accelerate as intended. The vehicle was not diagnosed or repaired. The contact stated that her husband hooked the vehicle up to a handheld diagnostic machine where codes: P003A, P006a, P0046 populated. The manufacturer was notified of the failure. The failure mileage was approximately 74,500.
NHTSA complaint #11736634 — an unverified report by a vehicle owner.
The contact owns a 2022 Ram 3500. The contact stated that while driving at an undisclosed speed, the engine made abnormal knocking and ticking sounds. The knocking and ticking sounds became louder while accelerating. There was no warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the piston had ingested the grid heater nut. The mechanic replaced the piston, cylinder head assembly, gaskets, rod, gasket intake, Hamilton flat tappet conversion kit, and XDP grid heater. The manufacturer was made aware of the failure. The failure mileage was 88,745.
NHTSA complaint #11731385 — an unverified report by a vehicle owner.
The contact owns a 2021 Ram 3500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11727064 — an unverified report by a vehicle owner.
The contact owned a 2019 Dodge Ram 3500 towing an empty container. The contact stated that while the vehicle was being driven uphill at unknown speeds, it unexpectedly caught fire. No warning lights illuminated. There were no reported injuries, air bag deployment, or police report. The fire department was on the scene, extinguished the fire, and provided a fire report. The fire chief was unable to determine the cause of the fire due to the extensive damage. The vehicle was towed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 150,000. The vehicle was deemed a total loss by the insurance company.
NHTSA complaint #11726482 — an unverified report by a vehicle owner.
### **NHTSA Complaint Statement of Facts** **RE: Recall Y43 (NHTSA Campaign 22V-406) – Failure of Recall Remedy** **Summary:** The manufacturer (Stellantis/FCA) is refusing to provide a complete and effective remedy for **Recall Y43**. My 2022 Ram 3500 was manufactured without the **Particulate Matter (PM) Sensor**, a defect officially acknowledged in Recall Y43. This factory omission has caused terminal blockage of the **Diesel Particulate Filter (DPF)**—a specific consequential failure documented in the manufacturer's own recall filing. **Technical Argument:** 1. **Causal Link:** The official Y43 recall notice states: *"The PM sensor... may not have been installed... This could increase vehicle emissions and **block the diesel particulate filter**."* My vehicle currently suffers from the exact "blocked DPF" condition described. 2. **Ineffective Remedy:** Stellantis has offered to install the missing sensor (the Y43 part) but refuses to replace the ruined DPF. Installing a sensor on a filter already terminally blocked due to the sensor's absence is not an "effective remedy" under the **National Traffic and Motor Vehicle Safety Act**. 3. **Warranty Admission:** Per **TSB 09-014-22 (X97)**, the manufacturer has issued a 1-year unlimited mile warranty extension for the DPF specifically for vehicles affected by Y43. Refusing to replace a filter that failed *before* the recall was performed is an attempt to circumvent this warranty obligation. **Safety Risk:** The vehicle is currently in "Limp Mode" with a "Filter Full - Power Reduced" message. This creates an unreasonable safety risk of **stalling or loss of power** while operating on public highways, a condition explicitly mentioned in the Y43 safety report as increasing the risk of an accident. I am seeking an order for the manufacturer to replace the DPF as part of the Y43 recall remedy at no cost to the consumer. The manufacturer’s Case Manager has denied the claim and refused further communication
NHTSA complaint #11726519 — an unverified report by a vehicle owner.
The contact owns a 2019 Ram 3500. The contact stated that while driving at an undisclosed speed, the engine made an abnormal rattling sound. The vehicle was towed to an independent mechanic; however, the vehicle was not yet diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000.
NHTSA complaint #11724554 — an unverified report by a vehicle owner.
Driving along normal and the engine started knocking, then the noise went away and about three miles later the engine started knocking extremely loud as I attempted to get off the road safely the engine locked up, I opened th hood and seen the engine connecting rods broke out of the engine and it now has holes in the block, and needs a total replacememt
NHTSA complaint #11724799 — an unverified report by a vehicle owner.
The contact owns a 2025 Ram 3500. The contact stated that while driving approximately 60 MPH, several unknown warning lights illuminated, and the vehicle stalled. The vehicle was towed to a dealer where it was diagnosed, and determined that several repairs were needed, and there was an issue with the battery. The dealer replaced two batteries, but the failure persisted. The vehicle was taken back to the same dealer, but the cause of the failure was not duplicated. On another occasion, while driving approximately 50 MPH and hauling a trailer, there were several unknown warning lights illuminated, and the contact heard a loud banging coming from the engine compartment before the vehicle stalled. The vehicle was towed to a different dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.
NHTSA complaint #11724654 — an unverified report by a vehicle owner.
The contact owns a 2019 Ram 3500. The contact stated that while driving approximately 55 MPH, a warning light for the exhaust system illuminated, and the vehicle stalled. The vehicle was pulled over to the side of the road, and the vehicle failed to restart. The vehicle was towed to an independent mechanic, where it was diagnosed, but the vehicle was not repaired. An unknown dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was notified of the failure and confirmed that an unknown recall repair was previously completed on the vehicle. Upon investigating the failure online, the contact related the failure to NHTSA Action Number: EA23001(Fuel System, Diesel). The failure mileage was approximately 214,000. The VIN was not available.
NHTSA complaint #11723090 — an unverified report by a vehicle owner.
I own this truck and have had issues with the exhaust regeneration process for about 6 months. I have taken it to the dealer 3 times and they have done diagnostics and replaced the diesel particulate filter, but the issue continues to happen. They have now told me that the system is not reparable and they don't have support from RAM manufacturer to troubleshoot and repair this issue. They have multiple customers with the same issue with the diesel exhaust system not operating properly, hampering the engine performance, damaging the engine and exhaust system, polluting from the exhaust discharge. This is a widely known issue with the 2022 Ram 3500 from other owners, yet RAM refuses to properly address the issue. They advertise their trucks with certain horsepower and output specs, which aren't accurate due to their faulty exhaust systems. Consumers are now completely removing the factoring exhaust systems because they damage the engines and cost thousands of dollars to attempt to repair, which many times never work. This needs to be addressed with RAM and recalls put in place to address the failures with their exhaust systems. My truck has 28,000 miles on it, 3 years old, and is not operable. The dealer has had 3 attempts to repair this and is now turning me away. Please help! Thank you
NHTSA complaint #11722490 — an unverified report by a vehicle owner.
The contact owns a 2022 Ram 3500. The contact stated that while driving approximately 10-15 MPH, there was an abnormal rattling sound coming from the vehicle. The engine warning light was illuminated. The local dealer was contacted, and it was determined that the grid heater bolt had melted and fallen into the engine. The vehicle was repaired after two months due to the piston being on backorder. The manufacturer was contacted, but no additional assistance was provided. The approximate failure mileage was 35,000. The VIN was not available.
NHTSA complaint #11721728 — an unverified report by a vehicle owner.
The contact owns a 2020 Ram 3500. The contact stated while driving approximately 50 MPH, the engine overheated. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that the cooling fan module had failed, and the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 97,000.
NHTSA complaint #11720681 — an unverified report by a vehicle owner.
The contact owns a 2020 Ram 3500. The contact stated while driving approximately 50 MPH, the engine overheated. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that the cooling fan module had failed, and the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 97,000.
NHTSA complaint #11720681 — an unverified report by a vehicle owner.