Owners have filed 443 complaints
about the 2018 Toyota RAV4 with NHTSA between 2017 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 6 of 30 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 55
Against the median year of the Toyota RAV4. 50 means typical for this
model; 100 means roughly double.
Severity — 100
28% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
75% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
830.8%
Warnings
415.4%
Adaptive Cruise Control
311.5%
Sun/Moon Roof Assembly
311.5%
12V/24V/48V Battery
311.5%
Automatic Emergency Braking
27.7%
Blind Spot Detection
27.7%
Key/Sender
13.8%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
2613.4%
1,000 – 9,999 miles
6433.0%
10,000 – 24,999 miles
4322.2%
25,000 – 49,999 miles
2914.9%
50,000 – 74,999 miles
199.8%
75,000 – 99,999 miles
52.6%
100,000 – 149,999 miles
63.1%
150,000+ miles
21.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2017peak 15Aug 2026
NHTSA investigations into the 2018 Toyota RAV4
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
PE21005Opened 25 Feb 2021Closed 12 Aug 2024ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Battery Hold Down Bracket Thermal Events
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to cont...
Recalls on the 2018 Toyota RAV4
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2023589249,416 units in Canada
Electrical
Issue: On certain vehicles, the battery hold-down assembly may not properly secure certain 12 V aftermarket batteries. As a result, the battery could shift positions and cause the positive battery post to contact the hold down bracket. If this happens, there could be a short circuit. Safety Risk: A short circuit could create the risk of a fire. Corrective Actions: Toyota will notify owners by mail and advise you to take your vehicle to a dealership to replace the battery clamp sub-assembly, battery tray, and positive terminal cover.
Recall 202172355,683 units in Canada
Electrical
Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.
Recall 20211575,315 units in Canada
Tires
Issue: Certain vehicles were built with tires that may have been cured too long. As a result, the sidewall could crack or the tread and belts could separate. This could lead to a sudden loss of air pressure and could cause a tire failure. Note: This recall only affects certain Continental tires, with specific date codes and mold numbers. Safety Risk: A tire failure could cause a loss of control and increase the risk of a crash. Corrective Actions: Toyota will notify the owners by mail and instruct them to take the vehicle to a dealer to inspect and replace the tires, if necessary.
Recall 2019428327,373 units in Canada
Accessories
Issue: On certain vehicles, the hook and loop material used to attach the carpet to its underpadding may not be flame resistant. As a result, when it is tested alone, the loop fasteners do not meet the requirements of Canadian regulations. Safety Risk: As the carpet is always assembled, and the loop fasteners are very small, this problem does not create a safety risk. Corrective Action: This is not a recall. The company has made production changes to ensure that all new vehicles meet the requirements of Canadian regulations.
Recall 20194205,327 units in Canada
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Reports where the owner recorded a crash, a fire, an injury or a death.
Los Angeles, CACrash
AIR BAGS
We were part of a 4 car collision on the freeway. A Ford Expedition that was slammed into then slammed into our RAV. The airbags never deployed and an error code came up saying fail for airbags.
NHTSA complaint #11745520 — an unverified report by a vehicle owner.
Northwood, NHFire
ELECTRICAL SYSTEM
On October 27, 2025, I was housesitting and watching a friends' son and dropped him off at school. I returned to their house, shut off the car, went into the house, started cleaning home in preparation of returning to my home. I was in downstairs master suite on opposite end of home when I heard a car horn. I went to the door, looked out and saw fire emitting from under the driver’s side wheel well, front of engine, from under the engine hood and half way up the windshield of the RAV4. I called [XXX] and informed the dispatcher that my car was on fire. The [XXX] fire department responded and extinguished the vehicle. I called my insurance company and also reported the incident to Toyota BEC, they assigned the incident Liability Case# XXX. I had also received 2 recall notifications from Toyota (NHTSA# 23V734). The car had been serviced by Grappone Toyota (now known as McGovern Toytota) in [XXX] on August 14, 2025 and the recall was documented as fixed on that date. The vehicle was a total loss and towed to a Coparts Salvage Yard in Candia NH. An inspection was performed by an inspector assigned by Toyota. I later received a letter from Toyota stating that the cause of the fire could not be determined and Toyota assumes no reponsibility whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11729761 — an unverified report by a vehicle owner.
Virginia Beach, VACrash2 injured
AIR BAGS
3/4/2026 5:10 pm Vehicle (2018 RAV4) was sitting in backed up traffic waiting to exist highway and was hit from behind by a sedan travelling at 65+ mph, pushed into a pickup truck in front, then deflected left into a guardrail. SO, three separate impacts with extensive damage to the entire rear of the car, the front end, and right front quarter. Two occupants in the car, driver and front passenger, no airbags deployed. Driver's head contacted the steerring wheel (back eye, cut lip, swelling on forehead and around eye, headache), and legs and arms of driver and passenger contacted other portions of the interior of the vehicle and experienced severe whiplash, but no broken bones per initial ER xrays and scans. Vehicle towed and is currently available for inspection.
NHTSA complaint #11722494 — an unverified report by a vehicle owner.
Baytown, TXFire
UNKNOWN OR OTHER
I had just gotten off my vehicle, we were at a shopping center specifically Marshall’s, the employee announced a blue Toyota, I went outside and my car was in flames, the Fire Department said it was an electrical fire. I had never received a letter of a recall let alone Toyota calling me to tell my car was defective. Not only until after my vehicle was damaged I received a call from them which made it suspicious.
NHTSA complaint #11695777 — an unverified report by a vehicle owner.
at 134,000 milesAustin, TXCrash1 injured
POWER TRAIN
The contact owns a 2018 Toyota Rav4. The contact stated that upon entering her carport in an attempt to park(P), the vehicle surged forward without warning. The vehicle blew through the carport's back wall and crashed into her neighbor's fence before coming to an independent stop. The air bags did not deploy upon impact. The contact did not seek medical attention but did sustain soreness in her neck, shoulders, and back. The carport's back wall, a bicycle, the neighbor's fence, and the hammock were all destroyed as a result of the accident. A police report was filed. The dealer was notified of the failure and immediately referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was filed. The manufacturer informed the contact that an engineer could be sent to a nearby dealer or independent mechanic to perform an investigation into the defect. The vehicle had yet to be serviced or diagnosed for the failure. The vehicle was not repaired. The failure mileage was approximately 134,000
NHTSA complaint #11685349 — an unverified report by a vehicle owner.
at 134,000 milesAustin, TXCrash1 injured
ELECTRICAL SYSTEM
The contact owns a 2018 Toyota Rav4. The contact stated that upon entering her carport in an attempt to park(P), the vehicle surged forward without warning. The vehicle blew through the carport's back wall and crashed into her neighbor's fence before coming to an independent stop. The air bags did not deploy upon impact. The contact did not seek medical attention but did sustain soreness in her neck, shoulders, and back. The carport's back wall, a bicycle, the neighbor's fence, and the hammock were all destroyed as a result of the accident. A police report was filed. The dealer was notified of the failure and immediately referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was filed. The manufacturer informed the contact that an engineer could be sent to a nearby dealer or independent mechanic to perform an investigation into the defect. The vehicle had yet to be serviced or diagnosed for the failure. The vehicle was not repaired. The failure mileage was approximately 134,000
NHTSA complaint #11685349 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Santa Maria, CA
STEERING
Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria and was told that I needed to pay for the sensors that had failed. They told me that I was responsible and I do not believe I am when AAA had just replaced my battery and only after that did the sensors have an issue. I do not feel safe driving my car now because all the sensors aren’t working anymore.
NHTSA complaint #11754574 — an unverified report by a vehicle owner.
Santa Maria, CA
ELECTRICAL SYSTEM
Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria and was told that I needed to pay for the sensors that had failed. They told me that I was responsible and I do not believe I am when AAA had just replaced my battery and only after that did the sensors have an issue. I do not feel safe driving my car now because all the sensors aren’t working anymore.
NHTSA complaint #11754574 — an unverified report by a vehicle owner.
Santa Maria, CA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria and was told that I needed to pay for the sensors that had failed. They told me that I was responsible and I do not believe I am when AAA had just replaced my battery and only after that did the sensors have an issue. I do not feel safe driving my car now because all the sensors aren’t working anymore.
NHTSA complaint #11754574 — an unverified report by a vehicle owner.
at 40,000 milesLas Vegas, NV
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The contact owns a 2018 Toyota Rav4. The contact stated that while in reverse(R), the rear-view camera was black and failed to operate as intended. The vehicle was taken to a dealer where it was diagnosed and determined that the camera was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 40,000.
NHTSA complaint #11753295 — an unverified report by a vehicle owner.
Minneapolis, MN
UNKNOWN OR OTHER
The hands free feature over the cars microphone/stereo is unusable; leaving vehicle owners frustrated, and more likely to operate cellphones outside of standard hands free practices. I have been on numerous phone calls where people have told me that they were unable to hardly hear a thing I was saying. To remedy this problem I have 1. Tried speaking up (even yelling) 2. Turning off HVAC systems 3. Positioning my body closer to the microphone 4. Bringing the car to a slow or stop to reduce road noise. 5. Calling myself to see if I can hear myself. 6. Talked with someone who owns the same car (year/model/spec/trim) and they were hardly audible as they called me over their hands free system.
NHTSA complaint #11749459 — an unverified report by a vehicle owner.
Methuen, MA
AIR BAGS
While I am driving my Toyota RAV4, the car will suddenly shut off and I can restart it and keep driving as the month is going on. The incidents are happening more often and now the dashboard is going black. I’ve had a couple of warning signs on the dashboard. I brought the car to Toyota and Pep Boys. Both of them checked the electrical systems and everything looks good according to their testing.
NHTSA complaint #11748370 — an unverified report by a vehicle owner.
Methuen, MA
EXTERIOR LIGHTING
While I am driving my Toyota RAV4, the car will suddenly shut off and I can restart it and keep driving as the month is going on. The incidents are happening more often and now the dashboard is going black. I’ve had a couple of warning signs on the dashboard. I brought the car to Toyota and Pep Boys. Both of them checked the electrical systems and everything looks good according to their testing.
NHTSA complaint #11748370 — an unverified report by a vehicle owner.
Methuen, MA
ELECTRICAL SYSTEM
While I am driving my Toyota RAV4, the car will suddenly shut off and I can restart it and keep driving as the month is going on. The incidents are happening more often and now the dashboard is going black. I’ve had a couple of warning signs on the dashboard. I brought the car to Toyota and Pep Boys. Both of them checked the electrical systems and everything looks good according to their testing.
NHTSA complaint #11748370 — an unverified report by a vehicle owner.
Watauga, TX
STRUCTURE:BODY:HATCHBACK/LIFTGATE
My lift tailgate is malfunctioning. Continued forced opening can cause the hinges to crack and messes with the alignment and closing of the tail gate making it a safety issue.
NHTSA complaint #11746910 — an unverified report by a vehicle owner.
Los Angeles, CACrash
AIR BAGS
We were part of a 4 car collision on the freeway. A Ford Expedition that was slammed into then slammed into our RAV. The airbags never deployed and an error code came up saying fail for airbags.
NHTSA complaint #11745520 — an unverified report by a vehicle owner.
Hoboken, NJ
STRUCTURE:BODY
Severe, chronic rainwater intrusion through the vehicle's front cowl and body seams, resulting in catastrophic flooding of the passenger-side cabin floorboards. This issue occurs even when all sunroof drains are completely clear and functional. Toyota has issued Technical Service Bulletin 0055-24 acknowledging body seam and cowl leaks for this vehicle type. The passenger-side floorboard houses critical electrical wire harnesses and sits adjacent to the Supplemental Restraint System (SRS/Airbag) control module. Chronic standing water on the floorboard presents an immediate risk of electrical short-circuits, potentially causing sudden vehicle stalling, electrical component fires, or the uncommanded deployment/failure of the vehicle's airbag safety systems. Furthermore, the thick foam insulation beneath the carpet remains saturated, creating an immediate, toxic mold hazard within an enclosed passenger cabin, severely impacting occupant health and air quality. The manufacturer and dealership have left the vehicle unrepaired for over 30 days, refusing to remediate this safety hazard.
NHTSA complaint #11740651 — an unverified report by a vehicle owner.
at 54,968 milesWashington, DC
ELECTRICAL SYSTEM
The contact owned a 2018 Toyota RAV4. The contact stated that the vehicle experienced a defect with the key fob and the door locks for the passenger doors. When starting the vehicle, the brake locking mechanism could not detect the key, and a message was displayed indicating that the key was not found. The contact stated that he had to open and close the door for the vehicle to engage and recognize the key. Additionally, the vehicle failed to lock automatically, which forced the contact to lock both the driver and passenger sides manually. Early corrections were made in an attempt to resolve these issues, but the problems persisted. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 54,968.
NHTSA complaint #11740582 — an unverified report by a vehicle owner.
Hoboken, NJ
ELECTRICAL SYSTEM
Severe, chronic rainwater intrusion through the vehicle's front cowl and body seams, resulting in catastrophic flooding of the passenger-side cabin floorboards. This issue occurs even when all sunroof drains are completely clear and functional. Toyota has issued Technical Service Bulletin 0055-24 acknowledging body seam and cowl leaks for this vehicle type. The passenger-side floorboard houses critical electrical wire harnesses and sits adjacent to the Supplemental Restraint System (SRS/Airbag) control module. Chronic standing water on the floorboard presents an immediate risk of electrical short-circuits, potentially causing sudden vehicle stalling, electrical component fires, or the uncommanded deployment/failure of the vehicle's airbag safety systems. Furthermore, the thick foam insulation beneath the carpet remains saturated, creating an immediate, toxic mold hazard within an enclosed passenger cabin, severely impacting occupant health and air quality. The manufacturer and dealership have left the vehicle unrepaired for over 30 days, refusing to remediate this safety hazard.
NHTSA complaint #11740651 — an unverified report by a vehicle owner.
Central Islip, NY
POWER TRAIN
Malfunction: Mechanical failure of the Torque Converter Clutch. The vehicle exhibits a persistent transmission shudder during acceleration between 25–50 mph. Warning Signs: None. There were no dashboard warning lights or error messages prior to or during the failure. The only indicator was the physical shuddering of the vehicle. Safety Risk: The malfunction causes unpredictable hesitation when merging or changing lanes, creating a dangerous speed differential and risk of rear-end collision. Documentation: Comprehensive maintenance records are available to prove the vehicle was serviced according to the manufacturer’s schedule at a third-party facility.
NHTSA complaint #11732003 — an unverified report by a vehicle owner.
Woodland, WA
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
See attached document for complaint.
NHTSA complaint #11731566 — an unverified report by a vehicle owner.
Woodland, WA
ELECTRICAL SYSTEM
See attached document for complaint.
NHTSA complaint #11731566 — an unverified report by a vehicle owner.
Northwood, NHFire
ELECTRICAL SYSTEM
On October 27, 2025, I was housesitting and watching a friends' son and dropped him off at school. I returned to their house, shut off the car, went into the house, started cleaning home in preparation of returning to my home. I was in downstairs master suite on opposite end of home when I heard a car horn. I went to the door, looked out and saw fire emitting from under the driver’s side wheel well, front of engine, from under the engine hood and half way up the windshield of the RAV4. I called [XXX] and informed the dispatcher that my car was on fire. The [XXX] fire department responded and extinguished the vehicle. I called my insurance company and also reported the incident to Toyota BEC, they assigned the incident Liability Case# XXX. I had also received 2 recall notifications from Toyota (NHTSA# 23V734). The car had been serviced by Grappone Toyota (now known as McGovern Toytota) in [XXX] on August 14, 2025 and the recall was documented as fixed on that date. The vehicle was a total loss and towed to a Coparts Salvage Yard in Candia NH. An inspection was performed by an inspector assigned by Toyota. I later received a letter from Toyota stating that the cause of the fire could not be determined and Toyota assumes no reponsibility whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11729761 — an unverified report by a vehicle owner.
Rochester, NH
UNKNOWN OR OTHER
Iam having transmission issues. I have been to 3 different Mechanic shops, 2 being transmission specialist. Going to a Toyota dealership on 3/26/26 to confirm. Was told I need a whole new transmission, My rav4 is a 2018 with only 115k for miles No engine light on or have any codes. I have spent a bit of money trying to address this issue. and was told that this particular year has a lot of transmission issues and have over 100 on back order. why is this not a recall?
NHTSA complaint #11726041 — an unverified report by a vehicle owner.
Ankeny, IA
STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
The automatic lift gate started failing and became misaligned causing the back lift gate to be unable to be closed and damaged my passenger rear tail light as well due to the malalignment issue resulting in having to drive without the back gate fully shut until I can afford the 2k cost quoted to fix it. My research shows this is a very common issue with the rav4's in this production cycle
NHTSA complaint #11725079 — an unverified report by a vehicle owner.
Virginia Beach, VACrash2 injured
AIR BAGS
3/4/2026 5:10 pm Vehicle (2018 RAV4) was sitting in backed up traffic waiting to exist highway and was hit from behind by a sedan travelling at 65+ mph, pushed into a pickup truck in front, then deflected left into a guardrail. SO, three separate impacts with extensive damage to the entire rear of the car, the front end, and right front quarter. Two occupants in the car, driver and front passenger, no airbags deployed. Driver's head contacted the steerring wheel (back eye, cut lip, swelling on forehead and around eye, headache), and legs and arms of driver and passenger contacted other portions of the interior of the vehicle and experienced severe whiplash, but no broken bones per initial ER xrays and scans. Vehicle towed and is currently available for inspection.
NHTSA complaint #11722494 — an unverified report by a vehicle owner.
Lincoln, NE
EXTERIOR LIGHTING
Both headlights and taillights are stained on the inside of the lens with a white residue. My headlights are very streaky and it makes it difficult to see out of. Not the outside of the headlight, because when i rub my hands along the outsides, i do not feel any grabbing, scratches, film, etc.
NHTSA complaint #11722314 — an unverified report by a vehicle owner.
Bismarck, ND
ELECTRICAL SYSTEM
The contact owned a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); and requested to be removed from the recall distribution list because she no longer owns the vehicle. The dealer and the manufacturer were not contacted.
NHTSA complaint #11709138 — an unverified report by a vehicle owner.
Suffern, NY
STEERING
While picking up my son from school, my 2018 Toyota RAV4 Hybrid suddenly experienced a complete steering failure. The steering wheel locked without warning and became impossible to move, making the vehicle inoperable and creating an immediate safety hazard. My son and I were stranded for over 7 hours in a public area. AAA was dispatched twice, but they were unable to resolve the issue. The vehicle ultimately had to be towed to a Toyota dealership. Toyota dealership diagnosed the car with a failed steering lock ECU, a critical safety component that should not malfunction under normal conditions. I was quoted over $2,000 for the repair. This issue aligns with multiple known recalls and technical service bulletins related to steering and electronic control failures in RAV4 Hybrid models, suggesting a potential manufacturer defect. This sudden steering failure placed me and my child at significant risk. There were no warning lights, no prior steering issues, and no indicators of malfunction before the event occurred. I am submitting this report because a steering lock ECU failure can lead to sudden loss of steering control, which poses a serious danger to vehicle occupants and others on the road.
NHTSA complaint #11702009 — an unverified report by a vehicle owner.
Suffern, NY
ELECTRICAL SYSTEM
While picking up my son from school, my 2018 Toyota RAV4 Hybrid suddenly experienced a complete steering failure. The steering wheel locked without warning and became impossible to move, making the vehicle inoperable and creating an immediate safety hazard. My son and I were stranded for over 7 hours in a public area. AAA was dispatched twice, but they were unable to resolve the issue. The vehicle ultimately had to be towed to a Toyota dealership. Toyota dealership diagnosed the car with a failed steering lock ECU, a critical safety component that should not malfunction under normal conditions. I was quoted over $2,000 for the repair. This issue aligns with multiple known recalls and technical service bulletins related to steering and electronic control failures in RAV4 Hybrid models, suggesting a potential manufacturer defect. This sudden steering failure placed me and my child at significant risk. There were no warning lights, no prior steering issues, and no indicators of malfunction before the event occurred. I am submitting this report because a steering lock ECU failure can lead to sudden loss of steering control, which poses a serious danger to vehicle occupants and others on the road.
NHTSA complaint #11702009 — an unverified report by a vehicle owner.
Kirtland, NM
POWER TRAIN
XXX XXX XXX XXX XXX 11/13/2025 National Highway Traffic Safety Administration Office of Defects Investigation 1200 New Jersey Avenue SE Washington, DC 20590 Toyota Motor Sales, U.S.A., Inc. 19001 South Western Avenue Torrance, CA 90501 Subject: Complaint Regarding Torque Converter Shudder – 2018 Toyota RAV4 AWD To Whom It May Concern, I am submitting this complaint regarding a serious transmission defect in my 2018 Toyota RAV4 AWD, specifically a torque converter shudder that has been documented by Toyota technicians. The vehicle exhibits pronounced shuddering between 25–50 mph under light throttle, consistent with the torque converter failures previously acknowledged by Toyota in earlier RAV4 models (2013–2015). Toyota has extended warranty coverage for torque converter replacement in those earlier models, yet my 2018 RAV4—despite showing identical symptoms—has been excluded. The dealership has quoted me $9,000 for a full transmission replacement, even though the issue is well-documented and appears to be systemic across multiple model years. This situation raises serious concerns: - Toyota is aware of the defect but has limited coverage to select VIN ranges. - The cost of repair is excessive and disproportionate to the defect. - Consumers are left without recourse despite clear precedent for warranty extension. I respectfully request: 1. That NHTSA investigate whether the torque converter shudder in 2016–2018 RAV4 models constitutes a broader safety defect. 2. That Toyota extend its warranty program to include affected 2018 RAV4 vehicles. 3. That Toyota provide reimbursement or coverage for necessary repairs to restore safe vehicle operation. I am prepared to provide service records, dealership documentation, and correspondence confirming Toyota’s acknowledgment of the defect. Please advise on next steps and ensure this issue receives the attention it deserve INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11699086 — an unverified report by a vehicle owner.