Owners have filed 219 complaints
about the 2022 Toyota RAV4 with NHTSA between 2022 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 20 of 30 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 27
Against the median year of the Toyota RAV4. 50 means typical for this
model; 100 means roughly double.
Severity — 97
18.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 81
48% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
1336.1%
Warnings
719.4%
Automatic Emergency Braking
513.9%
Warning
38.3%
Electronic Lock/Latch Actuator
25.6%
Assist
25.6%
Adaptive Cruise Control
25.6%
Sidewall
25.6%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
14.8%
1,000 – 9,999 miles
419.0%
10,000 – 24,999 miles
419.0%
25,000 – 49,999 miles
628.6%
50,000 – 74,999 miles
628.6%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Frontal crash test
Side barrier crash test
Side pole crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2022 Toyota RAV4 SUV AWD
15.5% risk
2022 Toyota RAV4 SUV FWD
15.9% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2022peak 10Aug 2026
Complaints that involved harm
Reports where the owner recorded a crash, a fire, an injury or a death.
at 62,000 milesDedham, MECrash
VEHICLE SPEED CONTROL
The contact owns a 2022 Toyota RAV4. The contact stated that while driving through a trench at 5 MPH, the brake pedal was depressed to avoid scraping the bottom of the vehicle however, the vehicle unintendedly accelerated and failed to stop. Additionally, the steering wheel failed to turn as needed, and the vehicle crashed into a picnic table and ran over the chairs. The vehicle came to a stop after crashing into a rock. The contact stated that the bumper and doors were damaged and had scratches from the crash. There was no injury sustained. A Police report was not filed. The dealer was contacted and performed an investigation and determined that the accelerator pedal was depressed during the crash and the vehicle was driving 25 MPH; however, the contact stated that the brake pedal was depressed during the crash. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.
NHTSA complaint #11755323 — an unverified report by a vehicle owner.
at 62,000 milesDedham, MECrash
SERVICE BRAKES, HYDRAULIC
The contact owns a 2022 Toyota RAV4. The contact stated that while driving through a trench at 5 MPH, the brake pedal was depressed to avoid scraping the bottom of the vehicle however, the vehicle unintendedly accelerated and failed to stop. Additionally, the steering wheel failed to turn as needed, and the vehicle crashed into a picnic table and ran over the chairs. The vehicle came to a stop after crashing into a rock. The contact stated that the bumper and doors were damaged and had scratches from the crash. There was no injury sustained. A Police report was not filed. The dealer was contacted and performed an investigation and determined that the accelerator pedal was depressed during the crash and the vehicle was driving 25 MPH; however, the contact stated that the brake pedal was depressed during the crash. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.
NHTSA complaint #11755323 — an unverified report by a vehicle owner.
Brownsville, TXCrash2 injured2 killed
ELECTRICAL SYSTEM:ADAS
The contact is an attorney concerned about a crash involving a 2022 Toyota Rav4. The attorney stated that the vehicle had a comma.ai device installed on the vehicle. The attorney stated that while 2 couples were occupying the vehicle and driving at night on an expressway, there was a police vehicle on the side of the road responding to a separate vehicle crash. The driver of the vehicle may have been asleep, along with the front passenger, while relying on the comma.ai device to operate the vehicle. The vehicle failed to engage the brakes in order to avoid crashing into the police vehicle, and as a result, the Toyota Rav4 crashed into the rear of the police vehicle. The vehicle speed was unknown at the time of the crash. The owner of the vehicle rear-ended a Louisiana state trooper. Air bags deployed in the front and on both sides of the vehicle. The vehicle was towed to a tow yard and then to a Progressive Insurance lot. No warning lights were noticed. All occupants were wearing seat belts. The driver of the vehicle sustained concussion injuries, and the front passenger occupant sustained arm and leg injuries. The two rear occupants succumbed to their injuries at the hospital. No other injuries were reported as the police officer was not occupying the vehicle during the impact. The comma.ai device failed to avoid the f vehicle in front. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11728650 — an unverified report by a vehicle owner.
Muskegon, MICrash
AIR BAGS
We were traveling across country from Michigan to Arizona. We were 50 miles outside Tucson, AZ on [XXX]. Traveling 80 mph in a 75 mph zone, in passing lane and felt like car exploded and all airbags deployed and we came to a quick stop. No major injuries to either of us. One vehicle incident, did not collide with anything or hit any debris. It was a clear day, road conditions good, no noises, lights etc. My husband was able to keep from rolling and we came to a stop with many semi's etc flying by, very scary. When we were able to safely get out and call 911, there was significant drivers side front end damage around tire area and inside near axle. Looked like something broke inside car, sheered off bottom of tire. Police arrived and had to push vehicle on to shoulder of road. He assessed scene and thought it had to be a mechanicla failure as there was no other vehicle or debris on site. We did contact our insurance company and subsequently it was totaled. We also have Toyota investigating what the cause was if it was a faulty part or mechanical failure. We have not heard back but did receive the "recording of time of crash". I have a short video of damage but I'm unable to attach it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11722251 — an unverified report by a vehicle owner.
Muskegon, MICrash
WHEELS
We were traveling across country from Michigan to Arizona. We were 50 miles outside Tucson, AZ on [XXX]. Traveling 80 mph in a 75 mph zone, in passing lane and felt like car exploded and all airbags deployed and we came to a quick stop. No major injuries to either of us. One vehicle incident, did not collide with anything or hit any debris. It was a clear day, road conditions good, no noises, lights etc. My husband was able to keep from rolling and we came to a stop with many semi's etc flying by, very scary. When we were able to safely get out and call 911, there was significant drivers side front end damage around tire area and inside near axle. Looked like something broke inside car, sheered off bottom of tire. Police arrived and had to push vehicle on to shoulder of road. He assessed scene and thought it had to be a mechanicla failure as there was no other vehicle or debris on site. We did contact our insurance company and subsequently it was totaled. We also have Toyota investigating what the cause was if it was a faulty part or mechanical failure. We have not heard back but did receive the "recording of time of crash". I have a short video of damage but I'm unable to attach it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11722251 — an unverified report by a vehicle owner.
Muskegon, MICrash
ENGINE
We were traveling across country from Michigan to Arizona. We were 50 miles outside Tucson, AZ on [XXX]. Traveling 80 mph in a 75 mph zone, in passing lane and felt like car exploded and all airbags deployed and we came to a quick stop. No major injuries to either of us. One vehicle incident, did not collide with anything or hit any debris. It was a clear day, road conditions good, no noises, lights etc. My husband was able to keep from rolling and we came to a stop with many semi's etc flying by, very scary. When we were able to safely get out and call 911, there was significant drivers side front end damage around tire area and inside near axle. Looked like something broke inside car, sheered off bottom of tire. Police arrived and had to push vehicle on to shoulder of road. He assessed scene and thought it had to be a mechanicla failure as there was no other vehicle or debris on site. We did contact our insurance company and subsequently it was totaled. We also have Toyota investigating what the cause was if it was a faulty part or mechanical failure. We have not heard back but did receive the "recording of time of crash". I have a short video of damage but I'm unable to attach it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11722251 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 50,000 milesStatesville, NC
STEERING
The contact owns a 2022 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power, and the "Low Steering" message was displayed on the instrument panel. The check engine warning light was illuminated, the vehicle shuddered, and then stalled as the contact pulled into a parking lot. The failure had occurred on several different occasions. The contact attempted to restart the vehicle; however, the vehicle failed to return to normal operation. The vehicle was towed to a dealer where it was diagnosed with an inoperable port fuel injector. The vehicle was repaired; however, the failure persisted. The vehicle was taken to another dealer and was diagnosed with inoperable port fuel injectors. The contact was informed that the port fuel injectors needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
NHTSA complaint #11758310 — an unverified report by a vehicle owner.
Los Angeles, CA
UNKNOWN OR OTHER
The car is Rav4 2022 fuel: gas. Dashboard showing Headlight System malfunction, Pre-Collision System malfunction and RSA System Malfunction. The alarm beep and sign of malfunction keep popping up on dashboard. I took it to Toyota dealership to be inspected and they notified me that "The Front Recognition camera Watchdog/Safety MCU Failure." This front camera is connecting to headlight system, Pre-Collision system and RSA system that causing them to be malfunction while I am driving. With all those system malfunction in the car, I am driving with a huge risk. I am certain that not only I have those problems but some owner of RAV4 2022 or perhaps other year that has the same microcomputer for Front Recognition camera for Safety have the same failure that would trickle down to safety of others on the road. The car is only 4 years old. The Microcomputer in the front camera should have been functioning with no problem, unless the factory didn't calibrate well or install malfunction microcomputer for the car. The dealership estimated the price to change the microcomputer $ 2000 and labor $ 400 something. Toyota should have recall and reimburse this service to customers since these problems are factory problems.
NHTSA complaint #11756791 — an unverified report by a vehicle owner.
at 71,800 milesBoerne, TX
ELECTRICAL SYSTEM
The contact owns a 2022 Toyota Rav4. The contact stated that while driving at an undisclosed speed, there was an abnormal odor outside the vehicle. The contact inspected the vehicle and became aware that there was smoke coming from the battery, and there was battery fluid leaking from the battery. The vehicle was towed to the dealer and was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was being repaired. The contact stated that in May 2026, the vehicle was serviced for electrical issues with the Start/Stop feature, parking brake error message, and the AC display unit was replaced. The contact stated that other electrical issues occurred intermittently. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 71,800.
NHTSA complaint #11756571 — an unverified report by a vehicle owner.
Surprise, AZ
FORWARD COLLISION AVOIDANCE: WARNINGS
Within the 1st year I purchased it new, I would get a warning that the RSA is malfunctioning. It seems to happen when I park in the sun and the windshield is very hot. The warning in my dash prevents me from seeing my other readings; mph, fuel, and I can't use my other safety features; LDA, PCS or cruise control. I've taken it in but then it does a reset and the technicians say there's nothing wrong. The warnings happen every month, weekly. I just got tired of taking it in to hear they don't see anything wrong!
NHTSA complaint #11755543 — an unverified report by a vehicle owner.
Surprise, AZ
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Within the 1st year I purchased it new, I would get a warning that the RSA is malfunctioning. It seems to happen when I park in the sun and the windshield is very hot. The warning in my dash prevents me from seeing my other readings; mph, fuel, and I can't use my other safety features; LDA, PCS or cruise control. I've taken it in but then it does a reset and the technicians say there's nothing wrong. The warnings happen every month, weekly. I just got tired of taking it in to hear they don't see anything wrong!
NHTSA complaint #11755543 — an unverified report by a vehicle owner.
Within the 1st year I purchased it new, I would get a warning that the RSA is malfunctioning. It seems to happen when I park in the sun and the windshield is very hot. The warning in my dash prevents me from seeing my other readings; mph, fuel, and I can't use my other safety features; LDA, PCS or cruise control. I've taken it in but then it does a reset and the technicians say there's nothing wrong. The warnings happen every month, weekly. I just got tired of taking it in to hear they don't see anything wrong!
NHTSA complaint #11755543 — an unverified report by a vehicle owner.
at 62,000 milesDedham, MECrash
VEHICLE SPEED CONTROL
The contact owns a 2022 Toyota RAV4. The contact stated that while driving through a trench at 5 MPH, the brake pedal was depressed to avoid scraping the bottom of the vehicle however, the vehicle unintendedly accelerated and failed to stop. Additionally, the steering wheel failed to turn as needed, and the vehicle crashed into a picnic table and ran over the chairs. The vehicle came to a stop after crashing into a rock. The contact stated that the bumper and doors were damaged and had scratches from the crash. There was no injury sustained. A Police report was not filed. The dealer was contacted and performed an investigation and determined that the accelerator pedal was depressed during the crash and the vehicle was driving 25 MPH; however, the contact stated that the brake pedal was depressed during the crash. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.
NHTSA complaint #11755323 — an unverified report by a vehicle owner.
at 62,000 milesDedham, MECrash
SERVICE BRAKES, HYDRAULIC
The contact owns a 2022 Toyota RAV4. The contact stated that while driving through a trench at 5 MPH, the brake pedal was depressed to avoid scraping the bottom of the vehicle however, the vehicle unintendedly accelerated and failed to stop. Additionally, the steering wheel failed to turn as needed, and the vehicle crashed into a picnic table and ran over the chairs. The vehicle came to a stop after crashing into a rock. The contact stated that the bumper and doors were damaged and had scratches from the crash. There was no injury sustained. A Police report was not filed. The dealer was contacted and performed an investigation and determined that the accelerator pedal was depressed during the crash and the vehicle was driving 25 MPH; however, the contact stated that the brake pedal was depressed during the crash. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.
NHTSA complaint #11755323 — an unverified report by a vehicle owner.
at 52,000 milesHaines City, FL
ENGINE
The contact owns a 2022 Toyota Rav4. The contact stated that the economy feature disengaged while driving. While the lane assist was activated, the vehicle drifted over into another lane. The engine was revving and backfired. The vehicle lost motive power while driving at undisclosed speeds. The driver's side windshield had a glaze or wax on the outside. While idling, the vehicle surged forward. The driver hovered a foot over the brake pedal. The vehicle was taken to the local dealer but was not diagnosed or repaired. The vehicle was taken to several dealers, AutoNation Toyota Winter Park Service Center (225 N Semoran Blvd, Winter Park, FL 32792); Claremont Toyota (601 Auto Center Dr, Claremont, CA 91711); and Miracle Toyota (37048 US-27, Haines City, FL 33844); but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 52,000.
NHTSA complaint #11751482 — an unverified report by a vehicle owner.
at 52,000 milesHaines City, FL
LANE DEPARTURE: LANE KEEP: STEERING ASSIST
The contact owns a 2022 Toyota Rav4. The contact stated that the economy feature disengaged while driving. While the lane assist was activated, the vehicle drifted over into another lane. The engine was revving and backfired. The vehicle lost motive power while driving at undisclosed speeds. The driver's side windshield had a glaze or wax on the outside. While idling, the vehicle surged forward. The driver hovered a foot over the brake pedal. The vehicle was taken to the local dealer but was not diagnosed or repaired. The vehicle was taken to several dealers, AutoNation Toyota Winter Park Service Center (225 N Semoran Blvd, Winter Park, FL 32792); Claremont Toyota (601 Auto Center Dr, Claremont, CA 91711); and Miracle Toyota (37048 US-27, Haines City, FL 33844); but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 52,000.
NHTSA complaint #11751482 — an unverified report by a vehicle owner.
Alto, GA
ELECTRICAL SYSTEM
COMPONENT: ELECTRICAL SYSTEM / TELEMATICS (DCM)The vehicle suffers from a documented manufacturing defect involving the Data Communication Module (DCM/Telematics system, Calibration N01D14B4644). The module enters an infinite transmission loop when the vehicle is turned off, causing a severe parasitic battery drain that repeatedly drops the 12V auxiliary battery below operational voltage.This creates a severe safety hazard, causing total electrical failure and leaving the driver unexpectedly stranded without warning, presenting an immediate safety risk in extreme weather or unsafe locations.An official Toyota Techstream diagnostic scan on 07/08/2026 confirmed 7 active DTC faults in the telematics system. Authorized dealerships are refusing to perform the mandatory firmware updates outlined in manufacturer service bulletins (T-SB-0089-21), opting instead to clear error logs temporarily without repairing the underlying defect. The manufacturer has failed to issue a safety recall despite widespread knowledge of this safety defect.
NHTSA complaint #11749469 — an unverified report by a vehicle owner.
Kilgore, TX
STRUCTURE:BODY
My 2022 Toyota RAV4 has experienced failures of the power door lock actuators on both front doors. Neither the driver's side nor the front passenger door consistently locks or unlocks using the key fob, interior power lock switch, or automatic locking system. This creates a significant safety concern because the doors may remain unlocked when the vehicle is parked, creating a security risk, or they may fail to unlock quickly during an emergency. In addition, occupants may believe the doors are secured when they are not. The problem has occurred on both front doors, indicating this is not an isolated component failure. The issue developed under normal use and was not caused by an accident, abuse, or modification to the vehicle. Multiple Toyota owners have reported similar failures involving door lock actuators in the same generation of vehicles, and there is pending litigation alleging Toyota has long been aware of this defect but has not issued a recall. I am submitting this complaint because I believe this defect presents a safety risk and warrants investigation by NHTSA
NHTSA complaint #11748820 — an unverified report by a vehicle owner.
The contact owns a 2022 Toyota RAV4. The contact stated that the infotainment system was not functioning as designed. The system continued to reboot and flash, the screen went blank, and it failed to stay connected. There were no warning lights illuminated. The contact was concerned about breaking the law by using her phone while driving. The vehicle was taken to a local dealer, where it was diagnosed that the infotainment system needed to be replaced; however, the vehicle was not repaired.The vehicle was then taken to another local dealer, Rohrich Toyota Parts & Toyota Service (2020 W Liberty Ave, Pittsburgh, PA 15226), where the vehicle was test-driven, but the dealer was unable to duplicate the failure. The vehicle was taken to an independent mechanic, where the infotainment system was replaced. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 36,000.
NHTSA complaint #11748707 — an unverified report by a vehicle owner.
The automatic locking system stopped working for 2 of my doors. Front passenger and back driver sides no longer lock or unlock. This poses a serious risk considering I live near the ghetto and my car has already been broken into.
NHTSA complaint #11746924 — an unverified report by a vehicle owner.
Los Angeles, CA
ELECTRICAL SYSTEM
Our 3 yrs old + Toyota RAV4 Hybrid SUV with barely over 30,000 miles on it had 2 safety issues within 2 months of each other! First was the driver's side mirror- it was rattling, feeling like it might fall off! Seems common issue, perhaps due to cheap plastic parts inside. We had it fixed- Toyota Brand Engagement Center gave a 'Goodwill' gesture to cover us replacing it at Dealership, though it should never have happened on such a newer vehicle in the first place! Then not even 2 months later, a Warning flashed- "Pre Collision System Malfunction!" Also "Headlights" with same warning- "SEE DEALER NOW!" Toyota Dealer. They said Forward Recognition Camera had 'INTERNAL MALFUNCTION' and needed to be replaced. It was going to be quite expensive, but the camera part is not even available in foreseeable future as there's back order for hundreds and they're still in production! It seems this too is a common safety problem~ We can't understand why there's not a RECALL on this. Toyota took no responsibility for this issue, which is APPALLING as, like the first 'side driver's side mirror failure' was also a safety issue! The whole reason we bought this vehicle was for its safety features! Without the front facing camera that comes with the car in same compartment as rear view mirror resides, we now have NO Pre-Collision Warnings, NO Headlight safety feature, NO RSA (Road Sign Assist System). It's infuriating that Toyota, who obviously is making inferior safety products, does not offer to help out in any way. We're both [XXX] and entitled to these safety features as we bought the car both new and paid top dollar! Our service advisor at the Toyota Dealership agrees this is 'not normal', the car is too young to have this happen! He will attest to this & we have paperwork. It stated 'No immediate remedy'. (replacement camera not available) I believe this is happening to hundreds of other RAV4 owners. It's outrageous! Please help! These electronics for safety should not fail! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFOR
NHTSA complaint #11746585 — an unverified report by a vehicle owner.
Los Angeles, CA
FORWARD COLLISION AVOIDANCE: WARNINGS
Our 3 yrs old + Toyota RAV4 Hybrid SUV with barely over 30,000 miles on it had 2 safety issues within 2 months of each other! First was the driver's side mirror- it was rattling, feeling like it might fall off! Seems common issue, perhaps due to cheap plastic parts inside. We had it fixed- Toyota Brand Engagement Center gave a 'Goodwill' gesture to cover us replacing it at Dealership, though it should never have happened on such a newer vehicle in the first place! Then not even 2 months later, a Warning flashed- "Pre Collision System Malfunction!" Also "Headlights" with same warning- "SEE DEALER NOW!" Toyota Dealer. They said Forward Recognition Camera had 'INTERNAL MALFUNCTION' and needed to be replaced. It was going to be quite expensive, but the camera part is not even available in foreseeable future as there's back order for hundreds and they're still in production! It seems this too is a common safety problem~ We can't understand why there's not a RECALL on this. Toyota took no responsibility for this issue, which is APPALLING as, like the first 'side driver's side mirror failure' was also a safety issue! The whole reason we bought this vehicle was for its safety features! Without the front facing camera that comes with the car in same compartment as rear view mirror resides, we now have NO Pre-Collision Warnings, NO Headlight safety feature, NO RSA (Road Sign Assist System). It's infuriating that Toyota, who obviously is making inferior safety products, does not offer to help out in any way. We're both [XXX] and entitled to these safety features as we bought the car both new and paid top dollar! Our service advisor at the Toyota Dealership agrees this is 'not normal', the car is too young to have this happen! He will attest to this & we have paperwork. It stated 'No immediate remedy'. (replacement camera not available) I believe this is happening to hundreds of other RAV4 owners. It's outrageous! Please help! These electronics for safety should not fail! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFOR
NHTSA complaint #11746585 — an unverified report by a vehicle owner.
Los Angeles, CA
LANE DEPARTURE: WARNING
Our 3 yrs old + Toyota RAV4 Hybrid SUV with barely over 30,000 miles on it had 2 safety issues within 2 months of each other! First was the driver's side mirror- it was rattling, feeling like it might fall off! Seems common issue, perhaps due to cheap plastic parts inside. We had it fixed- Toyota Brand Engagement Center gave a 'Goodwill' gesture to cover us replacing it at Dealership, though it should never have happened on such a newer vehicle in the first place! Then not even 2 months later, a Warning flashed- "Pre Collision System Malfunction!" Also "Headlights" with same warning- "SEE DEALER NOW!" Toyota Dealer. They said Forward Recognition Camera had 'INTERNAL MALFUNCTION' and needed to be replaced. It was going to be quite expensive, but the camera part is not even available in foreseeable future as there's back order for hundreds and they're still in production! It seems this too is a common safety problem~ We can't understand why there's not a RECALL on this. Toyota took no responsibility for this issue, which is APPALLING as, like the first 'side driver's side mirror failure' was also a safety issue! The whole reason we bought this vehicle was for its safety features! Without the front facing camera that comes with the car in same compartment as rear view mirror resides, we now have NO Pre-Collision Warnings, NO Headlight safety feature, NO RSA (Road Sign Assist System). It's infuriating that Toyota, who obviously is making inferior safety products, does not offer to help out in any way. We're both [XXX] and entitled to these safety features as we bought the car both new and paid top dollar! Our service advisor at the Toyota Dealership agrees this is 'not normal', the car is too young to have this happen! He will attest to this & we have paperwork. It stated 'No immediate remedy'. (replacement camera not available) I believe this is happening to hundreds of other RAV4 owners. It's outrageous! Please help! These electronics for safety should not fail! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFOR
NHTSA complaint #11746585 — an unverified report by a vehicle owner.
Fergus Falls, MN
STEERING
After driving for approximately 30-minutes in a heavy rain i pulled over and the automatic engine shutoff feature activated while i was waiting to go inside for an appointment. When attempting to restart the car, the engine would start but then shut off showing a "low power steering" warning message on my dash. The problem persisted for approximately 15-20 minutes. Eventually after about 10 attempts to restart the engine, the car started back up and drove fine the rest of the day. I have heard of this happening to many other rav4s on the Autosafety.org website and it causes me concern, especially if this problems causes the car to stall in high speed traffic in the rain. It is my understanding that this maybe a problem with the Mass Airflow Sensor getting wet in heavy rainfall.
NHTSA complaint #11746188 — an unverified report by a vehicle owner.
Fergus Falls, MN
ELECTRICAL SYSTEM
After driving for approximately 30-minutes in a heavy rain i pulled over and the automatic engine shutoff feature activated while i was waiting to go inside for an appointment. When attempting to restart the car, the engine would start but then shut off showing a "low power steering" warning message on my dash. The problem persisted for approximately 15-20 minutes. Eventually after about 10 attempts to restart the engine, the car started back up and drove fine the rest of the day. I have heard of this happening to many other rav4s on the Autosafety.org website and it causes me concern, especially if this problems causes the car to stall in high speed traffic in the rain. It is my understanding that this maybe a problem with the Mass Airflow Sensor getting wet in heavy rainfall.
NHTSA complaint #11746188 — an unverified report by a vehicle owner.
Post Falls, ID
VISIBILITY/WIPER
The panoramic moonroof on my 2022 Toyota RAV4 spontaneously shattered and exploded outward at approximately 2:09 PM on June 21, 2026 while my wife was driving and exiting the freeway. There was a loud bang, followed by glass shards ejecting primarily outward onto the roof with a pattern showing the glass failed/bent from the inside out. The outer glass panel broke into multiple large sections with a clean perimeter failure and no visible external impact point or road debris damage. This created an immediate safety hazard: loud distraction while driving at highway speeds, flying glass, and sudden exposure through the roof opening. No warning lights, messages, noises, or prior symptoms appeared. The moonroof had been used normally with no issues. The component (panoramic moonroof glass assembly) is available for inspection. I have a dealer appointment scheduled for tomorrow, June 22, 2026 at 9:45 AM for inspection. The vehicle has not yet been inspected by the dealer, manufacturer, insurance, or police. This matches numerous similar reports of spontaneous panoramic sunroof failures on RAV4 models.
NHTSA complaint #11745498 — an unverified report by a vehicle owner.
North Providence, RI
ENGINE
TSB T-SB-0010-24 P0303 code 163,000 miles Toyota denied goodwill assistance Cost: $2,549.65 Check engine light came on with vehicle hesitation on acceleration almost caused to stall with reduced power while driving , the dealership diagnosed the issue as TSB T-SB-0010-24 with cylinder #3 misfire requiring exhaust valve lash adjuster to be replaced. Contacted Toyota corporate to request help with goodwill or discount , was denied , was told they couldn't help no reason given .This issue is a well know Toyota RAV4 defect and even though they claim it only happens when is cold this happened to my SUV at 60*F. Please help.
NHTSA complaint #11740904 — an unverified report by a vehicle owner.
at 40,000 milesHarrisburg, NC
STRUCTURE
The contact owns a 2022 Toyota RAV4. The contact stated that while driving at various speeds during rainy weather conditions, water would leak inside the front driver-side door and puddle. The vehicle was taken to a local dealer, where it was diagnosed with a deteriorated sealant. The vehicle was repaired. In addition, the contact stated that while driving at various speeds during rainy weather conditions, water would intrude into the rear driver-side door and would accumulate inside. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to costs. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
NHTSA complaint #11740660 — an unverified report by a vehicle owner.
Caldwell, ID
SEAT BELTS
The drivers side front seat belt buckle will not latch. There is no dirt or other debris in the latch to stop it from functioning.
NHTSA complaint #11739557 — an unverified report by a vehicle owner.
Auburn, NY
ELECTRICAL SYSTEM
Please see attached complaint letter. Overall, this is related to the 2022 Toyota RAV4 Hybrid electronic hybrid system. This issue related to campaign 25TD01. The issue can cause the car to not start at any time because of the vehicle's start/stop hybrid system. If this happens in traffic, you could cause a safety issue that could lead to an accident and possibly fatalities.
NHTSA complaint #11737355 — an unverified report by a vehicle owner.
I am submitting this complaint to report a known and widespread safety defect involving the door lock actuators on my Toyota RAV4. My vehicle’s door actuators have failed at approximately 39,000 miles, just outside the 3‑year/36,000‑mile warranty. This failure prevents the doors from locking and unlocking properly, which poses a significant safety hazard while driving, especially in emergency situations. When I brought the issue to Beechmont Toyota, the dealership refused to repair the defect under goodwill or warranty consideration. I spoke with Stacy Meyer, Assistant Service Manager [XXX] ), who stated that the refusal was directed by Rodney Wetenkamp, Service Director. Despite the well‑documented nature of this defect, the dealership declined to assist in any way. This is not an isolated incident. There is an active class action lawsuit in Texas regarding defective Toyota RAV4 door lock actuators, demonstrating that Toyota is aware of the widespread nature of this problem. Source: Toyota Facing Class Action Lawsuit Over Allegedly Defective Door Lock Actuators I also contacted the Toyota Brand Engagement Center, which opened Case #260508001469. Toyota advised me to work through the dealership, stating that the dealer should escalate the issue through their internal channels. However, the dealership refused to do so, leaving me without support despite this being a manufacturer‑related defect. Door lock actuator failure is a serious safety issue. When the locks fail: Doors may not lock while driving, exposing occupants to risk Doors may not unlock in an emergency Children and passengers may be unable to exit the vehicle quickly The vehicle becomes vulnerable to theft and unauthorized entry Given the known defect, Toyota’s awareness of the issue, and the dealership’s refusal to escalate or repair the problem, I believe this represents a failure of manufacturer responsibility and a potential violation of safety standards. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5
NHTSA complaint #11737471 — an unverified report by a vehicle owner.
