Owners have filed 238 complaints
about the 2001 Toyota Sienna with NHTSA between 2000 and 2021.
The largest single group is the body & structure.
Across this model's run it ranks 19 of 23 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 25
Against the median year of the Toyota Sienna. 50 means typical for this
model; 100 means roughly double.
Severity — 59
11.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 53
31% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Door
1725.4%
Latch
1623.9%
Engine
1014.9%
Body
913.4%
Gasoline
46.0%
Rotor
46.0%
Power Window Devices AND Controls
46.0%
Tread/Belt
34.5%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
42.5%
1,000 – 9,999 miles
1710.8%
10,000 – 24,999 miles
1610.1%
25,000 – 49,999 miles
2817.7%
50,000 – 74,999 miles
2717.1%
75,000 – 99,999 miles
1610.1%
100,000 – 149,999 miles
3622.8%
150,000+ miles
148.9%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2001 Toyota Sienna
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2000peak 7Mar 2021
Recalls on the 2001 Toyota Sienna
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
10V160000
STRUCTURE
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Risk: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
01V072000
STRUCTURE:FRAME AND MEMBERS
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT SUB FRAME ASSEMBLY HAS NOT BEEN ADEQUATELY WELDED.
Risk: THIS CONDITION COULD CAUSE FAILURE OF THE ASSEMBLY FOLLOWING LONG-TERM USAGE, INCREASING THE RISK OF A CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202172355,683 units in Canada
Electrical
Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.
Recall 2010123138,409 units in Canada
Other
On certain vehicles operated where road salts are frequently used, excessive corrosion of the spare tire carrier assembly cable may cause the separation of the spare tire stowed under the vehicle. Spare tire falling on the road surface creates a safety hazard that may result in a crash causing property damage, personal injury or death. Correction: Dealers will inspect and, as required, either apply a corrosion resistance enhancement treatment to the spare tire carrier restraint cable, repair the cable and apply the corrosion resistance treatment, or replace the spare tire carrier assembly. Note: This recall has been superseded by recall 2014-188.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 150,000 milesSugar Land, TXCrash
AIR BAGS
THE DRIVER WAS UNABLE TO STOP THE VAN IN TIME AND THE PASSENGER SIDE OF FRONT BUMPER OF THE 2001 TOYOTA SIENNA VAN HIT THE WALL OF A HOUSE BUT NO AIR BAGS CAME OUT OR INFLATED. THE VAN IS TOTALLY DAMAGED AND NOT DRIVEABLE.
NHTSA complaint #10609176 — an unverified report by a vehicle owner.
at 90,000 milesRaleigh, NCCrash2 injured1 killed
AIR BAGS
ON OCTOBER 28,2006, MY SON AND I RETURNED TO THE SITE OF THE ACCIDENT, THE NC STATE HIGHWAY PATROL DRIVING TRACK. ONCE THROUGH REGISTRATION, WE RE-ENTERED THE 2001 TOYOTA SIENNA MINIVAN. UNFORTUNATELY, WE DID NOT USE THE SEAT BELTS, SINCE WE COULD SEE THE SPOT WE HAD BEEN ASSIGNED. SOMETIME DURING THIS MOVE, I MUST HAVE HAD A SEIZURE, SINCE THE ONLY THING I REMEMBER IS SOMEONE HELPING ME OUT OF THE DRIVER'S SIDE DOOR. ONCE AT THE HOSPITAL, I LAPSED INTO A COMA, WHICH WAS TO LAST FOR THE NEXT 18 DAYS. ONCE I WOKE UP, I WAS TOLD THAT MY SON HAD DIED, AND WAS BURIED. IT WAS STATED TO ME THAT WE WEREN'T WEARING OUR SEAT BELTS. I SAID, "WHAT ABOUT THE AIRBAGS?" THEY HADN'T DEPLOYED, IT TURNED OUT. I REALIZE THAT WE WOULD HAVE BEEN MORE SAFE IF WE HAD BEEN WEARING OUR SEAT BELTS. BUT I ALSO KNOW THAT THE AIRBAGS SHOULD HAVE DEPLOYED, SINCE THE ESTIMATED SPEED AT TIME OF IMPACT WAS 50 MPH. SINCE WE HAD GONE THROUGH A CREEK, AND SLAMMED INTO THE OPPOSITE CREEK BANK IN A BASIC HEAD ON COLLISION. I ALSO KNOW THAT THINGS WOULD HAVE BEEN CONSIDERABLY DIFFERENT IF THE AIRBAGS HAD DEPLOYED, SINCE BOTH MY SON AND I SUSTAINED TRAUMATIC BRAIN INJURIES (TBI'S) . ONCE I WAS ABLE TO USE A COMPUTER, I RESEARCHED AIRBAG FAILURES IN TOYOTA VEHICLES, AND FOUND NUMEROUS INCIDENTS AND ANECDOTES OF OTHER PEOPLES'S EXPERIENCE WITH THE SAME PROBLEM - FAILURE OF THE AIRBAGS TO DEPLOY, WHEN IT WAS CLEARLY OBVIOUS THAT THEY WERE NEEDED. I ALSO WONDERED ABOUT THE COMMONALITY OF THE PROBLEM, AND BEGAN TO SUSPECT A COMPANY-WIDE POLICY TO MAKE IT VERY HARD FOR THE AIRBAGS TO DEPLOY, SINCE IT WAS A HOT TOPIC THEN TO TALK ABOUT AIRBAGS AS AN ENEMY, SINCE SOME REPORTS WERE NOTING ACCIDENTS AND INJURIES ATTRIBUTED TO THE AIRBAGS' MIS-DEPLOYMENT. I AM NOT AT PEACE WITH THE TOYOTA COMPANY'S USUAL DENIAL OF ANYTHING NOT WORKING PERFECTLY AND PROPERLY AND THAT THERE WAS A SAFETY ISSUE INVOLVING THEIR AIRBAGS.
NHTSA complaint #10420211 — an unverified report by a vehicle owner.
at 82,506 milesRaleigh, NCCrash1 injured1 killed
AIR BAGS
AFTER STOPPING FOR REGISTRATION, MY SON AND I GOT BACK INTO OUR 2001 TOYOTA SIENNA MINIVAN TO CONTINUE ON TO OUR PREVIOUSLY REGISTERED SITE AT A CUB SCOUTS "JAMBOREE". I THINK THAT I HAD A SEIZURE (I DON'T REMEMBER ANYTHING AT THIS TIME). NEITHER I NOR MY CHILD WAS BUCKLED IN, AND WE TRAVELED ACROSS A FIELD AND ACROSS A SMALL CREEK, WITH THE END RESULT THE HEAD-ON COLLISION INTO THE FAR SIDE OF THE CREEK. I WAS BADLY INJURED, AND MY SON WAS DECLARED "BRAIN DEAD" 5 DAYS LATER. NO AIR BAGS DEPLOYED, AND I AM NOW REPORTING IT BECAUSE IF THEY HAD, WE MAY HAVE HAD AN ENTIRELY DIFFERENT RESULT. AFTER RESEARCHING THIS PARTICULAR PROBLEM, I DISCOVERED THAT THE FAILURE TO DEPLOY AIR BAGS WAS CITED BY A PREVIOUS AUTHOR. I AM INTRIGUED, TO SAY THE LEAST....
NHTSA complaint #10403690 — an unverified report by a vehicle owner.
at 120,000 milesWalpole, MACrash
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2001 TOYOTA SIENNA. WHILE APPLYING PRESSURE TO THE BRAKES, THE CONTACT HEARD A LOUD GRINDING NOISE COMING FROM THE ABS MOTOR. THE BRAKES DID NOT ENGAGE AND THE CONTACT CRASHED INTO ANOTHER VEHICLE. THE CONTACT DID NOT INFORM THE DEALER OR MANUFACTURER OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 120,000.
NHTSA complaint #10386911 — an unverified report by a vehicle owner.
at 70,000 milesGainesville, FLCrash
VEHICLE SPEED CONTROL
I WAS DRIVING A 2001 TOYOTA SIENNA. I TURNED LEFT INTO A PARKING SPACE AND PULLED FORWARD. WHILE STILL IN DRIVE, RATHER THAN STOPPING, THE CAR CONTINUED TO ACCELERATE SLOWLY, RAN OVER A WOODEN PARKING BARRIER, AND CRASHED INTO A CONCRETE WALL A FEW FEET AWAY.
NHTSA complaint #10318449 — an unverified report by a vehicle owner.
Grand Junction, COCrash
TIRES:VALVE
TL*THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE VEHICLE HAS DILL-ACP VALVE STEMS, MODEL TR-413. WHILE DRIVING 65 MPH, THE PASSENGER SIDE TIRE BLEW OUT. THE VEHICLE STRUCK A GUARDRAIL AND WAS DESTROYED. A POLICE REPORT WAS FILED AND THE CONTACT HAS PICTURES AVAILABLE. SHE RECEIVED A SAFETY RECALL NOTICE FOR THE VALVE STEMS ON SEPTEMBER 12, 2008. UPDATED 10/20/08
NHTSA complaint #10243159 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 75 milesAuburn, WA
ENGINE
A KNOWN ISSUE WITH THESE 3.0 L V6 ENGINE. HEAVY SMOKE FROM THE EXHAUST PIPE. VISIBLE OIL SLUDGE UNDER THE OIL REFILL CAP.
NHTSA complaint #11402825 — an unverified report by a vehicle owner.
at 147,000 milesArlington, MA
STRUCTURE:BODY
THE DRIVER'S SIDE REAR SLIDING DOOR HAS SEVERAL TIMES NOW REFUSED TO LATCH, AND WHEN IN EMERGENCY SITUATION I HAVE LOCKED IT AND FORCED IT TO SHUT THEN IT WILL NOT UNLOCK AND IT HAS TO BE TAKEN APART TO BE OPENED AND THE WHOLE LATCH AND LOCK MECHANISM REWORKED BY THE MECHANIC, AND IN THE MEANTIME THE DOOR IS UNABLE TO BE OPENED WHICH IS EXTREMELY UNSAFE WHEN I HAVE CHILDREN IN THE MIDDLE AND BACK ROWS OF THE VAN. THIS IS THE THIRD TIME IN THE PAST 3 YEARS THAT THIS PROBLEM HAS OCCURRED, SO IT IS DEFINITELY AN ACTUAL PROBLEM WITH THE HARDWARE OF THE DOOR LATCH MECHANISM ITSELF AND NOT SIMPLY A GLITCH THAT OCCURRED ONCE OR SOMETHING.
NHTSA complaint #11098879 — an unverified report by a vehicle owner.
at 154,000 milesPierpont, OH
FUEL/PROPULSION SYSTEM
MY 9 YEAR OLD SON AND I WERE ON OUR WAY HOME FROM WORK LAST NIGHT AND I HEARD SOMETHING SNAP ON MY 2001 TOYOTA SIENNA. I THEN HEARD SOMETHING DRAGGING SO I IMMEDIATELY PULLED OVER TO CHECK AND REALIZED THE FUEL TANK WAS DRAGGING AND THE BACK STRAPS HOLDING THE GAS TANK UP HAD BROKEN LOOSE CAUSING THE BACK SECTION OF THE TANK TO DRAG ON THE ROAD. I HAD TO CALL A TOW TRUCK TO TOW VEHICLE TO THE MECHANICS. SINCE I WORK 18 MILES AWAY I FIND GETTING TO WORK DIFFICULT.
NHTSA complaint #11000310 — an unverified report by a vehicle owner.
at 160,000 milesVictorville, CA
VEHICLE SPEED CONTROL
I HAD JUST DROPPED MY YOUNGEST DAUGHTER OFF AT SCHOOL AND AS I WAS LEAVING I HAD TO STOP BECAUSE SOME CHILDREN WITH THEIR PARENTS NEEDED TO CROSS IN FRONT OF ME I APPLIED MY BRAKES AS NORMAL AND I HAD NO ISSUES IN STOPPING BUT THEN IT FEELS LIKE A "GHOST" PUSHES THE GAS PEDAL DOWN BECAUSE I CAN FEEL IT MOVE AND SEE MY RPM GAUGE GO UP AND I HEAR MY ENGINE "VRRRROOOMMMM" I PUSHED MY BRAKES HARDER AND STILL NOTHING, THE END RESULTS ME HAVING TO PUT MY CAR INTO PARK TO KEEP IT FROM MOVING INTO THE CROSSWALK ONTO THE PEOPLE. WHEN I GET HOME IT DOES THE SAME THING AND I ALMOST CRASH INTO MY GARAGE BECAUSE THE CAR IS ACCELERATING ON ITS OWN AND AGAIN. IT WOULD ALWAYS HAPPEN AT RANDOM, AFTER I WOULD LET GO OF THE BRAKES ITS ALREADY MOVING FAST AS IF MY FOOT IS ON THE GAS, I SAY TO MY PASSENGER WHICH IS MY WIFE "LOOK THE VAN IS GOING ON IT'S OWN, I'M NOT EVEN PUSHING THE GAS" THE VAN WAS MOVING PRETTY FAST, BUT FAST ENOUGH FOR THE FLOW OF TRAFFIC FROM A STOP AND GO MOVEMENT. I NO LONGER DRIVE THE VAN BECAUSE I AM SCARED THAT I AM GOING TO GET INTO AN ACCIDENT AND I DON'T WANT THAT TO HAPPEN. NO CHECK ENGINE LIGHT IS ON I EVEN HAD THE VAN CHECKED FOR CODES AND NOTHING CAME UP.
NHTSA complaint #10905861 — an unverified report by a vehicle owner.
Fremont, CA
ENGINE
TAKATA RECALL. WHITE SMOKE COMES OUT OF THE EXHAUST WHEN I START THE CAR. THEN SMOKE DISAPPEARS OR STAY AT LOW LEVEL DURING DRIVING. DECREASE OIL. I PUT ONE QUARTER OIL EACH WEEK. MECHANICS SAYS IT MAY HEAD GASKIT OR SEALS. COSTS 2000 AND ABOVE TO REPAIR. IF NOT BETTER TO GARBAGE THIS VEHICLE. IT HAS A CLEAN TITLE WITH 106K.
NHTSA complaint #10893839 — an unverified report by a vehicle owner.
at 90,000 milesCastro Valley, CA
SEAT BELTS
THE SEAT BELT PRETENSIONER WAS FAULTY AND NOT WORKING PROPERLY. IT STOPPED THE SRS DEPLOY AND HAVE THE AIRBAG LIGHT ON.
NHTSA complaint #10875380 — an unverified report by a vehicle owner.
at 90,000 milesCastro Valley, CA
AIR BAGS
THE SEAT BELT PRETENSIONER WAS FAULTY AND NOT WORKING PROPERLY. IT STOPPED THE SRS DEPLOY AND HAVE THE AIRBAG LIGHT ON.
NHTSA complaint #10875380 — an unverified report by a vehicle owner.
at 118,203 milesPort Jefferson Station, NY
UNKNOWN OR OTHER
THE HORN ON THE SIENNA WORKS INTERMITTENTLY. THIS IS A VERY UNSAFE SITUATION WHEN DRIVING AS A HORN COULD POSSIBLY PREVENT AN ACCIDENT WITH A CAR OR PEDESTRIAN. FIRST HAD THE PROBLEM IN 2014, BUT WHEN WE BROUGHT IT TO TOYOTA, IT WOULD WORK, SO THEY COULDN'T CHECK IT OUT. IN APRIL 2015, THEY FINALLY THOUGHT IT WAS A DEFECTIVE SPIRAL CABLE, SO THEY REPLACED IT, TO THE TUNE OF $400+. THREE DAYS LATER, WE HAD THE PROBLEM AGAIN. WEREN'T ABLE TO BRING IT BACK UNTIL RECENTLY. REPLACED SPIRAL CABLE AGAIN. PROBLEM RETURNED BEFORE THE CAR MADE IT HOME. VEHICLE IS BACK IN SHOP. I BELIEVE THEY SAID THEY ARE REPLACING THE HORN PAD ASSEMBLY, WHICH WILL COST ANOTHER $150 FOR THE PART. THEY ARE NOT CHARGING FOR LABOR AS IT IS UNDER A 1 YEAR SERVICE WARRANTY. FOUND OUT TODAY A COWORKER HAS A SIMILAR PROBLEM WITH A 2005 SIENNA. I GOOGLED, "PROBLEMS WITH SIENNA HORN" AND FOUND MANY PEOPLE WITH THE SAME PROBLEM. WHY HAS THERE NOT BEEN A RECALL AS THIS IS CLEARLY A SAFETY ISSUE. I FEEL THAT MAYBE THERE HAS NOT BEEN ANY SERIOUS ACCIDENTS ATTRIBUTED TO THIS PROBLEM AND SO IT'S "FLOWN UNDER THE RADAR", SO TO SPEAK.
NHTSA complaint #10865275 — an unverified report by a vehicle owner.
at 142,112 milesMobile, AL
ELECTRICAL SYSTEM
HORN WILL NOT WORK IN THE RAIN OR WHEN YOU DRIVE IN WATER. IT TAKES ABOUT A DAY FOR THE HORN TO DRY OUT FOR THE HORN TO WORK AT ALL. PEOPLE COULD GET KILLED WHEN THE HORN WILL NOT WORK IN THE RAIN OR WATER. TOYOTA NEEDS TO HAVE A RECALL NOW TO SAVE THE LIVES OF MILLIONS OF MEN, WOMEN AND CHILDREN IN THE USA.
NHTSA complaint #10861483 — an unverified report by a vehicle owner.
at 120,000 milesFrankford, IL
STRUCTURE:BODY:HOOD
TL* THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE HOOD WAS SHAKING VIOLENTLY AND UNLATCHED FROM THE VEHICLE CAUSING THE WINDSHIELD TO CRACK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #10838136 — an unverified report by a vehicle owner.
at 120,000 milesFrankford, IL
VISIBILITY
TL* THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE HOOD WAS SHAKING VIOLENTLY AND UNLATCHED FROM THE VEHICLE CAUSING THE WINDSHIELD TO CRACK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #10838136 — an unverified report by a vehicle owner.
at 133,000 milesWestminster, MD
UNKNOWN OR OTHER
I WAS ENTERING THE PARKING AREA OF A SHOPPING CENTER. IMMEDIATELY AFTER TURNING IN THE CAR ACCELERATED QUICKLY. I BRAKED TO NO AVAIL. THEN I PUT ON THE FOOT EMERGENCY BRAKE, WHICH SLOWED BUT DID NOT STOP THE CAR. A PASSENGER THEN TURNED OFF THE KEY AND WE LURCHED TO AN ABRUPT STOP, SHORT OF A TYPICAL PARKING LOT LIGHT POLE. AFTER A BRIEF TIME I TURNED ON THE KEY AND WAS MET WITH A VERY LOUD GROWL FROM THE HOOD. AAA HAULED ME TO JOSEPH AIRPORT TOYOTA IN VANDALIA, OH. ON TUES, AUG 11, I CALLED TO SEE WHAT THEY HAD FOUND. THEY TOLD ME THAT THEY HAD FOUND NOTHING WRONG WITH THE CAR AFTER TESTING AND DRIVING THE CAR. I ASKED TO TALK WITH THE MECHANIC, WHO TOLD ME HE HAD TESTED EVERYTHING THOROUGHLY AND COULD NOT REPLICATE WHAT I HAD EXPERIENCED.
NHTSA complaint #10758671 — an unverified report by a vehicle owner.
at 131,000 milesCold Spring Harbor, NY
POWER TRAIN
[THIS INCIDENT HAS ALSO BEEN REPORTED TO TOYOTA - CASE # [XXX].] I EXITED PARKING LOT AND TURNED LEFT TO TRAVEL NORTH ON TWO-LANE STREET AT 5 PM. IMMEDIATELY AFTER ENTERING THE LANE, MY CAR BEGAN TO DECELERATE. I PRESSED THE ACCELERATOR, AND IT WAS STUCK IN POSITION. I TAPPED THE PEDAL, AT WHICH POINT THE PEDAL LOCKED IN THE DOWN POSITION, AND THE CAR RACED FORWARD, WITH TIRES SCREECHING. I IMMEDIATELY HIT THE BRAKES AND PUT IN CAR IN NEUTRAL. THE ENGINE CONTINUED TO REV AT 5000-6000 RPM WHILE I PULLED OFF TO THE SHOULDER ON THE RIGHT. AFTER PUTTING THE SHIFT INTO PARK, I REACHED DOWN WITH MY HAND, NOTED THERE WAS NO CARPET INTERFERING WITH THE PEDAL, YET IT WAS STUCK IN THE DOWNWARD POSITION. I PULLED BACK A FEW TIMES AND WAS ABLE TO FREE THE ACCELERATOR PEDAL MOVEMENT, AT WHICH POINT THE ENGINE BEGAN TO IDLE. I TESTED THE PEDAL SEVERAL TIMES BEFORE RESUMING MY ROUTE. AT MY FIRST LEFT TURN AFTER THE ACCELERATION INCIDENT, I NOTED THAT THE CAR HAD NO POWER STEERING, AND I WAS BARELY ABLE TO TURN THE CAR A SHARP 90 DEGREES TO THE LEFT. THE REMAINDER OF MY RIDE HOME, THE CAR HAD NO POWER STEERING. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 4/19/2016
NHTSA complaint #10690357 — an unverified report by a vehicle owner.
at 131,000 milesCold Spring Harbor, NY
STEERING
[THIS INCIDENT HAS ALSO BEEN REPORTED TO TOYOTA - CASE # [XXX].] I EXITED PARKING LOT AND TURNED LEFT TO TRAVEL NORTH ON TWO-LANE STREET AT 5 PM. IMMEDIATELY AFTER ENTERING THE LANE, MY CAR BEGAN TO DECELERATE. I PRESSED THE ACCELERATOR, AND IT WAS STUCK IN POSITION. I TAPPED THE PEDAL, AT WHICH POINT THE PEDAL LOCKED IN THE DOWN POSITION, AND THE CAR RACED FORWARD, WITH TIRES SCREECHING. I IMMEDIATELY HIT THE BRAKES AND PUT IN CAR IN NEUTRAL. THE ENGINE CONTINUED TO REV AT 5000-6000 RPM WHILE I PULLED OFF TO THE SHOULDER ON THE RIGHT. AFTER PUTTING THE SHIFT INTO PARK, I REACHED DOWN WITH MY HAND, NOTED THERE WAS NO CARPET INTERFERING WITH THE PEDAL, YET IT WAS STUCK IN THE DOWNWARD POSITION. I PULLED BACK A FEW TIMES AND WAS ABLE TO FREE THE ACCELERATOR PEDAL MOVEMENT, AT WHICH POINT THE ENGINE BEGAN TO IDLE. I TESTED THE PEDAL SEVERAL TIMES BEFORE RESUMING MY ROUTE. AT MY FIRST LEFT TURN AFTER THE ACCELERATION INCIDENT, I NOTED THAT THE CAR HAD NO POWER STEERING, AND I WAS BARELY ABLE TO TURN THE CAR A SHARP 90 DEGREES TO THE LEFT. THE REMAINDER OF MY RIDE HOME, THE CAR HAD NO POWER STEERING. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 4/19/2016
NHTSA complaint #10690357 — an unverified report by a vehicle owner.
at 137,315 milesUnion City, CA
AIR BAGS
TOYOTA SIENNA HAS AIR BAG FLASHING, IT JUST LAST 12/12/20014, SO I BROUGHT IT TO FREMONT TOYOTA FOR CHECK UP AND TOLD THEM ABOUT THE FLASHING AIR BAG ASK THEM IF IF IS PART OF TOYOTA AIR BAG RECALL. THEY CHARGE ME $152.00 TO FIND OUT THE PROBLEM. AFTER 2 HRS, THEY SAY, THEY NEED MORE HOURS TO FIND THE PROBLEM AND THEY ARE CHARGING ME ANOTHER $152.00. I THOUGHT THE $152.00 IN THE FIRST PLACE THEY TELL YOU THE PROBLEM.IS THIS RIGHT WHEN THEY ESTIMATE THE HOUR. THEY CAN DIAGNOSE THE PROBLEM. TO PAY EXTRA I DON"T HAVE ENOUGH MONEY.. IS THIS AIR BAG PROBLEM IS TOYOTA RECALL. I AM AFRAID FOR MY FAMILY SAFETY. THANKS: CONRAD
NHTSA complaint #10670520 — an unverified report by a vehicle owner.
at 150,000 milesSugar Land, TXCrash
AIR BAGS
THE DRIVER WAS UNABLE TO STOP THE VAN IN TIME AND THE PASSENGER SIDE OF FRONT BUMPER OF THE 2001 TOYOTA SIENNA VAN HIT THE WALL OF A HOUSE BUT NO AIR BAGS CAME OUT OR INFLATED. THE VAN IS TOTALLY DAMAGED AND NOT DRIVEABLE.
NHTSA complaint #10609176 — an unverified report by a vehicle owner.
at 258,000 milesHamilton, OH
WHEELS
THE SPARE TIRE MECHANISM BROKE ON MY 2001 TOYOTA SIENNA MINIVAN. THANKFULLY I WAS TRYING TO REMOVE THE SPARE WHEN IT HAPPENED AND THE SPARE TIRE DID NOT GO FLYING INTO TRAFFIC. THE CABLE BROKE AT THE END WHERE THE CABLE GOES THROUGH THE METAL HOLDER/BRACKET THAT ACTUALLY CLAMPS TO THE WHEEL. IF THIS HAD BROKEN OFF WHEN THE VAN WAS MOVING, EITHER THE VAN WOULD HAVE BEEN DAMAGED BY THE SPARE GETTING CAUGHT BETWEEN THE ROAD AND THE VAN OR THE SPARE MAY HAVE HIT ANOTHER CAR. THIS IS MAYBE THE SECOND TIME THAT WE HAVE HAD THE SPARE OFF IN THE 258K MILES WE HAVE OWNED THE CAR SO IT IS NOT SOMETHING THAT WE INSPECT REGULARLY. THERE ARE A LOT OF THESE VANS OUT THERE AND I REALLY DON'T WANT TO BE BEHIND ONE WHEN THE SPARE LETS GO. THE DEALERSHIP CLAIMED THAT MY VAN DID NOT HAVE A RECALL ON THIS ITEM.
NHTSA complaint #10565639 — an unverified report by a vehicle owner.
at 258,000 milesHamilton, OH
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
THE SPARE TIRE MECHANISM BROKE ON MY 2001 TOYOTA SIENNA MINIVAN. THANKFULLY I WAS TRYING TO REMOVE THE SPARE WHEN IT HAPPENED AND THE SPARE TIRE DID NOT GO FLYING INTO TRAFFIC. THE CABLE BROKE AT THE END WHERE THE CABLE GOES THROUGH THE METAL HOLDER/BRACKET THAT ACTUALLY CLAMPS TO THE WHEEL. IF THIS HAD BROKEN OFF WHEN THE VAN WAS MOVING, EITHER THE VAN WOULD HAVE BEEN DAMAGED BY THE SPARE GETTING CAUGHT BETWEEN THE ROAD AND THE VAN OR THE SPARE MAY HAVE HIT ANOTHER CAR. THIS IS MAYBE THE SECOND TIME THAT WE HAVE HAD THE SPARE OFF IN THE 258K MILES WE HAVE OWNED THE CAR SO IT IS NOT SOMETHING THAT WE INSPECT REGULARLY. THERE ARE A LOT OF THESE VANS OUT THERE AND I REALLY DON'T WANT TO BE BEHIND ONE WHEN THE SPARE LETS GO. THE DEALERSHIP CLAIMED THAT MY VAN DID NOT HAVE A RECALL ON THIS ITEM.
NHTSA complaint #10565639 — an unverified report by a vehicle owner.
at 32,231 milesDallas, TX
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2001 TOYOTA SIENNA. THE CONTACT STATED THAT THE PASSENGER'S SIDE SLIDING DOOR WARNING LAMP ILLUMINATED INDICATING THAT THE DOOR WAS AJAR. THE CONTACT MENTIONED THAT THE FAILURE DRAINED THE BATTERY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SLIDING DOOR ELECTRONIC CONTROL UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,231 AND THE CURRENT MILEAGE WAS 34,451.
NHTSA complaint #10551928 — an unverified report by a vehicle owner.
at 160,000 milesWoodside, NY
STRUCTURE:BODY
THE STEEL CABLE FOR THE POWER SLIDING DOOR SNAPPED WHILE DOOR WAS BEING OPENED ELECTRONICALLY. THE RIGHT SIDE SLIDING DOOR WAS UNABLE TO OPEN WIDER THAN A FOOT SINCE THE CABLE SNAPPED WHILE IN OPERATION. PASSENGERS, INCLUDING CHILDREN, HAD TO EXIT THE PARKED VEHICLE THROUGH THE DRIVER'S SIDE SLIDING DOOR INTO ONCOMING TRAFFIC. THE DOOR REMAINED INOPERABLE UNTIL WE WERE ABLE TO CUT THE REMAINING LENGTH OF STEEL CABLE HANGING FROM THE VEHICLE ONTO THE ROADWAY WITH WIRE CUTTERS. THE DOOR NOW IS A MANUAL SLIDING DOOR UNTIL THE ENTIRE MOTOR AND STEEL CABLE SYSTEM CAN BE REPLACED.
NHTSA complaint #10548002 — an unverified report by a vehicle owner.
at 160,000 milesWoodside, NY
ELECTRICAL SYSTEM
THE STEEL CABLE FOR THE POWER SLIDING DOOR SNAPPED WHILE DOOR WAS BEING OPENED ELECTRONICALLY. THE RIGHT SIDE SLIDING DOOR WAS UNABLE TO OPEN WIDER THAN A FOOT SINCE THE CABLE SNAPPED WHILE IN OPERATION. PASSENGERS, INCLUDING CHILDREN, HAD TO EXIT THE PARKED VEHICLE THROUGH THE DRIVER'S SIDE SLIDING DOOR INTO ONCOMING TRAFFIC. THE DOOR REMAINED INOPERABLE UNTIL WE WERE ABLE TO CUT THE REMAINING LENGTH OF STEEL CABLE HANGING FROM THE VEHICLE ONTO THE ROADWAY WITH WIRE CUTTERS. THE DOOR NOW IS A MANUAL SLIDING DOOR UNTIL THE ENTIRE MOTOR AND STEEL CABLE SYSTEM CAN BE REPLACED.
NHTSA complaint #10548002 — an unverified report by a vehicle owner.
at 275,000 milesKirtland, OH
SERVICE BRAKES
WITHIN THE LAST YEAR I HAVE REPLACED MY BRAKE PADS REPLACE 3 TIMES. JUST LAST MONTH I REPLACED MY PADS , ROTORS AND CALIPERS. BUT NOW MY PADS ARE GRINDING REALLY BAD AGAIN AND IT'S BEEN 30 DAYS SINCE I HAD NEW PADS, ROTORS AND CALIPERS PUT ON. SOMETHING IS DEFINITELY WRONG! I'M WORRIED ABOUT THE SAFETY OF TOYOTA SIENNA VAN.
NHTSA complaint #10546474 — an unverified report by a vehicle owner.
at 170 milesRapid City, SD
ELECTRICAL SYSTEM
INSTRUMENT AND VEHICLE LIGHTS BEGAN TO FLICKER. ELECTRIC DRIVERS SEAT WORKS RANDOMLY AND BACKGROUND LIGHT FOR RADIO HAS STOPPED WORKING AS WELL AS THE CRUISE LIGHT STOPPED WORKING ON THE INSTRUMENT DISPLAY.
NHTSA complaint #10537066 — an unverified report by a vehicle owner.
at 145,000 milesRapid City, SD
ELECTRICAL SYSTEM
THE REAR AUTOMATIC SLIDING DOOR FAILS TO OPEN OR CLOSE. CAN NO LONGER BE OPENED MANUALLY FROM INSIDE OR OUTSIDE. SEEN REPORTS OF SAME OR SIMILAR ISSUES ON LINE. OTHER ELECTRICAL ISSUES HAVE APPEARED WITH THE VEHICLE AS WELL.
NHTSA complaint #10537064 — an unverified report by a vehicle owner.
at 115,699 milesSAN Ramon, CA
SEATS
TL* THE CONTACT OWNS 2001 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT PASSENGER'S SEAT INDEPENDENTLY MOVED BACK AND FORTH. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE FRONT PASSENGER'S BACK REST BOLT WAS FRACTURED AND SEPARATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 115,699.
NHTSA complaint #10525762 — an unverified report by a vehicle owner.
