Owners have filed 148 complaints
about the 1997 Toyota Tacoma with NHTSA between 1997 and 2025.
The largest single group is the body & structure.
Across this model's run it ranks 31 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 22
Against the median year of the Toyota Tacoma. 50 means typical for this
model; 100 means roughly double.
Severity — 87
16.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 5
3% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
1928.8%
Frame AND Members
1624.2%
Underbody Shields
913.6%
Retractor
710.6%
Tread/Belt
69.1%
Leaf Spring Assembly
46.1%
Frontal
34.5%
Leaf
23.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
11.6%
25,000 – 49,999 miles
11.6%
50,000 – 74,999 miles
58.1%
75,000 – 99,999 miles
711.3%
100,000 – 149,999 miles
1829.0%
150,000+ miles
3048.4%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
1997 Toyota Tacoma
—
—
—
—
1997 Toyota Tacoma Extended Cab
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 1997peak 9Nov 2025
Recalls on the 1997 Toyota Tacoma
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
06E049000
EXTERIOR LIGHTING
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 1997141177 units in Canada
Other
THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 120 - TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS. COMPLIANCE LABEL CONTAINS AN INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATION. CORRECTION: CORRECT COMPLIANCE LABEL WILL BE INSTALLED ON AFFECTED VEHICLES.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 98,000 milesSarasota, FLCrash1 injured
AIR BAGS
DRIVING SOUTH ON MACINTOSH RD. TRIED TO AVOID HITTING A CAR THAT MADE AN ILLEGAL U-TURN IN FRONT OF ME. I RAN INTO THE WALL HARD ENOUGH TO KNOCK THE WALL (CEMENT) DOWN. THE AIR BAG DID NOT DEPLOY. I RECEIVED A CONCUSSION, AND AM STILL HAVING PROBLEMS WITH SIDE EFFECTS A YEAR LATER. ACCIDENT HAPPENED MAY 12, 2014.
NHTSA complaint #10723308 — an unverified report by a vehicle owner.
at 165,000 milesClackamas, ORCrash1 injured
AIR BAGS
WAS IN A TERRIBLE COLLISION AND ROLL OVER IN 1996 TOYOTA TACOMA AND BOTH THE PASSENGER AND DRIVERS SIDE AIRBAGS DID NOT DEPLOY. I SUSTAIN MAJOR FRACTURED FACE RESULTING IN RECONSTRUCTIVE SURGERY AND NOW HAVE NECK PROBLEMS AND FIBROMYALGIA.
NHTSA complaint #10631731 — an unverified report by a vehicle owner.
Jamestown, NYCrash
AIR BAGS:FRONTAL
CONSUMER HAD LOST CONTROL OF HIS VEHICLE AND HIT A GUARDRAIL AT A HIGH SPEED. UPON THE COLLISION, THE AIRBAGS FAILED TO DEPLOY. *LA (LAWYER MARY SPEEDY HAJDU ON BEHALF OF CONSUMER KENNETH C. MILLER)
NHTSA complaint #10059438 — an unverified report by a vehicle owner.
Chipley, FLCrash2 injured
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
WHILE DRIVING AND WITHOUT WARNING, THE UPPER BALL JOINT BROKE AND THE FRONT WHEEL CAME OFF, RESULTING IN A ROLLOVER, THERE WERE 2 INJURIES.*AK. CONSUMER BELIEVES THAT PART WAS DEFECTIVE AND THAT MANUFACTURER SHOULD REPLACE VEHICLE.
NHTSA complaint #8006014 — an unverified report by a vehicle owner.
Somerset, KYCrash
POWER TRAIN:MANUAL TRANSMISSION
DATE OF PURCHASE TOYOTA OF SOMERSET REPORTED THIS WAS A SECOND BUYER. THEY REPORTED A LADY HAD OWNED THE VEHICLE. THROUGH CARFAX I FOUND ME TO BE THE 5TH OWNER. THEY DID NOT HAVE THE WARRANTY INFORMATION IN WITH THE MANUAL INFORMATION. THEY DID NOT SUPPLY THIS AT TIME OF PURCHASE AND HAS NOT OFFERED UPON REQUEST. THEY SAID THEY WOULD HONOR THE SERVICE. UPON THE REVERSE COMING OUT THERE WAS DISAGREEMENT AND THE SERVICE MANAGER, MR. TURPIN AND MR. JOHNSON WERE VERY ADAMANT AND REFUSED TO HONOR THE MFG. WARRANTY ON THE DRIVE TRAIN. THEY FIRST ASKED $700 AND THEN NEGOTIATED FOR $450. WHICH I REFUSED. NEEDLESS TO SAY WE DO NOT HAVE ANY CORRESPONDENCE BUT I STILL HAVE TO DRIVE WITHOUT REVERSE IN MY VEHICLE. THIS IS WHY I DID NOT REPORT THE LUG NUTS BREAKING AND CAUSING MY WHEEL TO FALL OFF AND CAUSING DAMAGE TO THE TRUCK. TOYOTA OF SOMERSET DOES NOT OFFER ASSISTANCE AND ACCUSES ABUSE.
NHTSA complaint #741889 — an unverified report by a vehicle owner.
Somerset, KYCrash
WHEELS:LUGS/NUTS/BOLTS/STUDS
DATE OF PURCHASE TOYOTA OF SOMERSET REPORTED THIS WAS A SECOND BUYER. THEY REPORTED A LADY HAD OWNED THE VEHICLE. THROUGH CARFAX I FOUND ME TO BE THE 5TH OWNER. THEY DID NOT HAVE THE WARRANTY INFORMATION IN WITH THE MANUAL INFORMATION. THEY DID NOT SUPPLY THIS AT TIME OF PURCHASE AND HAS NOT OFFERED UPON REQUEST. THEY SAID THEY WOULD HONOR THE SERVICE. UPON THE REVERSE COMING OUT THERE WAS DISAGREEMENT AND THE SERVICE MANAGER, MR. TURPIN AND MR. JOHNSON WERE VERY ADAMANT AND REFUSED TO HONOR THE MFG. WARRANTY ON THE DRIVE TRAIN. THEY FIRST ASKED $700 AND THEN NEGOTIATED FOR $450. WHICH I REFUSED. NEEDLESS TO SAY WE DO NOT HAVE ANY CORRESPONDENCE BUT I STILL HAVE TO DRIVE WITHOUT REVERSE IN MY VEHICLE. THIS IS WHY I DID NOT REPORT THE LUG NUTS BREAKING AND CAUSING MY WHEEL TO FALL OFF AND CAUSING DAMAGE TO THE TRUCK. TOYOTA OF SOMERSET DOES NOT OFFER ASSISTANCE AND ACCUSES ABUSE.
NHTSA complaint #741889 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Palm Coast, FL
POWER TRAIN
When’s he start and you get gas it won turn off but don’t do it , and whend I hit a jump and I tuning he shake it wild
NHTSA complaint #11697175 — an unverified report by a vehicle owner.
Palm Coast, FL
SUSPENSION
When’s he start and you get gas it won turn off but don’t do it , and whend I hit a jump and I tuning he shake it wild
NHTSA complaint #11697175 — an unverified report by a vehicle owner.
Palm Coast, FL
ENGINE
When’s he start and you get gas it won turn off but don’t do it , and whend I hit a jump and I tuning he shake it wild
NHTSA complaint #11697175 — an unverified report by a vehicle owner.
Eugene, OR
UNKNOWN OR OTHER
It appears to be the clear coat of the paint job has been coming off for a very long time. Really does not look good at all now. I reside in the state of Oregon. Although it rains a fair amount here, that should not cause this rate of decay of the paint job. It was not painted very well!!
NHTSA complaint #11423372 — an unverified report by a vehicle owner.
at 172,000 milesBrentwood, NY
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE SHOOK AND THE SUBFRAME FRACTURED HALF. THE VEHICLE WAS DRIVEN TO THE SMITHTOWN TOYOTA DEALER LOCATED AT 360 JERICHO TURNPIKE, SMITHTOWN, NY 11787. WHERE IT WAS STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE CONTACT STATED THAT THE TECHNICIAN HAD NOT INSPECTED THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 172,000.
NHTSA complaint #11359783 — an unverified report by a vehicle owner.
at 172,774 milesBrentwood, NY
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME WAS EXTREMELY RUSTED, MAKING THE VEHICLE UNSAFE TO DRIVE. THE CONTACT STATED THAT A FRIEND TOLD HIM THAT THE FRAME WAS RUSTED AND NEEDED TO BE TAKEN TO THE DEALER. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 172,774.
NHTSA complaint #11344330 — an unverified report by a vehicle owner.
at 200,000 milesWare Shosls, SC
SUSPENSION
MY LEE SPRINGS ARE RUSTED FRAME IS TO LEE'S SPRINGS ARE BROKEN
NHTSA complaint #11338966 — an unverified report by a vehicle owner.
at 105,000 milesPlainwell, MI
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, THE MECHANIC FOUND THAT THE DRIVER'S SIDE FRAME AREA WAS CORRODED AND HAD HOLES. THE CONTACT STATED THAT THE MANUFACTURER PERFORMED A REPAIR UNDER WARRANTY FOR THE FRAME UNDERCOATING FOR 1995 TO 2005 TACOMA VEHICLES, WHICH DID NOT CORRECT THE CORROSION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS CONTACTED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 105,000.*PM CONSUMER STATED FRAME WAS ONCE COATED IN 2011, NOW PEELING AND CORRODED.
NHTSA complaint #11277282 — an unverified report by a vehicle owner.
at 120,000 milesLouisville, KY
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC TO HAVE THE MUFFLER REPLACED. THE MECHANIC STATED THAT THE VEHICLE COULD NOT BE REPAIRED DUE TO RUST ON THE FRAME. THE DEALER (TOYOTA OF LOUISVILLE, 6514 DIXIE HWY, LOUISVILLE, KY 40258) STATED THAT THE CONTACT NEEDED TO CALL THE MANUFACTURER. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE EXTENDED WARRANTY FOR THE FRAME EXPIRED ON JULY 31, 2014. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #11130221 — an unverified report by a vehicle owner.
Farmingville, NY
UNKNOWN OR OTHER
RECENTLY PURCHASED 97 TOYOTA TACOMA FROM PRIVATE OWNER WHO CLAIMS HE NEVER RECEIVED THE NOTIFICATIONS REGARDING THE FRAME WARRANTY EXTENSION FROM TOYOTA AND SUBSEQUENTLY HE NEVER HAD THE VEHICLE REPAIRED. NOW THE FRAME ON THE VEHICLE IS UNSAFE AND I NOTIFIED TOYOTA WHO CLAIMS THE EXTENSION EXPIRED AND THEY REFUSE TO DO ANYTHING TO HELP ME, HOPEFULLY SOMETHING CAN BE DONE BY SOMEONE BECAUSE THEY ARE ALLOWING UNSAFE VEHICLES TO STAY ON THE ROAD BECAUSE THEY DO NOT WANT TO PAY ANYMORE $ THEN THEY HAVE TO. MEANWHILE THEY ACKNOWLEDGE THAT THE FRAME ISSUE WAS CLEARLY THEIR FAULT. PLEASE HELP
NHTSA complaint #11120883 — an unverified report by a vehicle owner.
at 181,747 milesProspect, CT
STRUCTURE:BODY
TOOK VEHICLE TO CURRY HONDA TO HAVE PART INSTALLED AND THEY PERFORMED MULTI POINT INSPECTION. UPON INSPECTION FOUND FRAME IS RUSTED OUT AND VEHICLE IS UNSAFE TO DRIVE. HAVE NOT DRIVEN IT SINCE,AND AM WITHOUT A VEHICLE. CAN PROVIDE PHOTOS AND DOCUMENTATION.
NHTSA complaint #11089723 — an unverified report by a vehicle owner.
at 3,000 milesGreen Valley, AZ
STEERING
THE STEERING WHEEL BEGAN MAKING NOISES 7 MONTHS AFTER IT WAS PURCHASED NEW. DEALER TOOK THE DASH OUT, REPLACED SOMETHING AND PUT IT BACK TOGETHER AGAIN. 7 MONTHS LATER THE SOUND BEGAN AGAIN. THREE LETTERS TO TOYOTA COMPLAINING ABOUT THIS PROBLEM WERE TOTALLY IGNORED. I VISITED THE DEALER IN TUCSON, AZ ABOUT THIS AND I WANTED THE PROBLEM SOLVED AT TOYOTA EXPENSE. AGAIN I WAS PUT OFF AND THE RATTLE HAS PERSISTED TO THIS DAY. I AM TIRED OF LISTENING TO THIS RATTLE EVERY TIME I DRIVE THE TRUCK. IF THERE IS ANYTHING YOU CAN DO TO HELP ME GET THE TOYOTA FOLKS TO REPAIR, REPLACE OR PUT A GREASE FITTING ON THE DEFECTIVE PARTS IN THE COLUMN, PLEASE LET ME KNOW. THANK YOU.
NHTSA complaint #11074706 — an unverified report by a vehicle owner.
Nevada, IA
STRUCTURE:BODY
I BOUGHT THIS PICK UP FROM WILSON TOYOTA,(AMES,IA), ON JAN.17,2009.IN THE WALK AROUND/INSPECTION OF THE VEHICLE, WHILE TALKING WITH THE SALESMAN I LAYED ON THE GROUND,AND CRAWLED UNDER THE PICK UP LOOKING FOR ANY SIGNS OF TROUBLE. NOTING THE FRAME PROBLEMS I'D HAD WITH ANOTHER TOYOTA(1984) ASKED IF TOYOTA HAD "CLEANED" UP THEIR ACT AND MADE THE UNDER CARRIAGE ANY BETTER? WAS ASSURED "THAT THOSE PROBLEMS WERE ALL BEHIND THEM".FAST FORWARD ^ YEARS I'M PAYING A LOCAL BODY SHOP TO REPLACE THE REAR 60% OF THE FRAME @ A COST OF $1800.00.NOW I FIND I'M HAVING TO FIX/REPLACE PARTS OF THE FRONT END FRAME.
NHTSA complaint #11047712 — an unverified report by a vehicle owner.
at 240,000 milesMinooka, IL
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE VEHICLE WAS TAKEN TO A REPAIR SHOP FOR AN ALIGNMENT. THE TECHNICIAN STATED THAT A PART OF THE FRAME WAS MISSING DUE TO EXTREME RUST. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 240,000. UPDATED 06/02/17*LJ
NHTSA complaint #10966537 — an unverified report by a vehicle owner.
at 240,000 milesMinooka, IL
SUSPENSION
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE VEHICLE WAS TAKEN TO A REPAIR SHOP FOR AN ALIGNMENT. THE TECHNICIAN STATED THAT A PART OF THE FRAME WAS MISSING DUE TO EXTREME RUST. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 240,000. UPDATED 06/02/17*LJ
NHTSA complaint #10966537 — an unverified report by a vehicle owner.
Leon, WV
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE STRUCTURE WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
NHTSA complaint #10956129 — an unverified report by a vehicle owner.
Franklin, TX
SUSPENSION
THE TRUCK HAD BEEN RIDING ROUGHER ON THE ROADS WHEN FAMILY FOLLOWING ONE DAY NOTICED THE TRUCK LEANING LEFT. IT WAS BROUGHT TO THE REPAIR SHOP THINKING IT WAS A SUSPENSION PROBLEM. IT ENDED UP BEING MAJOR RUST AND CORROSION TO THE FRAME THAT WAS SO BAD THERE WAS NO STRUCTURAL SUPPORT OF THE STRUTS AND SPRINGS. OWNER OF THE AUTO SHOP AS WELL AS A BODY REPAIR SHOP IT WAS TAKEN TO SAID I WAS EXTREMELY LUCKY THERE WAS NO WRECK OR INJURY. THE PROBLEMS ARE SO EXTENSIVE THAT IT IS NOT SAFE TO DRIVE. NOW I AM STUCK WITH A TOYOTA TRUCK THAT SHOULD HAVE LASTED EASILY ANOTHER 100,000 MILES. THE FRAME WAS EXPECTED TO LAST LONGER THEN THE TRUCK WHEN PURCHASED AS TOYOTA USED TO BE A GOOD COMPANY AND PRODUCT. MY FIRST TRUCK WAS A TOYOTA BACK IN 1976. THERE WAS A RECALL THAT I WAS NEVER NOTIFIED OF REGARDING THIS PROBLEM. THE PERSONAL AND FINANCIAL IMPACT THIS HAS CAUSED IS SIGNIFICANT. TOYOTA NEEDS TO MAKE RESTITUTION AS EVIDENCE INDICATES IT HAS BEEN A LONG STANDING PROBLEM WITH CHEAPER/INFERIOR FRAMES USED BY TOYOTA GOING BACK SEVERAL YEARS. THE CURRENT MILEAGE IS 188,000, BUT THE PROBLEMS HAS EXISTED FOR AWHILE BASED ON THE AMOUNT OF DAMAGE.
NHTSA complaint #10934477 — an unverified report by a vehicle owner.
Franklin, TX
STRUCTURE:BODY
THE TRUCK HAD BEEN RIDING ROUGHER ON THE ROADS WHEN FAMILY FOLLOWING ONE DAY NOTICED THE TRUCK LEANING LEFT. IT WAS BROUGHT TO THE REPAIR SHOP THINKING IT WAS A SUSPENSION PROBLEM. IT ENDED UP BEING MAJOR RUST AND CORROSION TO THE FRAME THAT WAS SO BAD THERE WAS NO STRUCTURAL SUPPORT OF THE STRUTS AND SPRINGS. OWNER OF THE AUTO SHOP AS WELL AS A BODY REPAIR SHOP IT WAS TAKEN TO SAID I WAS EXTREMELY LUCKY THERE WAS NO WRECK OR INJURY. THE PROBLEMS ARE SO EXTENSIVE THAT IT IS NOT SAFE TO DRIVE. NOW I AM STUCK WITH A TOYOTA TRUCK THAT SHOULD HAVE LASTED EASILY ANOTHER 100,000 MILES. THE FRAME WAS EXPECTED TO LAST LONGER THEN THE TRUCK WHEN PURCHASED AS TOYOTA USED TO BE A GOOD COMPANY AND PRODUCT. MY FIRST TRUCK WAS A TOYOTA BACK IN 1976. THERE WAS A RECALL THAT I WAS NEVER NOTIFIED OF REGARDING THIS PROBLEM. THE PERSONAL AND FINANCIAL IMPACT THIS HAS CAUSED IS SIGNIFICANT. TOYOTA NEEDS TO MAKE RESTITUTION AS EVIDENCE INDICATES IT HAS BEEN A LONG STANDING PROBLEM WITH CHEAPER/INFERIOR FRAMES USED BY TOYOTA GOING BACK SEVERAL YEARS. THE CURRENT MILEAGE IS 188,000, BUT THE PROBLEMS HAS EXISTED FOR AWHILE BASED ON THE AMOUNT OF DAMAGE.
NHTSA complaint #10934477 — an unverified report by a vehicle owner.
at 210,000 milesNorth Bend, WA
SUSPENSION
I HAVE RUSTY HOLES IN MY FRAME AND TOYOTA WONT FIX SOMETHING THAT IS SO DANGEROUS AND NOW MY TACOMA IS UNSAFE TO DRIVE, WHAT AM I SUPPOSE TO DO NOW?!
NHTSA complaint #10916691 — an unverified report by a vehicle owner.
at 137,000 milesAshland, MO
SEAT BELTS
1997 TACOMA FRAME RUST AT LEADING EDGE OF REAR AXLE LEAF SPRINGS ALLOWED THE LEAF SPRINGS TO BECOME DETACHED FROM THE VEHICLE RENDERING THE VEHICLE UNSAFE TO DRIVE. THE SHOULDER LAP SEAT BELTS DO NOT RECOIL.
NHTSA complaint #10904665 — an unverified report by a vehicle owner.
at 137,000 milesAshland, MO
STRUCTURE:BODY
1997 TACOMA FRAME RUST AT LEADING EDGE OF REAR AXLE LEAF SPRINGS ALLOWED THE LEAF SPRINGS TO BECOME DETACHED FROM THE VEHICLE RENDERING THE VEHICLE UNSAFE TO DRIVE. THE SHOULDER LAP SEAT BELTS DO NOT RECOIL.
NHTSA complaint #10904665 — an unverified report by a vehicle owner.
at 232,828 milesCanada, KY
SUSPENSION
RECENTLY PURCHASE 1997 TACOMA TOOK IT TO REPLACE REAR TIRES SHOP INFORMED ME THE FRAME HAD MAJOR ROT AND IS NOT SAFE FOR HIGHWAY. CONTACTED LOCAL TOYOTA DEALER THEY PREFORMED A FREE INSPECTION ON 08-29-16 UPON COMPLETION OF THIS INSPECTION DEALERSHIP INFORMED ME BOTH IN WRITING AND VERBALLY THAT THIS VEHICLE IS NOT SAFE FOR HIGHWAY USE. MULTIPLE RUST PERFORATIONS THROUGH OUT FRAME OF THIS TRUCK. DEALERSHIP INFORMED ME THAT THE RECALL ON THE FRAME HAD EXPIRED HOWEVER THEY STATED THAT IF WE FILE A FORMAL COMPLAINT WITH TOYOTA THROUGH YOUR ORGANIZATION THAT WE COULD POSSIBLILY GET A CASH SETTLEMENT FOR THIS TACOMA.
NHTSA complaint #10899267 — an unverified report by a vehicle owner.
at 189,000 milesOakhurst, NJ
SUSPENSION
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, THE TECHNICIAN INFORMED THAT THE SUB FRAME, THE LEFT REAR WHEEL, THE LEAF SPRINGS AND THE CHASSIS WERE SEVERELY CORRODED AND THE VEHICLE WAS UNSAFE TO BE DRIVEN. THE MANUFACTURER WAS NOTIFIED AND INFORMED THAT THE CORROSION BUY BACK PROGRAM WAS NO LONGER VALID. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 189,000.
NHTSA complaint #10898772 — an unverified report by a vehicle owner.
at 160,000 milesBurnsville, NC
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1997 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE WAS RUSTED, WHICH MADE THE VEHICLE UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 160,000.
NHTSA complaint #10870401 — an unverified report by a vehicle owner.
at 208,000 milesPasadena, MD
SUSPENSION
FRAME RUST. NOT MADE AWARE OF RECALL OR EXTENDED WARRANTY. FRAME IS SEVERELY CORRODED AND HAS A HOLE WHERE THE SHOCK ABSORBER USE TO MOUNT. IT LITERALLY FELL OFF DUE TO RUST. SEVERAL OTHER AREAS SHOWING SIGNS OF CORROSION AS WELL. SEEMS THIS IS NOT AN UNCOMMON PROBLEM. NOT SURE IT IS SAFE TO DRIVE. TOYOTA DEALERSHIP SAYS THERE IS NOTHING THEY CAN DO.
NHTSA complaint #10820450 — an unverified report by a vehicle owner.
