309 of the
2,009 complaints filed about the Volkswagen Golf
are about the fuel system —
15% of everything owners reported.
The worst model year for it is 2017.
Vehicle brought in for Recall 20UF (fuel tank suction pump fire risk) on 04/15/2026. Upon pickup after approximately one week of dealer service, a strong chemical odor was present in the cabin that did not exist prior to service. Odor persists despite cabin air filter replacement with activated charcoal filter, professional carpet shampooing, and extended airing out over several weeks. Dealer dismissed concerns and suggested owner pay for cabin filter replacement which had no effect. VW's own Recall 20UF documentation acknowledges that fuel odor may be noticed by occupants when the recall condition exists. Requesting investigation into whether recall repair was fully completed and whether odor is related to incompletely resolved recall condition. A neighbor experienced identical odor issue after bringing their Tiguan to a different Westchester dealer for service.
NHTSA complaint #11741116 — an unverified report by a vehicle owner.
Took my car into VW in Johnson City TN because my millage has been dropping drastically. Went from about 420 miles to a tank, down to less than 300. There is hesitation and jerking when I accelerate as well as a gasoline odor in the cab of the vehicle after refueling. Service manager said there was no code thrown and when he took it for a drive her drove “conservatively” and the mpg was normal. They did not physically inspect the fuel pump jet and gaslit me saying it was how I’m driving. Refused to actually look at the problem and then threatened that if I wanted them to look they would charge me for the labor. They did not seem concerned that a safety hazard of smelling fuel in the cab and poor fuel efficiency was an issue.manager said he knew of the active extended recall but hid behind the no code from their scanner instead of listening to the customer who voiced concerns. They didn’t want to do the work if they had to pay for it.
NHTSA complaint #11740201 — an unverified report by a vehicle owner.
SUPPLEMENTAL INFORMATION OF ODI COMPLAINT NUMBER 11740201. I am submitting critical supplemental information to my active safety complaint regarding a 2018 Volkswagen Golf SportWagen (1.8T engine). My primary safety issues are a severe drop in fuel efficiency (cut completely in half), heavy vehicle hesitation/jerking during acceleration, and a powerful raw gasoline smell inside the cabin immediately after fueling. These symptoms heavily align with the known physical failures covered under Volkswagen's Suction Jet Pump safety campaigns. I took my vehicle to the Volkswagen dealership today for a diagnostic inspection. The service manager initially dismissed my complaints, refused to physically check the EVAP charcoal canister or suction pump, and claimed that my 50% drop in fuel economy was merely due to my 'driving style.' However, upon forcing me to pay a $136 diagnostic fee to retrieve my keys, the official paperwork provided by the dealership directly contradicted the manager. The technician documented finding a physical fuel leak. Alarmingly, this is the exact same 'small fuel leak' that this specific dealership claimed to have fully repaired a few months ago. That previous visit occurred because my steering wheel completely locked up while driving, nearly causing a severe accident—an issue the dealership also dismissed at the time because it 'failed to throw an error code.' The dealership has demonstrated a reckless pattern of ignoring severe mechanical safety hazards—including steering failures and active, recurring fuel leaks—solely because the vehicle's computer does not register a digital fault code. I am trapped driving a vehicle that is actively leaking fuel, smelling of raw gas inside the passenger cabin, and suffering from dangerous acceleration hesitation due to an unresolved fuel-system defect. I request a formal investigation into this ongoing safety hazard and the dealer's failure to remedy it.
NHTSA complaint #11740222 — an unverified report by a vehicle owner.
The contact owns a 2022 Volkswagen Golf. The contact stated that while driving at various speeds, the check engine warning light remained illuminated. The vehicle was taken to an independent mechanic, and it was determined that there was a leak in the evaporative emissions system after scanning the vehicle and retrieving DTC: P0456. The contact associated the failure with NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline). The local dealer was contacted; however, the vehicle was not diagnosed or repaired because the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 17,000.
NHTSA complaint #11717877 — an unverified report by a vehicle owner.
Sirs: I am reporting TWO issues: One: My car should have been included in the recall campaign for rear coil spring fracture that other 2015 Golfs have experienced. I had to pay to replace fractured rear coil springs myself, last year. Two: Volkswagen has made it impossible for me to get ANY recall performed, including the suction fuel pump recall. After I filed a 1 star review for the utter failure of the Ithaca NY VW dealer to repair my brakes in late October 2021, the service manager retaliated. He called and assailed me with four letter language. Afterward, I made an appointment with another local VW dealer AT RANDOM, and one I had never done business with. Before I could identify myself or my VIN number this second dealer proceded to accuse me of being a deadbeat who does not pay his bills. He said if I came to his shop, I would pay in advance for any servicing. I would have to agree to surrender my car for an indeterminate time, and pay to strip it of all aftermarket parts at my expense, before even proceeding with diagnosis. It was apparent to me that the service manager had badmouthed me to ALL the local dealerships. I am in effect, blacklisted. I complained to Volkswagen corporation about this treatment in writing. I sent them proof of payment. They refused to help me. There is so much hostility coming from VW dealers, that I don't feel I can trust them to do safety recalls. I don't deserve this. I've always been polite and paid my bills immediately. The Ithaca dealer was paid for their diagnosis, even though they lied to me about the problem and never fixed the brakes. I want VW to provide the parts and servicing information for the suction pump recall. I will find an independent mechanic to do the repairs.
NHTSA complaint #11707246 — an unverified report by a vehicle owner.
In December 2021, my fuel gauge read empty, so I stopped at a gas station near the Honolulu Airport and VW Honolulu dealership. As I was pumping the gasoline, it began overflowing from the top of the tank, although I had just started pumping. I immediately removed the pump which is when gas began leaking out of the bottom of the tank, like a faucet. Luckily, I was right by the dealership, and was able to make it there without anything dangerous happening. After assessing my vehicle, the VW technicians said there was an internal issue with a faulty fuel tank. They said this issue was not something that I caused. Attached are the invoices and notes provided by the technicians. I paid $3,877 to get the problem fixed.
NHTSA complaint #11689572 — an unverified report by a vehicle owner.
The EPC light has luminated 3 times in the last several months. The vehicle stutters and will not accelerate past 25 MPH. Shutting off the engine and restarting it clears the light and vehicle drives normally. The check engine light does not illuminate and no OBDII codes are stored. Manual states to take vehicle to authorized dealership for diagnosis if light stays illuminated.
NHTSA complaint #11688624 — an unverified report by a vehicle owner.
I was driving my vehicle on the highway when a driver stopped me and warned me that my vehicle was leaking a huge amount of gasoline. I had a technician inspect the car to see if it might be a fuel line, the technician told me the fuel.lines were good and there were no signs of the gas coming from the lines and no cracks on the tank either. I received a letter from Volkswagen about the recall and I researched it and it says that if that is the problem the car would be leaking gas and it was dangerous as an ignition might cause a fire. I towed my vehicle to the Volkswagen here in Laredo after calling and speaking to someone from service and told yes I could bring it in and the recall part would be replaced free but I would have to leave the vehicle there. When I arrived they told me I would have to pay a diagnostic of 185 dlls and the repair. Which was not what I was told when I called earlier. So I had to pay again to have the vehicle removed from the premises without having the recall part changed.
NHTSA complaint #11656404 — an unverified report by a vehicle owner.
I brought my 2015 Volkswagen (with only 50,000 miles) to Island Volkswagen in NY for a fuel system recall repair. Before this, the car had no fuel smell, no leaks, and was driving normally. Immediately after the recall work, I began smelling fuel. The dealership told me the fuel line is leaking and needs to be replaced. I never had this issue before, and it’s clearly related to the repair they performed. I’m now being told I must pay $550 out of pocket for something I believe was caused by their handling of the fuel system during the recall. This is a serious safety concern. If I drive this car and something goes wrong, it could result in a fire. I believe this issue deserves review, especially if other drivers experience similar problems after this recall.
NHTSA complaint #11653103 — an unverified report by a vehicle owner.
Car began spraying fuel upon turning the key in the ignition. Recall work pertaining to the suction jet pump was recently performed and is the only likely cause of this issue. Car did not leak when fuel pump was disengaged. Very lucky that issue occurred in a parking lot while not moving and did not lead to a fire or crash.
NHTSA complaint #11627766 — an unverified report by a vehicle owner.
The contact owns a 2015 Volkswagen Golf. The contact stated while driving at an undisclosed speed, the fuel gauge level dropped quickly, and there was an abnormal fuel odor before the vehicle shutoff in the middle of the roadway. The contact stated that the check engine warning light was illuminated. The contact exited the vehicle and push the vehicle to the side of the road. The contact stated that while checking underneath the vehicle, the contact became aware of a fuel leak. The vehicle was towed to an independent mechanic to be diagnosed. The independent mechanic confirmed the fuel leak and referred the contact to the dealer for assistance with the repair. The vehicle was not yet repaired. The contact referenced NHTSA Campaign Number: 24V110000 (FUEL SYSTEM, GASOLINE) as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 111,000.
NHTSA complaint #11626162 — an unverified report by a vehicle owner.
My EPC light began to appear randomly in early 2024. I received a recall notice on the gear shift trim around the same time, so called Jack Ingram VW in Montgomery to schedule a time for them to fix it (and also ensure they had the part). I asked them to also check on why the EPC light was coming on. Brought in my car on 2/28/24. Service Dept then tells me they weren't sure what was causing the EPC light to come on, and they didn't have the gear shift trim part. They quoted me a lot of work to do, which I wasn't prepared financially to have completed. EPC light continued to appear at random. Each time it did, my car would shake and it would feel like I was losing control of the vehicle. I received another recall notice for the suction jet pump inside the fuel tank. When I called Jack Ingram VW to schedule this work, I asked if this had anything to do with my EPC light coming on. They weren't sure. The recall work for both the suction jet pump inside the fuel tank and the gear shift trim were completed on 8/28/24. Car worked fine until about a month later and the EPC light came on again. Called another VW mechanic in Montgomery (Powell's Automotive) to see if they can fix it. On 9/20/24 they replaced battery, spark plugs, ignition coil, and did an oil change. Worked great until [XXX] when my engine failed and left me stranded in the road. There were no warning lights prior to the engine failing. Could not restart car. Had it towed to Powell's who could not fix it, then to Jack Ingram VW. I asked them if this had anything to do with the recall work that was done. They said this would be the first if it was. They told me the in tank fuel pump needed replacing. Work completed 10/25/24. How can they work on the suction jet pump inside the fuel tank and not get a diagnostic that the in tank fuel pump was failing? I've already paid a lot of money to try to resolve the issue, and my EPC light is still coming on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11623672 — an unverified report by a vehicle owner.
The component that failed, according to Volkswagen, is the rollover valve in the gas tank. This issue caused large amounts of gasoline to leak and pool from behind the rear passenger wheel well, creating a significant fire hazard and risk of harm. The vehicle was inspected by a Volkswagen service center as part of the repair process, whereupon the Volkswagen service center documented that the issue was caused by a faulty rollover valve in the gas tank. There were no warning lamps, messages, or other symptoms prior to the failure.
NHTSA complaint #11622253 — an unverified report by a vehicle owner.
I had a suction jet pump recall due on the car. I took it to the dealer to fix. Mind you, I have never had an issue with this car ever. Now about a week later from the car being in the shop I get an engine malfunction light that comes on due to the evap system. Vw dealership of cool springs has not worked with me on this at all and it is frustrating to say the least.
NHTSA complaint #11616046 — an unverified report by a vehicle owner.
Car has been leaking fuel for over a year. Had to pay out of pocket to get it fixed and VW refused to refund cost of repairs even though there is now a recall over a year later acknowledging the issue.
NHTSA complaint #11611590 — an unverified report by a vehicle owner.
I was driving to my grandparents house and once i got to the house there was gasoline dripping from the back of car, from the area of the tank. "61821 SE VERIFICO UNIDAD CON LIQUEO DE GASOLINA , SE VERIFICO Y SE ENCONTRO CHARCOL CANISTER LLENO DE GASOLINA , SE HIZO TEST PLAN Y SE ENCONTRO VALVULA INTERNA DEL TANQUE DE LA GASOLINA TRANCADA Y ESTO OCASIONANDO LIQUEO DE GASOLINA , SE REMOVIO Y SE INSTALO TANQUE DE GASOLINA NUEVO Y CANISTER DE LOS GASES NUEVO Y VALVULA N80 NUEVA Y SE LIMPIARON TODAS LAS LINES DEL SISTEMA , SE HIZO TEST Y NO PRESENTO LIQUEO DE GASOLINA" - Mecanic
NHTSA complaint #11609559 — an unverified report by a vehicle owner.
This has been an open recall for 5 years and the manufacturer will not fix it. This could lead to vehicle fires and injuries.. It is not acceptable that Volkswagen can just ignore these safety recalls!
NHTSA complaint #11609117 — an unverified report by a vehicle owner.
The contact owns a 2017 Volkswagen Golf. The contact stated that after refueling the vehicle, the contact became aware that the fuel had been consumed extremely quickly. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.
NHTSA complaint #11608176 — an unverified report by a vehicle owner.
Starting January 2023, I had issues putting fuel in my car (symptoms align with the recall issued this year). I took it to VW and paid their diagnostic fee for them to say there’s nothing wrong with the car (approx. $170) continued to drive the car and eventually due to the issue, my fuel pump went out and I had to replace it. (See attached image). This time, I took the car to a local mechanic who charged a $100 diagnostic fee. All of this was prior to the recall this year and I am hoping for reimbursement on everything I spent trying to resolve this issue.
NHTSA complaint #11607650 — an unverified report by a vehicle owner.
July 30,2024 I own a Golf 2017. My suction jet pump has failed. I cannot drive my car because I can't put gas into it. I need my car for work. The recall does not have the part available and it seems there hasn't been a part to fix this for a very long time. I'm really at a loss. What are my next steps? Should I report this to the Better Business Bureau? So far I've been on Volkswagen Of America's phone wait for 40 minutes. I've already taken my car to a dealership to have this problem verified. There were no warning messages.
NHTSA complaint #11605426 — an unverified report by a vehicle owner.