2015 Volkswagen Golf problems

SUSPENSION

While driving at approx 65 mph on a highway, I heard a loud thunk from the left rear side of my 2015 VW Golf and the car swerved a little bit. I was thankfully able to control the car and get myself to safety. A family member looked under the car and the broken coil spring was clearly visible, with a very sharp end at the point it broke, right next to the tire... could have been a disaster. I had the car towed to a local VW dealership where they confirmed the broken spring and replaced both rear coil springs.There was no warning about this issue in the form of symptoms, messages, or warning lights; it just happened suddenly. I've read that there was a recall for precisely this issue in 2019 (see NHTSA 19V188000), but apparently my VIN was (erroneously) not part of that recall.

NHTSA complaint #11757149 — an unverified report by a vehicle owner.

AIR BAGS

15V483000 (VW Recall Code 69L2) was issued for 2014 Volkswagen Golf's indicating a "clock spring" affecting a cable that powers the air bag. This is indicated also by the airbag emergency light coming on. I believe a similar, if not the same, issue is occurring in my 2015 VW Golf. Furthermore, the issue has affected all mechanical buttons on the steering wheel. I had taken my vehicle to a VW mechanic that indicated a recall had been issued for this problem. However, upon my own further investigation, I found 2014 was the cut off year for the recall. The issue appeared during the winter last year. I did contact my nearest VW dealership to instigate as to if this issue could be repaired under the aforementioned recall for the 2014. I was informed they could not. As this is an issue in pervious models and is a safety concern, I am issuing this letter in hopes this safety issue could be repaired at the expense of Volkswagen.

NHTSA complaint #11750947 — an unverified report by a vehicle owner.

SUSPENSION

Rear strut completely broke

NHTSA complaint #11744671 — an unverified report by a vehicle owner.

SUSPENSION

The right rear coil spring on my 2015 Volkswagen Golf fractured suddenly while the vehicle was completely stationary in a parking lot. There was no collision, pothole impact, curb strike, road hazard, or other external event that could reasonably explain the failure. The incident was captured on dash cam video. The failed component is the right rear suspension coil spring. I will retain the broken component and make it available for inspection upon request, although the vehicle must be repaired immediately because it is my primary means of transportation. Volkswagen has previously acknowledged potential manufacturing and material defects involving rear axle coil springs in technical service bulletin/campaign 42J5, which states that certain rear axle coil springs may not have met factory specifications due to defective materials or production process issues. This failure created a significant safety concern because a fractured coil spring can shift position, puncture a tire, damage suspension or brake components, or cause instability and loss of vehicle control if the failure occurs while driving at speed. In this case, the spring failed while the car was parked and stationary, but the same spontaneous failure could have occurred during highway driving. The defect has been confirmed by both an independent repair shop and a Volkswagen specialist, and I have written repair estimates documenting the broken spring. The vehicle and component have not been inspected by Volkswagen because the dealership required approximately $200 solely for diagnostic inspection despite the visible and documented mechanical failure. There were no warning lights, dashboard messages, noises, drivability symptoms, or other indications of impending failure prior to the incident. The spring failed without warning. I contacted Volkswagen/dealership personnel seeking goodwill assistance due to the known spring defect issue and the unusual circumstances of the failure, but was denied.

NHTSA complaint #11739492 — an unverified report by a vehicle owner.

SUSPENSION

Sirs: I am reporting TWO issues: One: My car should have been included in the recall campaign for rear coil spring fracture that other 2015 Golfs have experienced. I had to pay to replace fractured rear coil springs myself, last year. Two: Volkswagen has made it impossible for me to get ANY recall performed, including the suction fuel pump recall. After I filed a 1 star review for the utter failure of the Ithaca NY VW dealer to repair my brakes in late October 2021, the service manager retaliated. He called and assailed me with four letter language. Afterward, I made an appointment with another local VW dealer AT RANDOM, and one I had never done business with. Before I could identify myself or my VIN number this second dealer proceded to accuse me of being a deadbeat who does not pay his bills. He said if I came to his shop, I would pay in advance for any servicing. I would have to agree to surrender my car for an indeterminate time, and pay to strip it of all aftermarket parts at my expense, before even proceeding with diagnosis. It was apparent to me that the service manager had badmouthed me to ALL the local dealerships. I am in effect, blacklisted. I complained to Volkswagen corporation about this treatment in writing. I sent them proof of payment. They refused to help me. There is so much hostility coming from VW dealers, that I don't feel I can trust them to do safety recalls. I don't deserve this. I've always been polite and paid my bills immediately. The Ithaca dealer was paid for their diagnosis, even though they lied to me about the problem and never fixed the brakes. I want VW to provide the parts and servicing information for the suction pump recall. I will find an independent mechanic to do the repairs.

NHTSA complaint #11707246 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Sirs: I am reporting TWO issues: One: My car should have been included in the recall campaign for rear coil spring fracture that other 2015 Golfs have experienced. I had to pay to replace fractured rear coil springs myself, last year. Two: Volkswagen has made it impossible for me to get ANY recall performed, including the suction fuel pump recall. After I filed a 1 star review for the utter failure of the Ithaca NY VW dealer to repair my brakes in late October 2021, the service manager retaliated. He called and assailed me with four letter language. Afterward, I made an appointment with another local VW dealer AT RANDOM, and one I had never done business with. Before I could identify myself or my VIN number this second dealer proceded to accuse me of being a deadbeat who does not pay his bills. He said if I came to his shop, I would pay in advance for any servicing. I would have to agree to surrender my car for an indeterminate time, and pay to strip it of all aftermarket parts at my expense, before even proceeding with diagnosis. It was apparent to me that the service manager had badmouthed me to ALL the local dealerships. I am in effect, blacklisted. I complained to Volkswagen corporation about this treatment in writing. I sent them proof of payment. They refused to help me. There is so much hostility coming from VW dealers, that I don't feel I can trust them to do safety recalls. I don't deserve this. I've always been polite and paid my bills immediately. The Ithaca dealer was paid for their diagnosis, even though they lied to me about the problem and never fixed the brakes. I want VW to provide the parts and servicing information for the suction pump recall. I will find an independent mechanic to do the repairs.

NHTSA complaint #11707246 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I brought my 2015 Volkswagen (with only 50,000 miles) to Island Volkswagen in NY for a fuel system recall repair. Before this, the car had no fuel smell, no leaks, and was driving normally. Immediately after the recall work, I began smelling fuel. The dealership told me the fuel line is leaking and needs to be replaced. I never had this issue before, and it’s clearly related to the repair they performed. I’m now being told I must pay $550 out of pocket for something I believe was caused by their handling of the fuel system during the recall. This is a serious safety concern. If I drive this car and something goes wrong, it could result in a fire. I believe this issue deserves review, especially if other drivers experience similar problems after this recall.

NHTSA complaint #11653103 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2015 Volkswagen Golf. The contact stated while driving at an undisclosed speed, the fuel gauge level dropped quickly, and there was an abnormal fuel odor before the vehicle shutoff in the middle of the roadway. The contact stated that the check engine warning light was illuminated. The contact exited the vehicle and push the vehicle to the side of the road. The contact stated that while checking underneath the vehicle, the contact became aware of a fuel leak. The vehicle was towed to an independent mechanic to be diagnosed. The independent mechanic confirmed the fuel leak and referred the contact to the dealer for assistance with the repair. The vehicle was not yet repaired. The contact referenced NHTSA Campaign Number: 24V110000 (FUEL SYSTEM, GASOLINE) as a possible cause for the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 111,000.

NHTSA complaint #11626162 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

When I turn on the ignition it says on the screen Starting system fault please service the vehicle.

NHTSA complaint #11621842 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I was driving to my grandparents house and once i got to the house there was gasoline dripping from the back of car, from the area of the tank. "61821 SE VERIFICO UNIDAD CON LIQUEO DE GASOLINA , SE VERIFICO Y SE ENCONTRO CHARCOL CANISTER LLENO DE GASOLINA , SE HIZO TEST PLAN Y SE ENCONTRO VALVULA INTERNA DEL TANQUE DE LA GASOLINA TRANCADA Y ESTO OCASIONANDO LIQUEO DE GASOLINA , SE REMOVIO Y SE INSTALO TANQUE DE GASOLINA NUEVO Y CANISTER DE LOS GASES NUEVO Y VALVULA N80 NUEVA Y SE LIMPIARON TODAS LAS LINES DEL SISTEMA , SE HIZO TEST Y NO PRESENTO LIQUEO DE GASOLINA" - Mecanic

NHTSA complaint #11609559 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Vehicle had recall for "leaking fuel fire risk" Strong smell of fuel inside car. Manufacturer recall #20UF NHTSA recall 24V110 There has not been a fix yet available. Dealer (Team Volkswagen Merrillville IN) replaced the Jet fuel pump. Problem continued, VW engineering said bring the car back and replace the entire fuel tank. Completed. Problem returned 2 weeks later (XXX). While driving home from work noticed extremely strong fuel odor in car. Pulled off in a store parking lot, someone ran up and told me my car was leaking fuel. Gas was literally pouring out, I lost 1/4 tank of fuel on way home. The fuel was leaking under hood, under fuel tank area and under the rear passenger seat. I had the car towed to the dealer. Volkswagen does not have an actual fix for the problem. I should be given a replacement car due to Volkswagen being unable to correct this serious safety issue. What should I do, I am afraid to take the car back. I have videos and several pictures but unable to upload onto this website. Call [XXX] Crown Point Indiana INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11604416 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2015 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while refueling the vehicle, there was fuel leaking from the vehicle, making it impossible to fill the fuel tank. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 73,780. VIN tool confirms parts not available.

NHTSA complaint #11600861 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The hood release doesn’t work and cannot access anything in the engine bay. No oil changes until the hood can be opened. Clear recall due to the danger of not being able to open. The handle inside the car broke by attempting to open the hood.

NHTSA complaint #11599200 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2015 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue and informed the contact that a second notice would be mailed when parts became available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint #11585517 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Thermostat/water pump housing leaking coolant at 20,000 miles. No damage to vehicle that caused this, seems to be a common issue with VW Golfs. The repair is out of pocket and the dealership which sold me the car only a year ago is quoting $1600.

NHTSA complaint #11577119 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2015 Volkswagen Golf. The contact stated that while driving at an undisclosed speed, the stick shift was inoperable. The vehicle was taken to the dealer where it was diagnosed with a failed rear axle and coil springs. The contact was informed that the rear axle and coil springs needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 50,000.

NHTSA complaint #11577150 — an unverified report by a vehicle owner.

POWER TRAIN:AXLE ASSEMBLY

The contact owns a 2015 Volkswagen Golf. The contact stated that while driving at an undisclosed speed, the stick shift was inoperable. The vehicle was taken to the dealer where it was diagnosed with a failed rear axle and coil springs. The contact was informed that the rear axle and coil springs needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 50,000.

NHTSA complaint #11577150 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Leaking sunroof !!!!!!!

NHTSA complaint #11575002 — an unverified report by a vehicle owner.

STRUCTURE:BODY

There is a crack and leak in my sunroof. I have not done anything to my car that would result in the crack. Based on Reddit searches, this is a frequent problem for VW owners. Autobody shops do not want to touch my sunroof or fix it because they do not have success fixing sunroofs.

NHTSA complaint #11573889 — an unverified report by a vehicle owner.

ENGINE

Thermostat housing and water pump are leaking coolant. It is available for inspection. It can cause my engine to overheat and/or fail while being used. It has been confirmed by a dealership. It has not been inspected by the police, manufacturer, or insurance company. There have been occasional reports of low coolant, and the coolant drains significantly faster than expected especially in cold weather (e.g. needing to fill coolant every 7 days). It was first repaired in 2019, and has since failed again.

NHTSA complaint #11549044 — an unverified report by a vehicle owner.