Owners have filed 130 complaints
about the 2014 BMW X5 with NHTSA between 2013 and 2026.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 12 of 27 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 39
Against the median year of the BMW X5. 50 means typical for this
model; 100 means roughly double.
Severity — 83
16.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 80
47% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
56.7%
1,000 – 9,999 miles
1216.0%
10,000 – 24,999 miles
1722.7%
25,000 – 49,999 miles
45.3%
50,000 – 74,999 miles
1418.7%
75,000 – 99,999 miles
68.0%
100,000 – 149,999 miles
1013.3%
150,000+ miles
79.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2013peak 5Jun 2026
NHTSA investigations into the 2014 BMW X5
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
2
investigations are
still open.
EA23001Opened 17 Mar 2023Still openFUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP
High pressure fuel pump failure
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a compreh...
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
Recalls on the 2014 BMW X5
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V527000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series Sedan, 2014 4 Series Coupe, 2014 4 Series Convertible, 2014 3 Series Gran Turismo, and 2015 4 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, increasing the risk of injury or death.
23V797000
AIR BAGS:FRONTAL
BMW of North America, LLC (BMW) is recalling certain 2014 X3 xDrive28i, X3 xDrive35i, X5 sDrive35i, X5 xDrive35i, and 2015 X4 xDrive35i vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
21V907000
FUEL SYSTEM, DIESEL
BMW of North America, LLC (BMW) is recalling certain 2013-2018 328d, 328d xDrive, 2014-2018 328d Sports Wagon, 328d xDrive Sports Wagon, 2014-2016 535d, 535d xDrive, 2015 740Ld xDrive, 2015-2017 X3 xDrive28d SAV, and 2014-2017 X5 xDrive35d SAV diesel vehicles equipped with an Exhaust Gas Recirculation (EGR) module with an integrated cooler. The EGR cooler may leak internally, causing coolant to mix with diesel engine soot, which could result in smoldering particles and a melting intake manifold.
Risk: A melting intake manifold increases the risk of a fire.
21V586000
FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP
BMW of North America, LLC (BMW) is recalling certain 2014-2018 328d, 328d xDrive, X5 xDrive35d, 2014-2016 535d, 535d xDrive, 2015 740Ld xDrive, and 2015-2017 X3 xDrive28d vehicles. The high-pressure fuel pump may fail.
Risk: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
18V755000
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
BMW of North America, LLC (BMW) is recalling certain 2013-2018 BMW 328d and 328d xDrive, 2014-2018 328d Sports Wagon and 328d xDrive Sports Wagon, 2014-2016 535d and 535d xDrive, 2015 740Ld xDrive, 2015-2017 X3 xDrive28d SAV and 2014-2017 X5 xDrive35d SAV vehicles equipped with an Exhaust Gas Recirculation (EGR) module with an integrated cooler. If the EGR cooler leaks internally, the coolant can mix with diesel engine soot. The high EGR temperatures may result in these particles possibly smoldering and melting the intake manifold.
Risk: The melting intake manifold can increase the risk of a fire.
16V683000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
BMW of North America, LLC. (BMW) is recalling certain model year 2015 BMW X3 sDrive28i, X3 xDrive28i, X3 xDrive35i, X3 xDrive28d, X4 xDrive28i and X4 xDrive35i vehicles, and model year 2014-2015 X5 xDrive35i, X5 sDrive35i, X5 xDrive50i, and 2014 X5 xDrive35d vehicles. The affected vehicles have a driver's frontal air bag inflator that may have been improperly welded.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator housing could separate from the base plate and result in metal striking the vehicle occupants, potentially resulting in serious injury or death.
15V147000
AIR BAGS
BMW of North America, LLC (BMW) is recalling certain model year 2015 BMW X5 xDrive 35d Sports Activity Vehicles (SAV) manufactured August 19, 2014, to February 16, 2015, and 2014-2015 BMW X5 xDrive 35i, X5 sDrive 35i, X5 xDrive 50i, Sports Activity Vehicles (SAV) manufactured August 28, 2013, to February 16, 2015. In the affected vehicles, the Head Protection System (HPS) air bag may not be securely connected to the air bag inflator gas generator.
Risk: Without a secure connection to the inflator, the HPS air bags may have insufficient inflation during a vehicle crash, increasing the risk of injury.
14V202000
LATCHES/LOCKS/LINKAGES
BMW of North America, LLC (BMW) is recalling certain model year 2014 X5 SAV vehicles manufactured December 12, 2013, through March 10, 2014, and equipped with the Soft Close Automatic (SCA) option. The rear side door lock mechanisms may not have been manufactured to correct tolerances and when the inside door handle is pulled, the previously engaged child safety lock can disengage.
Risk: A disengaged child safety lock would allow the rear seat occupant to pull the door handle twice and open the door while the vehicle is parked or in motion, increasing the risk of injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024544587,250 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 2024402312 units in Canada
Airbag
Issue: On certain vehicles, the driver-front airbag inflator could rupture when the airbag deploys in a crash. If this happens, the airbag may not properly inflate and fragments could be propelled toward vehicle occupants. Safety Risk: An airbag inflator that ruptures can create a risk of injury or death. Corrective Actions: BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the driver-front airbag module.
Recall 20236347 units in Canada
Airbag
Issue: On a small number of vehicles, the driver-front airbag inflator could rupture when the airbag deploys in a crash. If this happens, the airbag may not properly inflate and fragments could be propelled toward vehicle occupants. Safety Risk: An airbag inflator that ruptures can create a risk of injury or death. Corrective Actions: BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the driver-front airbag module.
Recall 202171112,702 units in Canada
Engine
Issue: On certain vehicles, the exhaust gas recirculation (EGR) cooler could crack internally and leak. If this happens, you may notice the following symptoms: a warning symbol in the instrument cluster displaying a loss of coolant, reduced engine power, an unpleasant exhaust odour, an unusual noise from the engine and/or smoke from the engine compartment. Note: This recall replaces Transport Canada Recall no. 2018-587. Safety Risk: A cracked EGR cooler could create the risk of an engine fire. Corrective Actions: BMW will notify owners by mail and instruct you to take your vehicle to a dealer to replace the EGR cooler. The dealer will also inspect the intake manifold, and replace it, if necessary.
Recall 20214693,486 units in Canada
Fuel System
Issue: On certain vehicles equipped with a diesel engine, the high-pressure fuel pump may wear prematurely. This can cause reduced engine performance and could lead to a sudden engine stall. Note: A warning lamp on the instrument cluster will turn on if the fuel pressure drops. Safety Risk: A loss of engine power could increase the risk of a crash. Corrective Actions: BMW will notify owners by mail and instruct you to take your vehicle to a dealer to replace the high-pressure fuel pump.
Recall 201858710,368 units in Canada
Engine
This recall was replaced by Transport Canada Recall No. 2021-711. On certain vehicles, the cooler for Exhaust Gas Recirculation (EGR) module may develop an internal leak and coolant could mix with diesel engine soot/sediment. In rare circumstances, this condition could result in smouldering particles and lead to the melting of the intake manifold, increasing the risk of a fire causing injury and/or damage to property. Correction: Dealers will inspect the EGR cooler, and if necessary, replace it. If it is determined that the EGR cooler has leaked internally, the intake manifold will also be replaced. The EGR pipe connecting the cooler to the manifold will be cleaned. Note: An operator may be alerted to this condition by one or more of the following symptoms: A warning symbol in the instrument cluster displaying a loss of engine coolant, a reduction in engine power, an unpleasant odour (exhaust gas), an unusual noise from the engine compartment, and/or smoke from the engine compartment.
Recall 2016461395 units in Canada
Airbag
On certain vehicles, the housing of the driver's frontal airbag inflator may have been incorrectly welded during manufacturing and could separate from the base plate during an airbag deployment. If the vehicle were involved in a collision that warrants airbag deployment, metal fragments could be propelled toward vehicle occupants, which could increase the risk of injury. Correction: Dealers will replace the driver's frontal airbag.
Recall 2014142250 units in Canada
Structure
On certain vehicles, the rear side door lock mechanisms may have been manufactured incorrectly. As a result, child door locks may disengage if the interior rear door handle is pulled, thereby allowing a rear door to be opened with a second pull of the inside door handle. This could allow a child to open a rear door inadvertently, increasing the risk of injury and/or damage to property. Correction: Dealers will inspect the rear door locks and replace as necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
Lynwood, ILFire
ENGINE
I purchased a 2014 BMW X5 on 8/31 Took possession of it 9/7 because the dealership needed to replace tires. On 9/15 while driving for about 3 minutes, the powertrain warning came on my screen and the truck began to shake. I turned around and parked in my driveway and turned the vehicle off. At which time smoke was visible from the engine area. As the smoke began to worsen, flames shot out and I called the fire department for help. I was only in possession of the vehicle for 8 days and the dealership told me that there’s nothing that they can do for me. I was within the 15 day of possession or 500 mile time window
NHTSA complaint #11545017 — an unverified report by a vehicle owner.
Canyon Lake, TXFire
UNKNOWN OR OTHER
WAS DRIVING AND SAW MANY RANDOM WARNING LIGHTS GOING OFF IN THE CAR THEN SMOKE FILLED THE CABIN. I STOPPED WENT TO THE REAR OF THE VEHICLE OPENED THE TRUNK AND NOTICED AN ACTUAL FIRE COMING FROM THE SIDE WALL COMPARTMENT THAT HOLD THE CAR JACK. AFTER A COUPLE OF MINUTES THE ENTIRE INSIDE OF THE CAR WAS ENGULFED IN FLAMES.
NHTSA complaint #11387295 — an unverified report by a vehicle owner.
Canyon Lake, TXFire
ELECTRICAL SYSTEM
WAS DRIVING AND SAW MANY RANDOM WARNING LIGHTS GOING OFF IN THE CAR THEN SMOKE FILLED THE CABIN. I STOPPED WENT TO THE REAR OF THE VEHICLE OPENED THE TRUNK AND NOTICED AN ACTUAL FIRE COMING FROM THE SIDE WALL COMPARTMENT THAT HOLD THE CAR JACK. AFTER A COUPLE OF MINUTES THE ENTIRE INSIDE OF THE CAR WAS ENGULFED IN FLAMES.
NHTSA complaint #11387295 — an unverified report by a vehicle owner.
at 65,000 milesAttleboro, MACrash
VEHICLE SPEED CONTROL
2014 BMW X5 XDRIVE. AS I AM ENTERING A PARKING SPOT, MOVING FORWARD, I STEPPED ON THE BRAKE TO STOP MY CAR, AND INSTEAD OF DOING THAT, THE ENGINE REVVED UP AND ACCELERATED QUICKLY. TRIED TO CLICK PARKING BUT THE CAR HARD STOPPED BECAUSE IT HIT THE ROCK IN THAT AREA IN FRONT OF ME. ABLE TO PUT IT INTO PARKING AFTER IT HIT THE ROCK. FRONT RIGHT BUMPER DAMAGED PRETTY SEVERELY. FORTUNATELY NO ONE HURT BUT IF WE ROLLED PAST THE ROCK ALL 5 OF US WOULD HAVE BEEN DEAD AS THERE IS A VALLEY INFRONT OF US. SIMILAR THING HAPPENED 10 MONTHS BACK WHEN WE ARE AT A TRAFFIC SIGNAL ENGINE REVVED UP AND MOVED FORWARD. WHEN WE CALLED LOCAL DEALERSHIP THEY SAID NO RECALLS AT THAT TIME.
NHTSA complaint #11363960 — an unverified report by a vehicle owner.
at 65,000 milesAttleboro, MACrash
SERVICE BRAKES
2014 BMW X5 XDRIVE. AS I AM ENTERING A PARKING SPOT, MOVING FORWARD, I STEPPED ON THE BRAKE TO STOP MY CAR, AND INSTEAD OF DOING THAT, THE ENGINE REVVED UP AND ACCELERATED QUICKLY. TRIED TO CLICK PARKING BUT THE CAR HARD STOPPED BECAUSE IT HIT THE ROCK IN THAT AREA IN FRONT OF ME. ABLE TO PUT IT INTO PARKING AFTER IT HIT THE ROCK. FRONT RIGHT BUMPER DAMAGED PRETTY SEVERELY. FORTUNATELY NO ONE HURT BUT IF WE ROLLED PAST THE ROCK ALL 5 OF US WOULD HAVE BEEN DEAD AS THERE IS A VALLEY INFRONT OF US. SIMILAR THING HAPPENED 10 MONTHS BACK WHEN WE ARE AT A TRAFFIC SIGNAL ENGINE REVVED UP AND MOVED FORWARD. WHEN WE CALLED LOCAL DEALERSHIP THEY SAID NO RECALLS AT THAT TIME.
NHTSA complaint #11363960 — an unverified report by a vehicle owner.
at 120,000 milesAnaheim, CAFire
POWER TRAIN
DRIVING THE FOR 18 MILES UP A MOUNTAIN ROAD TO A SKY RESORT ON SNOW COVERED ROAD. NEVER EXCEEDED 20 MPH BECAUSE OF CONDITIONS. DURING THE TRIP THE BRAKE SYSTEM LIGHT CAME ON AND SCREEN SAID USE CAUTION. PARKED THE CAR AT THE PARKING LOT, TURNED IT OFF. TURNED IT BACK ON AND IT SEEMED OK, THE ERROR MESSAGE WAS GONE. WENT TO OUR ROOM. 20 MINUTES LATER THE SHERIFF CALLS AND SAID MY CAR IS ON FIRE. IT WAS A TOTAL LOSS.
NHTSA complaint #11185562 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Houston, TX
POWER TRAIN
I purchased my vehicle around Labor Day of 2020. I still own and operate the vehicle. Since I have owned my vehicle, I have repeatedly been told my turbos are leaking oil, etc. I have even had several oil leaks repaired on my car. Fast forward six years, and I am buying 5 quarts of oil every two weeks and topping up the oil in my vehicle every week, at least 2-3 quarts per week. I also have smoke coming out of the tail pipes intermittently. The car also smells like it is burning oil, but there are no visible oil drips on the ground currently. I discovered by research there have been two lawsuits: Isley v. BMW of North America LLC, et al., Case No. [XXX] in the U.S. District Court for the District of New Jersey ([XXX] [XXX]), and Bang v. BMW (Original [XXX]) ([XXX]). I have had repeated documented repairs and I never received a notice for these cases. I need my vehicle repaired and I need BMW to take ownership of this defect. I never received one notice regarding these lawsuits, or I would have had my vehicle repaired. I only have 102,000 miles (currently), so my vehicle should be covered in terms of mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11747246 — an unverified report by a vehicle owner.
Houston, TX
ENGINE
I purchased my vehicle around Labor Day of 2020. I still own and operate the vehicle. Since I have owned my vehicle, I have repeatedly been told my turbos are leaking oil, etc. I have even had several oil leaks repaired on my car. Fast forward six years, and I am buying 5 quarts of oil every two weeks and topping up the oil in my vehicle every week, at least 2-3 quarts per week. I also have smoke coming out of the tail pipes intermittently. The car also smells like it is burning oil, but there are no visible oil drips on the ground currently. I discovered by research there have been two lawsuits: Isley v. BMW of North America LLC, et al., Case No. [XXX] in the U.S. District Court for the District of New Jersey ([XXX] [XXX]), and Bang v. BMW (Original [XXX]) ([XXX]). I have had repeated documented repairs and I never received a notice for these cases. I need my vehicle repaired and I need BMW to take ownership of this defect. I never received one notice regarding these lawsuits, or I would have had my vehicle repaired. I only have 102,000 miles (currently), so my vehicle should be covered in terms of mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11747246 — an unverified report by a vehicle owner.
at 160,000 milesAndover, NJ
ELECTRICAL SYSTEM
The contact owns a 2014 BMW X5. While the contact's daughter was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the 12-Volt battery and the auxiliary battery needed to be replaced. The vehicle was repaired; however, the contact attempted to start the vehicle, but the vehicle failed to start. The vehicle was towed to an independent mechanic who specialized in foreign-made vehicles. The vehicle was diagnosed, and it was determined that the water pump was constantly running and was draining the 12-Volt battery. The mechanic determined that the water pump needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not associated with the recall. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 160,000.
NHTSA complaint #11712071 — an unverified report by a vehicle owner.
at 160,000 milesAndover, NJ
ENGINE AND ENGINE COOLING
The contact owns a 2014 BMW X5. While the contact's daughter was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the 12-Volt battery and the auxiliary battery needed to be replaced. The vehicle was repaired; however, the contact attempted to start the vehicle, but the vehicle failed to start. The vehicle was towed to an independent mechanic who specialized in foreign-made vehicles. The vehicle was diagnosed, and it was determined that the water pump was constantly running and was draining the 12-Volt battery. The mechanic determined that the water pump needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not associated with the recall. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 160,000.
NHTSA complaint #11712071 — an unverified report by a vehicle owner.
Belleville, NJ
SUSPENSION
I own a 2014 BMW X5 diesel, after the 4 yr warranty expired, my car has had 2 times driveshaft/drivetrain/differential replaced. Valve cover leaking. Chassis stabilization error, suspension/air pump problems, at this moment i have an initialization of driving stabilization error message. Please see what is going on with these expensive cars that after 4 yr warranty give all kind of problems. ThanksTeresa
NHTSA complaint #11710927 — an unverified report by a vehicle owner.
Phoenix, AZ
Other/I am not sure
Product: Diono Monterey 2XT Highback Booster Issue type: Child restraint usability / fit concern There is a significant height usability gap between Diono’s convertible seats and the Monterey 2XT booster. My child is approximately 32”–40” tall and cannot safely use either seat, leaving no appropriate Diono option during this growth range. This presents a real-world safety and usability issue for caregivers attempting to follow manufacturer guidance. I have attempted multiple direct contacts with Diono for clarification or exchange options, but no functional escalation contacts exist. This complaint is submitted to document the usability gap and request manufacturer review and some kind of help in rectifying this clearly safety issue. Thank you for your attention to this matter.
NHTSA complaint #11709473 — an unverified report by a vehicle owner.
at 101,078 milesMckinney, TX
ELECTRICAL SYSTEM
The contact owns a 2014 BMW X5. The contact stated that upon attempting to start the vehicle, the vehicle failed to start. The contact stated that several unknown warning lights were illuminated. The contact stated that after several attempts the vehicle started and driven to a service center where the battery was replaced; however, the contact became aware that the battery was draining abnormally. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that the water pump was leaking onto an electrical plug connector, causing the vehicle to short circuit. The contact stated that the water pump was replaced, and a shield was installed over the connector. The vehicle was repaired. The contact referenced NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); as a possible cause for the failure however, the VIN was not included. The manufacturer was notified of the failure. The approximate failure mileage was 101,078.
NHTSA complaint #11660687 — an unverified report by a vehicle owner.
at 101,078 milesMckinney, TX
ENGINE AND ENGINE COOLING
The contact owns a 2014 BMW X5. The contact stated that upon attempting to start the vehicle, the vehicle failed to start. The contact stated that several unknown warning lights were illuminated. The contact stated that after several attempts the vehicle started and driven to a service center where the battery was replaced; however, the contact became aware that the battery was draining abnormally. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that the water pump was leaking onto an electrical plug connector, causing the vehicle to short circuit. The contact stated that the water pump was replaced, and a shield was installed over the connector. The vehicle was repaired. The contact referenced NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); as a possible cause for the failure however, the VIN was not included. The manufacturer was notified of the failure. The approximate failure mileage was 101,078.
NHTSA complaint #11660687 — an unverified report by a vehicle owner.
Baldwin, NY
ENGINE
Due to issues in the engine design the timing chains become loose and get excessive slack. BMW has revised the design multiple times but the corrective action requires complete removal of transmission and engine to replace all timing chain components. Unfortunately my engine has suffered timing chain failure and requires replacement. This leads to engine failure while driving and unsafe conditions.
NHTSA complaint #11659201 — an unverified report by a vehicle owner.
Katy, TX
FUEL/PROPULSION SYSTEM
High Pressure Fuel Pump failed without any sensor notification or prior indication causing the car to suddenly go into safety mode shut down and lose all propulsion while driving at speed. This is a known NHTSA recall issue Part 573 Safety Recall Report 21V-586 specific to 2014 BMW X5 xdrive35d. Attempting to understand WHY this VIN is not included in the recall list especially in light of the fact the resulting catastrophic failure defined is exactly why the recall was supposed to prevent.
NHTSA complaint #11649264 — an unverified report by a vehicle owner.
at 78,000 milesOmaha, NE
ENGINE AND ENGINE COOLING
The contact owns a 2014 BMW X5. The contact stated while driving 65-70 MPH, there was an abnormal sound coming from the engine. The check engine warning light was illuminated. The contact drove to the residence. The following day, the vehicle was towed to SLM Auto Care LLC - Audi VW BMW Porsche, where it was diagnosed that the N63 engine had failed and needed to be replaced. The mechanic also informed the contact that the N63 engine was known to consume excessive oil. The vehicle was not repaired. The dealer and the manufacturer were notified of the failure. The The failure mileage was approximately 78,000.
NHTSA complaint #11637266 — an unverified report by a vehicle owner.
Horton, MI
FUEL/PROPULSION SYSTEM
Vehicle shutoff at high rate of speed causing me to not have power steering or brakes. This was very frightening and lucky to not cause a major accident. This was due to the High Pressure Fuel Pump failing that has extended warranty but should be a recall as this is very dangerous.
NHTSA complaint #11635056 — an unverified report by a vehicle owner.
Horton, MI
FUEL/PROPULSION SYSTEM
Almost caused a major accident when High Pressure Fuel Pump failed unexpectedly while driving. Good thing my family was not in car when this happened. This is completely unacceptable and should be recalled on this vehicle just like many others of this model. I have included picture of metal shavings in fuel system from high pressure fuel pump failure.
NHTSA complaint #11633019 — an unverified report by a vehicle owner.
Schererville, IN
POWER TRAIN
High Pressure fuel pump failure
NHTSA complaint #11630291 — an unverified report by a vehicle owner.
Schererville, IN
ENGINE
High Pressure fuel pump failure
NHTSA complaint #11630291 — an unverified report by a vehicle owner.
Schererville, IN
FUEL/PROPULSION SYSTEM
High Pressure fuel pump failure
NHTSA complaint #11630291 — an unverified report by a vehicle owner.
at 159,878 milesRock Hill, SC
ELECTRICAL SYSTEM
The contact owns a 2014 BMW X5. The contact stated while driving approximately 15 MPH, the contact discovered that there was water leaking from underneath the vehicle. No warning light was illuminated. The contact researched and was made aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included. The vehicle was towed to a dealer where it was diagnosed that the water pump had leaked onto the battery and the water pump, and the battery needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 159,878.
NHTSA complaint #11624988 — an unverified report by a vehicle owner.
at 159,878 milesRock Hill, SC
ENGINE AND ENGINE COOLING
The contact owns a 2014 BMW X5. The contact stated while driving approximately 15 MPH, the contact discovered that there was water leaking from underneath the vehicle. No warning light was illuminated. The contact researched and was made aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not included. The vehicle was towed to a dealer where it was diagnosed that the water pump had leaked onto the battery and the water pump, and the battery needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 159,878.
NHTSA complaint #11624988 — an unverified report by a vehicle owner.
Leonard, MI
FUEL/PROPULSION SYSTEM
High pressure fuel pump Failure
NHTSA complaint #11615181 — an unverified report by a vehicle owner.
Lynden, WA
FUEL/PROPULSION SYSTEM
2014 BMW x5 xdrive35D equipped with a Bosch Cp4 (HPFP) High Pressure Fuel Pump that is known to implode., cause severe damage to my vehicles fuel system that is costing me thousands in repairs. My year make model and build year all fall under the recall but my vin is not on the recall list. BMW has no answers for me and just says nothing they can do. BOSCH CP4 HPFP failed and released metal shavings throughout all fuel lines, injec BMW had a recall for 12K vehicles but mine was not on the recall list and BMW cannot explain why given that my fuel pump exploded like so many other BOSCH CP4 . I believe BMW knew that these pumps were bad and did not notify all owners that had them in in their car.
NHTSA complaint #11612716 — an unverified report by a vehicle owner.
Olean, NY
UNKNOWN OR OTHER
Water Pump I went to 2 BMW dealerships, Buffalo and PA, for repair and neither could diagnose and repair. I went to local repair shop and they changed water pump. I would like to be reimbursed for this recalled repair. Please advise.
NHTSA complaint #11610461 — an unverified report by a vehicle owner.
at 77,000 milesElizabethtown, KY
FUEL SYSTEM, DIESEL
The contact owns a 2014 BMW X5. The contact stated while driving 10–40 MPH, the vehicle stalled and independently shifted to neutral. The vehicle restarted after a while. The check engine warning light was illuminated. The contact stated that the drivetrain malfunction message was displayed. The contact stated that the failure was related to NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 77,000.
NHTSA complaint #11603126 — an unverified report by a vehicle owner.
at 77,000 milesElizabethtown, KY
ENGINE
The contact owns a 2014 BMW X5. The contact stated while driving 10–40 MPH, the vehicle stalled and independently shifted to neutral. The vehicle restarted after a while. The check engine warning light was illuminated. The contact stated that the drivetrain malfunction message was displayed. The contact stated that the failure was related to NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The approximate failure mileage was 77,000.
NHTSA complaint #11603126 — an unverified report by a vehicle owner.
Las Cruces, NM
FUEL/PROPULSION SYSTEM
The high-pressure fuel pump failed/disintegrated and released metal debris into the entire fuel system and most likely into the engine. The car stalled and shut off in the middle of intersection and almost caused a crash. The entire fuel system will need to be replaced due to the intrusion of the metal fragments into the fuel system.
NHTSA complaint #11590494 — an unverified report by a vehicle owner.
Canton, MI
POWER TRAIN
The vehicle has been part of recall #[XXX] related to engine EGR cooler leakage. The EGR cooler is part of emission's control. On this vehicle the egr can leak which causes coolant to get into intake manifold and potentially cause risk of fire. BMW denied to cover the repair on my vehicle reason I am asking for support. Have already called BMW customer service 1800-831-1117 but unfortunately no support was offered. Car have been fixed by replacing the egr with genuine BMW part. Invoice attached. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11583366 — an unverified report by a vehicle owner.