2001 Chevrolet Corvette problems

STEERING

My steering column lock has failed on my C5 Corvette. I understand that there was a previous recall for this, but I have been the owner of this car since 2001 and was never notified by mail of the recall by GM. When I contact GM, they indicate that the recall is expired and there is nothing that they can do. HELP!!!

NHTSA complaint #11469740 — an unverified report by a vehicle owner.

STEERING

Chevy / GM recalled over 100,000 Corvettes built between 1997 and 2004 for a steering column lock issue, that renders the car un drivable. The fuel supply cuts off at 2 miles per hour. Many of the dealers did a faulty job fixing the problem, causing it to recur. My 2001 Corvette (with less than 17,000 miles) repeatedly experiences this problem. GM says they will not warrant this known defective design, due to the recall expiring. According to an internet search on “Corvette Steering Column Lock”, there no telling how many unhappy Corvette owners this has created. Need your help getting this $50,000 car back on the road.

NHTSA complaint #11451962 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Chevy / GM recalled over 100,000 Corvettes built between 1997 and 2004 for a steering column lock issue, that renders the car un drivable. The fuel supply cuts off at 2 miles per hour. Many of the dealers did a faulty job fixing the problem, causing it to recur. My 2001 Corvette (with less than 17,000 miles) repeatedly experiences this problem. GM says they will not warrant this known defective design, due to the recall expiring. According to an internet search on “Corvette Steering Column Lock”, there no telling how many unhappy Corvette owners this has created. Need your help getting this $50,000 car back on the road.

NHTSA complaint #11451962 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

We purchased the car on 12/17/21. I went to Costco on 12/18/21 to get gas. I had a preset amount of $50 to put into the car. When I got to $50 I shut the pump off myself, the tank was not full enough for it to shut off automatically. As I look down on the ground I saw a fluid running out from underneath the car and rolling along the ground. I touched it with my finger and discovered it was gasoline. I put the nozzle back into the holder and I checked underneath the car and saw it was dripping from the drivers side in the area just behind the drivers door. I pulled the car over to the side to inspect it further. By now the gas had stopped dripping. Since the exhaust pipe is right next to the fuel tank I was afraid of a fire or explosion. Had some fuel vapors but they dissipated shortly after. My gas gauge was registering full at this time. Since then I have not had any gasoline leaks and or vapors present. I have not put any more gas in the car since then. (I contacted the previous owner and he said in an email response, if you overfill there is a vent hole that gas will leak out of at the top of the filler neck. It happened once when I put like 20 gallons in it.) I did some research and found that there is a problem with the Corvette gas tanks and or the crossover tube. I think this is a dangerous situation, thinking that if that gas ignited, the car and my passenger could have caught fire and possibly ignited the Costco gas station with an explosion. (This car will be going into the repair shop in January to have a diagnostic smoke test done to determine where the leak and or leaks are coming from.) I hope the NHTSA recognizes this as a very dangerous situation. All of this will be coming out of my own pocket for the repairs necessary to make this car safe to drive and not be dangerous to myself and family. I consider this a very serious dangerous situation.

NHTSA complaint #11445659 — an unverified report by a vehicle owner.

STEERING

Have 2001 manual 6 speed corvette. Column locks up. Have no way to start car or steer. Worried car will lock up steering column while driving. Gm says there's no recall on this. Seems to be a problem on c5 Corvettes.

NHTSA complaint #11437839 — an unverified report by a vehicle owner.

STEERING

TL* THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THE STEERING WHEEL CEASED WITH THE SERVICE STEERING COLUMN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO I.G. BURTON LEWES AUTOMALL (17861 COASTAL HWY, LEWES, DE 19958) WHERE IT WAS DIAGNOSED AND THE MECHANIC DETERMINED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED THREE ADDITIONAL TIMES HOWEVER, THE FAILURE RECURRED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO THE DEALER FOR THE REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 7,000.

NHTSA complaint #11385193 — an unverified report by a vehicle owner.

STEERING

I PULLED OUT INTO TRAFFIC AND ALMOST GOT KILLED! THE CONSOLE LOCK SCREEN CAME ON, AND MY CAR STOPPED AS WELL! THE WHEEL WAS NOT LOCKED. THE CAR THAT WAS SO VERY UNDERSTANDING, SUGGEST I GET A FORD. GM TRULY NEEDS TO RECALL EVERY CAR THEY HAVE TO BE RECALLED FOR THEIR LOYAL CUSTOMERS LIVES. I WILL BE CONTACTING A LAWYER AS WELL! I HAD JUST COME TO A STOP, AND PROCEEDED WITH THE TURN, WITH PLENTY OF DISTANCE HAD THIS FOOLISHNESS NOT HAVE HAPPENED. NOW I SEE THIS IN JUST ABOUT EVERYWHERE ON THIS COMPUTER! FIX THIS IDIOTS AT GENERAL MOTORS!!!

NHTSA complaint #11341435 — an unverified report by a vehicle owner.

STEERING

I HAVE OWNED THIS 2001 CORVETTE SINCE IT WAS NEW IT HAS LESS THAN 7000 MILES ON IT.ON FRIDAY MAY 8TH 2020 I HAD TO HAVE IT TOWED TO THE DEALER CENTURY CHEVROLET IN BROOMFIELD COLORADO.THE SERVICE COLUMN LOCK IS ON AT THE DASH AND I CANNOT TURN THE STEERING WHEEL AND IF YOU TRY TO DRIVE IT THE VEHICLE WILL STALL.I HAD RECALL 04006 PERFORMED ON THE CAR ON 10/25/2004 WITH 1912 MILES ON IT AND THIS WAS A REPROGRAMMING OF THE PCM.I HAVE SINCE LEARNED THERE HAS BEEN 2-3 UPDATES FOR THIS CONDITION AND THERE IS A RECALL 04006C AND SPECIAL POLICY #05081 FOR A NEW WIRING HARNESS TO BE INSTALLED TO CORRECT THIS CONDITION.I WAS NEVER CONTACTED BY GM ABOUT THIS AND FEEL I SHOULD NOT HAVE TO PAY FOR A DEFECT THEY KNOW ABOUT! THE VEHICLE WAS TOWED OUT OF MY GARAGE /DRIVEWAY WE HAD TO PUSH IT OUT OF THE GARAGE ONTO A TOW TRUCK AND IT IS CURRENTLY AT THE DEALERSHIP WAITING TO HERE WHAT THEY ARE GOING TO DO. I DON'T THINK THEY ARE GOING TO OFFER ANY HELP NOR DID THEY WANT TO PICKUP THE TOW CHARGES AND ADD IT TO THE BILL. REGARDLESS I HAVE TO FIX THE VEHICLE AS IT DOES ME NO GOOD THE WAY IT IS.WITH THIS SAID THE ORIGINAL FIX OF THE RECALL DID NOT FIX THE VEHICLE AND THE NOW KNOWN FIX SHOULD BE DONE AT NO CHARGE TO THE CONSUMER/CUSTOMER.THIS VEHICLE IS IN MINT CONDITION AND HAS NOT BEEN MODIFIED IN ANY WAY AND TAKEN CARE OF LIKE NEW SINCE OWNED. I AM REACHING OUT TO YOU BECAUSE THE RIGHT THING NEEDS TO HAPPEN AND GM SHOULD ACCEPT RESPONSIBILITY FOR THERE ACTIONS AND KNOWINGLY THAT THERE IS A DEFECT. I AM LUCKY I WAS NOT DRIVING THIS VEHICLE AS I WAS PLANNING ON DRIVING THE MORNING THIS HAPPENED AS I COULD OF KILLED MYSELF OR SOMEONE ELSE.

NHTSA complaint #11324054 — an unverified report by a vehicle owner.

ELECTRONIC STABILITY CONTROL (ESC)

I HAVE OWNED THIS 2001 CORVETTE SINCE IT WAS NEW IT HAS LESS THAN 7000 MILES ON IT.ON FRIDAY MAY 8TH 2020 I HAD TO HAVE IT TOWED TO THE DEALER CENTURY CHEVROLET IN BROOMFIELD COLORADO.THE SERVICE COLUMN LOCK IS ON AT THE DASH AND I CANNOT TURN THE STEERING WHEEL AND IF YOU TRY TO DRIVE IT THE VEHICLE WILL STALL.I HAD RECALL 04006 PERFORMED ON THE CAR ON 10/25/2004 WITH 1912 MILES ON IT AND THIS WAS A REPROGRAMMING OF THE PCM.I HAVE SINCE LEARNED THERE HAS BEEN 2-3 UPDATES FOR THIS CONDITION AND THERE IS A RECALL 04006C AND SPECIAL POLICY #05081 FOR A NEW WIRING HARNESS TO BE INSTALLED TO CORRECT THIS CONDITION.I WAS NEVER CONTACTED BY GM ABOUT THIS AND FEEL I SHOULD NOT HAVE TO PAY FOR A DEFECT THEY KNOW ABOUT! THE VEHICLE WAS TOWED OUT OF MY GARAGE /DRIVEWAY WE HAD TO PUSH IT OUT OF THE GARAGE ONTO A TOW TRUCK AND IT IS CURRENTLY AT THE DEALERSHIP WAITING TO HERE WHAT THEY ARE GOING TO DO. I DON'T THINK THEY ARE GOING TO OFFER ANY HELP NOR DID THEY WANT TO PICKUP THE TOW CHARGES AND ADD IT TO THE BILL. REGARDLESS I HAVE TO FIX THE VEHICLE AS IT DOES ME NO GOOD THE WAY IT IS.WITH THIS SAID THE ORIGINAL FIX OF THE RECALL DID NOT FIX THE VEHICLE AND THE NOW KNOWN FIX SHOULD BE DONE AT NO CHARGE TO THE CONSUMER/CUSTOMER.THIS VEHICLE IS IN MINT CONDITION AND HAS NOT BEEN MODIFIED IN ANY WAY AND TAKEN CARE OF LIKE NEW SINCE OWNED. I AM REACHING OUT TO YOU BECAUSE THE RIGHT THING NEEDS TO HAPPEN AND GM SHOULD ACCEPT RESPONSIBILITY FOR THERE ACTIONS AND KNOWINGLY THAT THERE IS A DEFECT. I AM LUCKY I WAS NOT DRIVING THIS VEHICLE AS I WAS PLANNING ON DRIVING THE MORNING THIS HAPPENED AS I COULD OF KILLED MYSELF OR SOMEONE ELSE.

NHTSA complaint #11324054 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I HAVE OWNED THIS 2001 CORVETTE SINCE IT WAS NEW IT HAS LESS THAN 7000 MILES ON IT.ON FRIDAY MAY 8TH 2020 I HAD TO HAVE IT TOWED TO THE DEALER CENTURY CHEVROLET IN BROOMFIELD COLORADO.THE SERVICE COLUMN LOCK IS ON AT THE DASH AND I CANNOT TURN THE STEERING WHEEL AND IF YOU TRY TO DRIVE IT THE VEHICLE WILL STALL.I HAD RECALL 04006 PERFORMED ON THE CAR ON 10/25/2004 WITH 1912 MILES ON IT AND THIS WAS A REPROGRAMMING OF THE PCM.I HAVE SINCE LEARNED THERE HAS BEEN 2-3 UPDATES FOR THIS CONDITION AND THERE IS A RECALL 04006C AND SPECIAL POLICY #05081 FOR A NEW WIRING HARNESS TO BE INSTALLED TO CORRECT THIS CONDITION.I WAS NEVER CONTACTED BY GM ABOUT THIS AND FEEL I SHOULD NOT HAVE TO PAY FOR A DEFECT THEY KNOW ABOUT! THE VEHICLE WAS TOWED OUT OF MY GARAGE /DRIVEWAY WE HAD TO PUSH IT OUT OF THE GARAGE ONTO A TOW TRUCK AND IT IS CURRENTLY AT THE DEALERSHIP WAITING TO HERE WHAT THEY ARE GOING TO DO. I DON'T THINK THEY ARE GOING TO OFFER ANY HELP NOR DID THEY WANT TO PICKUP THE TOW CHARGES AND ADD IT TO THE BILL. REGARDLESS I HAVE TO FIX THE VEHICLE AS IT DOES ME NO GOOD THE WAY IT IS.WITH THIS SAID THE ORIGINAL FIX OF THE RECALL DID NOT FIX THE VEHICLE AND THE NOW KNOWN FIX SHOULD BE DONE AT NO CHARGE TO THE CONSUMER/CUSTOMER.THIS VEHICLE IS IN MINT CONDITION AND HAS NOT BEEN MODIFIED IN ANY WAY AND TAKEN CARE OF LIKE NEW SINCE OWNED. I AM REACHING OUT TO YOU BECAUSE THE RIGHT THING NEEDS TO HAPPEN AND GM SHOULD ACCEPT RESPONSIBILITY FOR THERE ACTIONS AND KNOWINGLY THAT THERE IS A DEFECT. I AM LUCKY I WAS NOT DRIVING THIS VEHICLE AS I WAS PLANNING ON DRIVING THE MORNING THIS HAPPENED AS I COULD OF KILLED MYSELF OR SOMEONE ELSE.

NHTSA complaint #11324054 — an unverified report by a vehicle owner.

WHEELS

2001 CORVETTE, PASSENGER SIDE FRONT WHEEL HAS AN APPROX 3" CRACK WHERE THE SPOKE MEETS THE RIM AND RUNS FROM WHERE THE TIRE MOUNTS TO INSIDE THE WHEEL AFFECTED WHEEL LOSES 20PSI OF AIR PER HOUR.

NHTSA complaint #11282836 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

RECALL NUMBER 04V060000 RECALL DATE 02/09/2004 COMPONENT STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE SUMMARY. STEERING LOCKED AT EXITING FREEWAY. THE FUEL SUPPLY SHUT OFF SO THE VEHICLE CANNOT MOVED. THE VEHICLE CANNOT BE STEERED.

NHTSA complaint #11254333 — an unverified report by a vehicle owner.

STEERING

RECALL NUMBER 04V060000 RECALL DATE 02/09/2004 COMPONENT STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE SUMMARY. STEERING LOCKED AT EXITING FREEWAY. THE FUEL SUPPLY SHUT OFF SO THE VEHICLE CANNOT MOVED. THE VEHICLE CANNOT BE STEERED.

NHTSA complaint #11254333 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

RECALL NUMBER 04V060000 RECALL DATE 02/09/2004 COMPONENT STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE SUMMARY. STEERING LOCKED AT EXITING FREEWAY. THE FUEL SUPPLY SHUT OFF SO THE VEHICLE CANNOT MOVED. THE VEHICLE CANNOT BE STEERED.

NHTSA complaint #11254333 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN I FILL UP MY GAS TANK THERE ARE STRONG GAS FUMES IN THE GARAGE. THE FUMES ARE NOT THERE WHEN THE TANK IS 3/4 FULL OR LESS. THIS IS A CONTINUING ISSUE.

NHTSA complaint #11204537 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHEN YOU FILL UP THE FUEL TANKS YOU GET A VERY STRONG SMELL OF GAS IN THE CAR AS WELL AS IN THE GARAGE. GENERAL MOTORS KNOWS ABOUT THIS COMPLAINT AND WILL HELP THEIR CUSTOMERS. IN FACT THERE IS A CLASS ACTION LAWSUIT AGAINST GM FOR YEAR CORVETTE 2004. IT WILL COST ABOUT $ 2,000.00 TO $ 2,500.00 TO MAKE THE REPAIRS. A LOT OF TIMES THE RIGHT TANK IS CRACKED OR THE CROSSOVER TUBE IS CRACKED . I HAVE CALLED GM AND ASKED FOR HELP AND THEY WILL NOT ACCEPT THIS AS A WARRANTY ISSUE. THERE ARE MANY COMPLAINTS ABOUT THIS ISSUE . BY THE WAY ALL THE GM DEALERS ARE AWARE OF THE ISSUE. CAN YOU HELP ME OUT ? YOU SMELL THE FUEL WHEN THE CAR IS STOPPED.

NHTSA complaint #11195338 — an unverified report by a vehicle owner.

STEERING

TL* THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. WHEN THE CONTACT STARTED THE VEHICLE, THE STEERING COLUMN SEIZED AND THE CHECK STEERING COLUMN WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS TSB NUMBER: 04006C. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO CALL NHTSA. THE MANUFACTURER PROVIDED CASE NUMBER: 8-4532782724. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

NHTSA complaint #11120660 — an unverified report by a vehicle owner.

STEERING

TL* THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. WHILE RESTARTING THE ENGINE, A "SERVICE STEERING COLUMN" MESSAGE APPEARED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER (DAVE MCDERMOTT CHEVROLET, 655 MAIN ST, EAST HAVEN, CT) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN LOCKING MECHANISM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN ACTUATOR WAS FAULTY. THE VEHICLE WAS REPAIRED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 42,996.

NHTSA complaint #11115611 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

AFTER FILLING FUEL TANK. PARKED VEHICLE IN GARAGE AND NOTICED A FUEL LEAK ON PASSENGER SIDE UNDERNEATH FUEL TANK.

NHTSA complaint #11079922 — an unverified report by a vehicle owner.

WHEELS

SERVICE STEERING COLUMN LOCKED

NHTSA complaint #11051051 — an unverified report by a vehicle owner.

STEERING

SERVICE STEERING COLUMN LOCKED

NHTSA complaint #11051051 — an unverified report by a vehicle owner.

STEERING

THE STEERING WHEEL LOCK DOES NOT RELEASE. I BELIEVE THIS WAS ALREADY A RECALL ISSUE

NHTSA complaint #11024610 — an unverified report by a vehicle owner.