Owners have filed 441 complaints
about the 2006 Chevrolet Corvette with NHTSA between 2005 and 2025.
The largest single group is the body & structure.
Across this model's run it ranks 3 of 33 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Chevrolet Corvette. 50 means typical for this
model; 100 means roughly double.
Severity — 29
5.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 82
48% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2006 compares with every other Chevrolet Corvette
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Roof AND Pillars
4066.7%
Body
813.3%
Headlights
46.7%
Column
35.0%
Frame AND Members
23.3%
Automatic (Asc)
11.7%
Antilock
11.7%
Valve
11.7%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
71.9%
1,000 – 9,999 miles
4612.5%
10,000 – 24,999 miles
7319.8%
25,000 – 49,999 miles
8523.0%
50,000 – 74,999 miles
6918.7%
75,000 – 99,999 miles
5214.1%
100,000 – 149,999 miles
338.9%
150,000+ miles
41.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Oct 2005peak 11Dec 2025
NHTSA investigations into the 2006 Chevrolet Corvette
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA13007Opened 23 Aug 2013Closed 24 Jun 2014EXTERIOR LIGHTING
Simultaneous Loss of Low-Beam Headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate...
PE13013Opened 6 May 2013Closed 26 Aug 2013EXTERIOR LIGHTING
Loss of Low Beam Headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device...
EA09002Opened 14 Jan 2009Closed 11 May 2010ELECTRONIC STABILITY CONTROL
Electronic Stability Control
On April 26, 2010, at NHTSA's request following this investigation, General Motors submitted a Defect Information Report to NHTSA to correct a defect associated with the Vehicle Stability Control (VSC) system in approximately 40,000 Model Year (MY) 2005 and 2006 Chevrolet Corvette vehicles (NHTSA Recall No. 10V-172).According to the report, these vehicles may have a problem with the Steering Wheel Position Sensor (SWPS) connector created by a fretting condition in the connector (small movement of the pins back and forth creating a residue build up) which could change the electrical resistance...
PE08056Opened 17 Sep 2008Closed 14 Jan 2009ELECTRONIC STABILITY CONTROL
ELECTRONIC STABILITY CONTROL MALFUNCTION
ON SEPTEMBER 17, 2008, ODI OPENED PRELIMINARY EVALUATION PE08-056 TO INVESTIGATE ALLEGATIONS OF INAPPROPRIATE ACTIVATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM IN MODEL YEAR (MY) 2005 AND 2006 CHEVROLET CORVETTE VEHICLES.SOME REPORTS RECEIVED BY ODI AND SOME REPORTS TO GENERAL MOTORS (GM) CONTAINED IN GM'S RESPONSE TO PE08-056 ALLEGE THAT THE ESC SYSTEM MALFUNCTIONED CAUSING A SUDDEN AND INAPPROPRIATE BRAKING ACTION WITHOUT ILLUMINATION OF THE BRAKE LIGHTS AND CAUSING THE VEHICLE TO SWERVE LEFT OR RIGHT UNEXPECTEDLY. GM ISSUED A TECHNICAL SERVICE BULLETIN IN JANUARY 2006, LATER REVIS...
Recalls on the 2006 Chevrolet Corvette
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
14V251000
ELECTRICAL SYSTEM:WIRING
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Risk: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
10V172000
STEERING:COLUMN
GM IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 CHEVROLET CORVETTE PASSENGER CARS MANUFACTURED BETWEEN MARCH 2004 AND JANUARY 2006 EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN (RPO N37). IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR IN THE DRIVER INFORMATION CENTER, AND ONE OR MORE OF THE BRAKES MAY APPLY, POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT.
Risk: IF THE DRIVER DOES NOT RESPOND TO THE CHANGE IN VEHICLE MOVEMENT, A CRASH COULD OCCUR.
09V491000
STRUCTURE:BODY:ROOF AND PILLARS
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Risk: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
06V181000
STRUCTURE:BODY:ROOF AND PILLARS
ON CERTAIN 2005-2006 CHEVROLET CORVETTES EQUIPPED WITH PAINTED ROOFS, THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE.
Risk: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE AND IT COULD STRIKE ANOTHER VEHICLE AND CAUSE INJURY AND PROPERTY DAMAGE.
05V455000
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Risk: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20141743,054 units in Canada
Lights And Instruments
On certain vehicles, wiring within the underhood fuse panel wiring may break, causing intermittent low beam function. This could compromise driver visibility and increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the underhood fuse panel.
Recall 20101341,459 units in Canada
Brakes
Certain vehicles equipped with tilt and telescoping steering column may have an intermittent or open condition in a connector in the Steering Wheel Position Sensor (SWPS) circuit located in the steering column. If this intermittent or open condition occurs, the “SERVICE ACTIVE HANDLING SYSTEM” message is displayed, and a short-duration brake apply may occur if the signals for steering wheel rotation or ground are corrupted. The manufacturer assessed the brake application as observable, but controllable and vehicle handling is maintained by minor corrections in steering, however, if the driver does not respond to the change in vehicle movement, it could result in a crash causing property damage, personal injury or death. Correction: Dealers will inspect and, if necessary, install a terminal position assurance clip to the connector.
Recall 2009362972 units in Canada
Other
On certain vehicles equipped with a removable roof, the adhesive between the roof and the frame may separate. If there is a complete separation, the roof panel may detach from the vehicle and should this happen while driving, it could result in a crash causing property damage, personal injury or death. Correction: Dealers will install a new design roof panel.
Recall 2006123693 units in Canada
Other
On certain vehicles with a painted roof, the adhesive between the roof panel and the frame may separate. As a result, the roof panel may detach from the vehicle and strike a road user, causing injury and property damage. Correction: Dealers will inspect and, if required, replace the roof.
Recall 20052966,487 units in Canada
Steering
Certain vehicles may have been built with a power steering hose that is not to specification. Under extreme steering manoeuvres, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid. If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increase braking effort would be required. If power steering fluid were to spray onto hot engine parts, an engine compartment fire could occur. Correction: Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 70,000 milesNewbury Park, CACrash
ENGINE
CYLINDER HEAD VALVE GUIDES WORN REQUIRING REPLACEMENT BEFORE WARRANTY EXPIRATION. IF NOT REPAIRED CATASTROPHIC MOTOR FAILURE CAN OCCUR. IF THIS HAPPENS CAR BECOMES UNCONTROLLABLE WITH OIL AND COOLANT FLOODING OUT OF MOTOR. NEW HEADS WERE ORDERED FROM THE FACTORY AND THEY WERE OUT OF SPECIFICATION AND NEEDED MODIFICATION BEFORE INSTALLED. PREVIOUS 2008 CORVETTE (UNKNOWN VIN BUT CAN BE FOUND AT DEALERSHIP WHERE SERVICED HAD THIS SAME PROBLEM LEADING TO THE ABOVE MENTIONED FAILURE AND UNCONTROLLED VEHICLE CONDITION. THIS HAPPENED ON AN OFFLOAD VENUE SO THERE WAS NO ACCIDENT REPORT. I DON NOT KNOW THE EXACT DATES BUT ENTERED A DATE AS REQUIRED BELOW.
NHTSA complaint #11318652 — an unverified report by a vehicle owner.
at 66,000 milesKernersville, NCCrash
STEERING
STEERING WHEEL LOCKED WHILE DRIVING
NHTSA complaint #11234073 — an unverified report by a vehicle owner.
at 91,000 milesNEW Iberia, LACrash
POWER TRAIN
1ST THE PLASTIC BUSHING THAT HOLDS THE SHIFT CABLE TO THE TRANSMISSION SHIFT LINKAGE BROKE AND LEFT THE CAR INOPERABLE ( UNABLE TO SHIFT ) PARKED IN MY CARPORT ABOUT 4 MOTHS AGO , 2ND THE PLASTIC BUSHING THAT HOLDS THE SHIFT CABLE TO THE CENTER CONSOLE SHIFTER BROKE AND LEFT MY CAR IN REVERSE AND TOOK OFF AND ROLLED BACK INTO CARPORT WITH BOTH DOORS OPEN , NEEDLESS TO SAY WHAT HAPPENED I'VE ONLY SEEN IN THE MOVIES UNTIL NOW , BOTH DOORS ARE TOTALED , AND CHEVROLET KNOWS THIS TO BE A PROBLEM BUT DOES NOT FIX CHEAP PLASTIC BUSHINGS , ONLY OFFERS WHOLE CABLE WITH SAME CHEAP PLASTIC BUSHINGS ...
NHTSA complaint #10877026 — an unverified report by a vehicle owner.
at 25,000 milesMidlothian, VACrash1 injured
ELECTRICAL SYSTEM
FIRST THE ROOF BLEW OFF.THE COMMUNICATION MESSAGE CENTER GIVES MIS INFORMATION.THE CAR HAS ALWAYS MADE A GRINDING SOUND UNDER HOOD AT START UP.PROBLEMSM ACTIVATING EELECTRICAL STABILITY SYSTEM.ALSO AFTER ROOF REPAIR ROOF RATTLES AND ALWAYS SOUND LOOSE.
NHTSA complaint #10628167 — an unverified report by a vehicle owner.
at 25,000 milesMidlothian, VACrash1 injured
STRUCTURE
FIRST THE ROOF BLEW OFF.THE COMMUNICATION MESSAGE CENTER GIVES MIS INFORMATION.THE CAR HAS ALWAYS MADE A GRINDING SOUND UNDER HOOD AT START UP.PROBLEMSM ACTIVATING EELECTRICAL STABILITY SYSTEM.ALSO AFTER ROOF REPAIR ROOF RATTLES AND ALWAYS SOUND LOOSE.
NHTSA complaint #10628167 — an unverified report by a vehicle owner.
at 25,000 milesMidlothian, VACrash1 injured
ELECTRONIC STABILITY CONTROL (ESC)
FIRST THE ROOF BLEW OFF.THE COMMUNICATION MESSAGE CENTER GIVES MIS INFORMATION.THE CAR HAS ALWAYS MADE A GRINDING SOUND UNDER HOOD AT START UP.PROBLEMSM ACTIVATING EELECTRICAL STABILITY SYSTEM.ALSO AFTER ROOF REPAIR ROOF RATTLES AND ALWAYS SOUND LOOSE.
NHTSA complaint #10628167 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Middlesex, NJ
STRUCTURE
The contact owns a 2006 Chevrolet Corvette. The contact became aware that the VIN was included in NHTSA Campaign Number: 09V491000 (Structure). The vehicle was taken to the local dealer, where the contact was informed that the recall part was no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the part had been discontinued. The contact was advised to purchase the part from a junkyard or to order an entire roof from the dealer at his expense. The contact had not experienced a failure.
NHTSA complaint #11702411 — an unverified report by a vehicle owner.
Hamilton, OH
FUEL/PROPULSION SYSTEM
2006 Corvette convertible. Has a strong gas smell after filling up. I understand this is a common problem, but Chevrolet will not acknowledge it. The gas can drip down on the hot exhaust system, and start a fire, burning down our house, or out on the road with us in it! Please help us get this deadly problem resolved, with little expense heaped upon us. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11693156 — an unverified report by a vehicle owner.
Hayes, VA
FUEL/PROPULSION SYSTEM
Strong fuel smell coming from the vehicle after fueling filling.
NHTSA complaint #11682855 — an unverified report by a vehicle owner.
Pensacola, FL
ELECTRICAL SYSTEM
We were driving 55 and the car stalled. This has happened several times. Been at dealer and the codes show fine they replaced what they thought was issue and it still does this. Very scary
NHTSA complaint #11660289 — an unverified report by a vehicle owner.
Pensacola, FL
ENGINE
We were driving 55 and the car stalled. This has happened several times. Been at dealer and the codes show fine they replaced what they thought was issue and it still does this. Very scary
NHTSA complaint #11660289 — an unverified report by a vehicle owner.
Port Charlotte, FL
STEERING
I purchased this car from a dealer in Sarasota Florida. Driving it home from the dealer, I was driving approximately 70 mph on [XXX] near Sarasota. The vehicle suddenly braked and pulled to the left simultaneously. I have taken it to a repair shop that specializes in Corvettes, and trying to ID the problem. In doing research, evidently it is related to the active handling system. There is a recall NHTSA Campaign Number: 10V172000 Manufacturer GENERAL MOTORS CORP. Components STEERING Potential Number of Units Affected 40,028 and a service bulletin 10118. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11639257 — an unverified report by a vehicle owner.
Port Charlotte, FL
SERVICE BRAKES
I purchased this car from a dealer in Sarasota Florida. Driving it home from the dealer, I was driving approximately 70 mph on [XXX] near Sarasota. The vehicle suddenly braked and pulled to the left simultaneously. I have taken it to a repair shop that specializes in Corvettes, and trying to ID the problem. In doing research, evidently it is related to the active handling system. There is a recall NHTSA Campaign Number: 10V172000 Manufacturer GENERAL MOTORS CORP. Components STEERING Potential Number of Units Affected 40,028 and a service bulletin 10118. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11639257 — an unverified report by a vehicle owner.
Phoenix, AZ
FUEL/PROPULSION SYSTEM
Vehicle is leaving a strong gas order inside and around the vehicle. This issue is currently awaiting to be inspected but for the meantime, it’s parked inside a garage where it completely fills the area with said odor. This is particularly unsafe due to our water heater also being located in this section of the house. Gas smell first appeared about a month ago and had consistently releasing these vapors. I’ve seen that GM has released a service bulletin for a short period of time but hasn’t officially recalled the fuel issue (faulty fuel system).
NHTSA complaint #11638767 — an unverified report by a vehicle owner.
San Diego, CA
STRUCTURE
The contact owns a 2006 Chevrolet Corvette. The contact received recall notifications of NHTSA Campaign Number: 09V491000 (Structure) and would like to be removed from the recall distribution list because the vehicle was no longer equipped with the recalled part. The dealer and the manufacturer were contacted.
NHTSA complaint #11634338 — an unverified report by a vehicle owner.
Bardstown, KY
STRUCTURE
The contact owns a 2006 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 09V491000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11628407 — an unverified report by a vehicle owner.
Antioch, CA
STRUCTURE
The contact owns a 2006 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 09V491000(Structure); however, the part to do the repair was not yet available. No further information was provided. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11623640 — an unverified report by a vehicle owner.
Elkridge, MD
FUEL/PROPULSION SYSTEM
Strong smell of fuel after driven with more than 1/2 tank of fuel.
NHTSA complaint #11552378 — an unverified report by a vehicle owner.
Hemet, CA
AIR BAGS
Air bag light goes on and mostly when driver seat is adjusted
NHTSA complaint #11545857 — an unverified report by a vehicle owner.
at 50,000 milesWaukee, IA
EXTERIOR LIGHTING
The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.
NHTSA complaint #11545376 — an unverified report by a vehicle owner.
at 50,000 milesWaukee, IA
ELECTRICAL SYSTEM
The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.
NHTSA complaint #11545376 — an unverified report by a vehicle owner.
at 50,000 milesWaukee, IA
SERVICE BRAKES
The contact owns a 2006 Chevrolet Corvette. The contact stated while driving at speeds above 25 MPH, the ABS system failed, causing the front brakes to activate without the driver depressing the brake pedal. During the failure the active handling warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the active handling control module wiring harness was faulty and needed to be replaced. Additionally, while operating the vehicle the low beam headlights inadvertently turned off. The mechanic diagnosed that the wiring harness for the exterior lighting needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V251000 (Electrical System, Exterior Lighting). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000. The contact stated that he pulled the fuse box and wiring from the car. In the photos, we can see a damaged wire around a tight bend that has created tension and caused a faulty connection.
NHTSA complaint #11545376 — an unverified report by a vehicle owner.
Redford, MI
POWER TRAIN
Happened twice within a day. The main electric fan on the radiator stopped working and the car overheated. Once at idle, was able to shut the car off safely. The second time, there was traffic on the highway, and the fan stopped working and the car started to overheat. Had to shut the car off and wait for it to cool down on the side of the road. When I got the car home, I found the electrical connector of the fan to be melted and fused together. There was no indicator that the fan would stop running prior to the engine overheating.
NHTSA complaint #11538312 — an unverified report by a vehicle owner.
Redford, MI
ELECTRICAL SYSTEM
Happened twice within a day. The main electric fan on the radiator stopped working and the car overheated. Once at idle, was able to shut the car off safely. The second time, there was traffic on the highway, and the fan stopped working and the car started to overheat. Had to shut the car off and wait for it to cool down on the side of the road. When I got the car home, I found the electrical connector of the fan to be melted and fused together. There was no indicator that the fan would stop running prior to the engine overheating.
NHTSA complaint #11538312 — an unverified report by a vehicle owner.
Redford, MI
ENGINE
Happened twice within a day. The main electric fan on the radiator stopped working and the car overheated. Once at idle, was able to shut the car off safely. The second time, there was traffic on the highway, and the fan stopped working and the car started to overheat. Had to shut the car off and wait for it to cool down on the side of the road. When I got the car home, I found the electrical connector of the fan to be melted and fused together. There was no indicator that the fan would stop running prior to the engine overheating.
NHTSA complaint #11538312 — an unverified report by a vehicle owner.
Redford, MI
SEATS
This is a 2006 Corvette with roughly 82,000 miles. The driver's seat will intermittently collapse on the recline function, resulting in a seat that is reclined all the way back. When this occurs, I need to pull myself up by the steering wheel while the vehicle is going down the road.
NHTSA complaint #11531554 — an unverified report by a vehicle owner.
Redford, MI
ENGINE
while driving at ~45mph and 3500 rpm, an exhaust valve dropped on the pass side cylinder head. vehicle lost motive power. there was a hole in the block on the passenger side and the vehicle needed a long block replacement. the vehicle had 79,000 miles
NHTSA complaint #11531603 — an unverified report by a vehicle owner.
El Cajon, CA
AIR BAGS
Air bag warning light comes on intermittently...goes away when I move the seat back and forth indicating there is faulty wiring with this vehicle. Apparently according to a corvette forum, this is a common problem, which tells me there is a chance that the problem possibly came from the factory.
NHTSA complaint #11531488 — an unverified report by a vehicle owner.
Vero Beach, FL
FUEL/PROPULSION SYSTEM
Fuel leaks from drivers side fuel tank. I see fuel tracks down side of tank, so conclude fuel is leaking from top of tank or from fuel pump. Fuel components are plastic, and now 17 years old, so they are probably cracked from age. I have strong smell of fuel in my garage, and puddle of fuel under drivers side tank. This is a safety hazard and must be fixed. I am aware of a number of other C6 Corvette owners with identical problems. GM must fix!
NHTSA complaint #11521009 — an unverified report by a vehicle owner.
Heyward, CA
UNKNOWN OR OTHER
This is a safety concern when I start my car and can not put it in reverse. This in todays world of violence and crime everywhere is truly a safety concern for women stuck in a car that you can not get out of park. The shift is stuck in park and will not move in any other position. Looking on the web this is a known problem on many 2005 and 2006 Corvette's for years. This has happened to many times to count.
NHTSA complaint #11515864 — an unverified report by a vehicle owner.
Lake Elsinore, CA
STEERING
my service active handling and traction control light will come on randomly and disappear, when it does come on usually my car will brake on one side of the car and skip and skid over to one side. when it happens I have zero control of the braking and steering and it has taken my car into another lane completely. it is terrifying and I've had the whole brake system replaced, along with ecm, ebcm, rack and pinion all suspension and steering components, wiring harness and just about everything I could think of that may cause it. I have a tilting telescope steering wheel and I've heard that they can cause this
NHTSA complaint #11492389 — an unverified report by a vehicle owner.