Owners have filed 191 complaints
about the 2002 Chevrolet Corvette with NHTSA between 2001 and 2025.
The largest single group is the steering.
Across this model's run it ranks 16 of 33 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 52
Against the median year of the Chevrolet Corvette. 50 means typical for this
model; 100 means roughly double.
Severity — 11
2.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 78
46% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2002 compares with every other Chevrolet Corvette
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
31.9%
1,000 – 9,999 miles
1710.8%
10,000 – 24,999 miles
1710.8%
25,000 – 49,999 miles
5333.5%
50,000 – 74,999 miles
3924.7%
75,000 – 99,999 miles
1912.0%
100,000 – 149,999 miles
42.5%
150,000+ miles
63.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2001peak 7Aug 2025
NHTSA investigations into the 2002 Chevrolet Corvette
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA02031Opened 15 Nov 2002Closed 11 Mar 2004STEERING:COLUMN
STEERING COLUMN LOCKUP
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED I...
Recalls on the 2002 Chevrolet Corvette
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
04V060000
STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Risk: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20040525,132 units in Canada
Steering
On certain vehicles equipped with Electronic Column Lock systems (ECL), when the ignition switch is turned to "Lock", the ECL prevents turning of the steering system. When the vehicle is started, the ECL unlocks the steering system. The vehicle is designed so that if the column fails to unlock when the vehicle is started and the customer tries to drive, the fuel supply will be shut off so that the vehicle cannot move when the vehicle cannot be steered. If voltage at the Powertrain Control Module (PCM) is low or interrupted, the fuel shut off may not occur and the vehicle can be accelerated while the steering system is locked. Correction: On vehicle equipped with an automatic transmission, the dealer will disable the steering column lock by removing the column lock plate. When the ignition key is removed, the transmission shifter will lock but the steering column will not lock. On vehicle equipped with a manual transmission, the dealer will reprogram the PCM. The steering column on these vehicles will continue to lock when the key is removed..
Reports where the owner recorded a crash, a fire, an injury or a death.
at 55,000 milesDecatur, ALCrash
VEHICLE SPEED CONTROL
2002 CORVETTE Z06. VEHICLE WAS OPERATING NORMALLY BUT WHEN I TURNED THE CORNER THE VEHICLE WENT TO FULL THROTTLE BY ITSELF. I MANAGED TO STOP THE VEHICLE BUT ONLY AFTER STRIKING A METAL POST. THIS COULD HAVE BEEN VERY BAD IF I WAS AT AN INTERSECTION.
NHTSA complaint #10232989 — an unverified report by a vehicle owner.
at 33,500 milesWoodstock, GACrash
STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
WHILE DRIVING DRIVER WAS UNABLE TO STEER BECAUSE THE STEERING COLUMN LOCKED. THIS CAUSED THE VEHICLE TO HIT A CURB, AND THE FRONT LEFT WHEEL DETACHED FROM THE VEHICLE. CONSUMER HAD VEHICLE TOWED TO THE DEALER, BUT PROBLEM WAS NOT RESOLVED.
NHTSA complaint #10061059 — an unverified report by a vehicle owner.
Fayetteville, ARCrash1 injured
SUSPENSION:FRONT
THE STABILIZER BAR AND SUPPORT ARM BROKE, VEHICLE SKIDDED INTO A MUDDY DITCH INTO AN EMBANKMENT. *AK
NHTSA complaint #10010027 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 51,491 milesClinton, MD
STEERING
The contact owns a 2002 Chevrolet Corvette. The contact stated that while driving 5-10 MPH, the steering wheel locked-up, and the vehicle continued to drive in a circle. The steering column warning light was illuminated after the failure. The vehicle was towed to the local dealer, where the contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 04V060000 (Steering), and the dealer determined that the electronic steering column lock replacement was needed. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was referred to the dealer for financial assistance. The failure mileage was approximately 51,491.
NHTSA complaint #11678680 — an unverified report by a vehicle owner.
Seminole, FL
POWER TRAIN
The ignition key started the car but the car continued to stall out when the clutch was released failing to propel the car leaving me stranded with a running(ideling) but non functional vehicle.I could not move the vehicle and it was subject to traffic crash. I need to have the vehicle retrieved by the dealer for repait. It is non-operable. There weree no warnings to me on the vehicle that the p roblem existed
NHTSA complaint #11509749 — an unverified report by a vehicle owner.
Seminole, FL
ELECTRICAL SYSTEM
The ignition key started the car but the car continued to stall out when the clutch was released failing to propel the car leaving me stranded with a running(ideling) but non functional vehicle.I could not move the vehicle and it was subject to traffic crash. I need to have the vehicle retrieved by the dealer for repait. It is non-operable. There weree no warnings to me on the vehicle that the p roblem existed
NHTSA complaint #11509749 — an unverified report by a vehicle owner.
Seminole, FL
FUEL/PROPULSION SYSTEM
The ignition key started the car but the car continued to stall out when the clutch was released failing to propel the car leaving me stranded with a running(ideling) but non functional vehicle.I could not move the vehicle and it was subject to traffic crash. I need to have the vehicle retrieved by the dealer for repait. It is non-operable. There weree no warnings to me on the vehicle that the p roblem existed
NHTSA complaint #11509749 — an unverified report by a vehicle owner.
at 68,000 milesChesnee, SC
STEERING
STEERING WHEEL IS LOCKED AFTER PARKING IT AFTER WORK. THE RECALL ON ALL OTHER VEHICLES MY YEAR THAT HAS BEEN FIXED BY THE FACTORY HAS A WIRE RAN TO THE PCM ARE COMPUTER NOT SURE WHAT THEY ARE CALLING IT. BUT THE FIX WILL NOT LET THE STEERING WHEEL LOCK. AND I HAVE WATCHED A LOT OF YOUTUBE VIDEOS ON THIS IN ALL OF THE FACTORY FIXED RECALLS THE STEERING WHEEL DOESN'T LOCK. FROM WHAT I SEE IT TELLS ME THAT THE FIX IS COMPLETE. IT IS A 2002 WITH ONLY 68000 MILES. ANY HELP PLEASE?
NHTSA complaint #11353464 — an unverified report by a vehicle owner.
at 980,000 milesLouisville, MS
STEERING
I BOUGHT CAR OFF INTERNET NOT SURE IF ANY RECALLS HAVE BEEN DONE TRACTION CONTROLS SERVICE ABS STABILITY CONTROLS LIGHTS WILL NOT GO OFF TOLD THAT PARTS ARE DISCONTINUED YOU MAY REACH ME AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11311431 — an unverified report by a vehicle owner.
at 980,000 milesLouisville, MS
EXTERIOR LIGHTING
I BOUGHT CAR OFF INTERNET NOT SURE IF ANY RECALLS HAVE BEEN DONE TRACTION CONTROLS SERVICE ABS STABILITY CONTROLS LIGHTS WILL NOT GO OFF TOLD THAT PARTS ARE DISCONTINUED YOU MAY REACH ME AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11311431 — an unverified report by a vehicle owner.
at 980,000 milesLouisville, MS
ELECTRONIC STABILITY CONTROL (ESC)
I BOUGHT CAR OFF INTERNET NOT SURE IF ANY RECALLS HAVE BEEN DONE TRACTION CONTROLS SERVICE ABS STABILITY CONTROLS LIGHTS WILL NOT GO OFF TOLD THAT PARTS ARE DISCONTINUED YOU MAY REACH ME AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11311431 — an unverified report by a vehicle owner.
at 125,000 milesLouisville, TN
EXTERIOR LIGHTING
DRIVING TO WORK (IN THE DARK) THE LOW BEAM HEADLIGHTS SHUT OFF. PULLED THE CAR OVER AND TURNED THE HEADLAMP SWITCH TO ON AND THEY STARTED WORKING (WAS IN AUTO SENSOR MODE). NEXT DAY WHEN I WAS LEAVING THE HOUSE I TURNED THE HEADLAMP SWITCH ON, HEADLIGHTS POPPED UP BUT DID NOT COME ON. I COULD TURN THEM TO HIGH BEAM AND THEY WORKED BUT NOT ON LOW. AFTER DRIVING THE CAR AND SWITCHING BACK AND FORTH FROM HIGH TO LOW BEAM SEVERAL TIMES, THE LOW BEAMS STARTED WORKING AGAIN.
NHTSA complaint #11252853 — an unverified report by a vehicle owner.
at 22,000 milesEast Meadow, NY
STEERING
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). AFTER THE REPAIR, THE STEERING WHEEL SEIZED WITHOUT WARNING AND A WARNING MESSAGE APPEARED, INDICATING TO REMOVE THE KEY AFTER TEN SECONDS. THE RECALL REPAIR WAS PERFORMED BY PAPE CHEVROLET GEO (370 OAKWOOD RD, HUNTINGTON STATION, NY, (631) 427-0900), BUT WAS NO LONGER IN BUSINESS. THE VEHICLE WAS TAKEN TO ROBERT CHEVROLET (236 S BROADWAY, HICKSVILLE, NY 11801, (888) 619-7642) WHERE IT WAS DETERMINED THAT THE REMEDY FAILED TO PROVIDE A PERMANENT SOLUTION. THE DEALER REPLACED THE STEERING COLUMN LOCK AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER INDICATED THAT THE RECALL REPAIR 15 YEARS AGO SHOULD HAVE PROVIDED A PERMANENT REMEDY. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBER: EA02031 (STEERING); HOWEVER, THE VEHICLE EXHIBITED THE SAME FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.
NHTSA complaint #11219205 — an unverified report by a vehicle owner.
at 16,800 milesMiami, FL
STEERING
I HAVE RECEIVED SEVERAL NOTICES FROM AUTO NATION CHEVROLET DORAL FLORIDA TO BRING MY CAR IN FOR RECALL GM 04006. WHEN I TOOK MY CAR TO THEM FOR THE RECALL, I WAS TOLD "THE PARTS REQUIRED FOR THE RECALL ARE NO LONGER MADE". I JUST RECEIVED ANOTHER NOTICE FROM THEM. THEY SHOULD EITHER MAKE THE PARTS OR COME TO ANOTHER RESOLUTION . I MEANWHILE CAN'T DRIVE THE CAR BECAUSE THE STEERING WHEEL LOCKS UP. HELP!!!
NHTSA complaint #11202927 — an unverified report by a vehicle owner.
at 55,000 milesNEW Smyrna Beach, FL
WHEELS
NOTICED A SLIGHT VIBRATION COMING FROM REAR OF CAR WHEN DRIVING ON A PAVED SMOOTH ROAD AT 65 MPH. UPON LATER INSPECTION, I DISCOVERED A 2" LONG CRACKED LR WHEEL THE CRACK IS LOCATED AT THE BASE OF ONE OF 5 SLENDER SPOKES WHERE IT CONNECTS TO THE BARREL OF THE WHEEL. ANY RETAILER WHO LISTS THIS 18" FORGED ALUMINUM WHEEL IS OUT OF STOCK AS THIS UPGRADED WHEEL WAS UNDER-DESIGNED FOR THE LOADING THAT HAPPENS TO A HIGH PERFORMANCE VEHICLE. THIS IS A COMMON PROBLEM WITH THE C5 CORVETTES AND COULD RESULT IN A CATASTROPHIC ACCIDENT AT HIGH INTERSTATE SPEEDS.
NHTSA complaint #11153414 — an unverified report by a vehicle owner.
at 20,000 milesPahrump, NV
STEERING
BACKING UP FROM A PRIVATE PARKING PLACE I ALMOST CRASHED DUE TO THE STEERING COLUMN LOCKED ON ME. I TRIED TO FREE IT BUT IT WOULDN'T RELEASE. THE CAR COMPUTER INDICATED I SHOULD REMOVE KEY FOR 10 SECONDS AND REINSERT TO FREE THE LOCKED STEERING WHEEL, NO SUCCESS. HAD CAR TOWED TO THE CHEVY DEALER FOR A FIX. DEALER SAID THEIR WAS A RECALL ON THIS DEFECT BACK IN 2004. DEALER RECORDS INDICATE THAT I TOOK THE VEHICLE IN FOR A RECALL BUT I DON'T REMEMBER WHAT THE RECALL WAS FOR. NONETHELESS, I HAVE NO RECORDS EXPLAINING WHAT WAS SPECIFICALLY DONE AT THAT TIME ON THE RECALL. THE DEALER ALSO HAS NO SPECIFIC RECORDS ON THAT RECALL. I AM THE ORIGINAL OWNER. THE DEALER HERE IN PAHRUMP NV FIXED THE PROBLEM AND SAID THAT THE PROBLEM WAS A COMPUTER DEFECT CAUSING THE ANTI THEFT PLATE TO LOCK THE STEERING PLATE. THEY REMOVE THE STEERING PLATE AND INSTALL A HARNESS KIT AND LOCK PLATE ELIMINATOR AND CHARGED ME $199.60 . I UNDERSTAND THAT RECALL DON'T EXPIRED, WHETHER THEY HAVEN'T BEEN PERFORMED OR IMPROPERLY REPAIRED. I OBJECT TO BEING CHARGED FOR A DEFECT THAT GMC INTERDUCE. THIS DEFECT IS DANGERIOUS. CLEARLY GMC DID NOT THINK OUT THE COMPARATIVE RISK OF A COMPUTER FAILURE CAUSING THE LOCKING PLATE TO DISENGAGE CAUSING THE CAR TO BE STOLEN; OR CAUSING THE PLATE TO LOCK WHILE DRIVING THE CAR INTO A DEADLY EVENT.
NHTSA complaint #11115846 — an unverified report by a vehicle owner.
at 5,928 milesNorwalk, CA
STEERING
I TOOK MY CAR IN FOR A STEERING COLUM LOCK RECALL, THE CAR WAS RUNNING FINE BEFORE I TOOK IT IN. ONCE I GOT THE CAR BACK TO MY HOUSE, TWO DAYS LATER THE STEERING WHEEL LOCKED WHILE IN GEAR AND HAS NOT UNLOCKED TO THIS DAY. I CALLED THE DEALERSHIP (WHICH WAS PENSKE CHEVROLET) AND SPOKE TO JOHN WHO TOLD ME "WELL WE ALREADY DID THE RECALL SO IT MUST'VE BEEN A PART OR SOMETHING ELSE". I WAS FURIOUS AND EXPLAINED THAT I'M NOT GOING TO PAY FOR SOME PART FOR THE SAME THING THAT SHOULD'VE BEEN FIXED. I COULD SEE IF MAYBE THEY FOUND SOME PART UNRELATABLE THAT NEEDED TO BE REPLACED, BUT NOT THE EXACT SAME THING THAT WAS FOR THE RECALL!! WHAT IF THE WHEEL LOCKED UP ON ME WITH MY SON IN THE CAR ON THE FREEWAY OR SOMETHING? I DON'T KNOW IF THE DEALERSHIP IS JUST TRYING TO GET MONEY OUT OF CUSTOMERS LIKE THIS OR WHAT, BUT THE CAR ONLY HAS 6 MILES ON IT SINCE I TOOK IT HOME FROM THE DEALERSHIP THAT DAY. SO WITHIN THAT SIX MILES IT HAS BEEN LOCKED AND HASN'T UNLOCKED. I JUST SIMPLY WANT MY CAR TO BE SAFE TO DRIVE. ANY HELP YOU GUYS COULD GIVE ME I WOULD GREATLY APPRECIATE IT. I DON'T KNOW WHAT ELSE TO DO. THANK YOU.
NHTSA complaint #11039680 — an unverified report by a vehicle owner.
at 75,000 milesTucson, AZ
STEERING
WARNING LIGHT OCCURRED ONCE I TRIED WHAT WAS SAID, REMOVE KEY & WAIT 10 SECONDS, DID THIS NUMEROUS TIMES TO NO AVAIL. TRIED TO MOVE CAR ONCE IT HIT 1 MILE PER CAR STALLS. UPON READING MANUAL SAYS IF DOESN'T UNLOCK GAS FLOW IS SHUT OFF & STALLS. CHECKED THE VIN # AGAINST THE RECALL LIST & MY CAR NOT LISTED.
NHTSA complaint #11012589 — an unverified report by a vehicle owner.
at 30,000 milesPalmetto BAY, FL
STEERING
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK WARNING INDICATOR ILLUMINATED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE CONTACT EXPERIENCED A FAILURE RELATED TO THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF A DEALER COULD REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 07/18/17*LJ THE CONSUMER SAID THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. UPDATED 08/15/2017
NHTSA complaint #10992653 — an unverified report by a vehicle owner.
at 30,000 milesPalmetto BAY, FL
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE COLUMN LOCK WARNING INDICATOR ILLUMINATED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE CONTACT EXPERIENCED A FAILURE RELATED TO THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE TO DETERMINE IF A DEALER COULD REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 07/18/17*LJ THE CONSUMER SAID THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. UPDATED 08/15/2017
NHTSA complaint #10992653 — an unverified report by a vehicle owner.
at 150,000 milesHailey, ID
VISIBILITY/WIPER
PLASTIC FITTING ON COWL FOR RH WINDSHIELD WASHER BROKE AND DISABLED WASHER. ONLY SOURCE FOR THIS PART IS A USED ONE FROM A SALVAGE OPERATION. GM SHOULD SELL SAFETY RELATED PARTS, ESPECIALLY PLASTIC ONES WHICH ARE SUBJECT TO AGING AND BREAKAGE.
NHTSA complaint #10905567 — an unverified report by a vehicle owner.
at 73,500 milesGermantown, MD
STEERING
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. WHEN THE CONTACT SHIFTED FROM PARK TO DRIVE, THE STEERING WHEEL FAILED TO UNLOCK. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PREVIOUSLY PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,500.
NHTSA complaint #10898316 — an unverified report by a vehicle owner.
at 54,462 milesOAK, WI
FUEL/PROPULSION SYSTEM
AFTER FUELING VEHICLE AND PARKING IN GARAGE THE VEHICLE FOR DAYS WILL SMELL VERY STRONGLY OF GASOLINE UNTIL GALLONS ARE CONSUMED VIA DRIVING TO APPROX. 3/4 OF TANK. VEHICLE IS NOT OVER FILLED ! NO VISUAL INDICATIONS OF FUEL LEAKING ON GROUND. THIS ALSO HAPPENED SINCE ON JULY 12, 2016 LAST TIME VEHICLE WAS FUELED.
NHTSA complaint #10884633 — an unverified report by a vehicle owner.
at 80,765 milesShalimar, FL
SERVICE BRAKES
BRAKES FAILED WHILE BACKING OUT OF THE GARAGE. AFTER INSPECTION IT WAS DETERMINED THE BRAKE LINE TO THE LEFT REAR WHEEL DEVELOPED A HOLE DUE TO EXCESSIVE RUSTING OF THE STEEL BRAKE LINE.
NHTSA complaint #10855002 — an unverified report by a vehicle owner.
at 102,500 milesCibolo, TX
UNKNOWN OR OTHER
WHEN THE FUEL TANK IS FILLED THEIR IS AN ENORMOUS GAS SMELL IN AND OUT OF THE CAR.
NHTSA complaint #10807309 — an unverified report by a vehicle owner.
Houston, TX
FUEL/PROPULSION SYSTEM
CAR HAS FUEL LEAK. ONCE I TURN ON THE CAR IT STARTS LEAKING GAS. I COULD BE STATIONARY OR IN MOTION, IT STILL LEAKS GAS. IT ALSO SMELLS TERRIBLE INSIDE MY CAR. I AM WORRIED ABOUT MY HEALTH AND OTHER CORVETTE OWNERS. SOME CORVETTE OWNERS MAY NOT EVEN NOTICE AND NEXT THING YOU KNOW THERE CAR IS ON FIRE. WORSE CASE SCENARIO THEY COULD BE INJURED OR EVEN DEATH. THIS IS A SAFETY ISSUE AND GM SHOULD RECALL THIS. IM LUCKY TO BE EVEN WRITING THIS I COULD'VE BLOWN UP WHILE DRIVING THE CAR.
NHTSA complaint #10795286 — an unverified report by a vehicle owner.
at 147,000 milesHailey, ID
EXTERIOR LIGHTING
THE PLASTIC PIECE ATTACHING THE HEADLIGHT VERTICAL ADJUSTING MECHANISM TO THE HEAQDLIGHT FRAME BROKE AND FELL OFF, CAUSING LARGE SHIFTS IN THE HEADLIGHT AIM DUE TO ROAD IRRREGULARITIES. CHEVROLET DOES NOT MAKE AVAILABLE DETAIL PARTS OF THIS RATHER COMPLICATED MECHANISM, MAKING IT NECESSARY TO BUY A COMPLETE RETRACTABLE HEADLIGHT ASSEMBLY FOR $1,000+. THIS DISCOURAGES PROPER REPAIR OF THIS SAFETY RELATED ISSUE.
NHTSA complaint #10782109 — an unverified report by a vehicle owner.
at 28,000 milesLAS Vegas, NV
STEERING
TL* THE CONTACT OWNS A 2002 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 28,000.
NHTSA complaint #10767553 — an unverified report by a vehicle owner.