1996 Chevrolet Silverado problems

VISIBILITY/WIPER

TL* THE CONTACT OWNS A 1996 CHEVROLET SILVERADO. WHILE OPERATING THE VEHICLE, THE WINDSHIELD WIPERS OPERATED INTERMITTENTLY WITHOUT WARNING. THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 03V159000 (VISIBILITY/WIPER). THE CONTACT TOOK THE VEHICLE TO WITTMEIER CHEVROLET (2292 FOREST AVE, CHICO, CA 95928, (530) 895-8181) AND WAS INFORMED THAT THE PARTS FOR THE RECALL REPAIR WERE CURRENTLY ON BACKORDER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.

NHTSA complaint #11288439 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

DURING A JUMP START IGNITION WOULD NOT DISENGAGE EVEN AFTER I TURNED OFF, AND REMOVED KEY. HAD TO REMOVER BATTERY CABLE 2 TIMES NOW

NHTSA complaint #10873661 — an unverified report by a vehicle owner.

VISIBILITY

1996 CHEVY SILVERADO CUSTOMER STATES THAT THE WINDSHIELD WIPER MOTOR SHOULD BE RECALLED BECAUSE THE MOTOR MIGHT FAIL RESULTING IN CRACKING SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD CUSTOMER WANTS TO BE REIMBURSED**CC THE CONSUMER STATED HE HAS DOCUMENTATION THAT HIS VEHICLE WAS INCLUDED IN THE RECALL, HOWEVER THE DEALER STATES HIS VEHICLE WAS NOT INCLUDED.

NHTSA complaint #10188981 — an unverified report by a vehicle owner.

VISIBILITY:WINDSHIELD WIPER/WASHER

DT*: THE CONTACT STATED THE WINDSHIELD WIPERS WORK INTERMITTENTLY. THE MANUFACTURER WAS ALERTED HOWEVER NO INSPECTION HAS BEEN MADE.

NHTSA complaint #10158860 — an unverified report by a vehicle owner.

FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

CONSUMER CHEVROLET SILRADO PICKUP HAS HAD THREE INJECTION PUMPS IN 92000 MILES. *TS ***REF 10157351***

NHTSA complaint #10157362 — an unverified report by a vehicle owner.

STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS

TAILGATE STRAPS FAILURE. MAN WAS STANDING ON TAILGATE PREPARING TO JUMP DOWN, AND BOTH STRAPS SNAPPED AT THE SAME TIME. THERE WAS NO NOTICE THAT THE STRAPS WERE WORN OR FAILING. VEHICLE IS USED AS SHOW TRUCK, NOT WORK TRUCK, AND IS IN EXCELLENT CONDITION. FAILURE IS AS DESCRIBED IN YOUR RECALL 04E067000, NHTSA ACTION EA04005 AND GM DEFECT NOTICE 04V-129, EXCEPTION FOR PRE 2000 VEHICLES.

NHTSA complaint #10155559 — an unverified report by a vehicle owner.

SEATS:FRONT ASSEMBLY:RECLINER

DT*: THE CONTACT STATED WHILE DRIVING 65 MPH WHILE APPLYING BRAKE PRESSURE THE DRIVER SEAT RECLINER FAILED CAUSING THE DRIVER TO BE PUSHED UP AGAINST THE STEERING COLUMN. ALTHOUGH THE DEALERSHIP AND MANUFACTURER WAS CONTACTED. REPAIRS WERE MADE BY TEAM CHEVROLET SAMARIUM, TENNESSEE. THE COST WAS $ 250.00. THIS FAILURE ALMOST RESULTED IN A FATAL CLASH. THE VEHICLE ENDED UP OFF HIGHWAY IN A DITCH.

NHTSA complaint #10152001 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

METAL HYDRAULIC BRAKE FLUID LINE RUSTS, DEGRADING TO THE LEAKING OF FLUID AND TOTAL LOSS OF BRAKING ABILITY. METAL LINE TO BE REPLACED WITH STAINLESS-STEEL. FUEL LINE IS IN SAME CONDITION, THOUGH NOT LEAKING FUEL. FUEL LINE TO BE REPLACED WITH STAINLESS STEEL.

NHTSA complaint #10146990 — an unverified report by a vehicle owner.

STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS

ON MY 1996 SILVERADO, THE TAILGATE STRAPS ARE STARTING TO RUST AND BREAK. I THINK THAT THE RECALL SHOULD BE EXTENDED BECAUSE THE RECALLED TAILGATE STRAPS ARE PUT TOGETHER THE SAME WAS EVEN IF IT IS NOT THE SAME MODEL.

NHTSA complaint #10141094 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

1996 CHEVY 4X4 TRUCK (SILVERADO) ABS ENGAGING AT LOW SPEEDS ON DRY PAVEMENT. VERY DIFFICULT STOPPING THE VEHICLE WHEN APPROACHING A 4-WAY STOP. KIDS IN THE TRUCK CAUSED A VERY UNNERVING EXPERIENCE.

NHTSA complaint #10140014 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THE BRAKES ON OUR 1996 CHEVY SILVERADO 4X4 PICK UP FAIL TO WORK PROPERLY. THERE IS A DELAY BETWEEN APPLYING PRESSURE ON THE BRAKE & THE TRUCK ACTUALLY BRAKING. THIS PROBLEM SEEMS TO HAPPEN MORE OFTEN WHEN BRAKING & TURNING. I FIRST NOTICED IT WHEN PULLING INTO A PARKING SPACE. THE TRUCK MAKES THE SAME SOUND & VIBRATION THAT HAPPENS WHEN THE ANTI LOCK BRAKES KICK IN IF YOU'RE SLIDING ON A SLIPPERY SURFACE. THIS MAKES IT IMPOSSIBLE FOR US TO TRUST THAT THE VEHICLE WILL STOP COMPLETELY WHEN NEEDED. CAUTION IS REQUIRED TO OPERATE THIS VEHICLE. WE DON'T DARE TOW ANYTHING OR EVEN LOAD THE BED OF THE TRUCK WITH ANYTHING TO HEAVY SINCE WE'RE WORRIED THAT THE BRAKES WILL NOT HANDLE THE EXTRA WEIGHT. WE'RE ALSO WORRIED ABOUT OPERATING IT IN INCLEMENT WEATHER WHICH IS FAST APPROACHING IN THE NORTHEAST. A MECHANIC TOLD US THAT ALOT OF CHEVY PICK-UPS HAVE THIS SAME PROBLEM. WE INVESTIGATED THIS ON THE INTERNET & FOUND THAT GM DID A RECALL FOR THIS PROBLEM ON VEHICLES IN CANADA BUT HASN'T DONE ONE IN THE US YET. WE ALSO FOUND OUT THAT THE FEDERAL GOVERNMENT IS INVESTIGATING THIS COMPLAINT, BUT IT'S IN THE EARLY STAGES OF IT'S INVESTIGATION. WE WOULD LIKE TO SEE IMMEDIATE ACTION TAKEN BEFORE THIS PROBLEM CAUSES AN ACCIDENT WHICH WOULD RESULT IN SERIOUS PROPERTY DAMAGE AND/OR BODILY INJURY.

NHTSA complaint #10137362 — an unverified report by a vehicle owner.

TIRES

SIDEWALLS OF TWO TIRES SEPARATED, ONE AT THREE PLACES AND ONE AT ONE PLACE. ONE TIRE CRACKED ALONG THE BEAD. ONE TIRE WAS REPLACED AND PRORATED UNDER WARRANTY.

NHTSA complaint #10135858 — an unverified report by a vehicle owner.

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

SINCE PURCHASED FROM MAHER CHEVROLET IN 2001, THE "C CLIP" IN THE "TRANSFER CASE" HAS BROKEN THREE TIMES AND WE HAVE NEVER USED THE 4 WHEEL DRIVE. THIS OCCURS DURING NORMAL DRIVING! THE FIRST TIME WAS WITHIN MONTHS AFTER OWNING THE VEHICLE. THE SECOND TIME WAS 30,000 MILES AFTER IT REPLACED. NOW LESS THAN 20,000 MILES LATER, ITS BROKE AGAIN. THERE MUST BE SOMETHING DEFECTIVE INTERNALLY IN THE TRANSFER CASE. WHEN DRIVING AND THE "C CLIP" BREAKS, THE GEARS START GRINDING LOUDLY. YOU CAN NOT EXCEED 3 - 5 MILES PER HOUR. SINCE THIS IS AN INSTANT MOVEMENT, THIS CAN CAUSE AN ACCIDENT WEHN TRAVLING ON THE INTERSTATE. WHICH MY HUSBAND FREQUENTLY DOES WHILE DRIVING TO WORK. THE WARRANTY HAS EXPIRED ON THE VEHICLE AND I DON'T UNDERSTAND WHY THIS PROBLEM HAS NOT BEEN FIXED SINCE IT WAS BROUGHT BACK TO THE DEALER ON TWO OCCASIONS AND SUPPOSEDLY, FIXED THEN. IS THE DEALERSHIP THE PROBLEM OR AM I DEALING WITH UNSAFE DEFECT WITH THE TRANSFER CASE. I WILL LIST THE APPROX. DATE THAT THE DEALERSHIP LOOKED AT MY TRUCK LAST, AND THEN WANTED TO CHARGE ME OVER $2,500 TO "INVESTIGATE" WHY THE "C CLIP" KEEPS BREAKING.

NHTSA complaint #10120538 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

DT: WHILE DRIVING SHE WAS EXPERIENCING HESITATION, HIT POTHOLE AND HAD TO BE TOWED HOME. UPON INSPECTION OF THE VEHICLE, THE FACTORY WIRING INSIDE THE FUEL TANK TO THE FUEL PUMP WAS BURNED UP AT THE CONNECTOR, ONLY BEAR WIRING WAS PRESENT IN THE FUEL TANK. FEARFUL THIS MAY CATCH FIRE. HARDWIRED THIS FEATURE PER OWNER WHO IS ALSO MECHANIC. APPEARED TO BE FAULTY WIRING, DEFINITELY 4 PIN CONNECTOR AT THE TOP OF THAT WIRE ASSEMBLY. NO OTHER PROBLEMS.

NHTSA complaint #10120113 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

HEADLIGHTS WOULD INTERMITTENTLY GO OUT WHILE DRIVING AT NIGHT. CONSUMER WOULD HAVE TO MOVE THE TILT STEERING WHEEL TO GET THE HEADLIGHTS TO COME BACK ON. DEALER WAS NOTIFIED.

NHTSA complaint #10115205 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:WIRING

HEADLIGHTS WOULD INTERMITTENTLY GO OUT WHILE DRIVING AT NIGHT. CONSUMER WOULD HAVE TO MOVE THE TILT STEERING WHEEL TO GET THE HEADLIGHTS TO COME BACK ON. DEALER WAS NOTIFIED.

NHTSA complaint #10115205 — an unverified report by a vehicle owner.

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

INTERMITTENTLY WINDSHIELD WIPERS FAILED TO OPERATE OR FUNCTION PROPERLY DUE TO THE DEFECT DESCRIBED IN RECALL 03V159000. BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. THE WINDSHIELD WIPER MOTOR HAD TO BE REPLACED.

NHTSA complaint #10106647 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

WHILE PULLING INTO THE DRIVEWAY VEHICLE COMMENCED TO ACCELERATE AND LURCHED FORWARD. CONSUMER WAS ABLE TO SLAM ON THE BRAKES, AND TURN THE IGNITION SWITCH OFF BEFORE ANY OTHER DAMAGE COULD HAVE OCCURRED. DEALER WAS NOTIFIED.

NHTSA complaint #10090020 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

VEHICLE EXPERIENCED LOSS OF BRAKES WHILE TOWING A TRAILER. CONSUMER INSPECTED THE VEHICLE, AND REPLACED TWO FRONT BRAKE HOSES THAT ERUPTED. ALSO, VEHICLE STALLED WHILE IN MOTION. VEHICLE HAD BEEN TO DEALER ON TWO OCCASIONS, AND THEY WERE UNABLE TO DUPLICATE OR RESOLVE THE PROBLEM.

NHTSA complaint #10080225 — an unverified report by a vehicle owner.