474 of the 11,934 complaints filed about the Ford Expedition are about the fuel system — 4% of everything owners reported. The worst model year for it is 2005.
474
Complaints
4%
Share of all complaints
6
Crashes
29
Fires
FUEL/PROPULSION SYSTEM
vehicle shifting erratically and shows fuel mileage low and loss of speedometer
NHTSA complaint #11756398 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
vehicle shifting erratically and shows fuel mileage low and loss of speedometer
NHTSA complaint #11756399 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
While stopped at a traffic light, my 2021 Ford Expedition began running rough. When the light changed and I accelerated through the intersection, the vehicle experienced a severe loss of engine power and barely made it through the intersection. After I pulled off the roadway and released the accelerator, the engine stalled. I was able to restart the engine once while applying approximately one-quarter throttle. It continued running rough and stalled again when I released the accelerator. The vehicle was taken to Robinson Brothers Ford/Lincoln in Baton Rouge, Louisiana. The Ford dealer documented the rough running, low power and stalling and diagnosed the "fuel pump inop." The dealer removed the fuel tank and replaced the fuel pump/sender assembly. The replacement part listed on the dealer invoice is Ford part JL1Z-9H307-G. Vehicle mileage was approximately 79,390. Several months before the complete failure, during very cold weather, I also experienced one brief incident of unusually low engine power shortly after starting the vehicle. I do not know whether that earlier incident was related. I am concerned that this failure may be related to the low-pressure fuel pump failure condition addressed by Ford Safety Recall 25S75 / NHTSA Recall 25V-455, which includes certain 2022 Ford Expeditions. My 2021 Expedition is not currently included in that recall. The loss of power occurred while I was crossing an intersection and created a serious safety risk. I am submitting this complaint so NHTSA can evaluate this fuel pump failure along with failures involving other vehicles excluded from Recall 25V-455.
NHTSA complaint #11755789 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The engine stalled out while trying to pass someone. The car wouldn't go faster when hitting the gas and felt like I couldnt safely slow down to get back over. It felt like something slipped and lost traction, but roads were dry and not rocky or sandy. tapping breaks and letting off gas did nothing. it has happened before but usually in winter, and gettin up to speed. its like the gear shift got stuck.
NHTSA complaint #11753596 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
1) 2021 EXPEDITION TOWING A TRAILER, 30 MPH ON UPHILL ON RAMP HATHAWAY BRIDGE PANAMA CITY, FL. I FLOOR THE ACCELERATOR PEDAL TO DOWNSHIFT TO TRY TO ACCELERATE. I HEAR A LOUD CLUNK FROM THE TRANSMISSION. THE CAR GOES INTO NEUTRAL-NOTHING, NO ACCELERATION. I QUICKLY LET OFF THE ACCELERATOR PEDAL AND QUICKLY REAPPLY FORCE TO THE PEDAL IN A SMOOTH MANNER AND TRANSMISSION RE-ENGAGES AND I PULL AWAY. NO ACCIDENT THIS TIME. OCCURRED APRIL 2026. 2) WHEN STOPPED CAR WILL SOMETIMES LURCH FORWARD 2-3 FEET WHEN 1ST SHIFTING TRANSMISSION FROM PARK INTO DRIVE EVEN THOUGH FOOT IS ON BRAKE FIRMLY. OCCURS INTERMITTENTLY.
NHTSA complaint #11752216 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 26V204000 (Visibility), and 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11749999 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
This vehicle has 70K miles and the fuel pump died, confirmed by Dick Smith Ford in Columbia, SC. There were no warning lights or messages via our Ford app. There were no symptoms prior to failure. The vehicle just died in the middle of the road on a train track with our family in danger. We could have been hit by cars behind us or stuck on the train track with a train approaching. We were in the middle of the road on a train track in Columbia, SC, 2.5hrs away from our home. Our family waited 2.5hrs for the vehicle to be towed and then had to take a $200 Uber from Columbia, SC to Charleston, SC to get home. The quoted cost to repair the vehicle just to get it back home is $2,000. Ford has recalled all the Ford trucks for 2021 that use this same engine. Ford has recalled the 2022 Expedition which is identical to the 2021. Ford has recalled the 2021 Lincoln Navigator that is the same platform as the Expedition only aesthetically upgraded. I believe they didn't recall the 2021 Ford Expedition due the the volume of cars that would be recalled.
NHTSA complaint #11747243 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
This was a rental vehicle hybrid, while driving on a highway, the vehicle first developed a flat tire. Afterward, while the vehicle was in motion, smoke appeared and the vehicle caught fire spontaneously. There was no collision or impact of any kind. The driver pulled over and all passengers exited safely. The fire spread very rapidly and it's a total loss. The fire department responded and extinguished the fire. The fire appears to have originated in the hybrid battery area. The were no warnings. Safety risk: the fire occurred while vehicle was moving on a public highway with occupants inside, and spread very quickly after stopping. The Highway Patrol attended the scene and a police report was filled, incident documented. I'm reporting this as a serious safety concern.
NHTSA complaint #11743790 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.
NHTSA complaint #11743375 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no reports of bad gas. Towed to repair facility where dead fuel pump was diagnosed and replaced. Ford recall 25S75 includes some 2022 expeditions but not this 2021 with only 43,000 miles and no previous issues.
NHTSA complaint #11729294 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while depressing the accelerator pedal, the vehicle hesitated before accelerating to the intended speed. The dealer was contacted and confirmed that the part to do the recall repair was not available. The manufacturer was not made aware of the issue. The failure mileage was unknown.
NHTSA complaint #11727497 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
My vehicle shutters like it’s is going to die/shit off. When will this issue be resolved with the fuel pump system failure? I will be doing some research with the BBB to find out if this will be an actionable lawsuit. Most consumers who own these types of SUVs are mothers! This needs to be resolved asap!
NHTSA complaint #11726375 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Ford has a recall on the low pressure fuel pump but no fix yet. My fuel pump failed and I am being charged to fix it. But that also puts me back on the road with an unsafe vehicle. They will not provide me a rental until the recall has a solution or fix.
NHTSA complaint #11725500 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Low fuel pump pressure please can you fix it recall on this vehicle it’s been over 7 months I been waiting and no parts is available please let me know when will be available July 2026? Or longer?
NHTSA complaint #11720318 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25E070000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the transmission was slipping while driving and shifting into gear, and an unknown warning light was flashing. Additionally, the contact stated that while driving at various speeds on uneven pavement or over a minor bump in the roadway, the rear of the vehicle was jumping and the vehicle became slightly unstable, causing occupants or items in the rear passenger’s seats to bounce. Additionally, the contact stated that the vehicle made an abnormal rattling sound at start-up. The contact stated that the fuel pump was only pumping fuel at 33% and DTC: P00C6 was retrieved. The vehicle was taken to the dealer, where it was diagnosed and determined that the timing chain was stretched, and the valve cover was leaking. Additionally, the vehicle was diagnosed with the left catalytic converter, rear shocks and struts, timing chain, valve covers, fuel pump, and transmission failures. The parts were replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 105,000.
NHTSA complaint #11701638 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the recall was initiated in July 2025, and parts were still not available. The contact stated that the recall repair was urgently needed because the contact travelled with her grandchildren inside the vehicle. In addition, the contact was stuck in another State because the contact was afraid to drive the vehicle due to the safety recall. The manufacturer was made aware of the concern. The contact had not experienced a failure.
NHTSA complaint #11701437 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
The SUV was driving smoothly at 55mph speed, suddenly I hit the break and tried to reaccelerate and felt a hard transmission shift, felt like metal hitting metal, felt like it was forced to shift to drive mode from parking mode. After that I started using 93 octane rated gasoline, do not observe the problem too much. I will really scary and unsafe, the whole SUV shook hard for 2sec.
NHTSA complaint #11699359 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not available. The dealer was contacted, and the contact was informed that parts were not available. The contact stated that the recall notification was received shortly after the vehicle was purchased. The manufacturer was not made aware of the failure. The contact had not experienced a failure.
NHTSA complaint #11699447 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Vehicle stalls out upon driving when trying to accelerate. Has popped up error which states to check fuel pump.
NHTSA complaint #11698531 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the parts for the recall repair were not yet available. The contact called the local dealer and was informed that the manufacturer would mail another notice when parts were available. The contact stated that a year ago, while driving approximately 30 MPH, the vehicle stalled. The contact stated that there was no warning light illuminated during the failure. The contact was able to restart the vehicle. The dealer was contacted but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was 59,844.
NHTSA complaint #11690486 — an unverified report by a vehicle owner.