352 of the
11,934 complaints filed about the Ford Expedition
are about the steering —
3% of everything owners reported.
The worst model year for it is 1997.
1. There was front suspension failure where the lower ball joint has separated, causing the steering knuckle and wheel assembly to detach and collapse while driving- yes it is available to inspect if done tomorrow 2. Driver could not control car, passengers and other cars on road in immediate danger. Car was swerving with loss of control 3 Independent service center looked-this should have not have happened. 4 No happened yesterday was going to bring to dealer after Ind looked at it 5. No warning
NHTSA complaint #11758376 — an unverified report by a vehicle owner.
The rear suspension oscillates and bounces violently over bumps, expansion joints, broken or uneven pavement, and washboard surfaces. It occurs at highway speed, at normal neighborhood speeds, and while slowing or coming to a stop over rough pavement. The rear suspension does not recover after a bump: it continues bouncing, the rear of the vehicle steps sideways, and steering correction is required to keep the vehicle in its lane. The condition is highly unpredictable. It does not occur on every bump and the driver cannot anticipate it, so there is no way to drive around it. Because it is intermittent, a short test drive may not reproduce it. On a recent drive on [XXX] south of Salt Lake City it occurred approximately 20 to 40 times over a seven mile stretch, with my wife driving. She has had to slow well below the posted 70 mph limit to maintain control. She will no longer drive the vehicle or transport our children in it. The vehicle was previously presented to an authorized Ford dealer for this concern and the condition was not corrected. It has worsened since. We have stopped driving it and had it towed to the dealer on August 11, 2026 because we do not consider it safe to drive. The vehicle is at the dealer now and is available for inspection. The manufacturer has opened a case and a repurchase review. No warning lamps or messages have appeared. The vehicle is completely stock with no aftermarket suspension, wheels, or tires. This is a loss of control risk at highway speed to my family and to other road users. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11756339 — an unverified report by a vehicle owner.
The empty passenger sea, steering wheel, center console and sun visor has aggressive shake at speeds over 35MPH. Dealer did the road force balance but that didn't fix it, it's something in drivertaina nd they are refusing to fix it. Vehicle seems unsafe to derive
NHTSA complaint #11755439 — an unverified report by a vehicle owner.
While leasing this vehicle from Hertz via Priceline out of Seattle the vehicle was always was extremely difficult to keep in is own lane. Didn't matter if you were doing 20 mph or 60 mph. This was brought to Hertz via Priceline and they have not answered back to what the issues were other than saying no one else complained about it an apparently are investigating the problem. This vehicle was picked up on April 29,2026 from SeaTac and returned on May 4,2026. Neither Priceline did nothing but gave a $25 credit and Hertz will not answer any attempts to contact them.
NHTSA complaint #11752250 — an unverified report by a vehicle owner.
The contact owns a 2026 Ford Expedition MAX. The contact stated that while driving at 70 MPH or higher speeds, the steering wheel shuddered due to a front suspension issue. The contact completed some research online and learned that it was a known failure associated with 2025 - 2026 model years. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 800.
NHTSA complaint #11742718 — an unverified report by a vehicle owner.
While driving in heavy traffic on Interstate 10 west bound, I made a right blinker lane change. Right after complete lane change, vehicle emergency brake applied putting me into a spin and steering was fighting me trying to correct thus causing 2 impacts to a vehicle on side of me. It was light drizzle and dash cam footage is available of vehicle taking control.
NHTSA complaint #11740961 — an unverified report by a vehicle owner.
I purchased a new 2025 Ford Expedition Max. Since I left the dealer’s lot, the vehicle has had a strong vibration at any speed over 60 miles per hour, which makes highway driving and longer distance trips very challenging or impossible. Since I bought the vehicle, I have had to return it for dealership warranty service a total of three times. Despite the three warranty service repairs at Ford authorized dealers, I am still having the strong vibration at any speed over 60 miles per hour in my vehicle at this time. The strong vibration makes the driver feel fatigued, light-headed and dizzy after 30 minutes of highway driving at any speed over 60 mph, impacting driving the vehicle safely, increasing the risk of road accidents and potentially resulting in death or serious bodily injury. The vehicle does not feel safe to drive at highway speed or for longer distances. Driving at 60 miles per hour or more becomes extremely uncomfortable, as a strong vibration is felt in the seat shaking the back, in the steering wheel, shaking hands and arms and in the floor shaking the legs. It makes highway driving very unpleasant and longer distance trips very challenging or impossible, which is one of the main purposes of the intended use of the vehicle.
NHTSA complaint #11740274 — an unverified report by a vehicle owner.
With speeds in excess of 70 MPH, the car have a violent shake. The shake gets worse as you approach 80 MPH. This is in both the 2025 and 2026 Ford Expedition models. This put drivers at risk, as they must keep control of the car at all times on the highway if they are in excess of 70 MPH. The car has already been inspected by Ford and they did a road balance test and replaced one tire. The car still shakes at high speeds. Ford is looking to bring my car in a 2nd time to look at the issue again. No warning lights came on. This appears to be a driving issue not related to anything that would come up electronically.
NHTSA complaint #11738134 — an unverified report by a vehicle owner.
The contact owns a 2022 Ford Expedition. The contact stated that while the vehicle was parked, it failed to start with several unknown warning lights illuminated. The vehicle was jump-started. The dealer was contacted, but the vehicle was not repaired. The manufacturer was notified of the failure. Additionally, the contact stated that the air bag warning light continuously remained illuminated. The failure was associated with NHTSA Campaign Number: 23V847000 (Steering, Air Bags); however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.
NHTSA complaint #11734069 — an unverified report by a vehicle owner.
Steering wheel clicking when rotating, LOUD whirring/humming noise directly under where the sliding console is located, noise reverberates all throughout the cab and is worse at 65mph
NHTSA complaint #11726012 — an unverified report by a vehicle owner.
Since new the vehicle has had a vibration/shake while driving at all speeds. Initially the issue was only at highway speed but is still present after dealer 'fix'. New car spent 3 days at dealer with 1,000 miles on the odometer. At the time shake was so bad over 65mph it felt unsafe to drive at highway speed. The Dealer tried balance and rotate wheels. No fix. Then the driveshaft was re indexed. That was a temporary as the issue is still present
NHTSA complaint #11707472 — an unverified report by a vehicle owner.
The contact owns a 2025 Ford Expedition. The contact stated that while driving 75 MPH, the steering wheel failed to steer in the intended direction. The contact stated that the blue cruise hands-free system was activated during the failure. In addition, the vehicle was shaking and the brakes were independently activated. The contact was able to correct the steering wheel to the intended lane. No warning lights were illuminated. The contact stated that the failure could have caused a crash. In addition, the failure occurred while the contact was driving at night. The contact's wife and grandchild were occupants in the vehicle during the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 2,500.
NHTSA complaint #11703687 — an unverified report by a vehicle owner.
When you try to accelerate quickly, even when you’re switching lanes on the interstate or just driving down the road, the car will sometimes pop out of gear or something and almost comes to a complete stop causing you to almost get rear ended. I’ve almost been hit several times because the car stops and won’t go.
NHTSA complaint #11698224 — an unverified report by a vehicle owner.
The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and found that the battery was operational and there were no other electrical issues. The contact stated that later, while starting the vehicle, the message "Loss of Power Steering Assist" was displayed, and the steering wheel was difficult to turn to the left or the right. The vehicle was turned off and restarted, and regained power steering functionality; however, the failure reoccurred. The contact attempted to reset the electrical system by disconnecting the battery terminals. The contact stated that loss of power steering reoccurred with the loss of the Lane Keep Assist feature. The contact had taken the vehicle back to the same dealer who diagnosed the vehicle and checked the wiring harness and coated the terminal connectors with a gel for better connectivity. The vehicle was repaired; however, the failures reoccurred. Additionally, the contact stated that the “Driving Modes” light was illuminated. The contact stated that while attempting to switch modes to Snow or Sport, or another option, the light illuminated with the message that each selected mode was unavailable. The contact stated that the vehicle would be taken back to the dealer for the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 36,000.
NHTSA complaint #11683069 — an unverified report by a vehicle owner.
The vehicle stopped running while driving, my wife stopped at a stop sign after vehicle had run ~ 10 minutes. Upon entering the inter-section the vehicle started to run rough, and ultimately stalled and would not restart. She was able to coast into a parking lot entrance within On Top of World subdivision where we live and get off of main road. After multiple AAA attempts to jump start, AAA confirmed the vehicle was unable to be jump started, therefore vehicle was towed to local ford dealership for diagnostics. They tried to jump start multiple times and after 2 days, pushed it into garage. They confirmed fuel pump failure and replaced with current design. We were charged for towing, new battery, and fuel pump system replacement with current design and advised we would have to bring it back in when Ford identified remedy for current recall. No loaner vehicle provided. We are very concerned as if this event had occurred on an interstate, there is a high risk of accident/injury. After repair with existing part designs we are worried about another failure on busy road/interstate.
NHTSA complaint #11681839 — an unverified report by a vehicle owner.
The contact owns a 2019 Ford Expedition. The contact stated that while his wife was driving on a neighborhood road at an undisclosed speed, the steering wheel seized. There were no warning lights illuminated. The driver proceeded to pull over, and the vehicle was towed to a local dealer to be diagnosed. The contact was informed that the electronic steering control module was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 58,000.
NHTSA complaint #11680426 — an unverified report by a vehicle owner.
The contact owns a 2024 Ford Expedition. The contact stated that while driving on several occasions at speeds between 60 MPH - 80 MPH, the vehicle was shaking abnormally. The vehicle was taken to the dealer approximately six times however, the dealer was unable to duplicate the failure. The manufacturer was notified of the failure. The failure mileage was approximately 5,000.
NHTSA complaint #11679888 — an unverified report by a vehicle owner.
Was returning home from a drive on a freeway and noticed that car started shaking violently on right side rear of vehicle, like tires were loose, when I was close to the exit. Upon exiting freeway I noticed that vehicle at 20mph speeds+ (more noticeable at 25mph+) the car began shaking. Car shakes as well throughout braking. I took it to the tire shop to see if it was a tire issue or a balance issue, but the shop informed it wasn't a tire issue but possibly a CV related. Because I'm feeling the vibrations more from one side of vehicle, thinking it could be related to the toe link. Seeing car parked on driveway, it does seem to be leaning more to the right in the rear of the vehicle
NHTSA complaint #11669945 — an unverified report by a vehicle owner.
The contact owns a 2017 Ford Expedition. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The contact's friend inspected the vehicle; however, no cause for the failure was found. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was unknown.
NHTSA complaint #11648681 — an unverified report by a vehicle owner.
The vehicle's steering wheel became very loose at ~50k miles making it wobbly and potential to fall off which could cause danger while driving and possibility of airbag deployment. As seen in the attached pictures, there was no thread locker on the bolt that tightens the steering wheel down. I was able to remove it simply with my hands upon a few twist.
NHTSA complaint #11631929 — an unverified report by a vehicle owner.