Owners have filed 415 complaints
about the 2002 Ford Expedition with NHTSA between 2002 and 2024.
The largest single group is the engine & cooling.
Across this model's run it ranks 8 of 30 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 52
Against the median year of the Ford Expedition. 50 means typical for this
model; 100 means roughly double.
Severity — 100
34.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 29
17% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2002 compares with every other Ford Expedition
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Engine
3742.5%
Tread/Belt
1213.8%
Frontal
1011.5%
Cruise Control
910.3%
Automatic Transmission
89.2%
Accelerator Pedal
44.6%
Sidewall
44.6%
Front
33.4%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
61.9%
1,000 – 9,999 miles
61.9%
10,000 – 24,999 miles
144.4%
25,000 – 49,999 miles
5818.2%
50,000 – 74,999 miles
5015.7%
75,000 – 99,999 miles
5818.2%
100,000 – 149,999 miles
8025.2%
150,000+ miles
4614.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2002peak 10Jul 2024
NHTSA investigations into the 2002 Ford Expedition
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP05005Opened 22 Sep 2005Closed 4 Jan 2006ENGINE AND ENGINE COOLING:ENGINE
SPARK PLUG EJECTION FROM CYLINDER HEAD
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN A...
EA05005Opened 22 Mar 2005Closed 2 Aug 2006ELECTRICAL SYSTEM
ENGINE COMPARTMENT FIRES
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHIC...
Recalls on the 2002 Ford Expedition
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2005028304,417 units in Canada
Electrical
On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Initially as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. As soon as replacement parts are available, owners will be instructed to return to the dealers for installation of a new switch or fused wiring harness.
Recall 2004164305,024 units in Canada
Steering
On certain vehicles, Ford has issued a scheduled maintenance guide update which specifies that every 20 000 kms, the steering linkage, which includes tie-rod ends, should be inspected. The vehicle owner is asked to place the tie-rod end inspection procedure supplied with this maintenance guide update in the vehicle's glove box for reference and safekeeping. The vehicle owner is to provide the inspection procedure to their repair facility to help properly identify worn tie-rod ends. Performing the vehicle scheduled maintenance, including maintenance inspections, is the responsibility of the vehicle owner. Failure to replace worn tie-rod ends may eventually result in a tie-rod end separation that could adversely affect steering control. If the inspection reveals that a tie-rod end is worn and must be replaced, the repair will be at the owner's expense unless the vehicle is still covered by the basic vehicle warranty, or has an extended service plan coverage that includes these components.
Reports where the owner recorded a crash, a fire, an injury or a death.
Ontario, CAFire
VEHICLE SPEED CONTROL
Cruise control deactivation switch. I was getting in my truck on my way to work in the early morning. as I walked by the hood I could smell what seemed like burning wire, so I opened the hood & right as I got it all the way up flames started shooting up. I put the fire out and had to wait to call my mechanic he came and told me it was definitely the deactivation switch that had caught fire.
NHTSA complaint #11603537 — an unverified report by a vehicle owner.
at 146,457 milesHemet, CAFire
VEHICLE SPEED CONTROL
The contact owns a 2002 Ford Expedition. The contact stated that while the vehicle was parked, it caught fire. The fire started from under the hood of the vehicle. The contact was able to extinguish the fire with water. An independent mechanic came to the contact's residence and diagnosed that the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control) however, the contact did not receive notification of the recall. The mechanic informed the contact that the speed control deactivation switch caused the fire that damaged the hydraulic control unit and the pigtail. The vehicle was towed to the dealer. The dealer confirmed that the failure was related to the recall. However, the dealer denied the recall repair since the recall was open for many years but was left unrepaired. The contact stated that she had owned the vehicle for a couple of months and was not aware there was a recall. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,457.
NHTSA complaint #11446373 — an unverified report by a vehicle owner.
at 146,457 milesHemet, CAFire
FIRERELATED
The contact owns a 2002 Ford Expedition. The contact stated that while the vehicle was parked, it caught fire. The fire started from under the hood of the vehicle. The contact was able to extinguish the fire with water. An independent mechanic came to the contact's residence and diagnosed that the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control) however, the contact did not receive notification of the recall. The mechanic informed the contact that the speed control deactivation switch caused the fire that damaged the hydraulic control unit and the pigtail. The vehicle was towed to the dealer. The dealer confirmed that the failure was related to the recall. However, the dealer denied the recall repair since the recall was open for many years but was left unrepaired. The contact stated that she had owned the vehicle for a couple of months and was not aware there was a recall. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,457.
NHTSA complaint #11446373 — an unverified report by a vehicle owner.
at 183,000 milesMiddletown, CTFire
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
TL* THE CONTACT OWNED A 2002 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT FOUND THAT THE MASTER CYLINDER CAUGHT FIRE. THE FIRE DEPARTMENT WAS NOT CONTACTED. A FIRE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO CROWLEY FORD LINCOLN (225 NEW BRITAIN AVE, PLAINVILLE, CT 06062) WHERE IT WAS DEEMED DESTROYED. THE DEALER DID NOT GIVE A DIAGNOSIS, BUT CONTACTED THE MANUFACTURER MULTIPLE TIMES TO DETERMINE WHAT FORD SHOULD COVER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE MANUFACTURER PROVIDED CASE NUMBER: CAS12637815 AND ADVISED THE CONTACT TO CALL HIS INSURANCE COMPANY. THE MANUFACTURER STATED THAT THEY WOULD SEND AN INSPECTOR. THE APPROXIMATE FAILURE MILEAGE WAS 183,000. UPDATED 09/07/17*LJ
NHTSA complaint #11004132 — an unverified report by a vehicle owner.
at 183,000 milesMiddletown, CTFire
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNED A 2002 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT FOUND THAT THE MASTER CYLINDER CAUGHT FIRE. THE FIRE DEPARTMENT WAS NOT CONTACTED. A FIRE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO CROWLEY FORD LINCOLN (225 NEW BRITAIN AVE, PLAINVILLE, CT 06062) WHERE IT WAS DEEMED DESTROYED. THE DEALER DID NOT GIVE A DIAGNOSIS, BUT CONTACTED THE MANUFACTURER MULTIPLE TIMES TO DETERMINE WHAT FORD SHOULD COVER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE MANUFACTURER PROVIDED CASE NUMBER: CAS12637815 AND ADVISED THE CONTACT TO CALL HIS INSURANCE COMPANY. THE MANUFACTURER STATED THAT THEY WOULD SEND AN INSPECTOR. THE APPROXIMATE FAILURE MILEAGE WAS 183,000. UPDATED 09/07/17*LJ
NHTSA complaint #11004132 — an unverified report by a vehicle owner.
at 180,000 milesPEA Ridge, ARFire
ENGINE
TL* THE CONTACT OWNS A 2002 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED IN A RESIDENTIAL DRIVEWAY, THE ENGINE COMPARTMENT ERUPTED INTO FLAMES WITHOUT WARNING AND A LOUD EXPLOSION SOUND EMITTED FROM THE VEHICLE. THE CONTACT MENTIONED THAT THE VEHICLE WAS COMPLETELY BURNED AND PART OF THE GARAGE WAS DAMAGED. THE POLICE AND FIRE DEPARTMENTS FILED REPORTS. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 180,000.
NHTSA complaint #10874409 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Ontario, CAFire
VEHICLE SPEED CONTROL
Cruise control deactivation switch. I was getting in my truck on my way to work in the early morning. as I walked by the hood I could smell what seemed like burning wire, so I opened the hood & right as I got it all the way up flames started shooting up. I put the fire out and had to wait to call my mechanic he came and told me it was definitely the deactivation switch that had caught fire.
NHTSA complaint #11603537 — an unverified report by a vehicle owner.
at 163,745 milesAlhambra, CA
VEHICLE SPEED CONTROL
The contact's fiancée owns a 2002 Ford Expedition. The contact stated that there was smoke coming from the driver's side front end of the vehicle. The contact stated that while his fiancée was attempting to drive the vehicle the following day, the brake pedal was depressed but was firm, requiring the contact's fiancée to step on the brake pedal to drive. The brake pedal remained on the floorboard and was inoperable, causing the contact's fiancée to shift to park(P) to stop the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the speed control deactivation switch (SCDS) connectors had burned, and the brake fluid had leaked from the brake fluid reservoir. The dealer replaced the SCDS sensor and harness under NHTSA Campaign Number: 05V388000 (Vehicle Speed Control). The dealer declined to perform repairs for collateral damages. The contact stated that he was an auto-electrician mechanic who owned an auto shop. The vehicle was then towed to the contact's auto repair shop, where mechanics replaced the brake master cylinder and cleaned the brake fluid off the engine bay. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 163,745.
NHTSA complaint #11592816 — an unverified report by a vehicle owner.
at 163,745 milesAlhambra, CA
SERVICE BRAKES, HYDRAULIC
The contact's fiancée owns a 2002 Ford Expedition. The contact stated that there was smoke coming from the driver's side front end of the vehicle. The contact stated that while his fiancée was attempting to drive the vehicle the following day, the brake pedal was depressed but was firm, requiring the contact's fiancée to step on the brake pedal to drive. The brake pedal remained on the floorboard and was inoperable, causing the contact's fiancée to shift to park(P) to stop the vehicle. The vehicle was towed to the dealer, where it was diagnosed that the speed control deactivation switch (SCDS) connectors had burned, and the brake fluid had leaked from the brake fluid reservoir. The dealer replaced the SCDS sensor and harness under NHTSA Campaign Number: 05V388000 (Vehicle Speed Control). The dealer declined to perform repairs for collateral damages. The contact stated that he was an auto-electrician mechanic who owned an auto shop. The vehicle was then towed to the contact's auto repair shop, where mechanics replaced the brake master cylinder and cleaned the brake fluid off the engine bay. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 163,745.
NHTSA complaint #11592816 — an unverified report by a vehicle owner.
Aiken, SC
VEHICLE SPEED CONTROL
My spark plugs are going bad, I bought three tires. But now I'm having to take it to the shop because it's weird noises coming from the tire it may be the wheel baring or sway bar link and bushing the mechanic say.
NHTSA complaint #11470581 — an unverified report by a vehicle owner.
Aiken, SC
SERVICE BRAKES
My spark plugs are going bad, I bought three tires. But now I'm having to take it to the shop because it's weird noises coming from the tire it may be the wheel baring or sway bar link and bushing the mechanic say.
NHTSA complaint #11470581 — an unverified report by a vehicle owner.
Aiken, SC
FUEL/PROPULSION SYSTEM
My spark plugs are going bad, I bought three tires. But now I'm having to take it to the shop because it's weird noises coming from the tire it may be the wheel baring or sway bar link and bushing the mechanic say.
NHTSA complaint #11470581 — an unverified report by a vehicle owner.
Lampasas, TX
SERVICE BRAKES
re: IR 11467550. See attached photo.
NHTSA complaint #11467956 — an unverified report by a vehicle owner.
Lampasas, TX
SERVICE BRAKES
2002 expedition mfg date 12/2001 right front brake separated at swagged fitting to short tubing to caliper. had just parked, stopped fine. next day all fluid had drained through separated hose.
NHTSA complaint #11467550 — an unverified report by a vehicle owner.
at 146,457 milesHemet, CAFire
VEHICLE SPEED CONTROL
The contact owns a 2002 Ford Expedition. The contact stated that while the vehicle was parked, it caught fire. The fire started from under the hood of the vehicle. The contact was able to extinguish the fire with water. An independent mechanic came to the contact's residence and diagnosed that the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control) however, the contact did not receive notification of the recall. The mechanic informed the contact that the speed control deactivation switch caused the fire that damaged the hydraulic control unit and the pigtail. The vehicle was towed to the dealer. The dealer confirmed that the failure was related to the recall. However, the dealer denied the recall repair since the recall was open for many years but was left unrepaired. The contact stated that she had owned the vehicle for a couple of months and was not aware there was a recall. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,457.
NHTSA complaint #11446373 — an unverified report by a vehicle owner.
at 146,457 milesHemet, CAFire
FIRERELATED
The contact owns a 2002 Ford Expedition. The contact stated that while the vehicle was parked, it caught fire. The fire started from under the hood of the vehicle. The contact was able to extinguish the fire with water. An independent mechanic came to the contact's residence and diagnosed that the failure was related to NHTSA Campaign Number: 05V017000 (Vehicle Speed Control) however, the contact did not receive notification of the recall. The mechanic informed the contact that the speed control deactivation switch caused the fire that damaged the hydraulic control unit and the pigtail. The vehicle was towed to the dealer. The dealer confirmed that the failure was related to the recall. However, the dealer denied the recall repair since the recall was open for many years but was left unrepaired. The contact stated that she had owned the vehicle for a couple of months and was not aware there was a recall. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,457.
NHTSA complaint #11446373 — an unverified report by a vehicle owner.
at 256,547 milesLongview, TX
ENGINE
I HAVE REPLACE THE DRIVE BELT 2 TIMES THIS MONTH. THE BELT KEEP MESSING UP NOW I HAVE GET ANOTHER BELT BECAUSE IT IS TWISTED AROUND THE TENSIONER. I DON'T KNOW HIW IT HAPPEN I DRIVE ALL THAT DAY.
NHTSA complaint #11388908 — an unverified report by a vehicle owner.
Trinity, FL
SEAT BELTS
THE DRIVER'S SEAT BELT DISCONNECTS AT RANDOM TIMES.
NHTSA complaint #11282042 — an unverified report by a vehicle owner.
at 153 milesWildomar, CA
SEAT BELTS
TWO WEEKS BEFORE THIS PROBLEM HAPPEN ,THE TRUCK STARTS MAKING TOMUCH NOISE AND AIR SUPENTION DIDN'T GO UP NO MORE . AND STOP MAKING NOISE .
NHTSA complaint #11253901 — an unverified report by a vehicle owner.
at 153 milesWildomar, CA
SUSPENSION
TWO WEEKS BEFORE THIS PROBLEM HAPPEN ,THE TRUCK STARTS MAKING TOMUCH NOISE AND AIR SUPENTION DIDN'T GO UP NO MORE . AND STOP MAKING NOISE .
NHTSA complaint #11253901 — an unverified report by a vehicle owner.
at 153 milesWildomar, CA
FUEL/PROPULSION SYSTEM
TWO WEEKS BEFORE THIS PROBLEM HAPPEN ,THE TRUCK STARTS MAKING TOMUCH NOISE AND AIR SUPENTION DIDN'T GO UP NO MORE . AND STOP MAKING NOISE .
NHTSA complaint #11253901 — an unverified report by a vehicle owner.
Mineral Wells, TX
VEHICLE SPEED CONTROL
CRUSE CONTROL NOT WORKING AND NO HORN
NHTSA complaint #11052067 — an unverified report by a vehicle owner.
Mineral Wells, TX
ELECTRICAL SYSTEM
CRUSE CONTROL NOT WORKING AND NO HORN
NHTSA complaint #11052067 — an unverified report by a vehicle owner.
at 183,000 milesMiddletown, CTFire
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
TL* THE CONTACT OWNED A 2002 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT FOUND THAT THE MASTER CYLINDER CAUGHT FIRE. THE FIRE DEPARTMENT WAS NOT CONTACTED. A FIRE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO CROWLEY FORD LINCOLN (225 NEW BRITAIN AVE, PLAINVILLE, CT 06062) WHERE IT WAS DEEMED DESTROYED. THE DEALER DID NOT GIVE A DIAGNOSIS, BUT CONTACTED THE MANUFACTURER MULTIPLE TIMES TO DETERMINE WHAT FORD SHOULD COVER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE MANUFACTURER PROVIDED CASE NUMBER: CAS12637815 AND ADVISED THE CONTACT TO CALL HIS INSURANCE COMPANY. THE MANUFACTURER STATED THAT THEY WOULD SEND AN INSPECTOR. THE APPROXIMATE FAILURE MILEAGE WAS 183,000. UPDATED 09/07/17*LJ
NHTSA complaint #11004132 — an unverified report by a vehicle owner.
at 183,000 milesMiddletown, CTFire
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNED A 2002 FORD EXPEDITION. WHILE THE VEHICLE WAS PARKED, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT FOUND THAT THE MASTER CYLINDER CAUGHT FIRE. THE FIRE DEPARTMENT WAS NOT CONTACTED. A FIRE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO CROWLEY FORD LINCOLN (225 NEW BRITAIN AVE, PLAINVILLE, CT 06062) WHERE IT WAS DEEMED DESTROYED. THE DEALER DID NOT GIVE A DIAGNOSIS, BUT CONTACTED THE MANUFACTURER MULTIPLE TIMES TO DETERMINE WHAT FORD SHOULD COVER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). THE MANUFACTURER PROVIDED CASE NUMBER: CAS12637815 AND ADVISED THE CONTACT TO CALL HIS INSURANCE COMPANY. THE MANUFACTURER STATED THAT THEY WOULD SEND AN INSPECTOR. THE APPROXIMATE FAILURE MILEAGE WAS 183,000. UPDATED 09/07/17*LJ
NHTSA complaint #11004132 — an unverified report by a vehicle owner.
Buena Park, CA
ENGINE
TWO SPARK PLUGS BLEW OUT OF THE HEAD. PAIN IN THE BUTT TO FIX. FORD NEEDS TO STAND BEHIND ITS NAME AND FIX THE KNOWN PROBLEM.
NHTSA complaint #10983475 — an unverified report by a vehicle owner.
at 170,000 milesAtlanta, GA
ENGINE
I WENT TO GET AN OIL CHANGE I WAS TOLD BY WORKER AT SHOP THAT EVERYTHING UNDER HOOD WAS RUSTY AND CHANCES ARE THAT THIS TRUCK WAS IN THE NEW ORLEANS FLOOD (KATRINA) IT WAS DOWN HILL FROM THEN. EVERYTHING STARTED TO MALFUNCTION.
NHTSA complaint #10983319 — an unverified report by a vehicle owner.
at 240,000 milesHarrisburg, NC
SUSPENSION
TAKATA RECALL DURING AN INSPECTION OF MY SUSPENSION FOR WORN BUSHINGS, I NOTED SEVERE CORROSION ON MY REAR TRAILING ARMS FOR THE REAR AXLE. THE LOWER ARM ON THE PASSENGER SIDE ACTUALLY HAD A QUARTER SIZE HOLE IN THE INBOARD SIDE OF THE WEB. THIS OBVIOUSLY GREATLY REDUCES THE STRENGTH OF THE ARMS AND COULD CAUSE AXLE SEPARATION FROM THE VEHICLE AND AN OBVIOUS CONTROL HAZARD.
NHTSA complaint #10981416 — an unverified report by a vehicle owner.
at 170,000 milesMesa, AZ
SEAT BELTS
THE SEAT BELTS FRONT, PASSENGER SIDE UNLOCK BY THEMSELVES WHILE IN MOTION. IT CAN HAPPEN DURING CITY OR HIGHWAY DRIVING. THIS HAS NOT BEEN REPAIRED BY ANYONE AND IS FACTORY ORIGINAL. SEEMS LIKE A DANGER TO PASSENGERS.
NHTSA complaint #10958288 — an unverified report by a vehicle owner.
at 129,000 milesSAN Diego, CA
ENGINE
THIS IS ABOUT A BLOWN OUT SPARK PLUG. THE BLOWN OUT SPARK PLUG (#4 ON PASSENGER SIDE)) HAPPENED WHEN MY FAMILY & I WERE TRAVELING IN HIGHWAY NEAR STOCKTON CA AT AROUND 5 PM. THERE WAS NO SHOP OPEN AND I HAD TO CALL AAA TO TOW THE 2002 FORD EXPEDITION TO OUR FRIEND'S HOUSE ABOUT 30 MILES AWAY. IT WAS ALSO A VERY COLD NIGHT AND WE WAITED FOR ABOUT 1 HR FOR THE TOW TRUCK TO ARRIVE. IT WAS INCREDIBLY INCONVENIENT FOR THIS INCIDENT TO HAPPEN ON THE FREEWAY/HIGHWAY. I HEARD THAT THIS IS A COMMON PROBLEM FOR THE OLDER EXPEDITION WITH TRITON ENGINE. I LOVE FORD TRUCKS/SUVS AND I HOPE THEY CAN FIX THIS PROBLEM WITH THE ENGINE BEFORE SOMEBODY GETS IN SERIOUS TROUBLE. I WOULD RATHER WANT TO SEE A RECALL THAN A CLASS ACTION SUIT IN THE FUTURE.
NHTSA complaint #10938939 — an unverified report by a vehicle owner.
at 147,000 milesNewbury Park, CA
ENGINE
JUST WANT TO ADD MY CAR TO THE LIST OF FORD EXPEDITION 5.6L ENGINES THAT HAVE EXPERIENCED THE SPARK PLUG EJECTION ISSUE. THANKFULLY, THIS OCCURED WHEN STARTING THE VEHICLE, SO IT DID NOT CAUSE ANY ACCIDENT OR INJURY. THIS IS OUR SON'S CAR AND WE INTENDED IT TO BE THE VEHICLE OUR 15 YEAR OLD USED AS WELL. HOWEVER, NOW THAT WE KNOW ABOUT THE SPARK PLUG PROBLEM, WE NO LONGER FEEL IT'S SAFE AND HOPE TO TRADE IT IN. IT'S EXTREMELY DISAPPOINTING AND DISHEARTENING TO KNOW THAT FORD HAS NOT TAKEN RESPONSIBILITY FOR THIS ISSUE. OUR VEHICLE HAD ALL ORIGINAL FACTORY-INSTALLED SPARK PLUGS.
NHTSA complaint #10918916 — an unverified report by a vehicle owner.