4,187 of the
43,182 complaints filed about the Ford Explorer
are about the tires —
10% of everything owners reported.
The worst model year for it is 1997.
The contact owns a 2018 Ford Explorer. The contact stated that upon taking the vehicle to the dealer for service, the contact was made aware of NHTSA Campaign Number: 26V101000 (Suspension). The contact agreed to have the recall repair performed. The contact stated that approximately one month later, the contact discovered that the tread on the rear tires was shredding along the inner sidewalls. The vehicle was taken back to the dealer, and the tire failure was confirmed; however, the dealer stated that the work performed on the vehicle was not associated with the tire failure. The vehicle was later taken to an independent mechanic, and the contact paid out-of-pocket for two new tires and a rear wheel alignment. The contact stated that after the repair, the OBD2 scanner indicated that the rear wheel alignment was not properly performed. The contact stated that due to the failure, the tread on the new tires had started to shred. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 102,000.
NHTSA complaint #11757947 — an unverified report by a vehicle owner.
The contact owns a 2016 Ford Explorer. The contact stated that while driving in traffic, a trim piece detached from the vehicle. The TPMS and check engine warning light were illuminated. The dealer sent a tech to the contact’s place of employment, but the tech was unable to complete the recall repair due to the bolt not being available. The contact had received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that the turbocharger had been replaced on three occasions. Upon investigation, the contact had linked the failure to NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling). The contact called the local dealer, who confirmed the parts for the recall repairs were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a complaint was filed, but no assistance was provided. The failure mileage was unknown.
NHTSA complaint #11691665 — an unverified report by a vehicle owner.
The contact owns a 2016 Ford Explorer. The contact stated while driving 55-65 MPH, the exterior A-pillar applique trim detached from the front windshield. The tire pressure system fault warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact called two other local dealers Jenkins Lincoln of Crystal River Service (2440 US-19, Crystal River, FL 34428) and J. Allen Ford Service (9274 US 49, Gulfport, MS 39503), but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 97,000. VIN tool confirms parts not available.
NHTSA complaint #11673905 — an unverified report by a vehicle owner.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, while attempting to make a left or right turn, there was a popping sound coming from the steering wheel. Additionally, while driving on the highway at 70 MPH, the vehicle failed to exceed 70 MPH. The contact stated that there was an abnormal burning odor entering the cabin of the vehicle with the TPMS warning light illuminated. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 121,000.
NHTSA complaint #11658930 — an unverified report by a vehicle owner.
The contact owns a 2017 Ford Explorer. The contact stated that the A-pillar trim on the driver's and passenger’s side of the windshield was loose at the top. Additionally, the contact stated that the TPMS warning light was illuminated. The contact received notification of NHTSA Campaign Number 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 125,000. VIN tool confirms parts not available.
NHTSA complaint #11647404 — an unverified report by a vehicle owner.
Tire: 275/45/r21 110w all season Reported to authorized dealer (ford dealership) back in November 2024. Authorized representative from Pirelli came out this month to dealership regarding issue. No concern for safety whatsoever. Rep. Only offered maybe 25% that’s with purchasing new set of tires and sending my current tires back. Tires are falling apart in chunks.
NHTSA complaint #11637972 — an unverified report by a vehicle owner.
I recently had an increasing tire vibration problem on my 2020 ST with 18,500 miles. Took the ST to a Costco tire center to have the tire balance checked for lost weight, damaged rim or whatever. Balancer had massive weight shift so they took tire off the rim. Unknown to me, the original Pirelli P Zero tires have a foam coat inside the tire for noise comfort(????). It had deteriated and was formaing clumps and coming off the rubber.
NHTSA complaint #11559737 — an unverified report by a vehicle owner.
Two TPMS sensors have failed on this vehicle. Although these sensors are required under the TREAD act, Ford has advised through their dealer that this is not a safety issue and the TPMS sensor batteries failing less than 3 years from date of vehicle manufacture falls in the category of normal wear and tear. Note that the vehicle has 27,243 miles on it, and these are the original TPMS sensors/wheels/tires that the vehicle came equipped with from Ford.
NHTSA complaint #11555657 — an unverified report by a vehicle owner.
While traveling on I-85N at 70mph, the front passenger tire suddenly came apart from both sidewalls. The tire is a EVOLUXX CAPRICORN 4X4 HP, 255/50R20, 109V, XL. The tire blow-out only caused minor damage to the inner wheel well shroud.
NHTSA complaint #11539133 — an unverified report by a vehicle owner.
The contact owns a 2019 Ford Explorer equipped with Hankook Tires, Tire Line: Ventus S1 Noble 2, Tire Size: 255/50/R20, DOT Number: (Unavailable). The contact stated that the tread on all four tires were extremely low. The vehicle was taken to a tire shop where the tread depth was measured. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in TSB: SSM46905 and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was approximately 19,700.
NHTSA complaint #11534014 — an unverified report by a vehicle owner.
Hankook Ventus S1 Noble 2 P255R20 A/S BSW Tires 23,041 miles 2017 Ford Explorer Sport. These are the tires that came on the vehicle, there is only 23,041 miles on the vehicle and the tires are prematurely wearing on the outerside of all 4 tires. Chunks of the tire is pealing off. Hazardous to drive. The vehicle is not out of line, tires are rotated on schedule, and tire pressure maintained. Looks like defective tires, need to be investigated as safety recall. Ford Motor Company is aware of the problem and stated that we need they have a problem with those tires pealing and wearing out, most people have to replace around 20,000 to 30,000 miles. VERY DANGEROUS! I have safety inspections that shows tire are perfect.
NHTSA complaint #11527062 — an unverified report by a vehicle owner.
All 4 Tires Size 255/50R20 Have Cracked, Split and separated around tread. Extremely unsafe. Vehicle has near 40,000 miles. Vehicle was purchased in May 2018 with these tires already installed. There needs to be a recall, as now we will need to purchase 4 new tires at one time when this should not have happened. We can not use our vehicle until we can replace all 4.
NHTSA complaint #11513333 — an unverified report by a vehicle owner.
Pirelli Scorpion All season tires 275/45 R21. Tire completely "blew out" while driving 30 mph on a main road. There was no obvious hissing sound commonly when running over an object. There was an explosive sound and within seconds had a complete flat. The vehicle did get damaged on the inside tire well along with bumper damage/Crack.
NHTSA complaint #11508812 — an unverified report by a vehicle owner.
The contact owns a 2014 Ford Explorer. The contact stated while driving 60 MPH, the vehicle lost motive power with the TPMS warning light illuminated. Additionally, the vehicle was leaking coolant. The vehicle was taken to an independent mechanic who diagnosed that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 150,000.
NHTSA complaint #11472801 — an unverified report by a vehicle owner.
i notice that my car is sliding in somewhat wet terrain situations. I did notice it last year but didn't think at 24k miles my tire treads were bad. I had my car serviced and they are telling me at 32K miles I need new tires and they are bad. These tires are warranted for 50K miles. There are rubber tears at the tread and well as complete baldness. Terrible! Had I been driving much this winter there would no doubt be a incident. These are a issue on all 4 tires. I see there are many complaints with these Hankook Ventus Noble tires. Something needs to be done or recalled. We are the consumer. Protect us!
NHTSA complaint #11466345 — an unverified report by a vehicle owner.
i notice that my car is sliding in somewhat wet terrain situations. I did notice it last year but didn't think at 24k miles my tire treads were bad. I had my car serviced and they are telling me at 32K miles I need new tires and they are bad. These tires are warranted for 50K miles. There are rubber tears at the tread and well as complete baldness. Terrible! Had I been driving much this winter there would no doubt be a incident. These are a issue on all 4 tires. I see there are many complaints with these Hankook Ventus Noble tires. Something needs to be done or recalled. We are the consumer. Protect us!
NHTSA complaint #11466345 — an unverified report by a vehicle owner.
The contact owns a 2016 Ford Explorer equipt with Bridgestone Dueler Alenza Plus tires size P245/60/18 N/A, and DOT: RBVDRIM0916. The contact stated that while driving approximately 65 mph, a rotational noise was present coming from the front driver side of the vehicle. Upon inspection, it was discovered that the front driver side and passenger side tires had experienced cracking located above the tire bead area on the inside wall of the tire. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 41,000.
NHTSA complaint #11447077 — an unverified report by a vehicle owner.
Had new tires put on my 2014 Explorer. They are showing wear on the rear ones. Now it handles very poorly on roads that are grooved. Need to have both have hands on the wheel with a good grip to keep it on the road. Feels like the rear is trying to pass the front. Going back to the Ford dealer next week. Hopefully they can repair this problem. Perhaps recall 21S31 will address this.
NHTSA complaint #11426801 — an unverified report by a vehicle owner.
The front tires chewed to pieces, one blew, and the dealer initially felt it was an alignment issue from the factory. Up one further inspection, they found an aluminum toe rod with a 45 degree bend. I believe this was a factory issue as we hit nothing on the highway. It seems from an FMEA point of view, it is likely the blown tire and momentum of the car bent the tie rod and that the tire damage was caused by a part failure or some other issue with the car. It is a 3 month old car with 9,400 miles. The car struck Nothing on the highway.
NHTSA complaint #11422181 — an unverified report by a vehicle owner.
The contact owns a 2018 Ford Explorer equipped with four Hankook tires, Tire line: Ventus S1 Noble S2, Tire Size 255/50/R20. DOT Number: 5mnb1ah1218. The contact stated while having a routine inspection was informed that the rear driver and passenger tires needed to be replaced due to unusual wear. The vehicle was taken to the dealer where they were unable to determine the failure cause. The manufacturer was not notified. The tire mileage was 50,000. The failure mileage was 14,000.
NHTSA complaint #11421618 — an unverified report by a vehicle owner.