2018 Ford Explorer problems

UNKNOWN OR OTHER

I purchased this 2018 Ford Explorer from Speedway Motors in Murfreesboro, TN back in July 2026. Within a month I notice that the windshield was whistling. I took it back and they told me that it was a recall on the "A pillar exterior trim." I contacted the Murfreesboro Ford dealership and was told that the Ford dealership in Franklin had done a recall "check" in 2024 and it "passed" the recall. They did NOT replace seal the parts. Now two years later, the recall is supposedly not considered "open" by Ford Manufacturing. When I contacted their customer service to ask how a recall can be closed or ignored, they simply will not answer the question. My understanding is that a recall technically can not be "closed" if it a safety issue. In this case, the trim pieces come loose and become a road hazard. The pieces are not attached correctly or completely and the adhesive comes apart. This allows the trim and even the windshield to come off while driving down the road. There are hundreds of complaints and threats of class action lawsuits on line where people had to wait two years for the dealership to get the parts and replace them. Some people ended up ordering the trim pieces from Amazon and doing the work themselves. I do not feel it is my responsibility to have to fix this issue when clearly it is a safety recall by Ford. They should be held responsible for the repairs. If the windshield or trim were to come off and damage another car or injure someone, I would be held responsible. I am able to provide photos or bring the vehicle to any office for inspection if requested. I am happy to help in any way. Especially if I am able to get a resolution with this situation. I do not have money to fix this and do not want to report it to my insurance. Date of recall was January 2024 as far as I can tell. It was checked by Franklin Ford also in 2024.

NHTSA complaint #11758521 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2018 Ford Explorer. The contact stated that upon taking the vehicle to the dealer for service, the contact was made aware of NHTSA Campaign Number: 26V101000 (Suspension). The contact agreed to have the recall repair performed. The contact stated that approximately one month later, the contact discovered that the tread on the rear tires was shredding along the inner sidewalls. The vehicle was taken back to the dealer, and the tire failure was confirmed; however, the dealer stated that the work performed on the vehicle was not associated with the tire failure. The vehicle was later taken to an independent mechanic, and the contact paid out-of-pocket for two new tires and a rear wheel alignment. The contact stated that after the repair, the OBD2 scanner indicated that the rear wheel alignment was not properly performed. The contact stated that due to the failure, the tread on the new tires had started to shred. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 102,000.

NHTSA complaint #11757947 — an unverified report by a vehicle owner.

TIRES:TREAD/BELT

The contact owns a 2018 Ford Explorer. The contact stated that upon taking the vehicle to the dealer for service, the contact was made aware of NHTSA Campaign Number: 26V101000 (Suspension). The contact agreed to have the recall repair performed. The contact stated that approximately one month later, the contact discovered that the tread on the rear tires was shredding along the inner sidewalls. The vehicle was taken back to the dealer, and the tire failure was confirmed; however, the dealer stated that the work performed on the vehicle was not associated with the tire failure. The vehicle was later taken to an independent mechanic, and the contact paid out-of-pocket for two new tires and a rear wheel alignment. The contact stated that after the repair, the OBD2 scanner indicated that the rear wheel alignment was not properly performed. The contact stated that due to the failure, the tread on the new tires had started to shred. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 102,000.

NHTSA complaint #11757947 — an unverified report by a vehicle owner.

POWER TRAIN

The transmission is actively slipping and dropping out of gear while driving causing unexpected loss of acceleration on public roads. This represents an extreme road safety hazard. The manufacture was notified but refused to offer assistance or grace coverage immediately following a Premium CARE factory contract expiration.

NHTSA complaint #11755501 — an unverified report by a vehicle owner.

SUSPENSION

On March 25, 2026, an authorized Ford dealership in Florida performed a safety recall involving the rear suspension toe links. The recall addressed a condition that Ford states can result in loss of steering control and increased crash risk. After the recall was completed, I drove approximately 1,200 miles home believing the safety defect had been corrected. After returning home, I began experiencing rear-end instability. The vehicle would sway when driving over even small bumps. I took the vehicle to another authorized Ford dealership, which confirmed the original recall repair had not been performed correctly. The dealership found problems with the rear suspension and alignment that required extensive corrective repairs, including replacement of rear suspension components and correction of the rear suspension alignment. Both rear tires had also developed severe, uneven wear and were determined to be unsafe, requiring replacement despite being only about two months old. No warning lights or messages appeared before or during this condition. I was unaware that the recall repair had been performed incorrectly and unknowingly drove approximately 1,200 miles with a compromised rear suspension after being told the safety recall had been completed. I am submitting this complaint because an improperly performed safety recall repair may have exposed me, my passenger, and others to the same safety risk the recall was intended to prevent.

NHTSA complaint #11754682 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2018 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 26V448000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at an undisclosed speed, one of the windshield exterior A-Pillar trims detached and struck the windshield. The vehicle was taken to the dealer, where the remaining A-Pillar trim was removed. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the failure. The failure mileage was approximately 18,600.

NHTSA complaint #11752460 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that parts would be over a year to for the availability. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11752056 — an unverified report by a vehicle owner.

SEAT BELTS

The contact owns a 2018 Ford Explorer. The contact stated that the driver's side front seat belt failed to click securely into the buckle. The seat belt warning light was illuminated. The contact stated that the failure was associated with NHTSA Campaign Number: 25V093000 (Seat Belts); however, the VIN was not included. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 97,000.

NHTSA complaint #11750883 — an unverified report by a vehicle owner.

POWER TRAIN

This vehicle was inspected by a certified Ford dealership (Premier Ford, Service Advisor: Harry). Ford Motor Company’s Consumer Affairs Department subsequently reviewed the case under Complaint ID: XXX. In their official written response, Ford explicitly admitted the root cause, stating: "the vehicle experienced a failure to the harness for the alternator which melted due to heat from the exhaust." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11750708 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

This vehicle was inspected by a certified Ford dealership (Premier Ford, Service Advisor: Harry). Ford Motor Company’s Consumer Affairs Department subsequently reviewed the case under Complaint ID: XXX. In their official written response, Ford explicitly admitted the root cause, stating: "the vehicle experienced a failure to the harness for the alternator which melted due to heat from the exhaust." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11750708 — an unverified report by a vehicle owner.

ENGINE

This vehicle was inspected by a certified Ford dealership (Premier Ford, Service Advisor: Harry). Ford Motor Company’s Consumer Affairs Department subsequently reviewed the case under Complaint ID: XXX. In their official written response, Ford explicitly admitted the root cause, stating: "the vehicle experienced a failure to the harness for the alternator which melted due to heat from the exhaust." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11750708 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Dealership is not honoring active recalls due to body damage causing car to be deemed total loss by dealership and is in process of being rebuilt

NHTSA complaint #11750214 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

The windshield wiper motor failed, causing the windshield wipers to stop operating properly. At the same time, the windshield washer system is unable to spray washer fluid onto the windshield. This significantly reduces visibility during rain and when the windshield becomes dirty, creating a safety hazard. No warning lights were displayed

NHTSA complaint #11750024 — an unverified report by a vehicle owner.

ENGINE

While driving at highway speed on a 2-lane highway with three children under the age of [XXX] in the vehicle, my 2018 Ford Explorer experienced sudden complete engine failure with no prior warning. No warning lights, no temperature gauge change, no unusual sounds. The vehicle went from operating normally to catastrophic failure instantaneously, forcing me to sharply cross active traffic to exit the roadway. The vehicle came to rest near a train track. The root cause was internal water pump failure. Ford's design places the water pump inside the engine, causing coolant to leak internally with no external indicators and no dashboard warning until catastrophic damage has already occurred. Ford did not install a coolant level sensor in the reservoir, and the only coolant warning available is an overheating alert, which never triggered. I had taken every reasonable precaution. Two thousand miles prior, an oil change showed no coolant contamination. One week prior, I physically checked the coolant level and it was within safe range. Ford's design gave me zero opportunity to detect or prevent this failure. This is a known recurring issue. Over 86 engine complaints have been filed with NHTSA for this model year alone and Ford has been aware of this defect since at least 2007. Despite class action litigation in both Canada and the United States, Ford has not issued a U.S. recall. Repair costs exceed $9,000. I am requesting NHTSA open a formal investigation and compel Ford to issue a U.S. recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11749510 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 30 MPH, the check engine warning light illuminated. The vehicle was driven to the residence and then to an independent mechanic shop, where a full diagnostic inspection was not performed; however, the mechanic suspected that coolant bubbled internally and the contact was informed that the head gasket might need to be replaced. The mechanic was unable to disassemble the engine for further inspection. The vehicle was then taken to a dealer, who diagnosed that the water pump needed to be replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 112,000.

NHTSA complaint #11749329 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2018 Ford Explorer. The contact had received notification of NHTSA Campaign Number: 26V101000 (Suspension), and the recall repair was completed. The contact stated that immediately after the recall repair, while driving on several occasions at various speeds, the rear end of the vehicle fishtailed, and the contact lost control of the vehicle. The vehicle was taken to the same dealer on several occasions; however, the failure could not be duplicated. The contact was advised that the tires needed to be replaced. The contact purchased and replaced the tires and had a four-wheel alignment performed, but the failure persisted, although not as severe. While the vehicle was parked, the contact became aware that the tread on the rear tires was extremely worn. The manufacturer was notified of the failure. The failure mileage was approximately 118,000.

NHTSA complaint #11747980 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2018 Ford Explorer. The contact received notification of NTHSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11747664 — an unverified report by a vehicle owner.

STEERING

While driving out of a turn or curve, the steering does not return to center. Which may cause veering into other lanes or off the road.

NHTSA complaint #11747009 — an unverified report by a vehicle owner.

POWER TRAIN

Less that 100k miles and my transmission already needs replaced. Last year my engine was sputtering making my car jerk while driving went to shop they did a total transmission fluid changed but said my transmission is likely going bad it helped mostly and I had high hopes the problem was solved it was not fast forward to now my transmission went then caused the torque converter to go my car was shaking so bad while stopped and in drive in order to go i had to put my foot all the way to the floor and quickly move to the break sometimes my car would fly other times it would take so long to go that people would try to fly around me then my car would shoot forward and id have to slam on breaks and the rpm gage was all over the place while maintaining the same speed. My car should not need a new transmission at under 84000 miles. This was so dangerous. When I did a search so many reddit posts about 2018 explorers torque converters and Transmissions going bad. I'm livid. I don't have 8k to replace the transmission in a vehicle i still owe 10k on

NHTSA complaint #11745795 — an unverified report by a vehicle owner.

POWER TRAIN

Vehicle: 2018 Ford Explorer Mileage at Failure: 62,212 miles On [XXX] while driving my 2018 Ford Explorer, the wrench warning light suddenly illuminated on the dashboard. At the same time, the vehicle experienced a significant loss of power and became extremely sluggish in acceleration. When I pressed the accelerator pedal, the vehicle failed to respond normally and did not accelerate as expected. This condition created a serious safety hazard because the vehicle could not maintain or increase speed when needed in traffic. Had this occurred while entering a highway, crossing an intersection, or attempting to avoid another vehicle, it could have resulted in a crash. The vehicle has been inspected by McCarthy Ford. The dealership diagnosed transmission-related problems and provided a repair estimate of $6,384.94. Ford Motor Company previously issued Customer Satisfaction Programs 20B27 and 20N07 for certain Ford Explorer vehicles equipped with the 6F35 transmission. Ford's own documentation acknowledges that transmission torque converter overheating may result in low performance, lack of acceleration during launch, sluggish vehicle operation, vibration, shuddering, and related transmission concerns. These symptoms are consistent with the condition experienced in my vehicle. I reported the issue to Ford Motor Company and sent a certified letter to CEO James D. Farley, Jr. requesting assistance and a policy adjustment due to the known transmission and torque converter concerns. To date, I have not received a satisfactory response. I am submitting this complaint because the sudden loss of acceleration and reduced vehicle power created a significant safety risk while operating the vehicle on public roadways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11745317 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving 65 MPH, the front Driver-side A-pillar trim detached and struck a nearby vehicle. The contact pulled over to check on the vehicle that was struck by the front driver’s side A-pillar trim and retrieved the trim piece. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 45,000.

NHTSA complaint #11744994 — an unverified report by a vehicle owner.

ENGINE

My vehicles transmission has been replaced 2 times already (3 years apart)- now it is overheating. Absolutely no warning lights have came on at any time in regards to any of my situations - My vehicle is available for inspection at any time. When the transmission went in my vehicle, I was traveling on an interstate with my child. The dealer has confirmed replaced the transmission as it was still under the 5 year warranty - my vehicle is set to go back into the shop today to be inspected as to why it is overheating.

NHTSA complaint #11744514 — an unverified report by a vehicle owner.

AIR BAGS

The airbag light shown in the attached photo came on at an unknown period of time. We did not know when this came on that it was not a normal light. This is a safety issue as there are many causes for this light to come on, and with this light being on the airbag may not deploy properly or at all during a collision. We did take the vehicle to the Ford dealership for warranty work and they did not say anything about the light on the dash. Which adds to the reason why we did not know that the light meant there was a problem. There are other airbag lights that come on in the sinners console for the passenger side airbags that are orange as well.

NHTSA complaint #11743561 — an unverified report by a vehicle owner.