4,178 of the
43,316 complaints filed about the Ford Explorer
are about the steering —
100% of everything owners reported.
The worst model year for it is 2013.
Approximately 3 years ago, while driving my 2016 Ford Explorer on a [XXX], warning chimes sounded and a power steering/steering assist fault message appeared. Electric power-steering assist then stopped functioning and the steering became extremely difficult to operate. I slowed down and was able to maneuver safely off the freeway. I shut the vehicle off, opened the driver’s door, waited approximately 45 seconds and restarted it. Normal steering assist returned. Shortly afterward, I took the vehicle to Oakdale Ford in Oakdale, CA and reported the problem. I was advised that further diagnosis/investigation would involve approximately $5,600 in costs. I declined due to the expense, and no repair was performed. The cause of the failure remains UNKNOWN. The vehicle remains available for inspection. During the approximately 3 years since, the vehicle has unexpectedly lost electric power-steering assist at least a dozen additional times, at different speeds and on different types of roads. Sometimes warning chimes/messages occur without loss of assist; other times assist is actually lost. Shutting the vehicle down, opening the driver’s door, waiting approximately 45 seconds and restarting has restored steering assist each time, but the problem later recurs unpredictably. I live in a mountainous area and regularly drive narrow, winding roads with steep drop-offs and limited or no guardrails. Sudden loss of steering assist while negotiating a curve makes the vehicle significantly harder to control and creates a serious risk of leaving the roadway. No crash or injury has occurred to date. The failure is intermittent, unpredictable, repeatedly occurs while driving, and has not been repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11762935 — an unverified report by a vehicle owner.
Car has a history of showing a P07AE-09 code in the power steering control module. When the code logs in the computer the car loses power steering assist while driving causing the steering to be hard to turn. Upon researching the cars recall work we seen that the car had the power steering control module software updated but no steering gear changed. My wife and children ride in this car and I'm afraid that this is going to cause a serious accident.
NHTSA complaint #11762453 — an unverified report by a vehicle owner.
The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed and making turns, the steering wheel made loud grinding sounds and was loose. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 197,000.
NHTSA complaint #11760880 — an unverified report by a vehicle owner.
I am reporting a serious safety concern involving my 2011 Ford Explorer, VIN [XXX]. After recently filling the vehicle with fuel, I went to drive it and received a “Power Steering Assist Fault” message on the dashboard. The vehicle then lost power steering assistance, making the steering extremely difficult and requiring significantly more effort to control. The vehicle was inspected by a repair shop, and I was advised that the power steering/steering gear requires replacement at an estimated cost of $2,126.43. Because of the loss of steering assistance, I believe the vehicle is unsafe to drive and presents a serious safety risk, particularly during turns or emergency maneuvers. I understand that Ford previously recalled certain 2011–2013 Ford Explorers under NHTSA Recall 14V-286 (Ford Recall 14S06) for a defect involving the electric power steering gear that could result in loss of power steering assist. The symptoms I am experiencing appear very similar to the defect described in that recall. My vehicle does not appear to be covered by the existing recall based on its VIN. I am requesting that NHTSA review my vehicle and this failure to determine whether it should be included in the recall or whether additional action is warranted. I can provide the VIN, repair estimate, diagnostic information, photographs, and any other documentation needed. Thank you for investigating this potentially dangerous safety defect. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11760576 — an unverified report by a vehicle owner.
NHTSA COMPLAINT: VIN [XXX]: Transmission cooler (Part 7869) ruptured, mixing fluid/coolant into corrosive glycol-acid in violation of SSM 52917. Contamination dissolved wiring insulation and delaminated clutch plates, causing systemic short circuits and CAN-bus load-shedding. Boiling fluid released toxic glycol/hydrocarbon vapors through HVAC ducts into the cabin without notice, creating an inhalation hazard. Vehicle available for inspection at South Bay Ford (BAR #XXX; captive 93 days).RISK: On XXX short circuits caused complete power steering assist dropout mid-transit. Steering locked during a turn, causing a crash into gate posts, endangering my minor children inside. Cabin chemical vapor inhalation caused respiratory tract irritation, dizziness, and headaches. Open recall hazards remain for visibility loss (Recall 26S14) and rollaway (Recall 26S48 parts backordered to 2027).CONFIRMATION: Contamination, a -1,212-mile odometer fraud discrepancy, and bricked electrical starting systems confirmed by dealer records XXX. Admitted unauthorized repairs to mask trouble codes and evade SSM 52917 confirmed in writing by Service Director [XXX] XXX, violating CA Bus & Prof Code 9884.9.HISTORY: Tracked under Ford RAV buyback #XXX, Corporate Escalation #[XXX], and CA Bureau of Automotive Repair Investigator [XXX] (Case #XXX). Total statutory loss is $54,628.75.SYMPTOMS: Transmission drops began XXX (42,319 miles). Dealer cleared codes and coerced 500 extra miles. XXX alerts included "Powertrain Malfunction" loops. Telematics registered false "Vehicle is On" loops. On XXX, dealer blocked diagnostics via a manufactured battery charge demand exactly 24 hours before federal Recall 26S48 launched. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11759752 — an unverified report by a vehicle owner.
Hello. I purchased my car in 2018. 2-3 years later, the power steering would randomly go out while driving - on the highway and city roads. This could happen once and then not again for 6+ months. When this happened a message would display about a "steering assist fault, service now". I found that if I pulled over, turned the car off and then on, it would generally work again. We had the vehicle in to 3 separate repair shops between 10/2022 and 10/2025 and no one could diagnose the issue as they needed it to replicate the condition. (In hindsight find this strange (concerning!!) as a simple google search shows what I am describing is a very common issue with a number of Ford models and also other vehicles.) In June 2026, while on vacation with my family (on a mountain) it happened again. We turned the car on and off several time, disconnected/reconnected the battery and could not get the car to start working again and this time the steering wheel was completely locked. We had the vehicle towed and rented a car to drive home. The dealership was able to diagnose and repair the issue by replacing the entire steering rack assembly. No issues since then.
NHTSA complaint #11755766 — an unverified report by a vehicle owner.
Steering fails to self-center after slight bear-left such as lane change manuver or steering to track a gentle left bend in road, typically holding ~10 degree left position of the steering wheel. Center feel is "notchy." Behavior is almost completely a bear-left problem and only a slight similar behavior in bear-right condition. Self-centering from hard left seems to be correct in fully returning wheel to center. This behavior has been confirmed by many owners' complaints posted online, and is a problem unique to the Explorer model and 2020+ generation. Video demonstrating problem while driving: [XXX] Explorer ST Owner Forum post confirms similar behavior by others: [XXX] My dealer is treating this as "not a problem, they all do this." No other vehicle in my life (dozens) has ever exhibited this behaviour of steering not returning to center while moving. After delivery I returned the car almost immediately to the dealer on noticing the steering just felt "weird." They found nothing. I narrowed the behavior down to the specific circumstance of bear-left and notchy on-center feel, returned it again, and again they found nothing. With ~3000mi, no change in behavior --"break-in" is long past. I know how to correct for the issue, but if I loan out the car? While it can be called a fit and finish flaw, on the outside it could be a safety issue for unfamiliar drivers. Answers to General Guidelines questions >>> Dealer has identified no failed components or need for repair after two attempts and multiple discussions of the problem. >>> Safety? Issue results in fatigue after long use of the vehicle. Drivers unfamiliar with non-return-to-center behavior may not give the neccesary corrective input to return steering to center. >>> Two dealer repair visits, both inconclusive. >>>No warning lamps etc. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755788 — an unverified report by a vehicle owner.
I was driving at 65 mph on the highway when the light for the steering came up and the power steering shut down. I had a hard time to turn the steering wheel until I was able to exit the road. I shut the car down and restarted and everything was ok, but there is a problem because the light came up again. More cars with same problem.
NHTSA complaint #11755187 — an unverified report by a vehicle owner.
Power-assisted steering fails repeatedly. No warning lights, codes, or alarms are presented or shown. Steering reverts to manual control only and becomes very difficult to turn. This presents a potentially serious safety issue. Power-assisted steering returns to normal operation but fails again intermittently and repeatedly. Ford has not issued a recall and the price is exorbitantly expensive for consumer. additionally , only a dealer can replace or program the failing parts, consumer cannot replace them on their own using standard automotive repair tools. this is a serious safety risk and a known issue from Ford, and a clear violation of consumer protection acts. Ford's corporate behavior in this matter is inconscionable. I would not have purchased the vehicle had I known that Ford does not support warranty for this very common issue. it is a design flaw and a serious safety risk. consumers will soon be dying due to this problem, if they have not already.
NHTSA complaint #11755356 — an unverified report by a vehicle owner.
This is a 2013 Ford Explorer experiencing the exact catastrophic power steering failure described in Recall 14S06 / 15S18. The rack has failed twice, creating an immediate crash hazard. The current recall parameters are inadequate as they exclude my VIN despite identical component failure. Not only is this an immediate crash hazard, it is difficult to find any mechanic or dealership to remedy this problem because it is a major part with heavy labor. I have been sidelined and quoted high repair fees for a repair that should be covered as Ford admitted to the design flaws in the electrical steering, however restricting who actually gets protection from it. I feel this is reckless and greedy of Ford to do this. The failure to the electric steering went out while I was driving and I was unable to turn or control my steering, it is deeply frustrating this is a known issue that I was completely unaware of. I feel that Ford is not a good company to purchase from and their products are not safe for drivers. I'm posting this so others are warned that safety is not a priority with Ford and to shop with a brand that cares about safety and integrity for their consumers and families.
NHTSA complaint #11754999 — an unverified report by a vehicle owner.
On Friday 7/24/2026, I was driving and all the sudden my steering went out. Dash flashed No Power Steering Assist / AdvanTrac System Fail. I pulled over immediately to turn around & get home with zero power steering. The amount of strength to steer/control was extreme. To turn was almost impossible. I took my car to Ford AutoNation on Arapahoe in Centennial on 7/27/26, they ran full diagnostics & it came back that the car suffered a hard internal failure (DTC U3000) of the electronic Power Steering Control Module, creating an immediate, dangerous loss of steering assist while driving. This vehicle was subject to Federal Safety Recall 14S06 (NHTSA Campaign 14V286000). According to official Ford OASIS data, Ford attempted to remedy this safety defect in 2014 using a software reflash shortcut (Labor Code 14S06A) rather than replacing the physical defective hardware. I have a text (via their service dept) from the service manager as well stating "it was a reflash" when I asked which labor code was done under the 14S06; "was it the software reflash or the full rack replacement?". I have a formal case with Ford Corporate created 7/31/26, and have that number as well. IBecause Ford's software patch completely failed to prevent the component's internal hardware failure, the original federally mandated safety defect remains active, unresolved, and dangerous in this chassis. Ford Corporate is refusing to honor the recall remedy because the vehicle is past an arbitrary 10-year limit on their internal customer satisfaction extensions, violating the permanent nature of safety recalls. I stated I would be filing with the NHTSA and they pushed my information on to the Safety Auto Office on 7/31/26.
NHTSA complaint #11753968 — an unverified report by a vehicle owner.
The power steering has fully stopped working , the car cannot be steered, this started to happen on the road, I had to steer the entire weight of the car myself, at fast speed it was difficult but not impossible, at slow speed and zero speed or while the vehicle is stationary it was impossible or unmovable to steer. there were no warning lamps about this, the Ford dealer has not detect this in my vehicle's previous recall, further vehicle has two more recalls this year, that have been cited this year by the dealer. this needs to be addressed on their recalls because this can cause a very severe problem on the road
NHTSA complaint #11753984 — an unverified report by a vehicle owner.
I was driving and the steering locked. I could not move steering wheel either way. Towed to ford repair… they replaced steering rack. Four times it was replaced..4 times it locked.
NHTSA complaint #11753414 — an unverified report by a vehicle owner.
ABS module has failed. Causing a number of other safety systems to be deactivated. Power steering, traction control, drive mode selection, and braking. All these lights are illuminated on dash. Independent auto repair shop verified this ABS module has failed and there is no replacement parts from Ford.
NHTSA complaint #11753363 — an unverified report by a vehicle owner.
Begin with cliff, I was not wanting to lock or locked or start the vehicle as I was driving. I stopped at the light vehicle started shaking, and as I drove through the light to pull over power steering assist failure, terrain, failure, and control failure.
NHTSA complaint #11752959 — an unverified report by a vehicle owner.
Loss of power steering assist . Yes it is available for inspection on request. I can't steer it . It has not been confirmed by anybody yet. It has not been inspected by anybody yet. There are no warning lights on dash .
NHTSA complaint #11751715 — an unverified report by a vehicle owner.
The contact owns a 2011 Ford Explorer. The contact stated that while attempting to start the vehicle, the message "Power Steering Assist Fault" was displayed and the vehicle failed to start. The contact stated that the failure reoccurred after starting the vehicle, and the steering wheel locked up. The dealer was contacted, but the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Numbers: 14V286000 (Steering) and 14E001000 (Steering); however, the VIN was not included. The manufacturer was not contacted. The failure mileage was approximately 140,000.
NHTSA complaint #11751531 — an unverified report by a vehicle owner.
Same issue as in recall 14S06. However, I do not see this recall under my VIN, nor has this vehicle been repaired in the past for this issue. I was hoping that possibly the recall doesn't show up because it was established in 2014. I just want to get it corrected, as the electric power steering is disabled.
NHTSA complaint #11751091 — an unverified report by a vehicle owner.
The contact owns a 2019 Ford Explorer. The contact stated that while driving 80 MPH, the steering wheel was abnormally loose, and the vehicle became uncontrollable. The contact stated that the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle was driven to the shoulder of the road, and the brake pedal was depressed to the floorboard. The brake pedal was depressed several times, and the vehicle stopped. No warning lights were illuminated. A driver nearby assisted with stopping traffic to allow the contact to drive the vehicle off to the shoulder of the roadway. The vehicle was inspected, and the other driver became aware that the rear tires were completely bald. The vehicle was taken to Discount Tires, and the contact was informed that the failure was because of the rear suspension. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer and was informed that the vehicle was previously repaired under NHTSA Campaign Number: 26V101000 (Suspension) in March 24, 2026. In addition, the contact was informed that an alignment was not performed because the alignment machine was unavailable. The contact had not been informed that the recall repair was completed. The dealer informed the contact that an alignment had been completed. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 147,419.
NHTSA complaint #11750269 — an unverified report by a vehicle owner.