2016 Ford Explorer problems

STRUCTURE:BODY

B-Pillar door trim came off of 2016 Ford Explorer. There has been a recall on this problem since May 2025. This problem is still listed as no repair or parts available. It is now Sept. 2026. 1 1/2 years is too long for a company to delay in solving this safety problem and/or providing parts for said problem.

NHTSA complaint #11763832 — an unverified report by a vehicle owner.

STEERING

Approximately 3 years ago, while driving my 2016 Ford Explorer on a [XXX], warning chimes sounded and a power steering/steering assist fault message appeared. Electric power-steering assist then stopped functioning and the steering became extremely difficult to operate. I slowed down and was able to maneuver safely off the freeway. I shut the vehicle off, opened the driver’s door, waited approximately 45 seconds and restarted it. Normal steering assist returned. Shortly afterward, I took the vehicle to Oakdale Ford in Oakdale, CA and reported the problem. I was advised that further diagnosis/investigation would involve approximately $5,600 in costs. I declined due to the expense, and no repair was performed. The cause of the failure remains UNKNOWN. The vehicle remains available for inspection. During the approximately 3 years since, the vehicle has unexpectedly lost electric power-steering assist at least a dozen additional times, at different speeds and on different types of roads. Sometimes warning chimes/messages occur without loss of assist; other times assist is actually lost. Shutting the vehicle down, opening the driver’s door, waiting approximately 45 seconds and restarting has restored steering assist each time, but the problem later recurs unpredictably. I live in a mountainous area and regularly drive narrow, winding roads with steep drop-offs and limited or no guardrails. Sudden loss of steering assist while negotiating a curve makes the vehicle significantly harder to control and creates a serious risk of leaving the roadway. No crash or injury has occurred to date. The failure is intermittent, unpredictable, repeatedly occurs while driving, and has not been repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11762935 — an unverified report by a vehicle owner.

ENGINE

I am writing to report a severe, inherently dangerous engineering defect regarding the internal water pump design on the 2016 Ford Explorer equipped with the 3.5L naturally aspirated V6 engine.On September 8, 2026, my vehicle experienced a sudden, catastrophic primary seal failure of the internal water pump while operating. The vehicle immediately began dumping large quantities of engine coolant onto the ground from the designated engine block weep hole located on the lower passenger side. Because Ford engineered this specific engine with the water pump hidden entirely behind the front timing cover and driven directly by the engine's timing chain, any mechanical failure of the pump poses an immediate, severe safety risk to the driver and occupants. If the secondary pump seal fails or the weep hole becomes obstructed, coolant dumps directly into the engine crankcase, mixing with the engine oil. This sudden loss of lubrication can cause the internal pump bearings to seize rapidly, leading to the timing chain snapping or jumping tracks.The consequences of this design create two distinct, critical safety hazards:Sudden Engine Stall at Speed: A seized water pump or broken timing chain will cause an instantaneous, un-commanded engine shutdown while traveling at highway speeds. This immediately cuts off the vehicle's power steering assist and power brake booster, placing the driver at extreme risk of a high-speed collision. Passenger Cabin Hazmat Hazard: A major coolant dump underneath the engine bay onto hot exhaust components generates blinding steam and toxic chemical fumes that can enter the vehicle’s HVAC system, severely impairing driver visibility and breathing.This internal, chain-driven water pump design is a known, systemic manufacturing defect that forces vehicle owners to pay between $3,000 and $5,000 in preventative labor to fix an auxiliary cooling component before it destroys the entire engine block. I urge the NHTSA to open a formal safety investigation int

NHTSA complaint #11762805 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The contact reached out to the local dealer and stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the B-pillar trim was taped to the door; however, after the tape lost the stickiness, the trim became loose and was hanging down by the electrical wiring. The manufacturer was notified of the failure. The dealer confirmed the failure.

NHTSA complaint #11762206 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer. The vehicle and the contact were informed that the B-pillar trim needed to be replaced. The dealer confirmed that parts were not yet available and that only half of the B-pillar trim could be replaced. The dealer stated that the remaining part needed to be provided by the manufacturer. The dealer informed the contact that parts might to available April of 2027. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA complaint #11761615 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Transmission is company. Was driving and it bucked forward SO bad I had a panic attack with my kids in the back and had to have it towed home. Sounds like a computer issue because no me manic can figure out what’s wrong with it. Dealership had put in a ‘brand new’ transmission when I bought it in 2021.

NHTSA complaint #11760738 — an unverified report by a vehicle owner.

STRUCTURE:BODY

After multiple communications with the local Ford Dealership, the recall on the vehicle has not been completed nor inspected. The Ford Dealership has repeatedly stated that they do not have the parts and cannot give an estimated time frame of arrival. The conversation always ends, "we will call when the parts come in". This has been over a year now. Today I called a different dealership in the area and received the same response. The Recalled Part on my vehicle is deteriorating, and it is only a matter of time before it detaches and causes damage or injury. Any help resolving this issue would be appreciated.

NHTSA complaint #11759118 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact stated that while driving 70 MPH, the driver’s side B-pillar trim detached from the vehicle and was dangling by two wires. The contact later used black duct tape to seal the trim in place. The dealer was notified of the failure and later informed the contact that parts for NHTSA Campaign Number: 24V031000 (Structure) were not available for the recall repair. Additionally, the contact stated that the front driver’s side A-pillar trim was rattling while driving at various speeds. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 106,000.

NHTSA complaint #11757701 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving 70 MPH on two occasions, the driver's side A-pillar trim flew off the vehicle into traffic. The vehicle was taken to the same dealer twice, where it was diagnosed, and it was determined that the A-pillar trim needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

NHTSA complaint #11756446 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11756325 — an unverified report by a vehicle owner.

STEERING

Hello. I purchased my car in 2018. 2-3 years later, the power steering would randomly go out while driving - on the highway and city roads. This could happen once and then not again for 6+ months. When this happened a message would display about a "steering assist fault, service now". I found that if I pulled over, turned the car off and then on, it would generally work again. We had the vehicle in to 3 separate repair shops between 10/2022 and 10/2025 and no one could diagnose the issue as they needed it to replicate the condition. (In hindsight find this strange (concerning!!) as a simple google search shows what I am describing is a very common issue with a number of Ford models and also other vehicles.) In June 2026, while on vacation with my family (on a mountain) it happened again. We turned the car on and off several time, disconnected/reconnected the battery and could not get the car to start working again and this time the steering wheel was completely locked. We had the vehicle towed and rented a car to drive home. The dealership was able to diagnose and repair the issue by replacing the entire steering rack assembly. No issues since then.

NHTSA complaint #11755766 — an unverified report by a vehicle owner.

POWER TRAIN

The contact called on behalf of his wife, who owns a 2016 Ford Explorer. The contact stated that while reversing at an undisclosed speed, the vehicle independently accelerated. The check engine warning light was illuminated. The contact researched online and was made aware of NHTSA Campaign Number: 25V164000 (Power Train); however, the VIN was not included. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 155,000.

NHTSA complaint #11753015 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

25V347 and 24V031 I recieved a notice of the first recall in February 2024. Over the Summer of 2024 and 2025 both the A-pillar and B-pillar trim has melted and become detached from the vehicle during high heat warnings and during my commute to work on the interstate 60 miles each day. Parts from the vehicle flew off at high rates of speed and were at risk to others on the road. For 2.5 years now I have driven a duct taped windshield on both drivers and on the passenger sides windows and on the tops of the door frames. The windshield rattles on the interstate--I feel this is dangerous. I have now recieved my 3rd factory recall: 25N17 Every day I drive this duct taped FORD, it is cemented in my mind that I will never purchase another Ford or Ford related product.

NHTSA complaint #11753159 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Truck turns off

NHTSA complaint #11753172 — an unverified report by a vehicle owner.

ENGINE

Truck turns off

NHTSA complaint #11753172 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

25V347 and 24V031 I recieved a notice of the first recall in February 2024. Over the Summer of 2024 and 2025 both the A-pillar and B-pillar trim has melted and become detached from the vehicle during high heat warnings and during my commute to work on the interstate 60 miles each day. Parts from the vehicle flew off at high rates of speed and were at risk to others on the road. For 2.5 years now I have driven a duct taped windshield on both drivers and on the passenger sides windows and on the tops of the door frames. The windshield rattles on the interstate--I feel this is dangerous. I have now recieved my 3rd factory recall: 25N17 Every day I drive this duct taped FORD, it is cemented in my mind that I will never purchase another Ford or Ford related product.

NHTSA complaint #11753159 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Truck turns off

NHTSA complaint #11753172 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that upon further inspection, the contact became aware that the front A-pillar trim sealants were deteriorating. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

NHTSA complaint #11752338 — an unverified report by a vehicle owner.

STRUCTURE

The contact's wife owns a 2016 Ford Explorer. The owner received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the lower trim on the A-pillars on the front driver’s and passenger’s sides became loosened and pieces of the A-pillar trims fractured and detached from the vehicle while driving. The local dealer was contacted and informed the contact that parts for the recall repairs were still unavailable. The dealer recommended that the parts be taped down until the parts became available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure through the chat feature on the Ford website. The chat operator referred the contact to the NHTSA Hotline to report the failure. The vehicle was not yet repaired. The failure mileage was unknown.

NHTSA complaint #11751808 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

We received the recall 25S53/25V347 on XXX. Then on XXX; [XXX], sent me a picture of the trim / rubber coming off the front windshield. I contacted the dealership Gary Yeomans Ford [XXX] & sent them the pic. They said they don't have the parts & didn't know when they would be available. They recommended us to contact a glass repairer and have them to fix it. And then us to send the bill to the Ford Dealership for reimbursement. The trim / rubber was flapping and making noise on passenger side. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11751577 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Been waiting on parts to repair existing A pillar trim recall for almost 2 years. This is unacceptable.

NHTSA complaint #11751009 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the exterior a pillar trim on the driver’s and passenger’s side of the windshield detached. No warning light was illuminated. The dealer was contacted, and the contact was informed that the part was not available to repair the vehicle. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 107,000.

NHTSA complaint #11751125 — an unverified report by a vehicle owner.

POWER TRAIN

My 2016 ford explorers torque converter has failed. It causes a extremely rough idle while in drive or reverse, the rpms vary and at a complete stop the car will continue to lunge forward. If I were to continue to drive the vehicle at any point without warning my transmission could completely lock up causing me to stall in the middle of the road. The dealership has confirmed it as well as ford and ford has an active recall for my specific car but my vin isn't covered under the recall and ford is refusing any sort of fault.

NHTSA complaint #11750138 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Lost all power in the transmission while driving down the road. Transmission is not fixable. Could barely get the car off the road

NHTSA complaint #11749922 — an unverified report by a vehicle owner.