Owners have filed 1,533 complaints
about the 2008 Ford Fusion with NHTSA between 2008 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 10 of 15 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 40
Against the median year of the Ford Fusion. 50 means typical for this
model; 100 means roughly double.
Severity — 34
6.6% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 13
7% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
3454.0%
Door
1219.0%
Latch
46.3%
Automatic Emergency Braking
34.8%
Master Cylinder
34.8%
Automatic Transmission
34.8%
Dashboard
23.2%
Latch
23.2%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
60.7%
1,000 – 9,999 miles
70.8%
10,000 – 24,999 miles
252.8%
25,000 – 49,999 miles
768.5%
50,000 – 74,999 miles
14716.4%
75,000 – 99,999 miles
22324.9%
100,000 – 149,999 miles
25928.9%
150,000+ miles
15417.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2008peak 107Jul 2026
NHTSA investigations into the 2008 Ford Fusion
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA18002Opened 18 Apr 2018Closed 15 Jan 2021SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE
Extended Braking Distance
On April 18, 2018, the Office of Defects Investigation (ODI) opened Engineering Analysis (EA) 18-002 to investigate reports of braking concerns in model year (MY) 2006-12 Ford Fusion and Lincoln MKZ, and MY 2006-11 Mercury Milan vehicles manufactured with Continental Automotive System?s ABS hydraulic control units (HCUs). Complainants report that after an ABS braking event (initiated by slippery or uneven surfaces) the brake pedal moved towards the floor and the vehicle stopping distance increased beyond driver expectations.Inside the HCU are four hydraulic normally closed (NC) valves with zin...
PE16017Opened 20 Dec 2016Closed 4 May 2018SERVICE BRAKES
Extended Braking Distance
On December 20, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 16-017 to investigate reports of braking concerns in model year 2007 through 2009 Ford Fusion and Mercury Milan vehicles.Complainants report that after an ABS braking event (caused by braking on a slippery or uneven surface) the brake pedal moved towards the floor and the distance in which the vehicle stopped increased beyond what was expected by the driver.The cause of the problem appears to be the Antilock Braking System (ABS) Hydraulic Control Unit (HCU), a component manufactured for Ford by C...
EA12009Opened 12 Dec 2012Closed 12 Jun 2014VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated c...
PE10019Opened 28 May 2010Closed 11 Jan 2013VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Accel Pedal Interference - Acc Floormat
Unsecured mats may interfere with accelerator pedal return to idle. A heel blocker in the floor pan provides a platform that may lift an unsecured mat into contact with the pedal. Ford introduced new pedals as a running change early in model year (MY) 2010 vehicles. Analysis of complaints received by ODI and Ford show elevated rates of pedal entrapment incidents in MY 2008 through early 2010 production vehicles. Incidents typically occur following hard pedal applications to pass slower traffic or when merging into faster traffic. Drivers allege continued high engine power after releasing the a...
PE08060Opened 14 Oct 2008Closed 9 Apr 2009TIRES:VALVE
TIRE VALVE CRACKING
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BO...
Recalls on the 2008 Ford Fusion
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V158000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
21V081000
AIR BAGS:FRONTAL
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V904000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Risk: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
17V024000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
16V384000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
14E028000
EQUIPMENT
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
Risk: The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2021029274,737 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Ford will notify owners by mail. The corrective actions for this recall are under development. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 201966554,292 units in Canada
Brakes
Issue: On certain cars, a problem with the hydraulic control unit for the anti-lock brake system (ABS) could cause increased brake pedal travel. Safety Risk: Increased brake pedal travel could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your vehicle to a Ford or Lincoln dealer to inspect the ABS module assembly. The system will be flushed with DOT 4 brake fluid, and if necessary, the hydraulic control unit will be replaced. Dealers will also replace the DOT 3 reservoir cap with a new DOT 4 cap.
Recall 2019005300,898 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Actions: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional note: This recall supersedes recalls 2016-347 (Ford Safety Improvement Program 16S26), 2017-024 (Ford Recall 17S01) and 2018-035 (Ford Recall 18S01). Vehicles repaired under the previous recalls do not require repair under this recall.
Recall 2017024155,793 units in Canada
Airbag
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, metal fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Depending on the model, dealers will either replace the passenger frontal airbag inflator or airbag assembly. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected. Additional note: This recall is superseded by recall 2019005 (Ford Recall 19S01). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2019005">recall 2019005</a> for more information.
Recall 20163475,867 units in Canada
Airbag
Ford Canada is conducting a voluntary Safety Improvement Program involving passenger airbag inflators in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States equipped with Takata airbags. Ford will replace the driver or passenger inflator on affected vehicles, depending on the vehicle involved. Owners who believe their vehicles may have been originally purchased or registered in the states of New Jersey, Delaware, District of Columbia, Maryland, Pennsylvania, Ohio, Indiana, Illinois, Virginia, West Virginia, Kentucky, Missouri, Nebraska, Kansas, Oklahoma, Arkansas, Tennessee, North Carolina, Nevada, Arizona, New Mexico, California, Texas, Louisiana, Mississippi, Alabama, Georgia, South Carolina, Florida, Hawaii, Puerto Rico or the U.S. Virgin Islands should contact a Ford dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This Safety Improvement Program is superseded by recall 2019005 (Ford Recall 19S01). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2019005">recall 2019005</a> for more information.
Recall 20141952,810 units in Canada
Accessories
A safety defect may exist in Ford aftermarket all-weather floor mats sold as accessories or service replacement parts for 2006-2011 Ford Fusion, Lincoln Zephyr, and Lincoln MKZ vehicles. The floor mats are secured by a single retention device, which could allow the driver's floor mat to move out of position and interfere with the accelerator pedal. If this occurs, the accelerator pedal could fail to return to idle. This could result in a crash causing injury and/or property damage. Correction: Dealers will replace Ford aftermarket all-weather floor mats with an updated design having two retention devices.
Reports where the owner recorded a crash, a fire, an injury or a death.
Reddick, FLCrash
STEERING
My Breaks gave way for some odd reason I ran into a cable box trying to control or rather stop the vehicle.
NHTSA complaint #11474319 — an unverified report by a vehicle owner.
Reddick, FLCrash
STRUCTURE:BODY
My Breaks gave way for some odd reason I ran into a cable box trying to control or rather stop the vehicle.
NHTSA complaint #11474319 — an unverified report by a vehicle owner.
Reddick, FLCrash
SERVICE BRAKES
My Breaks gave way for some odd reason I ran into a cable box trying to control or rather stop the vehicle.
NHTSA complaint #11474319 — an unverified report by a vehicle owner.
at 169,000 milesMaple Grove, MNCrash
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE
The contact owns a 2008 Ford Fusion. The contact stated that while driving approximately 30 mph the brakes failed and the pedal extended to the floor causing the vehicle to crash into a stationary truck. During the crash, the front end was damaged but the airbags did not deploy. No injuries were reported, no police report was taken and the vehicle was not towed. The cause of the failure was not determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The contact was notified that the vehicle was included in the NHTSA campaign number 19v904000(service brakes) and 21v158000(airbags) however, the parts to do the recall repairs were unavailable.The contact indicated that the vehicle had experienced the same failure listed in the recall and the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 169,000.
NHTSA complaint #11438344 — an unverified report by a vehicle owner.
at 85,000 milesTuscaloosa, ALFire
ENGINE
ENGINE CAUGHT FIRE.*DT
NHTSA complaint #11399301 — an unverified report by a vehicle owner.
at 117,000 milesMiddleburg Hiehgts, OHCrash
SERVICE BRAKES
TL* THE CONTACT OWNS A 2008 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE BRAKING SYSTEM MALFUNCTIONED AND WOULD NOT IMMEDIATELY STOP THE VEHICLE CAUSING THE VEHICLE TO CRASH INTO THE REAR OF A SECOND VEHICLE. DURING THE CRASH NO INJURIES WERE REPORTED. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS LATER TOWED TO THE HOME. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER LIBERTY FORD LOCATED AT 6600 PEARL RD, PARMA HEIGHTS, OH 44130 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN THE NHTSA CAMPAIGN NUMBER 19V904000(BRAKING SYSTEM ) BUT THE PARTS TO REMEDY THE DEFECT WERE NOT AVAILABLE. THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 117,000.
NHTSA complaint #11372665 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Cherry Hill, NJ
SERVICE BRAKES
I had the Ford brake recall work completed in 2023, but the same brake issue has returned. This appears to be the same HCU problem covered by the recall, and Ford is now refusing to repair it. I am concerned because this is a serious safety issue, and the recall repair did not permanently correct the problem.
NHTSA complaint #11751872 — an unverified report by a vehicle owner.
Connelly Springs, NC
SERVICE BRAKES
I have been having issues with my 2008 ford fusion. I did research and found that the is a Ford customer satisfaction program( campaign # 21N11) which also goes along with recall number 19S54 and ford is refusing to fix the issues. Their lots of complaints and somethingd needs to be done ASAP before someone gets hurt cause this has to do with the brakes.
NHTSA complaint #11684088 — an unverified report by a vehicle owner.
Spring Hill, KS
SERVICE BRAKES
My brake pedal drops to the floor when braking at times. Mechanics say that is my ABS module. I believe this is a very common issue with these vehicles. This has happened to me several times. Only remedy without repair is disengaging the ABS system all together. There has not been a recall on this but there has been a customer satisfaction program associated with the brake system. I tried to have mine fixed and Ford says the program has expired. I feel like braking is the most important thing you need to be on the road. This needs to be a full recall and not a satisfaction program. Thank you
NHTSA complaint #11671375 — an unverified report by a vehicle owner.
Girard, IL
SERVICE BRAKES
HAVE TO PRESS DOWN HARD ON BRAKES TO SLOW OR STOP. HAD LANDMARK FORD INSPECT RECALL ISSUE & THEY STATED NOTHING WAS WRONG WITH BRAKES.
NHTSA complaint #11641534 — an unverified report by a vehicle owner.
South SAN Francisco, CA
SERVICE BRAKES
took in for two recalls to Serramonte ford, airbag recall fixed, braking issue not fixed due to as dealer put it, issues with computer system and was not given a timeframe to have it completed, vehicle was returned to me.
NHTSA complaint #11621078 — an unverified report by a vehicle owner.
Flower Mound, TX
STRUCTURE:BODY
Door handle is stuck/broken. Door cannot open from the inside or outside. Passengers are stuck in car.
NHTSA complaint #11619638 — an unverified report by a vehicle owner.
San Antonio, TX
SERVICE BRAKES
The vehicle brakes will engage at random intervals without the brake pedal being touched. This happens at all speeds, and even at a stop. Issue still occurs daily, and has been ongoing for 5+ years. Brake master cylinder and aux boost pump have been replaced twice with OEM parts, and three complete brake jobs (pads, calipers and rotors) in the last 5 years. At slower speeds, it manifests as a drag to forward motion. At higher speeds, the drag is more pronounced, and causes the car to decelerate. It has also caused the tires to "hop" during travel, causing loss of vehicle control. Luckily, no accidents so far. I am aware of the recall for the HCU (ABS Module) for this vehicle, but four different Ford dealerships have declined to examine closer, citing recall 19S54 as a "customer experience" issue, not a safety issue. The brake fluid replacement (DOT3 to DOT4) has been done, but dealer declined to examine or replace the HCU, citing "out of warranty".
NHTSA complaint #11616815 — an unverified report by a vehicle owner.
West Chester, OH
UNKNOWN OR OTHER
This isn't an incident. I just want to report that Ford Motors will not replace the Hydraulic Control unit that is under recall for my 2008 Ford Fusion. They will only replace cars that are 15 or less years old. My car has 117,000 miles on it. Far less than the yearly average of 14,000 miles. If this truly a safety issue, then I feel that my car should be serviced under the recall. I chatted with the Ford Customer service rep and he informed me that it was safe to drive, But he did tell me to take it to a Ford dealer (of course) and that I would be financially responsible for the repair. So I own a vehicle that is under a recall, but since it's 1 year past the 15 year ownership date, Ford will not repair it under the recall. Thus any Ford owner that owns a vehicle that is older than mine is also out of luck Thank you for taking the time to read this and maybe encourage Ford to do the right thing. My car should not be any less safe than a 2010 car
NHTSA complaint #11608804 — an unverified report by a vehicle owner.
Bridgeport, CT
STEERING
I want to file a safety complaint against Ford car company for their vehicle in which I purchased which is a 2008 Ford Fusion SEL for excessive and dangerous rot and rust problem on the frame and suspension and under component which can lead to accidents if one of these components fall apart . I purchased a 2008 Ford fusion SEL in Connecticut which used to be a Massachusetts state government vehicle before I've obtained it. It was well maintenance and had no flood damage. But just like a wide range of cars from Ford especially this model that I've purchased has a serious problem with excessive rust which make the car very dangerous to drive. Mind's speaking I've had to have framework done to my vehicle and change multiple suspension parts because of all the rust my transmission pan literally fell apart and all the oil came because it was so rusted. My stabilizer links and control arms have fell apart in which obstructs the steering which also caused a safety hazard for me and other people on the road. Ford has a duty to design their cars with a certain level of weather resistance. After doing research I found that there is a wide range of customers who's having the same having the same problems with this year make and model just like other vehicles that are made by ford. All the problems that stated in this complaint having verified by ASE certified mechanics that I've been working on my vehicle. The contact stated all the original metal components like control arms, tie rods, suspension shocks and struts and frame all have a issue with rot rust and corrosion which led to vehicles having alignment issues.
NHTSA complaint #11577817 — an unverified report by a vehicle owner.
Bridgeport, CT
SUSPENSION
I want to file a safety complaint against Ford car company for their vehicle in which I purchased which is a 2008 Ford Fusion SEL for excessive and dangerous rot and rust problem on the frame and suspension and under component which can lead to accidents if one of these components fall apart . I purchased a 2008 Ford fusion SEL in Connecticut which used to be a Massachusetts state government vehicle before I've obtained it. It was well maintenance and had no flood damage. But just like a wide range of cars from Ford especially this model that I've purchased has a serious problem with excessive rust which make the car very dangerous to drive. Mind's speaking I've had to have framework done to my vehicle and change multiple suspension parts because of all the rust my transmission pan literally fell apart and all the oil came because it was so rusted. My stabilizer links and control arms have fell apart in which obstructs the steering which also caused a safety hazard for me and other people on the road. Ford has a duty to design their cars with a certain level of weather resistance. After doing research I found that there is a wide range of customers who's having the same having the same problems with this year make and model just like other vehicles that are made by ford. All the problems that stated in this complaint having verified by ASE certified mechanics that I've been working on my vehicle. The contact stated all the original metal components like control arms, tie rods, suspension shocks and struts and frame all have a issue with rot rust and corrosion which led to vehicles having alignment issues.
NHTSA complaint #11577817 — an unverified report by a vehicle owner.
Bridgeport, CT
STRUCTURE:BODY
I want to file a safety complaint against Ford car company for their vehicle in which I purchased which is a 2008 Ford Fusion SEL for excessive and dangerous rot and rust problem on the frame and suspension and under component which can lead to accidents if one of these components fall apart . I purchased a 2008 Ford fusion SEL in Connecticut which used to be a Massachusetts state government vehicle before I've obtained it. It was well maintenance and had no flood damage. But just like a wide range of cars from Ford especially this model that I've purchased has a serious problem with excessive rust which make the car very dangerous to drive. Mind's speaking I've had to have framework done to my vehicle and change multiple suspension parts because of all the rust my transmission pan literally fell apart and all the oil came because it was so rusted. My stabilizer links and control arms have fell apart in which obstructs the steering which also caused a safety hazard for me and other people on the road. Ford has a duty to design their cars with a certain level of weather resistance. After doing research I found that there is a wide range of customers who's having the same having the same problems with this year make and model just like other vehicles that are made by ford. All the problems that stated in this complaint having verified by ASE certified mechanics that I've been working on my vehicle. The contact stated all the original metal components like control arms, tie rods, suspension shocks and struts and frame all have a issue with rot rust and corrosion which led to vehicles having alignment issues.
NHTSA complaint #11577817 — an unverified report by a vehicle owner.
at 79,259 milesOverland, MO
SERVICE BRAKES, HYDRAULIC
The contact owns a 2008 Ford Fusion. The contact stated that while his girlfriend was driving at undisclosed speeds, the vehicle hydroplaned, and the anti-lock brakes engaged and disengaged. The brake pedal became inoperable. The vehicle was taken to the local dealer, where it was determined that the vehicle had passed testing. The vehicle was repaired, but the failure recurred. While driving the vehicle, the brake pedal was squishy and would depress to the floorboard. The contact stated that the solenoid was stuck open. There were no warning lights illuminated. The manufacturer was contacted, but no assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The failure mileage was approximately 79,259.
NHTSA complaint #11565926 — an unverified report by a vehicle owner.
Fountain Valley, CA
UNKNOWN OR OTHER
The dashboard has warped. The seems on the dashboard around the passenger side airbag cover have become partially unattached to the rest of the dashboard and have caused an opening above passenger side airbag that may allow for debris/dirt to enter into safety equipment and could potentially lead to serious hazards to person if airbag unit deploys. The plastic vent and sensor under the windshield located in the very top front of the dashboard has cracked and has also become dislodged and lifteb from dashboard housing and can pose safety issues if in a collision. There is also some notable brittleness arising in the dashboard material. The warping of the dashboard and its components pose strong safety concerns and a risk to service departments doing recall repairs for manufacturers. There are many similar vehicles produced by this manufacturer during this time that have had same dashboard failures and at the very least it was been the root of stress anxiety for owners and repair dealerships.
NHTSA complaint #11565691 — an unverified report by a vehicle owner.
at 68,000 milesEddyville, KY
ENGINE AND ENGINE COOLING
The contact owns a 2008 Ford Fusion. The contact stated that while driving approximately 55 MPH, the check engine warning light illuminated. The message that the engine was overheated was displayed. The vehicle was towed to the local dealer, where it was diagnosed that coolant had leaked into the compression chamber and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 68,000. The VIN was not available.
NHTSA complaint #11542103 — an unverified report by a vehicle owner.
at 68,000 milesEddyville, KY
ENGINE
The contact owns a 2008 Ford Fusion. The contact stated that while driving approximately 55 MPH, the check engine warning light illuminated. The message that the engine was overheated was displayed. The vehicle was towed to the local dealer, where it was diagnosed that coolant had leaked into the compression chamber and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 68,000. The VIN was not available.
NHTSA complaint #11542103 — an unverified report by a vehicle owner.
Abbeville, GA
UNKNOWN OR OTHER
I just bought this car and the brakes do not feel right when i go to stop. They are new and i got them changed today and it still makes a pop noise.
NHTSA complaint #11529277 — an unverified report by a vehicle owner.
Abbeville, GA
SERVICE BRAKES
I just bought this car and the brakes do not feel right when i go to stop. They are new and i got them changed today and it still makes a pop noise.
NHTSA complaint #11529277 — an unverified report by a vehicle owner.
I just bought this car and the brakes do not feel right when i go to stop. They are new and i got them changed today and it still makes a pop noise.
NHTSA complaint #11529277 — an unverified report by a vehicle owner.
Ypsilanti, MI
EXTERIOR LIGHTING
I discovered my drivers rear brake light bulb melted in their socket. The socket themselves are burnt black and the drivers side tail light case has been hot enough to melt. A quick search on the Internet turns up a lot more chatter about this same issue. Even scarier is the fact that this happening with zero warning. No blown fuse, no codes, nothing to indicate your frying stuff in the back at all. The dealership denies hearing anything , Ford denies hearing anything, even though it's happening all over the country and I found at least five other complaints listed with the National Highway Traffic Safety Administratiion. I took car in for oil change and discovered this but want $250 for repair and no guarantee it won't happen again. I'm a senior with limited income and it's a 2008 Ford fusion SE HELP NEED RECALL!
NHTSA complaint #11526840 — an unverified report by a vehicle owner.
Ypsilanti, MI
ELECTRICAL SYSTEM
I discovered my drivers rear brake light bulb melted in their socket. The socket themselves are burnt black and the drivers side tail light case has been hot enough to melt. A quick search on the Internet turns up a lot more chatter about this same issue. Even scarier is the fact that this happening with zero warning. No blown fuse, no codes, nothing to indicate your frying stuff in the back at all. The dealership denies hearing anything , Ford denies hearing anything, even though it's happening all over the country and I found at least five other complaints listed with the National Highway Traffic Safety Administratiion. I took car in for oil change and discovered this but want $250 for repair and no guarantee it won't happen again. I'm a senior with limited income and it's a 2008 Ford fusion SE HELP NEED RECALL!
NHTSA complaint #11526840 — an unverified report by a vehicle owner.
at 143,300 milesMaysville, GA
POWER TRAIN
The contact owns a 2008 Ford Fusion. The contact stated that there was a squealing sound coming from underneath the dashboard. The vehicle was hard shifting while accelerating or while idling. The check engine warning light was illuminated. The vehicle was taken to the dealer who was unable to identify the cause of the failure. The vehicle had not been repaired. The failure persisted and the vehicle was taken to the dealer approximately 8-times. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in TSB Number: 10052190 (Power Train). The approximate failure mileage was 143,300. The repairs were made at the owner's expense in the amount of $2196.46.
NHTSA complaint #11517379 — an unverified report by a vehicle owner.
at 143,300 milesMaysville, GA
ENGINE
The contact owns a 2008 Ford Fusion. The contact stated that there was a squealing sound coming from underneath the dashboard. The vehicle was hard shifting while accelerating or while idling. The check engine warning light was illuminated. The vehicle was taken to the dealer who was unable to identify the cause of the failure. The vehicle had not been repaired. The failure persisted and the vehicle was taken to the dealer approximately 8-times. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in TSB Number: 10052190 (Power Train). The approximate failure mileage was 143,300. The repairs were made at the owner's expense in the amount of $2196.46.
NHTSA complaint #11517379 — an unverified report by a vehicle owner.
Mcewen, TN
SERVICE BRAKES
Driving around 55 and put brakes on and went 3/4 to floor like they were out. 2 other people experienced the same. HCA Unit must be bad or corrosive. I read online about this. Ford has extended warranty recall and sent letter and fluid changed 14 yes later. We'll that's a little late cause obviously unit bad now. Ford dealer will not replace cause can't duplicate problem. If I wreck, Ford is liable for 4 to 5 people in car. Common sense would be REPLACE PART!!!
NHTSA complaint #11511375 — an unverified report by a vehicle owner.
at 73,000 milesMc Ewen, TN
SERVICE BRAKES, HYDRAULIC
The contact owns a 2008 Ford Fusion. The contact stated while driving 50 MPH, the brake pedal was depressed and went to the floorboard. The contact was unsure if a warning light was illuminated. The contact pumped the brake pedal several times, and the brake pedal started operating normally. The vehicle was taken to the dealer for diagnostic test; however, the dealer stated that no failure was found. The manufacturer was contacted but offered no assistance. The failure mileage was 73,000.
NHTSA complaint #11510773 — an unverified report by a vehicle owner.
Virginia Beach, VA
POWER TRAIN
Transmission slipping
NHTSA complaint #11509571 — an unverified report by a vehicle owner.