2012 Ford Fusion problems

STEERING

While I was driving my 2012 Ford Fusion on August 3rd the steering cut out. I parked the car and re-started it and it worked again. It went to the shop (Extra Mile Automotive) on XXX where they informed me of the 2015 recall on the steering. Recall number 15S18 and program 15N01 When I spoke with [XXX] Ford in [XXX], they said they replaced the electrical piece of the recall on December 7th 2015, but not the steering shaft. [XXX] (the westlie ford employee) said because the electrical was completed, the recall procedure was marked as completed, even though [XXX] said that this is very much tied to the original recall. I asked him to submit a Special Service Support Center request to get this fixed and he did submit that on XXX. On XXX it was denied. On XXX I also requested to speak to [XXX] supervisor and was connected to [XXX] (id # XXX) who also said there was nothing she could do because this was already "solved" in 2015. This is not a new or unrelated repair request, it is the unresolved second half of a federally mandated safety recall. Ford's own dealership confirmed that my steering gear failure is directly connected to the original defect covered under Recall 15S18, and Ford's own extended coverage program, 15N01, exists specifically to remedy this exact scenario. Despite this documented connection, Ford has now denied a remedy twice, once through the dealer's SSSC request, and once directly through Ford Customer Service, without providing any technical explanation for why a known, recall-covered defect is being treated as ineligible for repair. My vehicle experienced a complete loss of steering assist while in motion. This is an active, unresolved safety hazard on a vehicle currently in use on public roads, and I am filing this formal complaint because Ford has failed to meet its obligation under federal law to remedy a safety defect without charge to the owner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11758395 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While I was driving my 2012 Ford Fusion on August 3rd the steering cut out. I parked the car and re-started it and it worked again. It went to the shop (Extra Mile Automotive) on XXX where they informed me of the 2015 recall on the steering. Recall number 15S18 and program 15N01 When I spoke with [XXX] Ford in [XXX], they said they replaced the electrical piece of the recall on December 7th 2015, but not the steering shaft. [XXX] (the westlie ford employee) said because the electrical was completed, the recall procedure was marked as completed, even though [XXX] said that this is very much tied to the original recall. I asked him to submit a Special Service Support Center request to get this fixed and he did submit that on XXX. On XXX it was denied. On XXX I also requested to speak to [XXX] supervisor and was connected to [XXX] (id # XXX) who also said there was nothing she could do because this was already "solved" in 2015. This is not a new or unrelated repair request, it is the unresolved second half of a federally mandated safety recall. Ford's own dealership confirmed that my steering gear failure is directly connected to the original defect covered under Recall 15S18, and Ford's own extended coverage program, 15N01, exists specifically to remedy this exact scenario. Despite this documented connection, Ford has now denied a remedy twice, once through the dealer's SSSC request, and once directly through Ford Customer Service, without providing any technical explanation for why a known, recall-covered defect is being treated as ineligible for repair. My vehicle experienced a complete loss of steering assist while in motion. This is an active, unresolved safety hazard on a vehicle currently in use on public roads, and I am filing this formal complaint because Ford has failed to meet its obligation under federal law to remedy a safety defect without charge to the owner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11758395 — an unverified report by a vehicle owner.

STEERING

Vehicle experienced loss of power steering so it was hard to steer.When I called a ford dealership I was told my vehicle didn’t qualify for any power steering recalls so I would have to pay full price which is unaffordable

NHTSA complaint #11757574 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the brake pedal was soft and spongy. The brake pedal was depressed to the floorboard before the vehicle stopped. No warning lights were illuminated. The vehicle was taken to an independent mechanic, and the contact was informed that the failure was not duplicated. The contact was informed that an inspection was completed, and the brake pads and rotors were in good working order. The contact stated that the failure had occurred two months after the brake pads and rotors were replaced by an independent mechanic. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 149,000.

NHTSA complaint #11755210 — an unverified report by a vehicle owner.

STEERING

I am submitting this formal complaint against Ford Motor Company and its authorized dealership network for falsely reporting a safety recall repair as "resolved" while applying an unauthorized, temporary workaround that left the primary safety defect active. In 2023, I brought my vehicle to an authorized Ford dealership to perform mandatory safety recall service regarding the Electric Power Assist Steering (EPAS) failure. The dealership subsequently updated Ford’s central database (OASIS) to show that the safety recall was fully resolved and completed for my VIN. However, the official Repair Order / Invoice provided to me by the technician explicitly documents that a permanent remedy was not performed due to a lack of replacement parts. The technician’s exact written notes state: "Customer states power steering is not working. Tech and advised verified concern finding that the ground wire pin on the high current wiring harness to PSCM had backed out of the connector. Reconnected pin and cleared codes finding issue resolved. Issue will continue to happen until the harness is replaced. Harness is unavailable at this time. Glued pin into connectors."Because the dealership glued the loose pin rather than replacing the backordered wiring harness, the temporary repair failed shortly thereafter, resulting in a total loss of power steering assist. For the past three years (approximately 47,698 miles driven), I have been forced to operate this vehicle without functional power steering. Every attempt to have Ford or its franchised dealerships address this safety hazard has been denied because Ford’s internal system incorrectly lists the recall as "The Harness Powers the Recalled Module: The "high current wiring harness to PSCM" is the primary electrical supply to the exact module being recalled. Reprogramming software on a module while leaving a damaged, glued power connector defeats the entire purpose of restoring power steering safety.see photoes of invoice below

NHTSA complaint #11754874 — an unverified report by a vehicle owner.

TIRES

I had purchased these tires P225/50R17 for my son‘s car in 2022. They have an 85,000 mile tread life warranty in April of this year. He had a blowout on the left rear tire where the tread separated from the tire and in late July this year is preparing for a 3500 mile trip as I was inspecting his car before his trip. I noticed the tire on the right rear looked to be defective. It looks like the tread where it meet the sidewall is separating from the tire on the inside with a tear about 8” long where the metal is showing. Two tires out of 4 losing their tread is disturbing and a concerning safety issue with these tires, see the Photos I have supplied.

NHTSA complaint #11753653 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to turn. The message "Power Steering Assist Fault" was displayed. The failure was a recurring failure. The first failure was serviced by the dealer under NHTSA Campaign Number: 15V340000 (Steering); however, a year later, the failure reoccurred. The vehicle was then taken to an independent mechanic where the rack and pinion was replaced but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 138,000.

NHTSA complaint #11753103 — an unverified report by a vehicle owner.

STEERING

No check engine, light or anything lost my electronic steering capabilities I’m going down the road

NHTSA complaint #11751442 — an unverified report by a vehicle owner.

STEERING

The power steering system, failure. completely without warning I see recalls on this model. But do not see it on the website. Nor will ford repair it

NHTSA complaint #11751292 — an unverified report by a vehicle owner.

SERVICE BRAKES

My car does not always respond when the brakes are tapped. They are soft/squishy at times and I have to push the pedal all the way to the floor for the car to stop. This issue has been occuring off & on for approximately 3 years though it's been more frequent since June of 2026. I have never seen any warning or failure light/notification any of the times this has happened. The issue was determined to be a faulty master cylinder by the service department at Colley Ford in Glendora, CA.

NHTSA complaint #11747816 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2012 Ford Fusion. The contact stated that while driving 50 MPH, the vehicle lost power steering functionality and almost caused a crash. The message "Service Power Steering Now" was displayed. The contact was able to drive to the destination. The contact stated that the vehicle had become undrivable due to the failure. The contact related the failure to NHTSA Campaign Number: 15V340000 (STEERING); however, the VIN was not included. The dealer and the manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 130,000.

NHTSA complaint #11747366 — an unverified report by a vehicle owner.

STEERING

unknown. just bought this car

NHTSA complaint #11746983 — an unverified report by a vehicle owner.

SERVICE BRAKES

Brake system. Pedal is soft and braking force to stop is reduced. Yes, at first they thought it was the brake booster, and know thinking it is the master cylinder, now they aren't even sure what it might be. Ford dealership techs. No, pedal was "squishy" when braking

NHTSA complaint #11746316 — an unverified report by a vehicle owner.

STEERING

I was just driving and I lost power steering, it was incredibly difficult to steer and it was Heavy Steering, and warnings appeared on the dash.

NHTSA complaint #11745989 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I was just driving and I lost power steering, it was incredibly difficult to steer and it was Heavy Steering, and warnings appeared on the dash.

NHTSA complaint #11745989 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I was just driving and I lost power steering, it was incredibly difficult to steer and it was Heavy Steering, and warnings appeared on the dash.

NHTSA complaint #11745989 — an unverified report by a vehicle owner.

STEERING

Se traba y se pone duro el "gobierno" junto con la cremallera electroasistida el volante no gira ni con el carro prendido, no eh echo uso de la campaña 15S18, nunca ah Sido asistido por el fabricante Ford, ni mucho menos lo eh metido a un taller de servicio independiente ni con aseguradoras y no me marco algún sensor del tablero antes de que me sucediera este problema con la "dirección asistida averiada"

NHTSA complaint #11739739 — an unverified report by a vehicle owner.

LANE DEPARTURE: ASSIST

Se traba y se pone duro el "gobierno" junto con la cremallera electroasistida el volante no gira ni con el carro prendido, no eh echo uso de la campaña 15S18, nunca ah Sido asistido por el fabricante Ford, ni mucho menos lo eh metido a un taller de servicio independiente ni con aseguradoras y no me marco algún sensor del tablero antes de que me sucediera este problema con la "dirección asistida averiada"

NHTSA complaint #11739739 — an unverified report by a vehicle owner.

LANE DEPARTURE: WARNING

Se traba y se pone duro el "gobierno" junto con la cremallera electroasistida el volante no gira ni con el carro prendido, no eh echo uso de la campaña 15S18, nunca ah Sido asistido por el fabricante Ford, ni mucho menos lo eh metido a un taller de servicio independiente ni con aseguradoras y no me marco algún sensor del tablero antes de que me sucediera este problema con la "dirección asistida averiada"

NHTSA complaint #11739739 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 40 mph, the steering wheel was hard to turn. The low tire pressure message was displayed. There was another unknown system message being displayed. The contact indicated the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The vehicle was taken to the local dealer, where it was diagnosed and determined that the power steering pump was the cause of the failure. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was unknown.

NHTSA complaint #11738704 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 40 mph, the steering wheel was hard to turn. The low tire pressure message was displayed. There was another unknown system message being displayed. The contact indicated the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The vehicle was taken to the local dealer, where it was diagnosed and determined that the power steering pump was the cause of the failure. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was unknown.

NHTSA complaint #11738704 — an unverified report by a vehicle owner.

STEERING

Our 2012 Ford Fusion had a sudden and complete loss of power steering & “Power Steering Assist Fault’ flashed on dash. The steering immediately became extremely difficult to operate, requiring both hands and excessive physical force just to turn the wheel. It felt less like driving a passenger car and more like wrestling a fully loaded dump truck with flat tires. This created a serious safety concern because the failure occurred without warning and fundamentally affected our ability to steer the vehicle safely. Fortunately, my wife was not driving at the time. The amount of force suddenly required to turn the wheel could easily be overwhelming, particularly during an emergency maneuver, in traffic, or while entering an intersection. After the failure occurred, we discovered vehicle had previously been subject to recall 15V340000 and Ford Safety Recall 15S18, both involving the exact electric Power Steering Control Module (“PSCM”) that has now failed. Under that recall, a Ford dealer performed only a software update on 10/17/2016. We opened a case with Ford, brought the vehicle to a local dealer & paid for a diagnostic inspection. Using Ford IDS equipment, dealer confirmed the condition and documented ‘NO COMMUNICATION WITH PSCM’. The dealer report quoted “Steering Gear Assembly - Rack & Pinion Assembly Replace: $3,215.81.” The diagnosis was reported directly to Ford under the active case number. Despite the recall history and confirmed failure of the same steering system covered by the prior recall, Ford denied assistance because the earlier software reprogramming had already been completed. Our position is that this is clearly a hardware failure involving the recalled electric power steering system itself — the precise condition the recall was intended to address. Ford’s own recall communications dated May 17, 2019 specifically instructed owners to retain recall documentation in the event this exact situation later occurred.

NHTSA complaint #11737842 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the power steering became inoperable with the electronic power steering warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 176,020.

NHTSA complaint #11736047 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 20 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to continue driving, but the steering wheel was difficult to turn. The vehicle was driven to an independent mechanic, where it was diagnosed, and determined that the steering gear had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure but denied assistance due the manufacturing date of the vehicle. The failure mileage was approximately 56,000.

NHTSA complaint #11729931 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

The contact owns a 2012 Ford Fusion. The contact stated that while driving at various speeds and making a left turn, the driver's side door unexpectedly opened. The contact stated that the door ajar warning light was illuminated. The failure became a recurring failure. The contact had taken the vehicle to a local dealer where it was diagnosed, and determined that the door latch needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 20V177000 (Latches/Locks/Linkages). The contact informed the dealer of the recall and was informed that the VIN was not included in the recall. The manufacturer was informed of the failure. The failure mileage was approximately 124,000.

NHTSA complaint #11730008 — an unverified report by a vehicle owner.