Owners have filed 574 complaints
about the 2018 Ford Fusion with NHTSA between 2017 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 15 of 15 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 15
Against the median year of the Ford Fusion. 50 means typical for this
model; 100 means roughly double.
Severity — 17
3.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 15
9% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
62.6%
1,000 – 9,999 miles
52.1%
10,000 – 24,999 miles
41.7%
25,000 – 49,999 miles
218.9%
50,000 – 74,999 miles
3916.6%
75,000 – 99,999 miles
7029.8%
100,000 – 149,999 miles
7732.8%
150,000+ miles
135.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2017peak 22Aug 2026
NHTSA investigations into the 2018 Ford Fusion
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
RQ22004Opened 8 Aug 2022Closed 24 Mar 2023SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Front Brake Jounce Hose Failures
On August 8, 2022, the Office of Defects Investigation (ODI) opened this investigation based on 50 Vehicle Owner Questionnaires (VOQs) alleging front brake jounce hose ruptures on model year (MY) 2013-2018 Ford Fusion and Lincoln MKZ vehicles. A ruptured front brake hose results in a brake fluid leak. As a result, the driver may experience an increase in pedal travel and a reduction in the rate of deceleration, increasing the risk of a crash. It should be noted that the subject vehicles identified fell outside the scope of NHTSA Safety Recall 20V-469, which addressed front brake hoses rupturin...
Recalls on the 2018 Ford Fusion
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
23V162000
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
Risk: A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.
18V167000
STEERING: STEERING WHEEL/HANDLE BAR
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
Risk: A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202313263,269 units in Canada
Brakes
Issue: On certain vehicles, the front brake hoses could fail and cause a progressive brake fluid leak. If this happens, the driver may experience a change in brake pedal feel and travel. This can cause reduced braking. Note: A brake fluid leak would cause the brake warning light to turn on. This recall doesn't affect models with a Hybrid engine. Vehicles repaired under Ford warranty extension program 22N02 already have updated brake hoses, and don't require this repair. Safety Risk: Reduced braking can cause an extended stopping distance and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to replace the front brake hoses.
Recall 201813059,266 units in Canada
Steering
On certain vehicles, the steering wheel bolt torque retention feature may not fully engage into the steering shaft. If the bolt loosens, the steering wheel may appear to be loose, which could affect vehicle control. If a loose bolt is left unrepaired, the steering wheel may detach from the steering column, which could result in a loss of steering control, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the steering wheel bolt with a longer bolt.
Reports where the owner recorded a crash, a fire, an injury or a death.
Windham, NHCrash1 injured
STRUCTURE:BODY
On August 10, 2026, I was driving my 2018 Ford Fusion at approximately 40 mph under normal driving conditions when, without warning, the hood unexpectedly released and flew completely backward into the windshield. The hood had been closed prior to driving and there was no warning before the failure. The hood struck the windshield with significant force, shattering it, immediately blocking my forward visibility, and sending broken glass into the passenger compartment and onto me. Because I suddenly could not see the roadway, I lost control and the vehicle left the road. Fortunately, no other vehicles or pedestrians were involved and I did not require medical treatment. This was not a hood that simply became loose or partially opened. The hood fully opened and struck the windshield. Based on what occurred, it appears the primary hood retention/latch and the secondary safety retention mechanism both failed to prevent the hood from fully opening. The exact mechanical cause requires inspection. The impact caused extensive damage to the hood and windshield and tore/deformed metal around the windshield/A-pillar/roof area. An independent eyewitness across the street personally witnessed the incident occur in real time, and I have photographs documenting the aftermath. The vehicle has approximately 156,000 miles, was in good operating condition, and remains unrepaired and unaltered following the incident so the hood latch, secondary safety catch, striker, hinges and related components can be inspected. Ford was notified immediately and opened case CXH-08862363-V8C8X7, which Ford advised was escalated to its Office of General Counsel. I am reporting this because this apparent hood-retention safety failure created an extremely dangerous situation. Had this occurred at highway speed, at a higher speed, in heavy traffic, or near pedestrians, the consequences could have been catastrophic.
NHTSA complaint #11756127 — an unverified report by a vehicle owner.
Lexington, KYCrash1 injured
AIR BAGS
Accident caused by brakes slipping and failing to stop even when pushed all the way down to the floor. Air bags failed to deploy. Resulting in a total loss estimate after accident.
NHTSA complaint #11660152 — an unverified report by a vehicle owner.
Lexington, KYCrash1 injured
SERVICE BRAKES
Accident caused by brakes slipping and failing to stop even when pushed all the way down to the floor. Air bags failed to deploy. Resulting in a total loss estimate after accident.
NHTSA complaint #11660152 — an unverified report by a vehicle owner.
at 89,000 milesHenderson, NVCrash1 injured
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
The contact owned a 2018 Ford Fusion. The contact stated that while driving at 65 MPH, the front driver side seat belt did not buckle appropriately, another vehicle driving at an unknown speed moved to the left lane, then the other vehicle changed lanes again moving in front of the contact, and the other vehicle abruptly depressed on the brakes causing the contact to rear end him. The vehicle came to a stop and merged into the shoulder. The vehicle was damaged on the front driver's and passenger's side. There were no warning lights illuminated. The driver’s and passenger’s side air bags did deploy however the seat belt did not retract the contact, causing the contact to be injured. There was no property damage. A police report was filed. The contact sustained a concussion and his eyes swelled shut. It was unknown if the other driver in the other vehicle sustained any injuries. The insurance company towed the vehicle to an impound lot and then towed it to Copart. The vehicle was deemed a total loss by the insurance company. The manufacturer was not notified of the failure. The dealer was not made aware of the failure. The failure mileage was 89,000.
NHTSA complaint #11649461 — an unverified report by a vehicle owner.
at 89,000 milesHenderson, NVCrash1 injured
SEAT BELTS:FRONT:RETRACTOR
The contact owned a 2018 Ford Fusion. The contact stated that while driving at 65 MPH, the front driver side seat belt did not buckle appropriately, another vehicle driving at an unknown speed moved to the left lane, then the other vehicle changed lanes again moving in front of the contact, and the other vehicle abruptly depressed on the brakes causing the contact to rear end him. The vehicle came to a stop and merged into the shoulder. The vehicle was damaged on the front driver's and passenger's side. There were no warning lights illuminated. The driver’s and passenger’s side air bags did deploy however the seat belt did not retract the contact, causing the contact to be injured. There was no property damage. A police report was filed. The contact sustained a concussion and his eyes swelled shut. It was unknown if the other driver in the other vehicle sustained any injuries. The insurance company towed the vehicle to an impound lot and then towed it to Copart. The vehicle was deemed a total loss by the insurance company. The manufacturer was not notified of the failure. The dealer was not made aware of the failure. The failure mileage was 89,000.
NHTSA complaint #11649461 — an unverified report by a vehicle owner.
at 119,943 milesKansas City, MOCrash
POWER TRAIN
Terrible car, after long thinking about it the last accident in this car I think was caused from the transmission literally as soon as I put it in reverse it acted as if I was accelerating and proceeded out of the parking spot a little bit, another scary thing I pulled out of a parking lot and almost got hit because the car acted as if it was in neutral when the car was in drive with on coming traffic!!!!!!!! One time it wouldn't allow me to go into drive it started rolling back wards. Transmission was replaced in 2020 and the car has been parked since late 2022 because of this issue while still peeing $6,000 on a damn car I can't even drive and seeing the same similar issue about this stupid car everywhere is ridiculous and I don't see how there's not a recall on this transmission or buy back issue or something how do you go buy a almost $30,000 car and every 60 thousand miles the transmission goes out if your able to even walk away from an accident to be able to even get the damn thing fixed
NHTSA complaint #11572850 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Oskaloosa, IA
ENGINE
The 1.5L EcoBoost motor has coolant intrusion problem on cylinder 3. The 1.5L EcoBoost motor sputters while driving causing the engine to be sluggish and not get up to speed when turning and might cause an accident on the highway due to the motor failing due to coolant intrusion design flaw in Ford Motor. Yes, Ford dealership confirmed the coolant intrusion problem on cylinder 3 and check engine light keeps coming on and off. Yes, the Ford dealership inspected the 1.5L engine in the vehicle and ran test to confirm the coolant intrusion problem on cylinder 3. There was no other warning lamps or symptoms prior to the failure/degrade of engine
NHTSA complaint #11756448 — an unverified report by a vehicle owner.
Windham, NHCrash1 injured
STRUCTURE:BODY
On August 10, 2026, I was driving my 2018 Ford Fusion at approximately 40 mph under normal driving conditions when, without warning, the hood unexpectedly released and flew completely backward into the windshield. The hood had been closed prior to driving and there was no warning before the failure. The hood struck the windshield with significant force, shattering it, immediately blocking my forward visibility, and sending broken glass into the passenger compartment and onto me. Because I suddenly could not see the roadway, I lost control and the vehicle left the road. Fortunately, no other vehicles or pedestrians were involved and I did not require medical treatment. This was not a hood that simply became loose or partially opened. The hood fully opened and struck the windshield. Based on what occurred, it appears the primary hood retention/latch and the secondary safety retention mechanism both failed to prevent the hood from fully opening. The exact mechanical cause requires inspection. The impact caused extensive damage to the hood and windshield and tore/deformed metal around the windshield/A-pillar/roof area. An independent eyewitness across the street personally witnessed the incident occur in real time, and I have photographs documenting the aftermath. The vehicle has approximately 156,000 miles, was in good operating condition, and remains unrepaired and unaltered following the incident so the hood latch, secondary safety catch, striker, hinges and related components can be inspected. Ford was notified immediately and opened case CXH-08862363-V8C8X7, which Ford advised was escalated to its Office of General Counsel. I am reporting this because this apparent hood-retention safety failure created an extremely dangerous situation. Had this occurred at highway speed, at a higher speed, in heavy traffic, or near pedestrians, the consequences could have been catastrophic.
NHTSA complaint #11756127 — an unverified report by a vehicle owner.
Germantown, MD
ENGINE
Coolant leaking into the engine.
NHTSA complaint #11754816 — an unverified report by a vehicle owner.
Oxford, CT
POWER TRAIN
There is a recall for the transmission cable bushings for years 2013-2106. The recall came out in 2022. This same bushing is used in the 2018 ford fusion model that was not fixed. The bushing on my vehicle which is a 2018 complete failed while I was driving and left me immobile until I searched for a fix and found the bushing completely gone. Ford Escape: Model years 2013–2019, Ford C-Max: Model years 2013–2018; Ford Fusion: Model years 2013–2016; Ford Transit Connect: Model years 2013–2021; Ford Edge: Model years 2015–2018. Each model besides the fusion went past the 2018 model in which the 2018 fusion should be apart of
NHTSA complaint #11754361 — an unverified report by a vehicle owner.
Spanaway, WA
POWER TRAIN
Transmission/cracked flexplate started approximately 12 months prior with vibrations getting progressively worse, complete failure needing replacement along with shift cable bushing causes vehicle to select wrong gear position when another is commanded by driver. Shrapnel from case or components could be expelled during flexplate/converter failure. Incorrect gear selection could lead to potential injury or damage from improper gear selection.
NHTSA complaint #11753612 — an unverified report by a vehicle owner.
Tazewell, TN
ENGINE AND ENGINE COOLING
See attached document for complaint.
NHTSA complaint #11752380 — an unverified report by a vehicle owner.
Saint Clair Shores, MI
ENGINE
There is a known coolant intrusion into the engine that caused the engine to suddenly only go to a certain speed while on the freeway. It could have caused an accident on the freeway by suddenly going at such a slow speed. It is now found out that the problem is known by Ford and is part of a technical service bulletin, but no recall has been issued on this known problem. The TSB associated are 19-2139, 19-2375, 20-2100. By not making this a recall, Ford is knowingly putting lives at risk with potential sudden loss of speed in these engines. It is lucky this was late at night when not many cars were on the road.
NHTSA complaint #11751875 — an unverified report by a vehicle owner.
Cincinnati, OH
UNKNOWN OR OTHER
Vehicle would not recognize car being in Park. Displayed warning messages: Shift Sys Fault Confirm Park Brake Before Exiting Vehicle. Transmission Not In Park
NHTSA complaint #11749574 — an unverified report by a vehicle owner.
Cincinnati, OH
STEERING
The electric power steering went out and locked my steering cannot figure out why and traction control light on and service light
NHTSA complaint #11748136 — an unverified report by a vehicle owner.
Cincinnati, OH
ELECTRICAL SYSTEM
The electric power steering went out and locked my steering cannot figure out why and traction control light on and service light
NHTSA complaint #11748136 — an unverified report by a vehicle owner.
Saint George, UT
ENGINE
Coolant Intrusion issue with the 1.5-litre EcoBoost. Short block was replaced by Ford Dealer then engine failed again after only 7,000-miles. Required complete new engine installed at my expense, $12,185.28.
NHTSA complaint #11747318 — an unverified report by a vehicle owner.
Mohnton, PA
ENGINE
I own a 2018 Ford Fusion EcoBoost. I purchase it in 2021 with 11K miles on it. Today it has 34K miles and the engine block developed a crack. Through my research and my Ford dealer, I've discovered this issue is a known issue with the 1.5 and 2.5 litre engines in the Fusion. My repair bill would be just about 7K.
NHTSA complaint #11746994 — an unverified report by a vehicle owner.
Pulaski, WI
ENGINE
My engine failed months ago, and my car has been sitting immobile ever since. My car stuttered while driving, and then turned off. As I started it back up and continued driving down the road, it was shaking very badly. I called my brother to come drive my car home and he pulled clear fluid out of my oil tank. The exact issue described has been put out in the new ford recall under code 26S43.
NHTSA complaint #11745411 — an unverified report by a vehicle owner.
Naples, FL
WHEELS
Ford's double-capped acorn lug nuts experienced outer cap expansion/separation during an emergency roadside tire change. A defective design known by Ford. Rendering the supplied tire iron and a separately purchased multisize tire iron ineffective at removing the lugs. The failure left the vehicle immobile on the side of a i75 in SWFL in the summer heat of June 2026. Present in the vehicle were the owner, spouse, and a [XXX] infant. They were stranded approximately 34 miles from home for nearly 3 hours, an extended period for a XXX, who quickly became visibly distressed. Standard FDOT Road Ranger assistance was unavailable, and towing services had estimated wait times exceeding 2 hours. The driver was unable to resolve the situation through any reasonable self-help measure due to the defective lugs, despite having successfully changed tires on the same vehicle previously using the same factory equipment. The defect was verbally identified during the incident by a responding AAA roadside technician. They recognized the defect as consistent with a known issue affecting Ford vehicles. No formal inspection by Ford Motor Company, law enforcement, or insurance representatives has taken place but will be pursued by the owner and available for inspection is requested. No warning lamps, dashboard alerts, or observable symptoms were present that would have indicated a lug nut defect to the owner. It only became apparent at the moment an emergency tire change was required. This is consistent with prior reported cases and litigation involving Ford. The owner was never informed of this defect during the vehicle purchase, service history, or extended warranty agreement. If known road side assistance would have been contacted, instead of self servicing the tire change which was rendered useless by a defect Ford has been aware of. Resulting in nearly 3 hours of preventable roadside exposure, emotional distress, and the endangerment of a [XXX] infant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
NHTSA complaint #11743999 — an unverified report by a vehicle owner.
Fayetteville, NC
ENGINE
I purchase this car on XXX Clinton Ford Dealership and engine need replacement Jan 2020 . I at that time did many replacement until the final diagnostic said engine replacement confirm by dealership Ford Dealership Fayetteville NC . The purge valve canister went out in 2022 and was replaced by Ed’sTire in Hope Mills Rd 11/19–11/22/2022 and now mechanic said it is in need of replacement again . Car problems started 2026 Feb and three pieces were replaced because the system was reading those code now to find out the purge valve canister needs replacement again. These hardship have cost me financial difficulties that a new car should never have had within 2 years . I believe no consumer should have to go through this.
NHTSA complaint #11743867 — an unverified report by a vehicle owner.
New Liberty, IA
ENGINE
Per mechanic, head gasket has failed due to known issue with 1.5L Ecoboost engines. Coolant is leaking into the engine. White smoke in the exhaust indicating coolant leak. Vehicle is currently availble for inspection upon request, but is destined to be sold. Driver safety as well as surrounding driver safety as risk should engine completely fail due to overheating while driving, potentially causing an accident. There is currently a class action lawsuit in the works for this issue as many other have had it. At this time vehicle has only been inspected by our local mechanic. There were no warning lamps, messages or other symptons prior ot the issue. When the issue stated, there was a "waterfall" sound in the engine compartment, which caused us to take the vehicle to the mechanic for diagnoses.
NHTSA complaint #11743917 — an unverified report by a vehicle owner.
Fayetteville, NC
FUEL/PROPULSION SYSTEM
I purchase this car on XXX Clinton Ford Dealership and engine need replacement Jan 2020 . I at that time did many replacement until the final diagnostic said engine replacement confirm by dealership Ford Dealership Fayetteville NC . The purge valve canister went out in 2022 and was replaced by Ed’sTire in Hope Mills Rd 11/19–11/22/2022 and now mechanic said it is in need of replacement again . Car problems started 2026 Feb and three pieces were replaced because the system was reading those code now to find out the purge valve canister needs replacement again. These hardship have cost me financial difficulties that a new car should never have had within 2 years . I believe no consumer should have to go through this.
NHTSA complaint #11743867 — an unverified report by a vehicle owner.
Glendale, AZ
ENGINE
My 1.5L EcoBoost engine experienced coolant intrusion into the cylinders, a known and documented defect associated with this engine family across multiple Ford model years. Prior to the failure, the vehicle displayed symptoms consistent with internal coolant loss, including white exhaust smoke, coolant level dropping without visible external leaks, and rough running. No external coolant leak was ever identified. The vehicle was subsequently diagnosed by an independent service center, which confirmed coolant intrusion into the engine internals consistent with a head gasket or coolant jacket failure. The component is available for inspection upon request. The failure rendered the vehicle completely undriveable. The vehicle has been out of service for approximately 12 months and has not been driven since the failure occurred. The repair was quoted at approximately $12,000 for a full engine replacement, exceeding the current market value of the vehicle. Safety was put at risk due to sudden loss of engine performance and drivability while the vehicle was in use on public roads. Coolant intrusion can cause hydrolock, catastrophic engine seizure, and sudden loss of power, all of which create risk of collision, particularly at highway speeds. This failure is consistent with a well-documented defect in the 1.5L EcoBoost engine design, which has been the subject of technical service bulletins and consumer complaints regarding coolant entering the combustion chamber. The failure occurred with no prior accident, overheating event, or owner-caused damage.
NHTSA complaint #11739917 — an unverified report by a vehicle owner.
Huntingdon, PA
ENGINE
On [XXX], I drove my 2018 Ford Fusion Titanium AWD to a doctor 37 miles away through rural PA. The car was a reliable workhorse, needing only regular shop visits, and had 108K miles by this date. Midway through the [XXX] drive , a red warning square popped up on the dash to tell me that the engine was overheating, and a pink warning square said the car would lessen electrical draw so that it could cool the engine. Both alerts disappeared quickly. There was no unusual sound or smell before the alerts nor the rest of the drive. I also had no prior dash alerts, only ?3 misfires months apart I now know were symptoms of [XXX]. During down time before/after the doctor, I Googled the error messages and read my owner's manual. I restarted the car w/o incident after it had sat for 45 minutes. Six miles into my way home, the same red square popped up, though no second alert did. I pulled over at a clearing 3 miles later. I sat by the side of the road without cell service for 45 minutes. I had no coolant or water with me. I was unable to remove the coolant lid after the wait, nor could I see if there were coolant in the reservoir. I needed to move the car because of having no cell service. After a total of 75 minutes, I restarted the vehicle and moved 2 miles up the road. A red triangle icon appeared and stayed on. I called my dealer, described what happened, and they told me to tow the car the 21 miles to them. My dealer found no issue beyond a cracked spark plug on cylinder 3 that they replaced 4K miles earlier. Not satisfied, my B-I-L and I researched the incident and found the 2.0L EcoBoost coolant intrusion issue. I had the car tested according to Ford's TSB #19-2346 at a separate dealer; they duplicated the intrusion in cylinder 3, and we had a diagnosis. I was fortunate that the car didn't stop mid-traffic, didn't catch fire, and I was stranded in daylight in an Amish community. The other side of that coin is grim. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11739937 — an unverified report by a vehicle owner.
Los Altos Hills, CA
ENGINE
Formal Complaint – 2018 Ford Fusion 1.5L EcoBoost – Engine Block Defect Statement of Issue:I am writing to report a premature engine failure on my 2018 Ford Fusion 1.5L. The vehicle is exhibiting all symptoms of the well-documented "coolant intrusion" defect described in Ford Technical Service Bulletin (TSB) 22-2222. Despite following all recommended maintenance intervals, the engine block has failed, allowing coolant to enter the combustion chamber.Observations:Confirmed coolant loss with no external leakage found via pressure test.Significant white smoke and rough idle upon cold start. Desired Resolution: Since this is a known manufacturing defect involving the engine block's cooling channels—and not a result of wear and tear—I am requesting a "Goodwill Repair" for a long-block replacement. The current TSB denial based on [8 years] is unacceptable for a known catastrophic design flaw that compromises vehicle safety.
NHTSA complaint #11739403 — an unverified report by a vehicle owner.
Los Altos Hills, CA
FUEL/PROPULSION SYSTEM
Formal Complaint – 2018 Ford Fusion 1.5L EcoBoost – Engine Block Defect Statement of Issue:I am writing to report a premature engine failure on my 2018 Ford Fusion 1.5L. The vehicle is exhibiting all symptoms of the well-documented "coolant intrusion" defect described in Ford Technical Service Bulletin (TSB) 22-2222. Despite following all recommended maintenance intervals, the engine block has failed, allowing coolant to enter the combustion chamber.Observations:Confirmed coolant loss with no external leakage found via pressure test.Significant white smoke and rough idle upon cold start. Desired Resolution: Since this is a known manufacturing defect involving the engine block's cooling channels—and not a result of wear and tear—I am requesting a "Goodwill Repair" for a long-block replacement. The current TSB denial based on [8 years] is unacceptable for a known catastrophic design flaw that compromises vehicle safety.
NHTSA complaint #11739403 — an unverified report by a vehicle owner.
Eupora, MS
ENGINE
Coolant intrusion
NHTSA complaint #11738902 — an unverified report by a vehicle owner.
Chicago, IL
POWER TRAIN:AUTOMATIC TRANSMISSION
When I put my car in drive it locked up on me & kept reversing all the way back to park the car would not move no matter what gear it was in it was just locked. I had to have the car towed.
NHTSA complaint #11735689 — an unverified report by a vehicle owner.
Chattanooga, TN
ENGINE
The engine has coolant intrusion. It is available upon inspection. Safety at risk due to side effects from the intrusion such as: engine overheating, misfiring, massive coolant loss that could cause an engine fire. The problem was diagnosed as a blown head gasket, but there is evidence of coolant loss and corrosion of spark plugs etc from coolant in engine. Has not been inspected by insurance or police. Symptoms started March 2026; check engine light on showing code P0303 (misfire in cylinder 3) and code for over temperature sensor. It occasionally ran hot, rough start up, misfiring, coolant loss (without external leaks), trouble accelerating, eventual service wrench light, and sometimes flashing engine light when it misfired bad.
NHTSA complaint #11735333 — an unverified report by a vehicle owner.
at 157,017 milesMemphis, TN
STEERING
The contact owns a 2018 Ford Fusion. The contact stated that while driving approximately 55 MPH on the highway, the vehicle experienced a sudden loss of power steering functionality while decelerating. The vehicle jerked, and a driver assistance system warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 157,017.
NHTSA complaint #11734771 — an unverified report by a vehicle owner.