312 of the
1,766 complaints about the 2015 Jeep Grand Cherokee are about the
seats — 18% of everything
reported for this model year.
Half of the failures with a mileage on record happened before
69,000 miles.
While driving home from the gym with my daughter in the front passenger seat, we were traveling less than 40 mph under normal driving conditions. Without warning, I heard a very loud pop/bang from inside the vehicle. We had not been in a collision, had not hit anything, and nothing had struck the vehicle. I immediately looked over and saw my daughter crouched down in her seat holding her neck. At first, I could not determine what had happened. I then noticed that the front passenger-side Active Head Restraint (AHR)/headrest had suddenly deployed or come apart and had struck her from behind. There were no warning lights, messages, alerts, or other symptoms before the incident. The deployment occurred suddenly and without any apparent event that should have triggered this safety system. My daughter sustained a neck injury as a result of the unexpected deployment and was taken to the hospital for evaluation and treatment. She was placed in a neck brace and had to wear it for approximately one week. The incident also created a safety risk while the vehicle was in motion. The sudden loud bang and my daughter's immediate reaction occurred without warning while I was driving, and I initially did not know whether something had struck the vehicle or what had happened to her. The vehicle has not yet been inspected by a dealer, manufacturer, insurance representative, police, or independent service center. The passenger-side Active Head Restraint remains in its deployed/dislodged condition.
NHTSA complaint #11757682 — an unverified report by a vehicle owner.
at 120,500 milesWoodinville, WA
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
The contact owns a 2015 Jeep Grand Cherokee. The contact stated that while driving approximately 25 MPH to a park with her children inside the vehicle, the head restraint suddenly exploded without warning or impact. The head restraint was protruding approximately three to four inches. The contact sustained nerve issues involving the arm but had not sought medical attention. The contact consulted with an attorney. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 120,500.
NHTSA complaint #11757684 — an unverified report by a vehicle owner.
Fond du Lac, WI
SEATS
part of the headrest assembly fractured suddenly causing the headrest to burst while I was sitting in the passenger seat. i was immediately sore from my shoulders up. there were no warning lights or recalls on my vehicle at the time.
NHTSA complaint #11755661 — an unverified report by a vehicle owner.
at 76,000 milesLoxahatchee, FL1 injured
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
The contact owns a 2015 Jeep Grand Cherokee. The contact stated that while driving approximately 40 MPH, there was a loud bang coming from behind the vehicle, and the contact was thrust forward. The contact looked around but saw no cause for the sound or for being thrust forward. The contact was able to drive back to the residence. After arriving at the residence, the contact became aware that the front driver's side seat headrest had exploded. The contact’s neck and head were hurt from the impact and from being thrust forward. The contact sought medical attention for whiplash. The vehicle was taken to the dealer and was diagnosed with a deployed headrest. The contact was informed that the headrest needed to be replaced. The dealer suggested replacing both front seat headrests. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 76,000.
NHTSA complaint #11753452 — an unverified report by a vehicle owner.
Brooklyn Park, MD
SEATS
I got into the car and noticed the front passenger head rest was not seated correctly and had extended forward. As soon as I moved the seat forward to see why, it sprung forward.
NHTSA complaint #11750761 — an unverified report by a vehicle owner.
Metairie, LA
SEATS
The passenger headrest exploded and whacked me in the head after we went over a little bump in the road.
NHTSA complaint #11750665 — an unverified report by a vehicle owner.
Metairie, LA
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
The passenger headrest exploded and whacked me in the head after we went over a little bump in the road.
NHTSA complaint #11750665 — an unverified report by a vehicle owner.
Houston, TX
SEATS
the clips in my active headrest broke and the headrest deployed while I was riding in the passenger seat.
NHTSA complaint #11747073 — an unverified report by a vehicle owner.
Winter Garden, FL
SEATS
The active headrest on the driver’s side deployed unexpectedly. No accident or rear end accident happened. The car was in park and it just went off.
NHTSA complaint #11741931 — an unverified report by a vehicle owner.
Huntvsille, TX
SEATS
While driving, the drivers side head rest exploded and pushed my body/neck forward. There was no accident that prompted this and was slowing down to a stop light.
NHTSA complaint #11740125 — an unverified report by a vehicle owner.
Wildwood, MO
SEATS
My husband was driving on a highway going 70 MPH and the drivers headrest exploded and lunged him forward
NHTSA complaint #11736991 — an unverified report by a vehicle owner.
at 110,000 milesPhenix City, AL
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
The contact owns a 2015 Jeep Grand Cherokee. The contact stated that while driving approximately 3 MPH and entering the garage, the passenger’s side active headrest inadvertently deployed. The contact stated that there were no warning lights illuminated; just a loud bang washeard when the headrest deployed. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 110,000.
NHTSA complaint #11720643 — an unverified report by a vehicle owner.
Arlington Heights, IL
SEATS
2/24/26 around 10:45am CST the passenger seat headrest exploded/combusted with a very loud popping noise while driving the car 40 mph on a smooth surface road. Luckily nobody was sitting in the passenger seat. I don't want to drive my car as now I'm afraid this will happen to the driver's seat headrest.
NHTSA complaint #11720203 — an unverified report by a vehicle owner.
Charleston, SC1 injured
SEATS
The drivers headrest randomly “popped” from the fixture smacking me in the back of the head hard enough to almost cause a collision
NHTSA complaint #11719719 — an unverified report by a vehicle owner.
at 60,000 milesFoley, AL
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
The contact owns a 2015 Jeep Grand Cherokee. The contact stated that while driving approximately 20 MPH, the front passenger’s side head restraint erroneously deployed. There was a loud popping sound during the failure. The vehicle was taken to the local mechanic, who replaced the head restraint. The cause of the failure was not yet determined. The local dealer and the manufacturer were not made aware of the failure. The failure mileage was 60,000.
NHTSA complaint #11714399 — an unverified report by a vehicle owner.
Inverness, FL
SEATS
front driver and passenger seat belts do not retract, front passenger headrest clips failed and will not snap back in place
NHTSA complaint #11708263 — an unverified report by a vehicle owner.
Tomball, TX
SEATS
The active head restraint deployed September 30, 2025 overnight while my Jeep was parked on my driveway. The restraint has not been repaired and is available for inspection. If this head restraint would have deployed while driving with my wife I believe it would have injured her. I believe there is a defective part in the head restraint. I brought it to the dealer where I purchased the Jeep. I was told there was and extended warranty but it ended Sept. 25, 2024 so my active head restraint is not covered. I was never notified by FCA or the dealer about this extended warranty. There was no warning that addressed this issue. I spoke with numerous Customer Service Specialists about my situation and they said I would have to purchase a replacement head restraint.
NHTSA complaint #11703817 — an unverified report by a vehicle owner.
Cincinnati, OH
SEATS
While i was driving my both of my headrests popped open out of nowhere and i freaked out and pulled to the side of the road. Not sure how this happened but i didn't get in any accident thankfully. Not sure what caused it i didn't hit any bumps in the road or anything.
NHTSA complaint #11697464 — an unverified report by a vehicle owner.
Mercedes, TX
SEATS
The adaptive headrest popped open without warning or accident. Wife was just trying to adjust headrest. Now can not pop back into place.
NHTSA complaint #11693678 — an unverified report by a vehicle owner.
at 95,000 milesHouston, TX
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
The contact’s mother owns a 2015 Jeep Grand Cherokee. The contact stated that while his mother was driving at an undisclosed speed, the driver’s side head restraint exploded. The driver had not sustained any injuries. The vehicle was taken to a dealer where it was determined that the head restraint needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 95,000.
NHTSA complaint #11689446 — an unverified report by a vehicle owner.
New Philadelphia, OH
SEATS
Driver side headrest deployed while driving almost causing an accident. Passenger headrest deployed 3-weeks later while parked with engine off. Both incidents left a metal pin behind.
NHTSA complaint #11689504 — an unverified report by a vehicle owner.
Tucson, AZ
SEATS
On 10 September 2025 I was driving home from work in heavy traffic. I was stopped at a red light when I heard a loud explosion and the headrest on the driver seat slammed into the back of my head hard. I thought I had been rear ended but there was no other car close to me. Luckily the vehicle was not in motion when this happened. When I was able to pull to a safe location I saw that the headrest was split wide open. Contacted dealership who said to contact Chrysler who was contacted but has never followed up with a call back.
NHTSA complaint #11687733 — an unverified report by a vehicle owner.
Nicholson, PA
SEATS
The driver's side head rest popped out and hit me in the back of the head, luckily I was not driving at the time, was stopped at a flagger for road work. It hit so hard that I thought the person behind me rear ended me, however when I looked in mirror that vehicle was nowhere near me. I have not had it to a dealer, nor called them yet, was checking first for a recall that maybe I missed. No warning lights at all, no noise ahead of time.
NHTSA complaint #11687444 — an unverified report by a vehicle owner.
Miramar, FL
SEATS
Last year while driving my 2015 Jeep Grand Cherokee, the headrest collision system went off for no reason, hitting me in the back of the head. Luckily I did not lose control of the vehicle and there was no collision or injury to myself. It was very scary, but I maintained control of the vehicle. I went to my local Jeep dealer Pembroke Pines Jeep Auto Nation at 13601Pines Blvd Suite A Pembroke Pines, FL 33027. They told me it was a known issue and the service person made an appointment for me later that week , at which they replaced the headrest at no cost to me under a recall service bulletin issued by Jeep/Stellantis. The same thing happened last week while driving, when the passenger side headrest activated for NO reason, this time striking my wife in the head. I went back to the same dealership. They told me that this headrest is no longer covered under the warranty which has now expired in April of 2025. and would cost $800 to repair. They told me to call Stellantis and see if they would cover the repair. I went home and called Stellantis, whose customer service agent advised me that he was going to escalate my concern to his supervisor. I got a call today and they told me that my car is not covered by any warranty and that I would be responsible for the repair. My car VIN number does not fall under the recall which has expired. He also told me that Stellantis is not responsible for the repair and he should ask the dealer to see if they would possibly split the cost of the repair with me. This could of been a very serious situation, had I lost control of the vehicle as a driver. I looked further online and in Jeep owners club forums and this seems to be a common problem with Jeeps and Dodge Durangos, both owned by Stellantis. This is a clear and dangerous safety issue!
NHTSA complaint #11685289 — an unverified report by a vehicle owner.
Union City, TN1 injured
SEATS
While driving down the highway the passenger seat headrest airbag deployed. Causing it to hit the back of my head with no warning. There were not any lights on or anything.
NHTSA complaint #11683555 — an unverified report by a vehicle owner.
Miami, FL
SEATS
I am writing to report a malfunction in the active headrest deployment system in my vehicle. While driving, the passenger’s side headrest unexpectedly deployed without any indication of an impact or collision, posing a potential safety risk. My wife was in the seat at the time when the unit deployed jarring her head forward. Upon my investigation, it appears that the one of the failure points were internal plastic components. This malfunction caused the headrest to deploy randomly, despite there being no collision or triggering event. While the headrest is designed to deploy during a rear-end collision to prevent neck injuries, its unintended activation while driving can cause discomfort, distraction, or even injury, especially if it occurs suddenly. If this happened during an emergency maneuver or while driving at high speed, it could also interfere with my ability to maintain control of the vehicle. At this time, the vehicle has not been inspected by the manufacturer, police, or insurance representatives. However, I believe a more thorough inspection of the headrest system, and perhaps the vehicle’s onboard diagnostics, could provide insight into the issue. There were no warning lamps, error messages, or other noticeable symptoms prior to the headrest deploying unexpectedly. This malfunction occurred without any prior indication of a problem. The deployment was a sudden event while driving, with no alerts or warnings beforehand.
NHTSA complaint #11678102 — an unverified report by a vehicle owner.
Bellflower, CA
SEATS
Carbon fiber door panels completely fell off and driver rear end safety headrest went off while driving and gave me a minor blast on back off my head… I was not in a rear end collision!
NHTSA complaint #11677923 — an unverified report by a vehicle owner.
Spokane Valley, WA
SEATS
While driving the passenger side active headrest made a popping sound and the headrest sprung forward.
NHTSA complaint #11674810 — an unverified report by a vehicle owner.
Benton, KS
SEATS
I was driving down the highway to work and all of a sudden my headrest came apart and hit my head. I was able to get pulled over but was stunned with what had just happened. I called a dealership to get the part fixed and they want 750 dollars. I do not have that kind of money and now am driving my jeep with the headrest messed up. I do not know what to do to get this fixed as it is a safety issue as I am driving down the road. Any help would be greatly appreciated.
NHTSA complaint #11674858 — an unverified report by a vehicle owner.
Orlando, FL
SEATS
Front passenger active headrest deployed for no reason. No accident or damage. It deployed all by itself for no reason.
NHTSA complaint #11673891 — an unverified report by a vehicle owner.