1997 Toyota Corolla problems

UNKNOWN OR OTHER

DRIVER SIDE DOOR WILL NOT OPEN MANUALLY TO REPAIR MALFUNCTIONING ELECTRIC DOOR LOCK

NHTSA complaint #11173000 — an unverified report by a vehicle owner.

AIR BAGS

I WAS SCANNING MY VEHICLE WITH AN OBD2 SCANNER AND LEARNED THAT MY CAR, WHICH I'M NOT THE ORIGINAL OWNER, HAS HAD RECALLS AND I DON'T KNOW IF THEY'VE BEEN RECTIFIED. ATTACHED ARE SCREENSHOTS OF THE RECALL INFORMATION. THE FIRST ONE HAS ME MORE WORRIED THAN THE OTHER....INADVERTENT DEPLOYMENT OF AIRBAGS. PLEASE READ THE DETAILS. THE SECOND (FRONT STRUTS) IS SOMETHING THAT ALSO CONCERNS ME BECAUSE OF ITS LACK OF SHOCK ABSORPTION. MY VIN# [XXX] (ALSO ON THE SCREENSHOTS) IF YOU HAVE ANY INFORMATION ON THE HISTORY OF MY VEHICLE AND WHETHER OR NOT THESE ISSUES HAVE BEEN RESOLVED, PLEASE SHARE IT WITH ME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11097722 — an unverified report by a vehicle owner.

SUSPENSION

I WAS SCANNING MY VEHICLE WITH AN OBD2 SCANNER AND LEARNED THAT MY CAR, WHICH I'M NOT THE ORIGINAL OWNER, HAS HAD RECALLS AND I DON'T KNOW IF THEY'VE BEEN RECTIFIED. ATTACHED ARE SCREENSHOTS OF THE RECALL INFORMATION. THE FIRST ONE HAS ME MORE WORRIED THAN THE OTHER....INADVERTENT DEPLOYMENT OF AIRBAGS. PLEASE READ THE DETAILS. THE SECOND (FRONT STRUTS) IS SOMETHING THAT ALSO CONCERNS ME BECAUSE OF ITS LACK OF SHOCK ABSORPTION. MY VIN# [XXX] (ALSO ON THE SCREENSHOTS) IF YOU HAVE ANY INFORMATION ON THE HISTORY OF MY VEHICLE AND WHETHER OR NOT THESE ISSUES HAVE BEEN RESOLVED, PLEASE SHARE IT WITH ME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11097722 — an unverified report by a vehicle owner.

WHEELS

ON MARCH 23, 2013, I PURCHASED FOUR NEW COOPER TIRES FROM SEARS AUTO CENTER IN LIMA, OHIO, FOR MY 1997 TOYOTA COROLLA. THE SPECIFIC TIRES INSTALLED WERE COOPER RESPONSE TOURING M+S 175/65R14, DOT U9EX LRC 4110, A08. SINCE THAT TIME, I HAVE DRIVEN LESS THAN 30,000 MILES ON THE TIRES AND MAINTAINED APPROPRIATE TIRE PRESSURE, MAINTENANCE, AND ALIGNMENT. IN THE EARLY HOURS OF THIS MORNING (OCTOBER 30, 2016), THE TIRE TREAD OF THE FRONT PASSENGER SIDE TIRE SEPARATED FROM THE TIRE, CAUSING CATASTROPHIC FAILURE AND FORCING ME OFF THE ROAD. THIS INCIDENT OCCURRED ON I-475 NORTH TRAVELLING AT THE SPEED LIMIT, IN THE MIDDLE LANE. IT TOOK LESS THAN TEN SECONDS TO COAST TO A STOP. WE WERE VERY FORTUNATE THAT THERE WERE NO OTHER VEHICLES TO IMPACT OURS BEFORE REACHING THE SHOULDER. ADDITIONAL DAMAGE FROM THIS TREAD SEPARATION INCLUDE DESTROYING THE WHEEL WELL, BODY DAMAGE, LAUNCHING THE HEADLIGHT APART FROM THE CAR, SPONTANEOUS RELEASE OF WIPER FLUID ON TO THE WINDOW AS THE TREAD RIPPED OFF FROM THE TIRE, AND OTHER SIGNIFICANT DAMAGE. THE VEHICLE HAS BEEN TOWED TO TOYONLY, 1050 VIJAY DRIVE, CHAMBLEE, GA 30341. WHILE THE TREAD SEPARATION HAS CAUSED THE AFOREMENTIONED SIGNIFICANT DAMAGE, THE VEHICLE IS OTHERWISE MECHANICALLY SOUND. I AM WAITING FOR A RESPONSE FROM COOPER TIRES.

NHTSA complaint #10920129 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

ON MARCH 23, 2013, I PURCHASED FOUR NEW COOPER TIRES FROM SEARS AUTO CENTER IN LIMA, OHIO, FOR MY 1997 TOYOTA COROLLA. THE SPECIFIC TIRES INSTALLED WERE COOPER RESPONSE TOURING M+S 175/65R14, DOT U9EX LRC 4110, A08. SINCE THAT TIME, I HAVE DRIVEN LESS THAN 30,000 MILES ON THE TIRES AND MAINTAINED APPROPRIATE TIRE PRESSURE, MAINTENANCE, AND ALIGNMENT. IN THE EARLY HOURS OF THIS MORNING (OCTOBER 30, 2016), THE TIRE TREAD OF THE FRONT PASSENGER SIDE TIRE SEPARATED FROM THE TIRE, CAUSING CATASTROPHIC FAILURE AND FORCING ME OFF THE ROAD. THIS INCIDENT OCCURRED ON I-475 NORTH TRAVELLING AT THE SPEED LIMIT, IN THE MIDDLE LANE. IT TOOK LESS THAN TEN SECONDS TO COAST TO A STOP. WE WERE VERY FORTUNATE THAT THERE WERE NO OTHER VEHICLES TO IMPACT OURS BEFORE REACHING THE SHOULDER. ADDITIONAL DAMAGE FROM THIS TREAD SEPARATION INCLUDE DESTROYING THE WHEEL WELL, BODY DAMAGE, LAUNCHING THE HEADLIGHT APART FROM THE CAR, SPONTANEOUS RELEASE OF WIPER FLUID ON TO THE WINDOW AS THE TREAD RIPPED OFF FROM THE TIRE, AND OTHER SIGNIFICANT DAMAGE. THE VEHICLE HAS BEEN TOWED TO TOYONLY, 1050 VIJAY DRIVE, CHAMBLEE, GA 30341. WHILE THE TREAD SEPARATION HAS CAUSED THE AFOREMENTIONED SIGNIFICANT DAMAGE, THE VEHICLE IS OTHERWISE MECHANICALLY SOUND. I AM WAITING FOR A RESPONSE FROM COOPER TIRES.

NHTSA complaint #10920129 — an unverified report by a vehicle owner.

STRUCTURE:BODY

ON MARCH 23, 2013, I PURCHASED FOUR NEW COOPER TIRES FROM SEARS AUTO CENTER IN LIMA, OHIO, FOR MY 1997 TOYOTA COROLLA. THE SPECIFIC TIRES INSTALLED WERE COOPER RESPONSE TOURING M+S 175/65R14, DOT U9EX LRC 4110, A08. SINCE THAT TIME, I HAVE DRIVEN LESS THAN 30,000 MILES ON THE TIRES AND MAINTAINED APPROPRIATE TIRE PRESSURE, MAINTENANCE, AND ALIGNMENT. IN THE EARLY HOURS OF THIS MORNING (OCTOBER 30, 2016), THE TIRE TREAD OF THE FRONT PASSENGER SIDE TIRE SEPARATED FROM THE TIRE, CAUSING CATASTROPHIC FAILURE AND FORCING ME OFF THE ROAD. THIS INCIDENT OCCURRED ON I-475 NORTH TRAVELLING AT THE SPEED LIMIT, IN THE MIDDLE LANE. IT TOOK LESS THAN TEN SECONDS TO COAST TO A STOP. WE WERE VERY FORTUNATE THAT THERE WERE NO OTHER VEHICLES TO IMPACT OURS BEFORE REACHING THE SHOULDER. ADDITIONAL DAMAGE FROM THIS TREAD SEPARATION INCLUDE DESTROYING THE WHEEL WELL, BODY DAMAGE, LAUNCHING THE HEADLIGHT APART FROM THE CAR, SPONTANEOUS RELEASE OF WIPER FLUID ON TO THE WINDOW AS THE TREAD RIPPED OFF FROM THE TIRE, AND OTHER SIGNIFICANT DAMAGE. THE VEHICLE HAS BEEN TOWED TO TOYONLY, 1050 VIJAY DRIVE, CHAMBLEE, GA 30341. WHILE THE TREAD SEPARATION HAS CAUSED THE AFOREMENTIONED SIGNIFICANT DAMAGE, THE VEHICLE IS OTHERWISE MECHANICALLY SOUND. I AM WAITING FOR A RESPONSE FROM COOPER TIRES.

NHTSA complaint #10920129 — an unverified report by a vehicle owner.

STEERING

TL* THE CONTACT OWNS A 1997 TOYOTA COROLLA EQUIPPED WITH COOPER RESPONSE TOURING TIRES, SIZE: 175/65/R14. WHILE DRIVING 65 MPH, THE CONTACT FELT A VIBRATION COMING FROM THE STEERING WHEEL AND THE FRONT PASSENGER SIDE TIRE BLEW OUT. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. THE CONTACT PREVIOUSLY NOTICED BUBBLES ON THE SIDEWALLS OF BOTH FRONT AND REAR PASSENGER TIRES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 93,000 AND THE TIRE FAILURE MILEAGE WAS 6,000.

NHTSA complaint #10777736 — an unverified report by a vehicle owner.

SEAT BELTS

MY DRIVER SIDE SEAT BELT WILL NOT COME OUT. I HAVE ACTUALLY HAD THIS PROBLEM BEFORE AND GOT IT FIXED ABOUT A YEAR OR TWO AGO. I PAID OVER 300.00 FOR A MECHANIC SHOP TO COMPLETELY REPLACE MY SEAT BELT. NOW IT IS HAPPENING AGAIN TO THE REPLACEMENT SEAT BELT. I REALLY DON'T THINK IT SHOULD BE MY RESPONSIBILITY TO GET THIS SEAT BELT THING FIXED EVERY TWO YEARS BECAUSE OF FAULTY/DEFECTIVE ENGINEERING.

NHTSA complaint #10731876 — an unverified report by a vehicle owner.

AIR BAGS

TOYOTA COROLLA DX 1997 THE CAR WAS SOLD BY THE MANUFACTURER IN ST LOUIS MISSOURI WHILE I WAS IN LAW SCHOOL. THE CAR HAS BEEN NOW IN FLORIDA FOR THE LAST TEN YEAR IN A WARM, EXTREMELY HUMID CLIMATE. THE MANUFACTURER HAS ADMITTED TO A PROBLEM WITH THE AIRBAGS. APPARENTLY IN HUMID CLIMATES. NOW DOES IT NOT MAKE SENSE TO CHECK OUT THE AIRBAG IF THE CAR HAS BEEN IN A HUMID CLIMATE .REGARDLESS WHERE THE CAR WAS SOLD ? OR IS THE CAR SAFE BECAUSE IT WAS SOLD SOMEWHERE ELSE AND IF THE CAR IS THEN DRIVEN IN A HUMID CLIMATE THE AIRBAG WILL WORK SINCE THE DEALERSHIP WAS IN A COLD WEATHER CLIMATE?

NHTSA complaint #10606820 — an unverified report by a vehicle owner.

SERVICE BRAKES

DRIVING ON SH 79 FREEHOLD BORO WHEN ATTEMPTING TO APPLY BRAKES TO STOP AND MAKE TURN PEDAL WENT ALL THE WAY TO THE FLOOR WITHOUT ANY WARNING AND FAILED TO STOP VEHICLE. PUMPED BRAKE PEDAL IN PANIC MANY TIMES WHEN VEHICLE PULLED SHARP RIGHT AND WHILE STILL PUMPING BRAKE PEDAL AND ATTEMPT TO USE HAND BRAKE VEHICLE FINALLY SLOWED AND STOPPED. MECHANIC ADVISED BOTH BRAKE LINES IN REAR WERE NOT COATED AND FLUID LEAKED FROM PLACE WHERE CLAMP STRAPPED THEM TO UNDERCARRIAGE OF CAR. LINES WERE RUSTED AS NO PROTECTION COATING WAS APPLIED DURING MANUFACTURING. THEY HAVE REPLACED MANY COROLLA BRAKE LINES DUE TO THIS LACK OF COATING. NO WARNING PRIOR TO BRAKES FAILING. NO TRAFFIC CLOSE WHILE BRAKING JUST TOTALLY SCARED TO DEATH.

NHTSA complaint #10525946 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 1997 TOYOTA COROLLA. THE CONTACT STATED THAT THE VEHICLE WAS DRIVEN OVER A SPEED BUMP AND THE FUEL TANK IMPACTED THE PAVEMENT AND CRACKED. AS A RESULT, THERE WAS A FUEL LEAKAGE. THE CONTACT STATED THAT THE PROBLEM WAS THAT THE FUEL TANK DID NOT HAVE A PROTECTIVE SHIELD INSTALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 319,695.

NHTSA complaint #10422918 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

THE DESIGN OF THE 1997 TOYOTA COROLLA SEDAN HAS A QUESTIONABLE SAFETY DESIGN IN THE FUEL FILLER TUBE. PART # 77201 OR 7720112500 APPEARS TO BE MAKE OF SIMPLE TUBE STEEL. THIS PART IS NOT PROTECTED FROM ROAD HAZARDS, CHEMICALS, OR ROAD SPRAY THAT CONTAIN SALT SUCH AS NORTHERN U.S., OR SEASIDE ARES. SINCE THIS GAS TUBE IS UNPROTECTED CLAMPS 77216A & 77218A HOLD THIS CORROSIVE CAUSING ACCELERATED RUSTING, AND PREMATURE FAILURE OF THE STEEL PIPE. THIS CAUSES A FUEL LEAK THAT RESULT IN A LARGE DISCHARGE OF FUEL WHILE FUELING, AND A LARGE DISCHARGE OF FUEL WHILE DRIVING . WHILE DRIVING, PRESSURE PULLS FUEL FROM THE MOUNTED TANK, TO THE LOWEST POINT BEHIND THE TANK WHICH IS RIGHT WHERE THE ABOVE LISTED CLAMPS TO THE BODY. THIS COULD SEE AN ESTIMATED DISCHARGE OF 25% OF THE TANK 13G CAPACITY OR 3.25G OF FUEL DISCHARGED PER TANK. ADDITIONALLY, WITH THE WEAKENING OF THE FUEL TUBE, AT THE OUTSIDE EDGE OF THE UNI-BODY FRAME. A DRIVER SIDE REAR COLLISION COULD SHEAR OFF THE FUEL TUBE FROM THE BODY-FRAME CLAMPS, AND IGNITING FROM THE SPARKS GENERATED BY THE CHEAP STEEL TUBE.THEN FED DIRECTLY FROM THE BACK FLUSH OF FUEL FROM THE TANK.

NHTSA complaint #10421535 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

1997 TOYOTA COROLLA. CONSUMER WRITES TO INQUIRE ABOUT A RECALL ON THE GAS PEDAL ENTRAPMENT *TGW

NHTSA complaint #10389229 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I HAVE A TOYOTA COROLLA 1997 AND THE GAS TANK IS PRESSED SO THAT IT BREAKS. I HAVE ALREADY CHANGED TWO TANKS IN LESS THAN SIX MONTHS AND TELL ME THAT LOOKS LIKE A FACTORY FLAW WANTED TO KNOW IF I COULD HELP?

NHTSA complaint #10384230 — an unverified report by a vehicle owner.

EQUIPMENT

I HAVE A TOYOTA COROLLA 1997 AND THE GAS TANK IS PRESSED SO THAT IT BREAKS. I HAVE ALREADY CHANGED TWO TANKS IN LESS THAN SIX MONTHS AND TELL ME THAT LOOKS LIKE A FACTORY FLAW WANTED TO KNOW IF I COULD HELP?

NHTSA complaint #10384230 — an unverified report by a vehicle owner.

SEAT BELTS

TL*THE CONTACT OWNS A 1997 TOYOTA COROLLA. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT STATED THAT THE SEAT BELT WOULD NOT RELEASE. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND TRIED TO UNLATCH THE SEAT BELT WHILE THE VEHICLE WAS STOPPED BUT IT STILL WOULD NOT RELEASE. SHE HAD TO USE A SCREWDRIVER TO OPEN THE SEAT BELT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS SUGGESTED THAT THE RELEASE BUTTON BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AND THE VIN WAS UNAVAILABLE WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE CURRENT MILEAGE WAS APPROXIMATELY 99,000.

NHTSA complaint #10324546 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

I EXPERIENCE SUDDEN ACCELERATION ON MY TOYOTA COROLLA 1997 WHEN THE CRUISE CONTROL IS ACTIVE AND SET ON SPEED. IT HAPPENED ABOUT 4 TIMES OVERT HE LAST THREE YEARS AND I CAN CORRECT IT BY TURNING OFF THE CRUISE CONTROL. SOMETIMES IT WOULD HAPPEN WHEN I SET THE SPEED AND SOMETIMES WOULD HAPPEN WHEN I ACCELERATE WITH THE CRUISE CONTROL SET ON SPEED.

NHTSA complaint #10319446 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

TL* THE CONTACT OWNS A 1997 TOYOTA COROLLA. WHILE DRIVING 65 MPH WITH THE VEHICLE SPEED CONTROL ACTIVATED, THE VEHICLE ACCELERATED UP TO 80 MPH AND WOULD NOT DECELERATE. AFTER REPEATED BRAKE APPLICATION THE VEHICLE DECELERATED TO 20 MPH, AND THEN SHE TURNED THE ENGINE OFF. A MECHANIC DISABLED THE CRUISE CONTROL. ALSO THEY HAD TO REPAIR THE ENTIRE BRAKE SYSTEM BECAUSE THE BRAKE SYSTEM WAS DAMAGED DUE TO HER EXCESSIVE BRAKING. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS 99,876.THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.

NHTSA complaint #10290932 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I HAD TRANSMISSION FLUSH ON 1997 COROLLA ON DEC 31, 2008. ON JAN 17, 2009, WHILE DRIVING, CAR SUDDENLY STOPPED AFTER STRONG VIBRATIONS. FORTUNATELY, THIS DID NOT HAPPEN ON HIGHWAY. THE FIRST REPAIR SHOP SAID TRANSMISSION TORQUE CONVERTER LOCKING UP. TRANSMISSION IS NEEDED?. THE SECOND REPAIR SHOP OPENED THE TRANSMISSION AND FOUND ?TRANSFER CASE HAS NO OIL INSIDE?, WITH BROKEN BEARING THAT CAUSE DAMAGE TO THE TRANSMISSION AND NEED TOTAL REBUILD. BOTH SHOPS SAID IT COULD BE THE RESULTS OF THE TRANSMISSION FLUSH JOB. I CONTACTED THE SHOP THAT PERFORMED THE TRANSMISSION FLUSH AND THEY DENIED OF ANY POSSIBLE MISTAKE. IF THEY HAD ACCIDENTALLY EMPTIED THE DIFFERENTIAL UNIT, THE CAR SHOULD HAVE SEIZED IMMEDIATELY, NOT A FEW WEEKS AFTERWARDS. THEY SAID THAT WITH AGE, THE SEAL BETWEEN THE TRANSMISSION AND THE DIFFERENTIAL CASE COULD HAVE BEEN DAMAGED AND THE OIL IN THE DIFFERENTIAL UNIT (TRANSFER CASE) TO LEAK AND EVENTUALLY DRIED UP AND CAUSE THE FAILURE. I DID SOME RESEARCH ON TOYOTA RECALL AND SERVICE BULLETIN. NOTHING OF THIS NATURE CAME UP FOR THIS MODEL YEAR BUT FOUND SIMILAR DESCRIPTION FOR 1997 TOYOTA PREVIA DEFECT RECALL DATE APR04, 1997 WITH DEFECT CONSEQUENCE: ?OIL LEAKAGE WILL RESULT IN A SUFFICIENTLY LOW OIL SUPPLY TO CAUSE BEARING DAMAGE TO THE FRONT DIFFERENTIAL UNIT LEADING TO EVENTUAL SEIZURE OF THE UNIT INCREASING THE RISK OF A CRASH. SO COULD IT BE A DEFECT SIMILAR TO THE 1997 TOYOTA PREVIA OR COULD IT BE THE SHOPS MISTAKE TO UNKNOWINGLY DRAIN THE DIFFERENTIAL COMPARTMENT WHICH CAN LEAD TO THE SAME SYMPTOM EVENTUALLY (NOT NECESSARILY IMMEDIATELY AS THEY CLAIMED)

NHTSA complaint #10257773 — an unverified report by a vehicle owner.