Toyota Highlander seat belt problems

SEAT BELTS

The third row seat belts in the 2024 Highlander are very difficult to latch. I had to bring my Highlander to the dealership twice over the seatbelt buckles in the third row. The buckle part does not lift up high enough to grab the buckle to latch it. Anytime a child old enough to be in the third row sits back there an adult has to Buckle them because they can’t get the seat belt to latch to the buckle. It’s supposed to be a family friendly vehicle but if a 7 year old can’t buckle themselves, that is an extremely unsafe design. It often takes me 10-15 minutes to get kids buckled in my third row because of how challenging it is to get the seat belts to latch as an adult. I have had to use a butter knife to get them to latch. This safety issue , I did not have in my 2021Highlander. I don’t feel children are safe in the third row of my vehicle. This time the dealership said it had a debris in the buckle and that’s why it wouldn’t latch. However even when they do all latch they are very difficult to latch. These should be replaced with safe buckles that latch the first attempts

NHTSA complaint #11745432 — an unverified report by a vehicle owner.

SEAT BELTS

The contact owns a 2023 Toyota Highlander. The contact stated that while starting the vehicle, and driving at an undisclosed speed, the seat belt alarm chimed while the seat belts were properly buckled. The contact turned off and restarted the vehicle, and released and fastened the seat belt securely however, the failure persisted. The vehicle was taken to the dealer twice, but the dealer was unable to duplicate the failure. The failure recurred, and the vehicle was taken back to the dealer a third time; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000.

NHTSA complaint #11727519 — an unverified report by a vehicle owner.

SEAT BELTS

When right front pax sits in seat and fastens seatbelt, the airbag indicator correctly says "ON." But after a few minutes, the airbag turns "OFF" and the driver's dash gets an "unfastened seatbelt" warning and a "faulty airbag" warning. All of these occur while the front right pax has remain seated and buckled. If the pax unbuckles and exits the seat, these incorrect warnings all remain the same. The right front pax seat belt buckle has been replaced with no effect. The seat has been recalibrated (seat sensors) with no effect. The wires under the seat have been disconnected, cleaned, and re-connected with no effect. This is a safety issue in that the airbag on that front right side de-activates when a passenger is in that seat. There is a Toyota Recall Campaign for this identical problem, but it does not include my model year (2015). Requesting NHTSA get Toyota to extend their recall to include 2015 models, please.

NHTSA complaint #11704027 — an unverified report by a vehicle owner.

SEAT BELTS

Car seats and booster seats for infants and children with the age and weight requirement for seats in a vehicle do not meet safety requirements. The second row and the third row you literally have to pick the car seat up to buckle the seatbelt in appropriately. I have asked on numerous occasions if there is a seatbelt extension that can be purchased and I was told no. My concern is for safety of children/infants. We should not have to pick a car seat or booster seat up after a child is placed in the car seat to be able to buckle the car seat in appropriately or the booster seat appropriately. In the third row, my son literally has to stand behind the hatchback to get the seatbelt for the booster seat in the third row Locked in place. This is a safety concern. I brought it up to two dealerships and Toyota’s customer complaint who actually gave me this website.

NHTSA complaint #11693766 — an unverified report by a vehicle owner.

SEAT BELTS

Passenger seat belt won't extend half of the time. We have tried with engine on or off, put it in park and in gear, door open or closed and every other trick. We have pulled the belt straight up and down and every other angle. We have adjusted the height for tall or short riders. We took to the auto dealership, and they said it would not work for them at first then it started to work. We have had riders in the passenger front seat ride with no seat belt on because they couldn't extend it and gave up. It should work every time there because it is a safety issue that should be fixed.

NHTSA complaint #11676416 — an unverified report by a vehicle owner.

SEAT BELTS

Driver side airbags (curtain and left seat) spontaneously deployed while I was parking the car. I did not hit anything. I was not injured but my safety was put at risk because I likely would have crashed if it had happened while I was driving. I contacted Toyota and they sent an investigator to inspect the car. He found no issues in the data he collected and could not give a reason for the airbags deployment. I received a letter saying they were not going to help in any way. There were no warnings lights or indicators that could have warned me of the airbags deploying prior to the incident.

NHTSA complaint #11667147 — an unverified report by a vehicle owner.

SEAT BELTS

Currently having issues for my active recall with no remedy available

NHTSA complaint #11655725 — an unverified report by a vehicle owner.

SEAT BELTS

Driver side seat belt is difficult to pull out and often does not retract properly. This is a safety issue for the driver. Issue has been seen by local Toyota dealer who can confirm the problem. Stated that it will require a $500 repair, replacing the entire retractable unit of the driver side seatbelt system.

NHTSA complaint #11594258 — an unverified report by a vehicle owner.

SEAT BELTS

The contact owns a 2019 Toyota Highlander. The contact stated that while her grandkids were attempting to latch the rear seat belts, the seat belts independently unlatched. The seat belt warning light illuminated. The vehicle was not taken to the dealer. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V877000 (Seat Belts). The manufacturer was made aware of the failure and confirmed that the vehicle was not included in the recall. The failure mileage was approximately 40,000.

NHTSA complaint #11591324 — an unverified report by a vehicle owner.

SEAT BELTS

The contact's wife owns a 2020 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the audible seat belt chime sounded after the front passenger's side seat occupant had buckled the seat belt. The seat belt warning light was illuminated. The vehicle was taken to the dealer, where it was determined that the failure was related to the recall. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 67,080. VIN tool confirms parts not available.

NHTSA complaint #11591063 — an unverified report by a vehicle owner.

SEAT BELTS

Subject: Urgent Safety Concern - Recurring Issues with Toyota Highlander Hybrid Models Dear National Highway Traffic Safety Administration, We owned the car since almost new, after repeated attempts with Toyota, like others 300K customers from their own site, I am writing to file a formal complaint regarding persistent safety issues with Toyota Highlander Hybrid models, specifically between the years 2004 and 2007. Despite previous reports and numerous attempts to seek assistance from Toyota, the response has been unsatisfactory, with the company deflecting responsibility rather than providing a resolution. **Vehicle Information:** - Make: Toyota - Model: Highlander Hybrid - Year: 2007 - VIN: [XXX] **Description of the Issue:** 1) The primary concerns involve the hybrid a) BRAKE actuators failing/loosing braking power 2) the electrical inverters, which have shown a pattern of failure across many vehicles, including my own. 3) Leaky blow back from engine into intake. 4) Seat belts are not properly retracting, These failures could compromise the safety of the vehicle but also risk to the driver, passengers, and others on the road. **Previous Reports:** I have previously reported these issues to Toyota, but the attempts to resolve the matter have been met with deflection of blame. It is imperative to note that these issues are not isolated incidents but are widely reported by other owners of the same model. **Impact on Safety:** The malfunctioning of critical components such as the braking system has led to near-miss incidents that could have resulted in severe injuries or fatalities. It is unacceptable for such critical safety issues to remain unaddressed. **Request for Action:** I urge the NHTSA to investigate these reports thoroughly and take appropriate action to hold Toyota and its CEO accountable. The safety of countless drivers and the integrity of our transportation system depend on your prompt attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S

NHTSA complaint #11590708 — an unverified report by a vehicle owner.

SEAT BELTS

The ECU requires a reflash or replacement. The hybrid batteries over heat and regen braking randomly shuts off during braking or before/after due to overheating becuswe the cooling fans do not engage past level 1 or 2. The fans in fact never go full speed unless commanded by a Toyota service tech via the software during fan testing. Upon testing I noticed they not once went high enough to be audible and thus overheated. Manu forms indicate this is a common issue and requires 180-$300 for a reflash and/or replacement of the compu) ECU to alleviate this issue. Second issue I've found is the 3rd row seat belts just like some other MY Highlanders have their restraints cut at the shackle holding them to the body of the vehicle. I have seen several sheered this way including my own vehicle.

NHTSA complaint #11577484 — an unverified report by a vehicle owner.

SEAT BELTS:FRONT:ANCHORAGE

The contact owns a 2017 Toyota Highlander. The contact stated that upon entering the vehicle and attempting to buckle the seat belt, the contact became aware that the seat belt was no longer attached. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the anchor point bolts were severely corroded. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 75,000.

NHTSA complaint #11565106 — an unverified report by a vehicle owner.

SEAT BELTS

The 3rd row seat belt buckle is imbedded too deep in the seat. This makes it very difficult for a child to buckle themselves and in several attempts the parent or another adult was required to insert the seat belt into the locking device. What is more concerning is the difficulty a child has when trying to release the seat belt. While this may be an annoyance that requires adult intervention it is of particular concern when a child, in an emergency is required to release the seat belt.

NHTSA complaint #11560784 — an unverified report by a vehicle owner.

SEAT BELTS

Seat belt refused to retract and was pressing on our son's belly 911 was called and notified of the issue, Policeman had to cut off the seat belt for my son's safety Insurance was notified and we were informed that insurance will cover the repair cost but we have a $ 500 deductible Toyota gave us a quote for $ 470.12 plus sales tax 19.29 for a total of $545.73

NHTSA complaint #11539140 — an unverified report by a vehicle owner.

SEAT BELTS

I took delivery of the new vehicle without testing all the seatbelts. The third row passenger side seat belt is fully retracted as it should be, but it's locked in that position. It came from the dealer that way, and it cannot be used. If I hadn't noticed while testing out the seats, I might incorrectly assume that it is functioning while inviting 6 passengers into my vehicle. This could lead to somebody taking a ride without a seatbelt. Third rows of these mid-size SUV's aren't commonly used, so I imagine it could be a long time (years) before somebody notices that their seat belt doesn't work, unless they happened to check them all. I have a service appointment in 2 days at my local dealer to have the seatbelt inspected and fixed or replaced.

NHTSA complaint #11520305 — an unverified report by a vehicle owner.