2023 Toyota Tundra problems

ENGINE

Ive been waiting for years for the previous recalls I have been informed about to get fixed. Feul system,brake lights.Was told by Toyota that someone would call me to come to get them taken care of. In the meantime, constantly checking that my brake lights are working before departing on any excursions in truck & patiently waiting for toyota to reach out when they were gonna fix the first 2 recalls that I was notified about. I can't recall the date exactly, but I was driving on the highway w/ my still backward carseat, facing 2y.o. baby safely strapped in,ThankGod.As accelerating into my lane, heard huge BOOM like an IED. Immediately, the check engine light among others came on.Truck immediately lost power & was violently shaking.Felt it in the steering wheel, but largely in engine compartment.@this time,I tried to get over to shoulder to a safe place.I turned the car off.Let it rest checked on my infant in back made sure he was ok. After letting car rest, turn back on to my surprise All lights were off.I was w/in few miles of home so went directly back, never getting to my intended destination. Shortly before driveway, all lights came back on & multiple service messages.Since then the truck has not been driveable,As we have specifically looked up recalls,thusly Nov.recall matched lights on the dash for the specific make,year, model of truck. From my understanding, it says that there is no remedy for such recall. But that is untrue. The remedy is an entirely new engine. They just haven't rolled out the recall info to everyone applicable. I am unable to work. My home is without a vehicle and this is unacceptable.Along w/ safety risk to me and infant. I'm sure Toyota doesn't want to admit or remedy Because that is very costly. But this was a mistake made by the company. And it should be remedied, because our family is suffering in various ways. Lost revenue. Inability to respond if emergency etc.I need a new engine.& in the interim,I need a car supplied while fixed.

NHTSA complaint #11758505 — an unverified report by a vehicle owner.

SERVICE BRAKES

Ive been waiting for years for the previous recalls I have been informed about to get fixed. Feul system,brake lights.Was told by Toyota that someone would call me to come to get them taken care of. In the meantime, constantly checking that my brake lights are working before departing on any excursions in truck & patiently waiting for toyota to reach out when they were gonna fix the first 2 recalls that I was notified about. I can't recall the date exactly, but I was driving on the highway w/ my still backward carseat, facing 2y.o. baby safely strapped in,ThankGod.As accelerating into my lane, heard huge BOOM like an IED. Immediately, the check engine light among others came on.Truck immediately lost power & was violently shaking.Felt it in the steering wheel, but largely in engine compartment.@this time,I tried to get over to shoulder to a safe place.I turned the car off.Let it rest checked on my infant in back made sure he was ok. After letting car rest, turn back on to my surprise All lights were off.I was w/in few miles of home so went directly back, never getting to my intended destination. Shortly before driveway, all lights came back on & multiple service messages.Since then the truck has not been driveable,As we have specifically looked up recalls,thusly Nov.recall matched lights on the dash for the specific make,year, model of truck. From my understanding, it says that there is no remedy for such recall. But that is untrue. The remedy is an entirely new engine. They just haven't rolled out the recall info to everyone applicable. I am unable to work. My home is without a vehicle and this is unacceptable.Along w/ safety risk to me and infant. I'm sure Toyota doesn't want to admit or remedy Because that is very costly. But this was a mistake made by the company. And it should be remedied, because our family is suffering in various ways. Lost revenue. Inability to respond if emergency etc.I need a new engine.& in the interim,I need a car supplied while fixed.

NHTSA complaint #11758505 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Ive been waiting for years for the previous recalls I have been informed about to get fixed. Feul system,brake lights.Was told by Toyota that someone would call me to come to get them taken care of. In the meantime, constantly checking that my brake lights are working before departing on any excursions in truck & patiently waiting for toyota to reach out when they were gonna fix the first 2 recalls that I was notified about. I can't recall the date exactly, but I was driving on the highway w/ my still backward carseat, facing 2y.o. baby safely strapped in,ThankGod.As accelerating into my lane, heard huge BOOM like an IED. Immediately, the check engine light among others came on.Truck immediately lost power & was violently shaking.Felt it in the steering wheel, but largely in engine compartment.@this time,I tried to get over to shoulder to a safe place.I turned the car off.Let it rest checked on my infant in back made sure he was ok. After letting car rest, turn back on to my surprise All lights were off.I was w/in few miles of home so went directly back, never getting to my intended destination. Shortly before driveway, all lights came back on & multiple service messages.Since then the truck has not been driveable,As we have specifically looked up recalls,thusly Nov.recall matched lights on the dash for the specific make,year, model of truck. From my understanding, it says that there is no remedy for such recall. But that is untrue. The remedy is an entirely new engine. They just haven't rolled out the recall info to everyone applicable. I am unable to work. My home is without a vehicle and this is unacceptable.Along w/ safety risk to me and infant. I'm sure Toyota doesn't want to admit or remedy Because that is very costly. But this was a mistake made by the company. And it should be remedied, because our family is suffering in various ways. Lost revenue. Inability to respond if emergency etc.I need a new engine.& in the interim,I need a car supplied while fixed.

NHTSA complaint #11758505 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling). The contact stated that while driving 40 MPH, there was white smoke coming from the exhaust pipe. The vehicle was taken to a dealer to be diagnosed, and the head gasket needed to be replaced. The vehicle was not repaired under the recall because there was sludge found inside the engine. The manufacturer was notified of the failure. The failure mileage was 70,000.

NHTSA complaint #11758060 — an unverified report by a vehicle owner.

POWER TRAIN

-Our Toyota Tundra Hybrid suffered total catastrophic engine failure due to metal shavings found throughout the engine and oil system. This is the same issue that prompted NHTSA ID Number: 25V767000 recall of Toyota's V35A engines. The tundra is available for inspection. -Statement regarding safety put at risk by my husband: I felt a vibration from the engine compartment (seeming to come from the front right side) and then I suddenly lost complete power. I was traveling in the number one lane (the fast lane). I immediately put my hazards on and had to navigate to the number two lane and then over to the narrow shoulder under no power whatsoever. I had to navigate around multiple semi-trucks. This was a very dangerous situation and I barely got it over to the shoulder. If my teenage daughters were driving this car they likely wouldn't have been able to safely navigate it across two lanes with no power in the setting of multiple semi-trucks on a two-lane divided highway. Again, a very dangerous situation. I shut down the engine and waited five minutes and restarted it. Shifting into gear the warning indicator said 'hybrid system disconnected'. -The total catastrophic engine failure has been confirmed by the Toyota Dealership. Th4ey Confirmed multiple shavings of metal in the entire oil system and the engine has seized. He said that the engine needed to be replaced. -The tundra has not been inspected by the manufacturer, police, insurance (yet) or others besides the Toyota dealership. -There were no warning lamps, messages, or other symptom of the pending catastrophic total engine failure.

NHTSA complaint #11757587 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

-Our Toyota Tundra Hybrid suffered total catastrophic engine failure due to metal shavings found throughout the engine and oil system. This is the same issue that prompted NHTSA ID Number: 25V767000 recall of Toyota's V35A engines. The tundra is available for inspection. -Statement regarding safety put at risk by my husband: I felt a vibration from the engine compartment (seeming to come from the front right side) and then I suddenly lost complete power. I was traveling in the number one lane (the fast lane). I immediately put my hazards on and had to navigate to the number two lane and then over to the narrow shoulder under no power whatsoever. I had to navigate around multiple semi-trucks. This was a very dangerous situation and I barely got it over to the shoulder. If my teenage daughters were driving this car they likely wouldn't have been able to safely navigate it across two lanes with no power in the setting of multiple semi-trucks on a two-lane divided highway. Again, a very dangerous situation. I shut down the engine and waited five minutes and restarted it. Shifting into gear the warning indicator said 'hybrid system disconnected'. -The total catastrophic engine failure has been confirmed by the Toyota Dealership. Th4ey Confirmed multiple shavings of metal in the entire oil system and the engine has seized. He said that the engine needed to be replaced. -The tundra has not been inspected by the manufacturer, police, insurance (yet) or others besides the Toyota dealership. -There were no warning lamps, messages, or other symptom of the pending catastrophic total engine failure.

NHTSA complaint #11757587 — an unverified report by a vehicle owner.

ENGINE

-Our Toyota Tundra Hybrid suffered total catastrophic engine failure due to metal shavings found throughout the engine and oil system. This is the same issue that prompted NHTSA ID Number: 25V767000 recall of Toyota's V35A engines. The tundra is available for inspection. -Statement regarding safety put at risk by my husband: I felt a vibration from the engine compartment (seeming to come from the front right side) and then I suddenly lost complete power. I was traveling in the number one lane (the fast lane). I immediately put my hazards on and had to navigate to the number two lane and then over to the narrow shoulder under no power whatsoever. I had to navigate around multiple semi-trucks. This was a very dangerous situation and I barely got it over to the shoulder. If my teenage daughters were driving this car they likely wouldn't have been able to safely navigate it across two lanes with no power in the setting of multiple semi-trucks on a two-lane divided highway. Again, a very dangerous situation. I shut down the engine and waited five minutes and restarted it. Shifting into gear the warning indicator said 'hybrid system disconnected'. -The total catastrophic engine failure has been confirmed by the Toyota Dealership. Th4ey Confirmed multiple shavings of metal in the entire oil system and the engine has seized. He said that the engine needed to be replaced. -The tundra has not been inspected by the manufacturer, police, insurance (yet) or others besides the Toyota dealership. -There were no warning lamps, messages, or other symptom of the pending catastrophic total engine failure.

NHTSA complaint #11757587 — an unverified report by a vehicle owner.

ENGINE

While I was driving on Highway 459, the vehicle suddenly experienced a complete engine failure and lost power in the middle of the roadway. The vehicle could no longer accelerate or maintain its speed, leaving me stranded in an active traffic lane. This sudden failure placed me and other motorists at serious risk of a collision. Vehicles approaching from behind had to slow down, stop or change lanes to avoid hitting my disabled vehicle. I activated the hazard lights and attempted to move the vehicle to a safer location, but because the engine was no longer functioning, I was unable to safely remove it from the roadway. Before the incident, the vehicle displayed the following warning lights, messages or symptoms: NO PRIOR WARNING The vehicle was transported to OURISMAN TOYOTA OF WOODBRIDGE for inspection. The facility determined that ENGINE WAS BAD. The engine and vehicle remain available for inspection upon request. This was an abrupt and dangerous loss of engine power in active traffic. A vehicle should not experience a sudden engine failure that leaves it immobilized in the middle of a highway, especially without sufficient warning to allow the driver to reach a safe location. I am reporting this incident because the failure created a serious safety hazard for me and other motorists, and I am concerned that the same defect could affect other vehicles.

NHTSA complaint #11757819 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

1. Driver's door lock actuator failed. 2. Safety Hazard - the controls and key fob no longer lock or unlock the door, which could allow the door to be opened at any time during operation. 3. No, I have not taken it to confirm the door lock is not functioning. 4. No 5. The lock started to show signs of malfunction by not fully locking, then it stopped responding all together. This problem started on 7/31/26.

NHTSA complaint #11757408 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Toyota Tundra. The contact stated that upon starting the vehicle, the engine was idling rough; however, there was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V767000 (ENGINE AND ENGINE COOLING). The local dealer was contacted, but the vehicle was not diagnosed or repaired because the remedy for the recall was not yet available. The manufacturer was notified of the failure. The failure mileage was 30,000.

NHTSA complaint #11757406 — an unverified report by a vehicle owner.

POWER TRAIN

My wife and I purchased a brand new Tundra LTD in May 2023. An important note to keep in mind is that my wife and I not only purchased the new Tundra but also a new travel trailer so we could enjoy our nation's national parks during our retirement years. I will relate that to my complaint shortly. It wasn't long after our purchase that we became aware of the issue of machining debris possibly contaminating the engine block which can result in sudden engine failure. Right now, because Toyota has not resolved our issue and communication has generally been close to non-existent. We no longer feel we can safely take our truck and trailer to the remote national parks of the American southwest where distances are huge and help few and far between. We have visited the SW twice and want to do more while we are still young enough to do so but are worried about what a sudden breakdown would do. I called up Toyota and asked them to repurchase the Tundra so I could buy a new onw without the issue. I explained that I paid for the Truck in good faith but that they have not kept up the end of the bargain, the truck Toyota sold us is potentially unsafe and we'd like it fixed or repurchases which would allow us to buy a new truck. They closed out my official inquiry without comment or communication of any kind. Apparenty, they are just fine with consumers being sold a truck that may suddenly die on them. Anyway you folks can get Toyota to fairly take care of its customers?

NHTSA complaint #11757302 — an unverified report by a vehicle owner.

ENGINE

My wife and I purchased a brand new Tundra LTD in May 2023. An important note to keep in mind is that my wife and I not only purchased the new Tundra but also a new travel trailer so we could enjoy our nation's national parks during our retirement years. I will relate that to my complaint shortly. It wasn't long after our purchase that we became aware of the issue of machining debris possibly contaminating the engine block which can result in sudden engine failure. Right now, because Toyota has not resolved our issue and communication has generally been close to non-existent. We no longer feel we can safely take our truck and trailer to the remote national parks of the American southwest where distances are huge and help few and far between. We have visited the SW twice and want to do more while we are still young enough to do so but are worried about what a sudden breakdown would do. I called up Toyota and asked them to repurchase the Tundra so I could buy a new onw without the issue. I explained that I paid for the Truck in good faith but that they have not kept up the end of the bargain, the truck Toyota sold us is potentially unsafe and we'd like it fixed or repurchases which would allow us to buy a new truck. They closed out my official inquiry without comment or communication of any kind. Apparenty, they are just fine with consumers being sold a truck that may suddenly die on them. Anyway you folks can get Toyota to fairly take care of its customers?

NHTSA complaint #11757302 — an unverified report by a vehicle owner.

POWER TRAIN

As many have spoken about already, I have the hesitation or lag from stop or rolling at very slow speeds. I kind of learned to live with it but feel it's getting worse. My wife had to drive the truck, and she said it was very scary and did not feel safe. I know it is not the engine as I had it replaced and problem is still very much there! There have been so many issues with this truck. Brakes have never stopped squeaking; one dealership guy told me it is the cheap pads Toyota put on them.

NHTSA complaint #11756896 — an unverified report by a vehicle owner.

SERVICE BRAKES

As many have spoken about already, I have the hesitation or lag from stop or rolling at very slow speeds. I kind of learned to live with it but feel it's getting worse. My wife had to drive the truck, and she said it was very scary and did not feel safe. I know it is not the engine as I had it replaced and problem is still very much there! There have been so many issues with this truck. Brakes have never stopped squeaking; one dealership guy told me it is the cheap pads Toyota put on them.

NHTSA complaint #11756896 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES:ELECTRONIC LOCK/LATCH ACTUATOR

The door actuator mechanism (Driver's Door) periodically does not work or makes a ratcheting sound like a machine gun when placing the vehicle in drive or in park.

NHTSA complaint #11756928 — an unverified report by a vehicle owner.

ENGINE

On April 7, 2026, at 5:00 PM, while driving, I noticed something unusual with my car, and it broke down on the side of the road, leaving me panicked and frightened. After the car stopped, I got out and looked at the engine from underneath; I saw engine oil spraying out of the engine. I then had the car towed to a safe location, and a few days later, I took it to the Toyota dealership.

NHTSA complaint #11755392 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2023 Toyota Tundra. The contact stated that while driving at an undisclosed speed, several warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed with turbo boost failure. The contact was informed that the turbo boost needed to be replaced. The vehicle was repaired. In addition, the contact was informed that the failure was not associated with NHTSA Campaign Number: 25V767000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the part for the recall repair had been unavailable for approximately nine months. The manufacturer was made aware of the failure, and several cases were filed. The failure mileage was approximately 41,000.

NHTSA complaint #11754453 — an unverified report by a vehicle owner.

ENGINE

November 2025 notice there was issue with engine February 24 2026 serviced for engine April 13 2026 serviced for engine May 05 2026 serviced for engine June 15,2026 serviced for engine NO remedy Problem still presist

NHTSA complaint #11754267 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

November 2025 notice there was issue with engine February 24 2026 serviced for engine April 13 2026 serviced for engine May 05 2026 serviced for engine June 15,2026 serviced for engine NO remedy Problem still presist

NHTSA complaint #11754267 — an unverified report by a vehicle owner.

BACK OVER PREVENTION: WARNINGS

November 2025 notice there was issue with engine February 24 2026 serviced for engine April 13 2026 serviced for engine May 05 2026 serviced for engine June 15,2026 serviced for engine NO remedy Problem still presist

NHTSA complaint #11754267 — an unverified report by a vehicle owner.

TIRES

Vehicle Information: 2023 Toyota Tundra Limited TRD Off-Road (Equipped with Factory Tires) [1] Current Mileage: Approximately 26,000 miles Description of Safety Defect: The factory-installed tires on this vehicle are exhibiting premature, severe tire dry rot (sidewall/tread cracking) and highly accelerated, uneven tread wear at only 26,000 miles. The depth of the rot and the erratic wear pattern present an immediate structural hazard, significantly increasing the risk of a sudden tread separation, sidewall blowout, or catastrophic tire failure at highway speeds. Despite proper vehicle maintenance, alignment checks, and routine tire rotations, the rubber compound has degraded at an unacceptable and unsafe rate for a low-mileage, modern vehicle. This premature deterioration compromises wet-weather traction, braking efficiency, and overall vehicle handling. The severe degradation of these original equipment manufacturer (OEM) tires constitutes a clear manufacturing defect that poses an ongoing safety risk to the driver, passengers, and other motorists on the road.

NHTSA complaint #11752253 — an unverified report by a vehicle owner.

ENGINE

Car stalled on multiple occassions while driving

NHTSA complaint #11752254 — an unverified report by a vehicle owner.

ENGINE

Recall # 25V767 has been open since November 6, 2025 and the remedy is not yet available. There is a possibility that certain machining debris may not have been cleared from the engine when it was produced which can lead to potential engine knocking, engine rough running, engine no start, and/or a loss of motive power. I am concerned about this being a major safety issue and also concerned about the fact that the recall has been open since November 2025 and there is still no remedy.

NHTSA complaint #11751746 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

2 RECALLS ISSUES: Since I bought that Toyota Tundra from 2023 to now, I was reporting several times issues with knocking engine and losing of engine power (rough running), but service department said nothing happens with. Then, now I have a recall, waiting to get a new engine, that I saw it over the dealer Toyota computer, as the adviser told me "I am in waiting line", but time is running, and no one is contacting me to done it. I am very worry to get issues when I am driving, Then I have to get a long trip no Mexico with the truck, but can not do it like this. Then my reverse lamp lights have a recall too. I'D CONTACT TOYOTA CAMELBACK OF PHOENIX AZ. TWO TIMES, BUT I RECEIVED NO ANSWERS. Thank you so much

NHTSA complaint #11751445 — an unverified report by a vehicle owner.

ENGINE

2 RECALLS ISSUES: Since I bought that Toyota Tundra from 2023 to now, I was reporting several times issues with knocking engine and losing of engine power (rough running), but service department said nothing happens with. Then, now I have a recall, waiting to get a new engine, that I saw it over the dealer Toyota computer, as the adviser told me "I am in waiting line", but time is running, and no one is contacting me to done it. I am very worry to get issues when I am driving, Then I have to get a long trip no Mexico with the truck, but can not do it like this. Then my reverse lamp lights have a recall too. I'D CONTACT TOYOTA CAMELBACK OF PHOENIX AZ. TWO TIMES, BUT I RECEIVED NO ANSWERS. Thank you so much

NHTSA complaint #11751445 — an unverified report by a vehicle owner.