FaultScore report
Owners have filed 142 complaints about the 1995 Volkswagen Passat with NHTSA between 1995 and 2009. The largest single group is the windows, mirrors & wipers. Across this model's run it ranks 26 of 30 worst.
FaultScore 23/100
Higher is worse. Measured against the other years of the Volkswagen Passat.
How this is worked out142
Complaints
4
Crashes reported
2
Fires reported
3
Injuries reported
153,015 mi
Median mileage at failure
Half of reported failures happened before this
8%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
Median failure at 114,000 miles
Median failure at 175,000 miles
2 crashes, 1 fires
Median failure at 175,000 miles
Median failure at 110,000 miles
NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.
FUEL TANK PUNCTURE
FUEL TANK PUNCTURE
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.
Risk: A WORN AND NOISY FAN MOTOR SHAFT CAN SEIZE RENDERINGTHE FAN MOTOR INOPERATIVE, EVENTUALLY CAUSING THE ENGINE TO OVERHEAT AND STALL. A STALLED VEHICLE IN TRAFFIC CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.
Canada runs its own recall programme, and its campaigns do not always mirror the American ones.
Seats And Restraints
On certain vehicles equipped with seat heating units, the front seat back heaters may supply concentrated heat in a localized area of the seat back or produce excessive heat that could not be reduced by operating the seat heater controls except by switching off the controls completely. The concentrated heat could singe the fabric at the lower backrest and, in some instances, injure the seat occupant. Correction: Dealers will affect repairs.
Engine
NOTE: INCLUDES PASSAT, GOLF AND JETTA TURBO DIESEL. ON 1993-94 MODELS, THE RADIATOR FAN MOTOR SHAFT COULD SEIZE AND RENDER THE FAN MOTOR INOPERATIVE. 1994-95 MODELS COULD EXPERIENCE A CONDITION WHEREBY THE LOCK NUT SECURING THE RADIATOR FAN BLADE HUB TO THE MOTOR COULD LOSE ITS REQUIRED TORQUE. A LOOSE LOCK NUT COULD CAUSE THE FAN HUB TO LOOSEN FROM THE SHAFT AND CAUSE THE BELT PULLEY TO RUN "OFF-CENTER". THIS IN TURN COULD CAUSE THE FAN BELT TO DISCONNECT OR BREAK. EITHER OF THE ABOVE CONDITIONS COULD RESULT IN ENGINE OVERHEATING AND STALLING. A VEHICLE STALLING IN TRAFFIC COULD CAUSE AN ACCIDENT. CORRECTION: VEHICLES WITH EITHER HAVE THE COMPLETE COOLING FAN ASSEMBLY REPLACED OR A NEW FAN BLADE WITH A NEW LOCK NUT INSTALLED.
Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.
Reports where the owner recorded a crash, a fire, an injury or a death.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
THE HEATER CORE FAILED ON OUR 1995 VW PASSAT WHILE MY SON WAS DRIVING IT. WITHOUT WARNING IT FAILED AND POURED 190 DEGREE ANTIFREEZE OVER HIS ANKLES. FORTUNATELY HE WASN'T SEVERELY BURNED OR CRASHED THE CAR, BUT IT WAS SERIOUS ISSUE. WE SPOKE TO VW BUT THEY WOULDN'T REPLACE THE HEATER CORE. MANY CUSTOMERS HAVE HAD THE CORE REPLACED UNDER WARRANTY, BUT IT SEEMS TO BE RANDOMLY SELECTED. I HAVE READ ON THE FORUMS OF THIS HAPPENING OFTEN AND WOULD LIKE TO KNOW IF THERE IS RECALL THAT VW NEEDS TO ADDRESS. THANK YOU FOR YOUR HELP.
NHTSA complaint #10249400 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
95 PASSAT HEATER CORE RUPTURE FILLING THE VEHICLE CABIN WITH HOT RADIATOR FLUID AND STEAM. WINDSHIELD BECAME COATED WITH ANTI-FREEZE SOLUTION THAT JUST SMEARED AND COULD NOT BE WIPED OFF. VEHICLE LEFT THE ROAD INTO THE DITCH. I WILL BYPASS THE HEATER CORE FOR I CAN'T AFFORD TO HAVE IT REPAIRED AT THIS TIME. CONTACTED VWOA AND NO SPECIFIC RECALLS HAVE BEEN ISSUED.
NHTSA complaint #10151853 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
1. NORMAL DRIVING ON A SURBURBAN ROAD AT ABOUT 45MPH. ALL OF A SUDDEN, SMOKE/STEAM FROM THE VENTS, A COMPLETELY FOGGED WINDSHIELD, A SWEET SMELL, AND SCALDING HOT COOLANT ONTO MY FEET, ALMOST CAUSING ME TO HIT A PEDESTRIAN WALKING ALONGSIDE THE ROAD. 2. IT WAS THE HEATER CORE. A VERY COMMON PROBLEM TO 80'S AND 90'S VW PASSENGER CARS. SO NOW I HAVE NO WORKING HEATER (LUCKILY ITS SUMMER) AND MY CAR WONT REACH ITS MAX COOLING CAPACITY. THUS, CAR RUNS HOT. 3. BECAUSE I AM A COLLEGE STUDENT AND CANNOT AFFORD A $1200USD FIX, I HAVE BYPASSED IT WITH A COPPER U-PIPE. THE PART IS AVALIBLE, AND VWOA HAVE DONE A MASSIVE NUMBER OF 'GOOD-WILL' FIXES. I'M STILL TALKING WITH THEM TO COME OF WITH A RESOLUTION.
NHTSA complaint #10125669 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
HEATER CORE ON THE VR6 POWERED VEHICLES IS THE VALEO BRAND, KNOWN TO FAIL. IT JUST BLEWS COOLANT THROUGH THE DASH VENTS ALL OVER THE COUPE INSIDE.
NHTSA complaint #10114256 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
CONSUMER WAS DRIVING AND THE RPM ACCELERATED AND VEHICLE JERKED, CAUSING A CRASH. PLEASE DESCRIBE .
NHTSA complaint #806138 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
WHEN APPLYING THE BRAKES, SPEED CONTROL WOULD NOT DISENGAGE GOING NORMAL SPEED, LOST CONTROL OF VEHICLE, RESULTING IN AN ACCIDENT..
NHTSA complaint #986113 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
HEATER CORE "DOORS " MELTED FROM THE R TYPE ANTIFREEZE BREAKING DOWN TO AN ACID. THIS CAUSE THE HEATERCORE TO BREAK, ANTIFREEZE ENTERED THE CAR THROUGH THE VENTS AND ALSO ODDLY ENOUGH FILLED THE GAUGE CLUSTER WITH STEAM FOGGING THE CLUSTER. IT'S $800 FOR A REPLACEMENT SO I BOUGHT A FITTING AND SOME HOSE CLAMPS AND BYPASSES THE HEATER CORE SO I COULD STILL OPERATE THE VEHICLE WHEN IT WASN'T TOO COLD. HOWEVER WHEN OPERATING THE VEHICLE IN COLD WEATHER ALL THE WINDOWS HAD TO BE DOWN DUE TO YOUR BODY HEAT CAUSING ALL GLASS IN THE VEHICLE TO FOG. REPLACED THE HEATER CORE IN JANUARY, FLUSHED THE RADIATOR AND INSTALLED REGULAR TYPE 50/50 ANTIFREEZE AND NOT THE VW R-TYPE FLUID TO PREVENT BREAK DOWN INTO ACID AGAIN.
NHTSA complaint #10255023 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
BACKUP LIGHTS DIDN'T TURN ON, WHEN THE BRAKES WERE DEPRESSED THE ACCENT LIGHTS (LIGHTS THAT ILLUMINATE THE GAUGES, WINDOW, A/C & HEATER CONTROLS AND LOCK BUTTONS ETC.) WOULD TURN ON. ALSO IF THE CAR IF THE KEYS WERE TURNED TO THE FIRST NOTCH (STEERING WHEEL UNLOCK) AND THE HEATER VENTS TURNED TO THE ON POSITION BUT NOT BLOWING (DUE TO NO POWER) WHEN YOU PRESSED THE BRAKE PEDAL THE AIR WOULD START BLOWING... I TRACED IT DOWN TO AN IGNORANT ELECTRICAL ENGINEER DESIGNING THE CAR. THE REVERSE LIGHTS WERE LOOMED ON TO THE TRUNK ARM, EVERYTIME THE TRUNK WAS CLOSED IT BENT THE WIRE CAUSING THE WIRE TO BREAK AND SHORT OUT OVER TIME, I FIXED THE WIRE AND REROUTED IT LOW AND BEHOLD THE REVERSE LIGHTS ARE APPARENTLY TIED INTO THE ACCENT LIGHTS AND THE A/C & HEATER CONTROLS CAUSING THOSE TO MALFUNCTION IF THE REVERSE WAS SHORTED, MY GUESS IS THEY MUST ALL SHARE A COMMON GROUND.
NHTSA complaint #10255029 — an unverified report by a vehicle owner.
PARKING BRAKE
5SP VRG PASSAT. EMERGENCY/PARKING BRAKE WHEN APPLIED UNDER 40 DEGREES STICKS ON CAUSING THE REAR WHEEL TO DRAG DOWN THE ROAD FOR UP TO A MILE BEFORE THEY BREAK LOOSE AGAIN AND MOVE FREELY.
NHTSA complaint #10255042 — an unverified report by a vehicle owner.
LATCHES/LOCKS/LINKAGES
DRIVER SIDE DOOR FAILS TO OPEN 75% OF THE TIME, YOU HAVE TO YANK THE HANDLE MULTIPLE TIMES FOR IT TO OPEN, THE REAR DRIVER SIDE DOOR DOESN'T OPEN FROM THE OUTSIDE ANYMORE, THE OTHER DOORS ARE STARTING TO HAVE THE SAME PROBLEM, WHEN YOU LOCK THE CAR THE REAR PASSENGER DOORS LOCK MECHANISM SLOWLY RISES TO THE UNLOCKED POSITION. DRIVERS SIDE DOOR AND PASSENGER SIDE DOOR MANY TIMES FAIL TO CLOSE. WHEN YOU CLOSE THE DOORS THEY FLY BACK OPEN EITHER IMMEDIATELY AFTER CLOSING OR WHILE OPERATING THE VEHICLE. **THERE IS A SIMILAR COMPLAINT MISPLACED INTO THE AIR CONDITIONER SECTION BY ANOTHER INDIVIDUAL.**
NHTSA complaint #10255026 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
5SP VRG PASSAT. EMERGENCY/PARKING BRAKE WHEN APPLIED UNDER 40 DEGREES STICKS ON CAUSING THE REAR WHEEL TO DRAG DOWN THE ROAD FOR UP TO A MILE BEFORE THEY BREAK LOOSE AGAIN AND MOVE FREELY.
NHTSA complaint #10255042 — an unverified report by a vehicle owner.
SERVICE BRAKES, ELECTRIC
BACKUP LIGHTS DIDN'T TURN ON, WHEN THE BRAKES WERE DEPRESSED THE ACCENT LIGHTS (LIGHTS THAT ILLUMINATE THE GAUGES, WINDOW, A/C & HEATER CONTROLS AND LOCK BUTTONS ETC.) WOULD TURN ON. ALSO IF THE CAR IF THE KEYS WERE TURNED TO THE FIRST NOTCH (STEERING WHEEL UNLOCK) AND THE HEATER VENTS TURNED TO THE ON POSITION BUT NOT BLOWING (DUE TO NO POWER) WHEN YOU PRESSED THE BRAKE PEDAL THE AIR WOULD START BLOWING... I TRACED IT DOWN TO AN IGNORANT ELECTRICAL ENGINEER DESIGNING THE CAR. THE REVERSE LIGHTS WERE LOOMED ON TO THE TRUNK ARM, EVERYTIME THE TRUNK WAS CLOSED IT BENT THE WIRE CAUSING THE WIRE TO BREAK AND SHORT OUT OVER TIME, I FIXED THE WIRE AND REROUTED IT LOW AND BEHOLD THE REVERSE LIGHTS ARE APPARENTLY TIED INTO THE ACCENT LIGHTS AND THE A/C & HEATER CONTROLS CAUSING THOSE TO MALFUNCTION IF THE REVERSE WAS SHORTED, MY GUESS IS THEY MUST ALL SHARE A COMMON GROUND.
NHTSA complaint #10255029 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
THE HEATER CORE FAILED ON OUR 1995 VW PASSAT WHILE MY SON WAS DRIVING IT. WITHOUT WARNING IT FAILED AND POURED 190 DEGREE ANTIFREEZE OVER HIS ANKLES. FORTUNATELY HE WASN'T SEVERELY BURNED OR CRASHED THE CAR, BUT IT WAS SERIOUS ISSUE. WE SPOKE TO VW BUT THEY WOULDN'T REPLACE THE HEATER CORE. MANY CUSTOMERS HAVE HAD THE CORE REPLACED UNDER WARRANTY, BUT IT SEEMS TO BE RANDOMLY SELECTED. I HAVE READ ON THE FORUMS OF THIS HAPPENING OFTEN AND WOULD LIKE TO KNOW IF THERE IS RECALL THAT VW NEEDS TO ADDRESS. THANK YOU FOR YOUR HELP.
NHTSA complaint #10249400 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
DT*: THE CONTACT STATED THE VEHICLE VIBRATES AND IS WORSE WHEN IN HIGH GEAR. PART OF THE FAN FRACTURED CAUSING THE VEHICLE TO OVERHEAT. THERE IS AN NHTSA RECALL, # 95V178000, REGARDING THE ENGINE AND ENGINE COOLING: COOLING SYSTEM: FAN. THE VEHICLE VIN WAS NOT INCLUDED IN THE RECALL.
NHTSA complaint #10165716 — an unverified report by a vehicle owner.
TIRES:SIDEWALL
1995 PASSAT SIDEWALL BLEW OUT WHILE DRIVING 65 MPH. *TS THE TECHNICIAN WHO PERFORMED THE INSPECTION POINTED TO CRACKS WHICH WERE NEAR THE RIM LINE.
NHTSA complaint #10159456 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
95 PASSAT HEATER CORE RUPTURE FILLING THE VEHICLE CABIN WITH HOT RADIATOR FLUID AND STEAM. WINDSHIELD BECAME COATED WITH ANTI-FREEZE SOLUTION THAT JUST SMEARED AND COULD NOT BE WIPED OFF. VEHICLE LEFT THE ROAD INTO THE DITCH. I WILL BYPASS THE HEATER CORE FOR I CAN'T AFFORD TO HAVE IT REPAIRED AT THIS TIME. CONTACTED VWOA AND NO SPECIFIC RECALLS HAVE BEEN ISSUED.
NHTSA complaint #10151853 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
DT: CONTACT STATED WHILE DRIVING AT 35 MPH. THE VENTS STARTED STEAMING. THE VEHICLE WAS THEN TOWED TO A MECHANIC. THEY PERFORMED A DIAGNOSTICS TEST, WHICH INDICATED THAT THE HEATER CORE MALFUNCTIONED. THE VEHICLE WAS NOT AT A LOCAL DEALERSHIP, AND NO REPAIRS HAVE BEEN MADE.
NHTSA complaint #10144473 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
DT: CALLER CAN NOT OPEN DOOR FROM THE OUTSIDE. SHE HAS TO USE THE HANDLE ON THE INSIDE OF ALL THE DOORS EXCEPT THE REAR PASSENGER DOOR. DEALER SAID THEY NEVER HEARD OF THIS. MANUFACTURER SAID THEY COULD NOT DO ANYTHING TO HELP HER.
NHTSA complaint #10126508 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
1. NORMAL DRIVING ON A SURBURBAN ROAD AT ABOUT 45MPH. ALL OF A SUDDEN, SMOKE/STEAM FROM THE VENTS, A COMPLETELY FOGGED WINDSHIELD, A SWEET SMELL, AND SCALDING HOT COOLANT ONTO MY FEET, ALMOST CAUSING ME TO HIT A PEDESTRIAN WALKING ALONGSIDE THE ROAD. 2. IT WAS THE HEATER CORE. A VERY COMMON PROBLEM TO 80'S AND 90'S VW PASSENGER CARS. SO NOW I HAVE NO WORKING HEATER (LUCKILY ITS SUMMER) AND MY CAR WONT REACH ITS MAX COOLING CAPACITY. THUS, CAR RUNS HOT. 3. BECAUSE I AM A COLLEGE STUDENT AND CANNOT AFFORD A $1200USD FIX, I HAVE BYPASSED IT WITH A COPPER U-PIPE. THE PART IS AVALIBLE, AND VWOA HAVE DONE A MASSIVE NUMBER OF 'GOOD-WILL' FIXES. I'M STILL TALKING WITH THEM TO COME OF WITH A RESOLUTION.
NHTSA complaint #10125669 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
HEATER CORE ON THE VR6 POWERED VEHICLES IS THE VALEO BRAND, KNOWN TO FAIL. IT JUST BLEWS COOLANT THROUGH THE DASH VENTS ALL OVER THE COUPE INSIDE.
NHTSA complaint #10114256 — an unverified report by a vehicle owner.
SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE
ABS LIGHT FAILURE - CONTINUE LIGHT ON AND POSSBILE BRAKE FAILURE
NHTSA complaint #10111874 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
HEATER CORE EXPLODING, NO EVENTS LEADING UP TO THIS I WAS SIMPLY GOING FROM A STOPLIGHT WHEN SMOKE STARTED POURING IN THROUGH THE VENTS AND ENGINE COOLANT GOING EVERYWHERE. I HAVE NOT REPLACED ANYTHING YET, BUT THE HEATER CORE IS DESTROYED.
NHTSA complaint #10090994 — an unverified report by a vehicle owner.
STEERING:RACK AND PINION
RACK AND PINION STEERING FAILED. AS RESULT STEERING MALFUNCTIONED. HOWEVER TCONSUMER WAS ABLE TO GAIN CONTROL.
NHTSA complaint #10073989 — an unverified report by a vehicle owner.
SEAT BELTS
TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.
NHTSA complaint #10071395 — an unverified report by a vehicle owner.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.
NHTSA complaint #10071395 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.
NHTSA complaint #10071395 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.
NHTSA complaint #10071395 — an unverified report by a vehicle owner.
EQUIPMENT
TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.
NHTSA complaint #10071395 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION:SWITCH
I WAS STARTING MY 1995 VOLKSWAGEN PASSAT VR6 (MANUAL), AND IT STARTED UP JUST FINE, BUT AS I STARTED TO GET GOING, THE CAR DIED. I LOST ALL ELECTRICAL FUNCTIONS OF THE CAR INITIATED BY THE IGNITION SWITCH, INCLUDING POWER BRAKES, POWER STEERING, AND HEADLIGHTS. I FOUND OUT THAT MY IGNITION SWITCH HAD MALFUNCTIONED. I CALLED VW OF AMERICA (1-800-822-8987), AND THEY TOLD ME THAT A RECALL WAS OUT FOR THE 1996 AND 1997 MODELS. THE ONLY DIFFERENCE BETWEEN THESE TWO MODEL YEARS AND MY MODEL YEAR IS THE SWITCH IN THE ON BOARD DIAGNOSTIC SYSTEM FROM OBD 1 TO OBD 2. I KNEW FROM EXPERIENCE THAT THE IGNITION SWITCH WAS THE SAME FOR ALL 1995 TO 1997 PASSATS, BUT JUST TO BE SURE, I CALLED STEVENS CREEK VOLKSWAGEN PARTS DEPARTMENT (1-408-492-1200). THE GUY THERE TOLD ME THAT PART NUMBERS MATCHED THROUGH ALL 3 YEARS, AND THAT THE IGNITION SWITCH MALFUNTCIONS AN ALL 3 MODEL YEARS INCLUDING 1995. SO, I CALLED VW OF AMERICA AGAIN, AN ASKED THEM WHY THEY DIDN'T RECALL MY MODEL YEAR. THEY STATED THAT "VW COULD HAVE RECTIFIED THE PROBLEM" WHICH IS IMPOSSIBLE WHEN ALL 3 PART NUMBERS ARE THE SAME. THEY THEN SAID THAT THEY WOULD LAUNCH THEIR OWN INVESTIGATION INTO IT, AND TOLD ME TO CALL NHTSA. MY FINAL SAY ON THIS MATTER IS THAT IT DEFINITELY IS LIFE THREATENING, BECAUSE THE IGNITION SWITCH IS ELECTRICAL, AND CAN MALFUNTCION AT AND TIME, CAUSING YOU TO LOSE POWER STEERING, BRAKES, AND LIGHTING ON THE ROAD. I WAS LUCK BECAUSE I JUST GOT GOING, AND WAS ABLE TO PUSH THE CAR BACK BY MY HOUSE. MEANWHILE, VOLKSWAGEN OF AMERICA IS CUTTING CORNERS TO SAVE MONEY BY ONLY RECALLING THE MODEL YEARS THAT YOU HAVE TESTED, EVEN THOUGH THE MALFUNCTIONING PART IS THE SAME INALL 3 MODEL YEARS: 1995, 1996, AND 1997. AS A MEMBER OF A VW VORTEX FORUM, I WILL TELL OTHERS WITH THIS SAME PROBLEM TO WRITE IN TO YOU.
NHTSA complaint #10062619 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
FRONT END WAS MAKING A RATTLING NOISE. ALSO, RADIATOR OVERHEATED. TOOK VEHICLE TO DEALER, AND THEY REPLACED THE HEAD GASKET.
NHTSA complaint #10060957 — an unverified report by a vehicle owner.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
REAR DOOR LATCH IS MALFUNCTIONING. LATCH RELEASES WHEN DRIVING
NHTSA complaint #10057073 — an unverified report by a vehicle owner.