2021 Volkswagen Passat problems

AIR BAGS

I was parking my car and then I heard a loud crack. Then I noticed my car's airbag malfunction warning notice came up on the dashboard along with other failures. I can see on the edges of the horn panel on the left that its slightly detached, so it seem the airbag has somewhat inflated. I haven't taken it to the dealer yet, but will later after work. I didn't notice any issues prior to this happening

NHTSA complaint #11701230 — an unverified report by a vehicle owner.

SERVICE BRAKES

Driving home from work around 1:00 am at night with street lights and no other cars in the vicinity the auto brake engaged, causing an abrupt stop. Once the auto brake ceased I was able to complete my trip. There was a light coating of water in a spot on the road but nothing else and no reason for this to occur.

NHTSA complaint #11692184 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Driving home from work around 1:00 am at night with street lights and no other cars in the vicinity the auto brake engaged, causing an abrupt stop. Once the auto brake ceased I was able to complete my trip. There was a light coating of water in a spot on the road but nothing else and no reason for this to occur.

NHTSA complaint #11692184 — an unverified report by a vehicle owner.

EQUIPMENT

See attached document for complaint.

NHTSA complaint #11682324 — an unverified report by a vehicle owner.

EQUIPMENT:ELECTRICAL:INFOTAINMENT

See attached document for complaint.

NHTSA complaint #11682324 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2021 Volkswagen Passat. The contact stated that while stopped at a red traffic light, the engine stalled. The low oil pressure and the battery warning lights were illuminated. The contact was able to restart the vehicle. The vehicle was taken to a local independent mechanic, where it was diagnosed that the piston ring and engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 37,995.

NHTSA complaint #11678501 — an unverified report by a vehicle owner.

AIR BAGS

Known issue in previous VW models. Broken clock spring in steering wheel from normal <100k miles no connection for all steering wheel electronics (airbags, radio controls, etc)

NHTSA complaint #11648017 — an unverified report by a vehicle owner.

STEERING

Known issue in previous VW models. Broken clock spring in steering wheel from normal <100k miles no connection for all steering wheel electronics (airbags, radio controls, etc)

NHTSA complaint #11648017 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Known issue in previous VW models. Broken clock spring in steering wheel from normal <100k miles no connection for all steering wheel electronics (airbags, radio controls, etc)

NHTSA complaint #11648017 — an unverified report by a vehicle owner.

STRUCTURE:BODY

There is a headlight chrome accent piece right above the left headlight that one day just blew off the vehicle when driving down the highway. Oddly enough, I live in a small town of Mason City, IA and I saw another VW Passat (same year) missing the same exact piece so I know this is a vehicle defect. You also can not just replace this one part, it costs over $1,000 to replace the full headlight assemble. I hope others report this defect as this is very dangerous when you have chrome pieces flying off your vehicle when it is not even windy and the vehicle has never had any other damage.

NHTSA complaint #11627446 — an unverified report by a vehicle owner.

TIRES:SIDEWALL

I own a 2021 Volkswagen Passat R-Line that has GITI 235/40R19 Comfort tires, I have had bubbles on two of the tires that blew out going down the interstate. I now have a third tire with the same issue.

NHTSA complaint #11569898 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I have encountered severe and unresolved issues with the vehicle, and despite multiple visits to Serramonte VW dealership, the problems persist. I leased this car from VW Serramonte on 8/29/2021, and their contact information is as follows: Serramonte Volkswagen 711 Serramonte Blvd. Colma, CA 94014 (650) 756- 9000 www.serramontevw.com To provide context, the vehicle began experiencing unresolved electrical problems at just 7,000 miles. Despite repeated attempts for repairs at the dealership, these issues persist. Additionally, at only 9,000 miles, abnormal wear on the rear brake pads and rotors was discovered, requiring replacement. The dealership acknowledged the unusual nature of this problem, stating that it typically occurs after 30,000 miles in a typical car. The combination of these issues in a new vehicle with such low mileage is concerning and raises questions about the vehicle's quality and safety standards.

NHTSA complaint #11549058 — an unverified report by a vehicle owner.

SERVICE BRAKES

I have encountered severe and unresolved issues with the vehicle, and despite multiple visits to Serramonte VW dealership, the problems persist. I leased this car from VW Serramonte on 8/29/2021, and their contact information is as follows: Serramonte Volkswagen 711 Serramonte Blvd. Colma, CA 94014 (650) 756- 9000 www.serramontevw.com To provide context, the vehicle began experiencing unresolved electrical problems at just 7,000 miles. Despite repeated attempts for repairs at the dealership, these issues persist. Additionally, at only 9,000 miles, abnormal wear on the rear brake pads and rotors was discovered, requiring replacement. The dealership acknowledged the unusual nature of this problem, stating that it typically occurs after 30,000 miles in a typical car. The combination of these issues in a new vehicle with such low mileage is concerning and raises questions about the vehicle's quality and safety standards.

NHTSA complaint #11549058 — an unverified report by a vehicle owner.

SERVICE BRAKES

Rear brakes needed to be replaced at 17,000 miles. Same thing happened to my wife’s 2021 Passat.

NHTSA complaint #11542362 — an unverified report by a vehicle owner.

SERVICE BRAKES

Rear brakes needed to be replaced at less than 20k miles The dealer comped it since we lease 2 different 2021 VW Passats and they both needed their rear wheels replaced at sub 20k miles

NHTSA complaint #11542363 — an unverified report by a vehicle owner.

SERVICE BRAKES

The contact owns a 2021 Volkswagen Passat. The contact stated that the rear brake pads were generating an excessive amount of brake dust. The dealer was notified. The contact stated that he was informed a year later at a vehicle State Inspection, that the rear brakes were significantly worn. The vehicle was taken to the dealer, where it was diagnosed that there was an uneven brake wear as the rear brakes were prematurely worn while the front brakes were in very good condition. The dealer notified the manufacturer, who informed the dealer that there would be no assistance as the vehicle was not covered under warranty. The vehicle was not repaired. The failure mileage was approximately 5,000.

NHTSA complaint #11530411 — an unverified report by a vehicle owner.

LANE DEPARTURE: ASSIST

The vehicle lane assistance feature for my 2021 Volkswagen Passat nearly caused me to collide with another vehicle on two separate occasions. While driving home on my regular route, there are many cross streets where intersecting traffic may cross in order to facilitate a left turn. On one such occasion a vehicle pulling a utility trailer crossed in front of me but did not proceed through entirely, leaving the trailer sticking out into the lane ahead of me. As I approached I attempted to pilot the car into the right lane adjacent to me, in order to avoid a collision. The lane assist feature took control of the vehicle's steering, pulling me back on a collision-course toward the trailer and other vehicle. I was forced to wrest control of the wheel in order to avoid the other vehicle resulting in a near-miss. Several days later a similar occurrence happened, causing me to lose confidence in the vehicle entirely. This feature can not be permanently disabled, meaning that each and every time I start the car, I am forced to actively disable it. Should I forget to do so, I am in danger of another similar incident. A phone call to Volkswagen confirmed that there is no way to disable this feature permanently, and there is no intent to make an update to vehicle software. This feature, rather than assisting in the safety of individuals, is actively putting lives at risk! Volkswagen refused to offer a vehicle buy-back. I think that the dangers posed here are enough to investigate and also to mandate that manufacturers offer an option to permanently disable the active lane assist feature.

NHTSA complaint #11493921 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2021 Volkswagen Passat. The contact stated that while driving in the rain at an undisclosed speed, the Lane Departure Assist malfunctioned, causing the steering wheel to inadvertently move to the right or left. Additionally, the high-beam headlights were aimed too high upwards, making it difficult for the contact to see the road ahead. The vehicle was taken to the dealer, but the dealer informed the contact that the Lane Departure Assist function could not be deactivated and that the high-beam headlights could not be adjusted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100.

NHTSA complaint #11442406 — an unverified report by a vehicle owner.

LANE DEPARTURE: ASSIST

The contact owns a 2021 Volkswagen Passat. The contact stated that while driving in the rain at an undisclosed speed, the Lane Departure Assist malfunctioned, causing the steering wheel to inadvertently move to the right or left. Additionally, the high-beam headlights were aimed too high upwards, making it difficult for the contact to see the road ahead. The vehicle was taken to the dealer, but the dealer informed the contact that the Lane Departure Assist function could not be deactivated and that the high-beam headlights could not be adjusted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100.

NHTSA complaint #11442406 — an unverified report by a vehicle owner.

LANE DEPARTURE: LANE KEEP: AUTOMATIC STEERING

The contact owns a 2021 Volkswagen Passat. The contact stated that while driving through a pedestrian intersection with thick white lines, the vehicle automatically veered to the left or right. The contact stated that the failure occurred while driving 30 to 45 MPH. The contact had not contacted the manufacturer or the dealer. The failure mileage was 27,232.

NHTSA complaint #11441566 — an unverified report by a vehicle owner.