Owners have filed 779 complaints
about the 2006 Volkswagen Passat with NHTSA between 2005 and 2025.
The largest single group is the airbags.
Across this model's run it ranks 6 of 30 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Volkswagen Passat. 50 means typical for this
model; 100 means roughly double.
Severity — 25
4.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 42
24% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2006 compares with every other Volkswagen Passat
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
254.3%
1,000 – 9,999 miles
498.5%
10,000 – 24,999 miles
518.8%
25,000 – 49,999 miles
6912.0%
50,000 – 74,999 miles
14124.4%
75,000 – 99,999 miles
8915.4%
100,000 – 149,999 miles
11920.6%
150,000+ miles
345.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Oct 2005peak 19Oct 2025
NHTSA investigations into the 2006 Volkswagen Passat
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA11002Opened 26 Jan 2011Closed 17 Feb 2012ELECTRICAL SYSTEM
Engine Compartment Fire
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire report...
Recalls on the 2006 Volkswagen Passat
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
24V834000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
18V247000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2007 Volkswagen Passat sedan and wagon vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
17V509000
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2016 Volkswagen CC, 2006-2010 Passat and Passat Wagon vehicles. Interruption of electrical power to the fuel pump control module may cause the fuel pump to fail.
Risk: If the fuel pump fails, the engine will stall, increasing the risk of a crash.
16V079000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2006 Volkswagen Passat sedans and wagons, 2005-2013 Audi A3, and 2006-2009 Audi A4 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
06V472000
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.0L ENGINE WITH 147 KW MAY HAVE A VACUUM LINE THAT MAY FRACTURE AND BECOME DISCONNECTED AT LOW AMBIENT TEMPERATURES.
Risk: IF THIS HAPPENS, THE BRAKE POWER ASSIST CAN BECOME INOPERATIVE, AND THE DRIVER WILL EXPERIENCE INCREASED EFFORT TO APPLY THE BRAKES POSSIBLY INCREASING VEHICLE STOPPING DISTANCE. THIS COULD LEAD TO A CRASH WITHOUT WARNING.
06V470000
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
ON CERTAIN '6' GENERATION PASSENGER VEHICLES, THE WIPER MOTOR MAY FAIL DURING HEAVY RAIN DUE TO EXCESSIVE MOISTURE ENTERING THE WIPER MOTOR. IF THIS HAPPENS, THE WIPERS CAN BECOME INOPERATIVE.
Risk: THIS COULD LEAD TO REDUCED VISIBILITY INCREASING THE RISK OF A CRASH WITHOUT WARNING.
05V540000
STEERING:LINKAGES:TIE ROD ASSEMBLY
ON CERTAIN PASSENGER VEHICLES, THE LEFT AND RIGHT TIE ROD SECURING NUT MAY BE INSUFFICIENTLY TORQUED.
Risk: AN INSUFFICIENTLY TIGHTENED TIE ROD NUT MAY LOOSEN, RESULTING IN SEPARATION OF A TIE ROD. THIS CAN CAUSE A LOSS OF STEERING CONTROL, WHICH COULD CAUSE A CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202464918,995 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Volkswagen will notify owners by mail and advise you to take your vehicle to a dealership to replace the driver-front airbag. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 20181923,339 units in Canada
Airbag
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the driver frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the driver frontal airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected. Additional Note: This recall replaces Volkswagen recall 69M8 (TC 2016-065). Volkswagen vehicles that were not repaired under recall 69M8 (TC 2016-065) require repair under this recall.
Recall 201739819,508 units in Canada
Fuel System
On certain vehicles, there could be an interruption in electrical power to the fuel pump control module. This could result in the fuel pump running continuously, resulting in a drained battery and/or a no start condition, or cause a loss of motive power while the vehicle is in motion, which could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the fuel pump control module and relocate it within the vehicle.
Recall 201606515,039 units in Canada
Airbag
On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Correction: Dealers will replace the front driver airbag inflator. Note: This only affects the Cabriolet versions of the Audi A4 and S4 models.
Recall 20063403,381 units in Canada
Brakes
On certain Passat and Passat wagon, a vacuum line may fracture and become disconnected at low ambient temperatures. If this happens, brake power assist could become inoperative. As a result, the driver would experience increased effort to apply the brakes and therefore possible increased vehicle stopping distance. This could lead to a crash without warning. Correction: Dealers will install a re-designed vacuum line.
Recall 20063392,896 units in Canada
Electrical
On certain Passat and Passat wagon, the wiper motor may fail during heavy rain due to moisture intrusion. This could lead to reduced visibility and a crash without warning. Correction: Dealers will install a special cover and sealing kit.
Reports where the owner recorded a crash, a fire, an injury or a death.
New Tripoli, PACrashFire
AIR BAGS
The contact owned a 2006 Volkswagen Passat. The contact stated that while her husband was driving in traffic, he rear-ended a vehicle at approximately 25 MPH. The air bags did not deploy upon impact. While her husband was exchanging information with the other driver, the other driver alerted him that his vehicle had caught fire. As her husband attempted to retrieve a fire extinguisher from the truck, he was alerted that the fire had worsened and was instructed to move away from the vehicle. Within minutes, the vehicle became engulfed in flames and was incinerated. A police report was filed. No injuries were reported. The contact had the vehicle towed to her home where it remained in her possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was a total loss. The failure mileage was unknown. The VIN was not available.
NHTSA complaint #11483092 — an unverified report by a vehicle owner.
New Tripoli, PACrashFire
ENGINE
The contact owned a 2006 Volkswagen Passat. The contact stated that while her husband was driving in traffic, he rear-ended a vehicle at approximately 25 MPH. The air bags did not deploy upon impact. While her husband was exchanging information with the other driver, the other driver alerted him that his vehicle had caught fire. As her husband attempted to retrieve a fire extinguisher from the truck, he was alerted that the fire had worsened and was instructed to move away from the vehicle. Within minutes, the vehicle became engulfed in flames and was incinerated. A police report was filed. No injuries were reported. The contact had the vehicle towed to her home where it remained in her possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was a total loss. The failure mileage was unknown. The VIN was not available.
NHTSA complaint #11483092 — an unverified report by a vehicle owner.
at 91,000 milesPalm Beach Gardens, FL1 injured
POWER TRAIN
THE AUTOMATIC TRANSMISSIONS USED IN THE B6 VOLKSWAGEN PASSAT 2.0T ALONG WITH SEVERAL OTHER VW MODELS ARE NOTORIOUSLY PROBLEMATIC. THERE WAS A RECALL ON THE TRANSMISSION CONTROL UNIT NEEDING A SOFTWARE UPDATE WHICH WAS DONE ON MY VEHICLE, HOWEVER THIS DOES NOT ADDRESS THE REAL ISSUE WITH THESE TRANSMISSIONS. THE WIDESPREAD AND MORE SERIOUS ISSUE WITH THESE TRANSMISSIONS IS THE VALVE BODY ASSEMBLY PART OF THE TRANSMISSION CAUSING HARD SHIFTS USUALLY BETWEEN FIRST AND SECOND OR THIRD AND FOURTH GEAR. THESE HARD SHIFTS CAUSE THE ENTIRE CAR AND IT'S PASSENGERS TO JERK VIOLENTLY DURING UPSHIFTS AND SOMETIMES DOWNSHIFTS BETWEEN THESE GEARS. AT ONLY 91,000 MILES AND WELL TAKEN CARE OF MY CAR HAS DEVELOPED THIS PROBLEM BETWEEN THIRD AND FOURTH GEAR MAKING IT FEEL VERY DANGEROUS AND UNSETTLING FOR THE DRIVER AND PASSENGERS OF THE VEHICLE WHEN GETTING UP TO SPEED ESPECIALLY ON ON-RAMPS TO THE HIGHWAY. I ALSO WANT TO MENTION THAT THIS PROBLEM HAS DESTROYED MY MOTOR MOUNTS AS WELL. VW SHOULD TAKE RESPONSIBILITY FOR THIS DEFECTIVE PART OF THE TRANSMISSION SIMILAR TO THE WAY HONDA DID WITH THEIR ODYSSEY, ONLY THIS DOES NOT REQUIRE THE WHOLE TRANSMISSION TO BE REPLACED LIKE WITH THE ODYSSEY. THIS IS AN ENORMOUS SAFETY CONCERN THAT NEEDS TO BE ACKNOWLEDGED AND ADDRESS BY VOLKSWAGEN, THE LARGEST AUTOMOBILE MANUFACTURER IN THE WORLD.
NHTSA complaint #11326103 — an unverified report by a vehicle owner.
at 120,000 milesSanta ANA, CACrash
UNKNOWN OR OTHER
FRONT GRILL OF THE VEHICLE IS DENTED BUT NOT DAMAGED. CAR WORKS PERFECTLY FINE. JUST NEEDS SLIGHT BODY WORK, BUT OTHER THAN THAT, VEHICLE IS OPERATIVE. IT WAS ON HIGHWAY 91 W NEAR IMPERIAL EXIT AND TRAFFIC WAS STOP AND GO. AS TRAFFIC WAS PICKING BACK UP, VEHICLE IN FRONT OF ME CONTINUED TO PRESS FORWARD AND BY THE TIME I HIT MY BREAKS, I SLIGHTLY HIT THE BACK OF THEIR BUMPER AND DENTED MY GRILL.
NHTSA complaint #11163278 — an unverified report by a vehicle owner.
at 150,000 milesBuena Park, CACrash
VEHICLE SPEED CONTROL
I WAS BACKING OUT OF A PARKING SPACE WITH THE CAR IN REVERSE. I LIFTED MY FOOT FROM THE BRAKE AND STARTED TO APPLY THE ACCELERATOR AT WHICH POINT THE VEHICLE ACCELERATED TO FULL SPEED AND HIT A STAIRCASE RAIL BEHIND ME. I THEN SLAMMED THE BRAKE AND PUT THE CAR INTO DRIVE TO AVOID REVERSING INTO ANYONE. I APPLIED THE ACCELERATOR AND ONCE AGAIN IT ACCELERATED FORWARD AT FULL SPEED, THIS TIME HITTING A CONCRETE COLUMN WHICH DISABLED THE VEHICLE.
NHTSA complaint #11140332 — an unverified report by a vehicle owner.
at 80,000 milesBend, ORCrash
FUEL/PROPULSION SYSTEM
RECEIVED A RECALL NOTICE 10/2017 MY VEHICLE EXPERIENCED A LOSS OF MOTIVE POWER - ALMOST CRASHED - HAD REPAIR COMPLETED SENT LETTER TO VOLKSWAGEN 12/2017 - NO RESPONSE, ACTION OR REIMBURSEMENT - CALLED VW TODAY - STILL NO RESPONSE,ACTION OR REIMBURSEMENT FOR PART THE KNOW WOULD FAIL. COULD HAVE BEEN A LARGE SAFETY CONCERN - FEEL VW IS SHIRKING RESPONSABILITY - I HAVE COPIES OF ALL MY BILLS AND RECALL NOTICE -NHTSA:17V509
NHTSA complaint #11101904 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Barstow, MD
AIR BAGS
The contact owned a 2006 Volkswagen Passat . The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.
NHTSA complaint #11692301 — an unverified report by a vehicle owner.
Silver Spring, MD
AIR BAGS
recalled airbag
NHTSA complaint #11671216 — an unverified report by a vehicle owner.
Lutz, FL
FUEL SYSTEM, GASOLINE
The contact owns a 2006 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump module had failed and needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline). The manufacturer was made aware of the failure to obtain assistance with reimbursement. The failure mileage was not available. Parts distribution disconnect.
NHTSA complaint #11660470 — an unverified report by a vehicle owner.
Lutz, FL
ENGINE
The contact owns a 2006 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump module had failed and needed to be replaced. The vehicle was repaired. The contact later received notification of NHTSA Campaign Number: 17V509000 (Fuel System, Gasoline). The manufacturer was made aware of the failure to obtain assistance with reimbursement. The failure mileage was not available. Parts distribution disconnect.
NHTSA complaint #11660470 — an unverified report by a vehicle owner.
Duluth, MN
AIR BAGS
The contact owns a 2006 Volkswagen Passat. The contact received notification of NHTSA Campaign Number: 24V834000 (Air Bags) and would like to be removed from the recall distribution list. The local dealer was contacted however, the manufacturer was not.
NHTSA complaint #11631089 — an unverified report by a vehicle owner.
New York, NY
AIR BAGS
My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the NHTSA, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577635 — an unverified report by a vehicle owner.
New York, NY
ELECTRICAL SYSTEM
My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the NHTSA, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577635 — an unverified report by a vehicle owner.
New York, NY
ENGINE
My family and I have been VW owners for over 60 years. Unfortunately, the 2006 VW Passat has been layered with defects, negligent manufacturing issues, faulty wiring, electrical problems, computer glitches, to mention a few. There have been many recalls including an official recall by the NHTSA, for steering linkage problems and tie rod assembly which caused a loss of steering, crashes and deaths. Over 292 complaints are filed with Consumer Affairs, over 561 defects reported, and thousands of horror stories like mine about this car. It's considered a lemon by many car professionals. Many dealerships in the USA offered to inspect, and replace the electronic steering column lock free of charge and address any other concerns, which should be standard, reasonable behavior for all VW dealerships, mandated by this Federal agency. Shortly after this car almost killed me in 2013, VW put me through countless stressful hours of calls, emails and the like and still refused to be fully accountable. Shortly after my almost end of life, the notorious VW Emissions Scandal spoke volumes. VW was well aware of their defects including the electrical system in the steering column/immobilizer, (the system won’t recognize the key; a module in the car that connects the key and starts the engine is defective). In many cases, the entire steering column is defective and has to be completely replaced because the car’s pistons, internal combustion and engine are all subpar. Even the Sunroof and drains are defective and every time it rains, there is a flood in my car which has caused life threatening mold and mildew. I am respectfully asking for your help in having VW provide me, a near [XXX] woman, a safe, reliable, car without another defective sunroof and without defective water drains. It can be used as long as it's reliable and without deadly mold and mildew. I have photos. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11577635 — an unverified report by a vehicle owner.
Las Vegas, NV
POWER TRAIN
Transmission clunks into gear and loses traction while shifting.
NHTSA complaint #11523759 — an unverified report by a vehicle owner.
at 45,000 milesNew York, NY
ENGINE
The contact owns a 2006 Volkswagen Passat. The contact stated that while approaching an off ramp while driving approximately 45 MPH, the vehicle stalled. There were no warning lights illuminated. The vehicle was towed to the local dealer where an unknown diagnostic test and repair was completed. Additionally, the dealer fractured an unknown part underneath the hood and water entered the vehicle near the sun visor and there was water accumulating on the rear passenger’s side door location. The manufacturer was contacted. The failure mileage was approximately 45,000.
NHTSA complaint #11514628 — an unverified report by a vehicle owner.
Winthrop, MA
POWER TRAIN
We owned vehicle approx 8yrs and in late 2022 will driving/on highway 55mph or local roads like Broadway 15-20mph the vehicle goes into neutral. VErY dangerous it wil work as it should after a restart
NHTSA complaint #11500131 — an unverified report by a vehicle owner.
New Tripoli, PACrashFire
AIR BAGS
The contact owned a 2006 Volkswagen Passat. The contact stated that while her husband was driving in traffic, he rear-ended a vehicle at approximately 25 MPH. The air bags did not deploy upon impact. While her husband was exchanging information with the other driver, the other driver alerted him that his vehicle had caught fire. As her husband attempted to retrieve a fire extinguisher from the truck, he was alerted that the fire had worsened and was instructed to move away from the vehicle. Within minutes, the vehicle became engulfed in flames and was incinerated. A police report was filed. No injuries were reported. The contact had the vehicle towed to her home where it remained in her possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was a total loss. The failure mileage was unknown. The VIN was not available.
NHTSA complaint #11483092 — an unverified report by a vehicle owner.
New Tripoli, PACrashFire
ENGINE
The contact owned a 2006 Volkswagen Passat. The contact stated that while her husband was driving in traffic, he rear-ended a vehicle at approximately 25 MPH. The air bags did not deploy upon impact. While her husband was exchanging information with the other driver, the other driver alerted him that his vehicle had caught fire. As her husband attempted to retrieve a fire extinguisher from the truck, he was alerted that the fire had worsened and was instructed to move away from the vehicle. Within minutes, the vehicle became engulfed in flames and was incinerated. A police report was filed. No injuries were reported. The contact had the vehicle towed to her home where it remained in her possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was a total loss. The failure mileage was unknown. The VIN was not available.
NHTSA complaint #11483092 — an unverified report by a vehicle owner.
West Monroe, LA
AIR BAGS
Stalled out as I started to accelerate from a stop light. It's like not getting and fuel. Possibly some type of issue pertaining to that Then my airbag light keeps flashing. Floor board lights cut on an off for no reason. Electrical equipment Possibly incorrect?
NHTSA complaint #11474741 — an unverified report by a vehicle owner.
at 50,000 milesPearblossom, CA
AIR BAGS
The contact owns a 2006 Volkswagen Passat. The contact stated that the passenger’s side frontal air bag failed to function as designed. The passenger’s side frontal air bag light remained illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the air bag needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure. The approximate failure mileage was 50,000.
NHTSA complaint #11434870 — an unverified report by a vehicle owner.
at 140,000 milesLake Carmel, NY
SERVICE BRAKES
I PURCHASED THIS CAR 2 YEARS AGO AND HAVE HAVE THE PARKING BRAKE FAIL AND BREAK THREE TIMES. THE FIRST TIME WAS SHORTLY AFTER THE PURCHASE AND THE CAR CAME OUT OF GEAR IN MY DRIVEWAY AND BEGAN ROLLING. MY 65 YO MOM HAD TO STOP IT AND PUSH IT UP AS SHE WAS HOME ALONE. IT TURNED ON ANOTHER TIME WHILE I WAS CROSSING AN INTERSECTION AND I WAS ALMOST T-BONED. I HAD IT REPLACED AFTER THIS INCIDENT. IN MAY 2020 THE PARKING BRAKE WOULD NOT DISENGAGE AND I NEEDED TO HAVE IT TOWED TO MY MECHANIC. THE BRAKE WAS STUCK ON AND THE COMPUTER CONTROL UNIT BROKE. I PAID $2500 TO HAVE THE UNIT REPLACED. IN DEC 2020 (ONLY 7 MONTHS LATER) THE EXACT THING HAPPENED AGAIN. I WAS UNABLE TO DISENGAGE THE PARKING BRAKE AND NEEDED TO TOW IT TO MY MECHANIC. THE CALIPER AND COMPUTER BROKE AGAIN. THE COST IS SIMILAR. THIS IS A SAFETY ISSUE. IF YOU LOOK AT ANY VW FORUMS YOU WILL SEE THIS IS A KNOWN ISSUE WITH MANY PEOPLE HAVING THEIR BRAKE STUCK AND UNABLE TO ENGAGE/DISENGAGE THE UNIT. I REACHED OUT TO VW AND HAD NO RESOLUTION. I REQUEST THE PARKING BRAKE BE RECALLED AND EVERYONE WHO HAD WORK DONE ON IT, INCLUDING MYSELF, RECEIVED A FULL REFUND.
NHTSA complaint #11385604 — an unverified report by a vehicle owner.
at 55,000 milesRoanoke, TX
ENGINE
WE HAVE 2006 3.6L VW PASSAT WITH 55K MILES FOR MY DAUGHTER. JUST RECENTLY THE OIL LIGHT CAME ON AND THE ENGINE SEIZED WHILE DRIVING UNDER 30 MPH. IT HAD BEEN RUNNING GOOD AND NO OIL WAS LEAKING. THIS SEEMS TO BE RELATED TO AN ISSUE MANY OTHER PASSAT OWNERS EXPERIENCED WHERE THE OIL PUMP BOLT BECOMES LOSE AND CAUSES A FATAL FAILURE.
NHTSA complaint #11383386 — an unverified report by a vehicle owner.
at 119,521 milesRaleigh, NC
FUEL/PROPULSION SYSTEM
I HAVE A GAS LEAK COMING FROM THE TOP OF THE GAS TANK. VERY HEAVY FUMES COMING IN THE CAR AND AROUND THE CAR. WHEN THE CAR IS IN MOTION AND STATIONARY.
NHTSA complaint #11337828 — an unverified report by a vehicle owner.
at 211,742 milesRipley, WV
POWER TRAIN
HAVE REPLACED NUMEROUS PARTS ...THE EPX LIGHT KEEPS COMING ON WHICH MAY REFERENCE TO THE OIL PUMP BOLT FAILING...CRANKSHAFT AND CAM SHAFTS CODES KEEP COMING ON EVEN THOUGH THEY WERE REPLACED...TRANSMISSION SHIFTING SLIGHTLY HARD.. OVERHEATING EVEN THOUGH NEW PARTS WERE INSTALLED...AIR BAG LIGHT STAYS ON..BRAKES HAVE BEEN BLEED OVER 10 TIMES AND ARE STILL TOO SOFT CAUSE ME TO BRAKE AT A FURTHER DISTANCE TO AVOID A WRECK....I AM ON A FIXED INCOME AND CANT AFFORD A MASSAGE BILL TO FIX IT AND VW IS AWARE OVER THESE YEARS OF THE ISSUES AND WONT RECALL TO REPAIR ANY OF THE ISSUES...I HAVE ALL RECEIPTS FOR THE PARTS REPLACED...
NHTSA complaint #11329365 — an unverified report by a vehicle owner.
at 211,742 milesRipley, WV
ENGINE
HAVE REPLACED NUMEROUS PARTS ...THE EPX LIGHT KEEPS COMING ON WHICH MAY REFERENCE TO THE OIL PUMP BOLT FAILING...CRANKSHAFT AND CAM SHAFTS CODES KEEP COMING ON EVEN THOUGH THEY WERE REPLACED...TRANSMISSION SHIFTING SLIGHTLY HARD.. OVERHEATING EVEN THOUGH NEW PARTS WERE INSTALLED...AIR BAG LIGHT STAYS ON..BRAKES HAVE BEEN BLEED OVER 10 TIMES AND ARE STILL TOO SOFT CAUSE ME TO BRAKE AT A FURTHER DISTANCE TO AVOID A WRECK....I AM ON A FIXED INCOME AND CANT AFFORD A MASSAGE BILL TO FIX IT AND VW IS AWARE OVER THESE YEARS OF THE ISSUES AND WONT RECALL TO REPAIR ANY OF THE ISSUES...I HAVE ALL RECEIPTS FOR THE PARTS REPLACED...
NHTSA complaint #11329365 — an unverified report by a vehicle owner.
at 211,742 milesRipley, WV
SERVICE BRAKES
HAVE REPLACED NUMEROUS PARTS ...THE EPX LIGHT KEEPS COMING ON WHICH MAY REFERENCE TO THE OIL PUMP BOLT FAILING...CRANKSHAFT AND CAM SHAFTS CODES KEEP COMING ON EVEN THOUGH THEY WERE REPLACED...TRANSMISSION SHIFTING SLIGHTLY HARD.. OVERHEATING EVEN THOUGH NEW PARTS WERE INSTALLED...AIR BAG LIGHT STAYS ON..BRAKES HAVE BEEN BLEED OVER 10 TIMES AND ARE STILL TOO SOFT CAUSE ME TO BRAKE AT A FURTHER DISTANCE TO AVOID A WRECK....I AM ON A FIXED INCOME AND CANT AFFORD A MASSAGE BILL TO FIX IT AND VW IS AWARE OVER THESE YEARS OF THE ISSUES AND WONT RECALL TO REPAIR ANY OF THE ISSUES...I HAVE ALL RECEIPTS FOR THE PARTS REPLACED...
NHTSA complaint #11329365 — an unverified report by a vehicle owner.
at 91,000 milesPalm Beach Gardens, FL1 injured
POWER TRAIN
THE AUTOMATIC TRANSMISSIONS USED IN THE B6 VOLKSWAGEN PASSAT 2.0T ALONG WITH SEVERAL OTHER VW MODELS ARE NOTORIOUSLY PROBLEMATIC. THERE WAS A RECALL ON THE TRANSMISSION CONTROL UNIT NEEDING A SOFTWARE UPDATE WHICH WAS DONE ON MY VEHICLE, HOWEVER THIS DOES NOT ADDRESS THE REAL ISSUE WITH THESE TRANSMISSIONS. THE WIDESPREAD AND MORE SERIOUS ISSUE WITH THESE TRANSMISSIONS IS THE VALVE BODY ASSEMBLY PART OF THE TRANSMISSION CAUSING HARD SHIFTS USUALLY BETWEEN FIRST AND SECOND OR THIRD AND FOURTH GEAR. THESE HARD SHIFTS CAUSE THE ENTIRE CAR AND IT'S PASSENGERS TO JERK VIOLENTLY DURING UPSHIFTS AND SOMETIMES DOWNSHIFTS BETWEEN THESE GEARS. AT ONLY 91,000 MILES AND WELL TAKEN CARE OF MY CAR HAS DEVELOPED THIS PROBLEM BETWEEN THIRD AND FOURTH GEAR MAKING IT FEEL VERY DANGEROUS AND UNSETTLING FOR THE DRIVER AND PASSENGERS OF THE VEHICLE WHEN GETTING UP TO SPEED ESPECIALLY ON ON-RAMPS TO THE HIGHWAY. I ALSO WANT TO MENTION THAT THIS PROBLEM HAS DESTROYED MY MOTOR MOUNTS AS WELL. VW SHOULD TAKE RESPONSIBILITY FOR THIS DEFECTIVE PART OF THE TRANSMISSION SIMILAR TO THE WAY HONDA DID WITH THEIR ODYSSEY, ONLY THIS DOES NOT REQUIRE THE WHOLE TRANSMISSION TO BE REPLACED LIKE WITH THE ODYSSEY. THIS IS AN ENORMOUS SAFETY CONCERN THAT NEEDS TO BE ACKNOWLEDGED AND ADDRESS BY VOLKSWAGEN, THE LARGEST AUTOMOBILE MANUFACTURER IN THE WORLD.
NHTSA complaint #11326103 — an unverified report by a vehicle owner.
at 128,000 milesOdessa, TX
STEERING
TRYING TO START CAR AND WON'T TURN ON WITH KEY ALL MY KEYS DON'T WORK SAYS STEERING WHEEL LOCK DEFECTIVE CAN'T GET MY CAR TO TURN MY RADIO ON I AM PARKED IN MY DRIVE WAY AND CAN'T EVEN TOW IT TO DEALER NOW BECAUSE IT WON'T GO INTO NEUTRAL.
NHTSA complaint #11324052 — an unverified report by a vehicle owner.
at 128,000 milesOdessa, TX
ELECTRICAL SYSTEM
TRYING TO START CAR AND WON'T TURN ON WITH KEY ALL MY KEYS DON'T WORK SAYS STEERING WHEEL LOCK DEFECTIVE CAN'T GET MY CAR TO TURN MY RADIO ON I AM PARKED IN MY DRIVE WAY AND CAN'T EVEN TOW IT TO DEALER NOW BECAUSE IT WON'T GO INTO NEUTRAL.
NHTSA complaint #11324052 — an unverified report by a vehicle owner.
at 150,000 milesPahrump, NV
SERVICE BRAKES
WHEN STOPPED AND START GOING AND GET TO ABOUT 30 MPH AND SHIFTS INTO THIRD GEAR THE EMERGENCY BRAKE SYSTEM ENGAGES AND I CAN BARELY MOVE. I HAVE TO TURN MY VW PASSAT OFF, WAIT A COUPLE MINUTES AND TURN IT BACK ON FORM THE EMERGENCY BRAKE TO DISLODGE. EXAMPLE: I'M IN VEGAS AT A STOP LIGHT IT TURNS GREEN SO IM GOING UP A ON RAMP TO GET ON FREEWAY AND AS SOON AS I ACCELERATE AND CAR SHIFTS INTO 3RD GEAR A YELLOW P WITH A CIRCLE AROUND IT COMES ON MY DASH AND WHEN I PUSH ON THE GAS ( I HAD MANY CARS BEHIND ME) MY CAR REVVED UP BUT WOULD NOT GO BECAUSE THE EMERGENCY PARKING BRAKE CAME ON. AND IT CONTINUES TO DO IT TO ME. IF I CAN GET PAST THIRD GEAR IT'S FINE AND 1ST AND 2ND GEAR ARE OK. I JUST PURCHASED THE CAR AND CALLED ON RECALLS THERE WEREN'T ANY. THIS ALMOST MADE ME HAVE A SERIOUS ACCIDENT ON MY WAY HOME THE SAME DAY. BECAUSE I HAVE TO GO OVER A PASS TO GET HOME IT DID IT TO ME 4 TIMES AND THE LAST TIME CP8LD OF KILLED ME. IVE BEEN READING THE PROBLEM OTHERS ARE HAVING WITH VEHICLE AND THEY ARE THE SAME AS MINE. BRAKING SYSTEM FAILURE ON 2006 VOLKSWAGON PASSAT. PLEASE HELP US WHO CAN NOT AFFORD TO PAY TO HAVE IT FIXED. AND I CANT SELL IT BECAUSE I CANT LET SOMONE ELSE GET HURT. THIS IS MY ONLY TRANSPORTATION AND I LOVE MY CAR. BUT NOW I'M SCARED TO DRIVE NOW. I CAN'T AFFORD TO FIX IT AND CAN'T RISK SELLING IT AND NOW HAVE NOTHING TO GET TO WORK. PLEASE HELP. THANK YOU
NHTSA complaint #11298582 — an unverified report by a vehicle owner.