Owners have filed 2,001 complaints
about the 2005 Dodge Durango with NHTSA between 2004 and 2025.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 5 of 28 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Dodge Durango. 50 means typical for this
model; 100 means roughly double.
Severity — 31
6.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 31
18% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Tank Assembly
7626.7%
Filler Pipe AND CAP
6823.9%
Engine
6221.8%
Automatic Transmission
3612.6%
Instrument Cluster/Panel
134.6%
Control Module (Tcm/Pcm/Tecm)
113.9%
Body
113.9%
Gasoline
82.8%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
412.4%
1,000 – 9,999 miles
925.4%
10,000 – 24,999 miles
865.1%
25,000 – 49,999 miles
22713.4%
50,000 – 74,999 miles
38222.6%
75,000 – 99,999 miles
31018.3%
100,000 – 149,999 miles
33820.0%
150,000+ miles
21712.8%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2005 Dodge Durango 4-DR.
—
—
—
19.1% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2004peak 35Feb 2025
NHTSA investigations into the 2005 Dodge Durango
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
EA06004Opened 9 Mar 2006Still openSTEERING
STEERING WHEEL AND STEERING SHAFT BOLTS
ON MARCH 9, 2006 ODI UPGRADED PRELIMINATRY EVALUATION PE05-056 TO ENGINEERNING ANALYSIS EA06-004 TO INVESTIGATE ALLEGATIONS OF LOOSE OR MISSING STEERING SHAFT COUPLING BOLTS AND STEERING COLUMN RETAINING BOLTS IN MODEL YEAR (MY) 2004 THROUGH 2006 DODGE DURANGO SPORT UTILITY VEHICLES AND MY 2005 THROUGH 2006 DODGE DAKOTA PICKUP TRUCKS.EITHER CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL.ALTHOUGH ODI IDENTIFIED SOME QUALITY ISSUES IN THE MANUFACTURING PROCESSES FOR THE DAKOTA AND DURANGO VEHICLES, THE DATA DO NOT INDICATE THAT A SAFETY DEFECT TREND IS PRESENT IN EITHER POPULATION.THE FAIL...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
AQ10001Opened 18 Nov 2010Closed 28 Dec 2015UNKNOWN OR OTHER
Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this...
RQ08005Opened 28 Jul 2008Closed 9 Jan 2009FUEL SYSTEM, GASOLINE:STORAGE
FUEL SPIT-BACK DURING REFUELING
IN ITS LETTER DATED JANUARY 6, 2009, CHRYSLER INFORMED THE AGENCY THAT IT WILL EXPAND THE SCOPE OF RECALL 05V-034 TO INCLUDE APPROXIMATELY 19,000 ADDITIONAL MY 2005 DODGE DURANGO VEHICLES BUILT FROM 10/13/04 THROUGH 11/30/04 (REFER TO RECALL 09V-003).DEALERS WILL INSPECT THE INLET CHECK VALVES AND REPLACE THE FUEL TANK ASSEMBLY IF NECESSARY.IN MARCH 2005, CHRYSLER INITIATED A SAFETY RECALL OF APPROXIMATELY 24,000 MY 2005 DODGE DURANGO VEHICLES BUILT FROM 3/1/04 TO 10/12/04 (REFER TO RECALL 05V-034).THE RECALL WAS CONDUCTED TO REMEDY FUEL-SPIT BACK PROBLEMS CAUSED BY STUCK INLET CHECK VALVES IN...
EA06015Opened 28 Aug 2006Closed 15 Mar 2007ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
INSTRUMENT PANEL FIRES
THIS INVESTIGATION ORIGINATED FROM COMPLAINTS RECEIVED BY THE AGENCY REPORTING INSTRUMENT PANEL (IP) FIRES ON VEHICLES THAT WERE COVERED UNDER A PRIOR RECALL (RECALL 03V528) BY DAIMLER CHRYSLER (DCC) TO CORRECT A CRACKED CAPACITOR IN THE IP.DCC HAS NOW IDENTIFIED ANOTHER CONDITION THAT CAN CAUSE OVERHEATING OF AN INTEGRATED CIRCUIT THAT CONTROLS INTERIOR LIGHTING.THIS CONDITION AFFECTS CERTAIN MODEL YEAR 2004-2006 DODGE DURANGO VEHICLES.DCC'S MARCH 6, 2007 LETTER TO THE AGENCY STATES, UNDER CERTAIN OPERATING CONDITIONS, AN INTEGRATED CIRCUIT LOCATED IN THE INSTRUMENT CLUSTER MAY OVERHEAT AND R...
EA05018Opened 2 Nov 2005Closed 29 Aug 2007POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
ENGINE STALL
ANALYSIS OF THE COMPLAINT, FIELD REPORT AND WARRANTY DATA SHOWS THAT THE MAJORITY OF STALLING INCIDENTS IN THE SUBJECT VEHICLES APPEAR TO BE RELATED TO THE ENGINE CALIBRATION CONCERNS THAT DAIMLERCHRYSLER ADDRESSED WITH SERVICE BULLETINS RELEASING REVISED PCM SOFTWARE.ANALYSIS OF THE COMPLAINTS AND ODI'S SURVEY OF OWNERS OF VEHICLES THAT RECEIVED ENGINE MANAGEMENT SOFTWARE UPDATES UNDER TSB #18-013-05 SHOW THAT THESE STALLING INCIDENTS HAVE THE FOLLOWING CHARACTERISTICS: - THEY OCCUR AT LOW SPEEDS, OFTEN DURING PARKING LOT ORDRIVEWAY MANEUVERS; - THEY OCCUR DURING DECELERATIONS, SUCH AS BRAKIN...
Recalls on the 2005 Dodge Durango
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
16V352000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mits
Risk: These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V313000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
14V770000
AIR BAGS
Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
09V003000
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
CHRYSLER IS RECALLING 18,951 MY 2005 DODGE DURANGO VEHICLES. THE FUEL TANK FILLER TUBE INLET CHECK VALVE MAY NOT FULLY CLOSE AT THE END OF REFUELING. THIS COULD ALLOW SOME FUEL TO ESCAPE FROM THE VEHICLE THROUGH THE FILLER NECK AT THE END OF REFUELING.
Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
07V092000
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ON SOME SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, AN INTEGRATED CIRCUIT IN THE INSTRUMENT CLUSTER THAT CONTROLS INTERIOR LIGHTING MAY OVERHEAT.
Risk: THIS COULD POTENTIALLY CAUSE AN INSTRUMENT PANEL FIRE.
06V067000
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
Risk: DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
05V460000
POWER TRAIN:AUTOMATIC TRANSMISSION
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Risk: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2016265459,492 units in Canada
Airbag
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected.
Recall 2015228374,508 units in Canada
Airbag
On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall supersedes special service campaign 2015-003. Correction: Dealers will replace airbag inflators. All vehicles having received a replacement inflator as part of the previous special service campaign will have a replacement inflator installed.
Recall 20150941,000 units in Canada
Airbag
Fiat Chrysler Automobiles (FCA) Canada is conducting a voluntary Safety Improvement Program involving Takata passenger airbag inflators installed in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States. Fiat Chrysler Automobiles (FCA) will replace the passenger inflator on affected vehicles. Owners who believe their vehicles may have been originally purchased or registered in Florida, Hawaii, Puerto Rico, U.S. Virgin Islands, Texas, Mississippi, Alabama, Louisiana, Georgia, Guam, American Samoa and Saipan should contact a Fiat Chrysler Automobile (FCA) dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This Safety Improvement Campaign is superseded by recall 2016-265 (FCA Recall S43). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2016265">recall 2016265</a> for more information.
Recall 20150931,000 units in Canada
Airbag
Fiat Chrysler Automobiles (FCA) Canada is conducting a voluntary Safety Improvement Program involving Takata driver and/or passenger airbag inflators installed in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States. Fiat Chrysler Automobiles (FCA) will replace the driver and/or passenger inflator on affected vehicles, depending on the vehicle involved. Owners who believe their vehicles may have been originally purchased or registered in Florida, Hawaii, Puerto Rico, and the U.S. Virgin Islands should contact a Fiat Chrysler Automobile (FCA) dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: For the 2003 model year Dodge RAM, only the passenger side inflator would need replacement. Additional Note: This special service campaign was replaced by recalls 2015094 and 2015228. Please see these recalls for more information: <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015094">Click here for more information on the 2015094 recall</a> <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015228">Click here for more information on the 2015228 recall</a>
Recall 2015003258,600 units in Canada
Airbag
Chrysler Canada is conducting a voluntary Safety Improvement Campaign concerning the driver's airbag inflator on certain vehicles equipped with Takata airbags. Chrysler Canada will replace the driver's inflator on affected vehicles. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This special service campaign was replaced by recall 2015228. Please see recall 2015228 for more information: <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015228">Click here for more information</a>
Recall 2009007445 units in Canada
Fuel System
On certain vehicles, the fuel tank inlet check valve may not fully close after refueling. This could allow some fuel to escape from the fuel tank filler tube. Fuel, in the presence of an ignition source, can result in a fire. Correction: Dealers will inspect the check valve and, if required, replace the fuel tank assembly.
Recall 200705813,308 units in Canada
Electrical
On certain vehicles, the instrument cluster circuit that controls interior lighting may overheat and cause an instrument panel fire. Correction: Dealers will inspect and, if necessary, replace the instrument cluster assembly. If the cluster shows no evidence of damage, it will be re-programmed to prevent this condition. In addition, all vehicles will receive a modification that directs interior lighting to a portion of the integrated circuit with additional current carrying capacity.
Recall 200605838,034 units in Canada
Other
On certain vehicles, the front windshield wiper motor armature shaft may break which could result in a loss of front windshield wiping capability. This could impair the driver's vision and cause a crash without warning. Correction: Dealers will inspect and, if necessary, replace the front windshield wiper motor.
Reports where the owner recorded a crash, a fire, an injury or a death.
Paragould, AR1 injured
POWER TRAIN
Was on a delivery order with Doordash suddenly the truck started bucking back and forth it had felt as if someone was slaming into the back of truck anyway I was on the highway in traffic when this had started leaving me 1st and 2nd gear than final with no gears cause the transmission was burning hot to the touch causing burns on my hand when I tried to check out I was told my truck went into some kind of limp mode cause of transmission control module and shifted solenoid A on the transmission someone needs to hold Dodge responsible for its failures
NHTSA complaint #11511381 — an unverified report by a vehicle owner.
Gulfport, MSFire
STRUCTURE:BODY
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
NHTSA complaint #11483550 — an unverified report by a vehicle owner.
Gulfport, MSFire
ENGINE
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
NHTSA complaint #11483550 — an unverified report by a vehicle owner.
Gulfport, MSFire
FUEL/PROPULSION SYSTEM
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
NHTSA complaint #11483550 — an unverified report by a vehicle owner.
Dearing, GAFire
UNKNOWN OR OTHER
Vehicle spontaneously caught on fire while I was at an ATM. No known cause. The vehicle was in good condition for its age with no major repairs needed and no significant body damage. There had been no major mechanical changes to the vehicle during the time I owned it. It was used regularly with appropriate oil changes and repairs as needed and had otherwise been safe to drive. I was unable to extinguish the fire. Thomson-McDuffie Fire and EMS was called to extinguish flames. Vehicle was totally destroyed/irreparable. This has been a devastating financial blow to me as a single parent as due to the age of the car, it was only insured for collision. It was also a terrifying experience.
NHTSA complaint #11467251 — an unverified report by a vehicle owner.
at 168,000 milesNewport News, VACrash
VEHICLE SPEED CONTROL
CAR ACCELERATED ON ITS ON. COULD NOT STOP VEHICLE- CAUSED A COLLISION. HAPPENED WHILE TRYING TO PARK CAR AT WORK.
NHTSA complaint #11396751 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Aiken, SC
FUEL/PROPULSION SYSTEM
My car is having identical symptoms to a recall for it, but dodge is saying my vehicle is "Not affected", despite having identical symptoms from an identical cause. The check valve on my fuel tank has failed, and it overflows when I fill it with gas
NHTSA complaint #11640321 — an unverified report by a vehicle owner.
at 180,000 milesDayton, NV
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the contact became aware that gasoline was spilling out of the fuel filler neck. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline); however, the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.
NHTSA complaint #11592499 — an unverified report by a vehicle owner.
Crawford, GA
VEHICLE SPEED CONTROL:CRUISE CONTROL
See attached document from complainant
NHTSA complaint #11550647 — an unverified report by a vehicle owner.
Spring Lake, NC
Carry Handle, Shell, Base
The carseat will not lock into the base proper in any recline position except 1. 1 is supposed to be for a newborn. When you place the seat (till you hear it "lock" into place per the manual and a CPST) in 2, 3, or 4 then the seat drops down into the 1 position while driving down the road. We've contacted evenflo repeatedly and no help from them. Now it's to the point it doesn't even lock into 1. We've had this seat since Jan 17, 2023. I have checked online and am able to find 30+ reviews of parents with the same issue across reddit, Amazon, and Walmart. A recall on the seat needs issued immediately. This has been going on since Jan 21st, 2023.
NHTSA complaint #11548756 — an unverified report by a vehicle owner.
Lawai, HI
AIR BAGS
The contact owns a 2005 Dodge Durango. The contact received notification of NHTSA Campaign Number: 16V352000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11548297 — an unverified report by a vehicle owner.
at 126,337 milesMount Dora, FL
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Dodge Durango. The contact stated while refueling the vehicle, the fuel started leaking from the filler neck. The contact waited for a while to refuel the vehicle. Additionally, the contact stated that a message was displayed on the instrument cluster "Gas Cap". The contact stated that she checked the gas cap and was properly placed then replaced the gas cap however, the message recurred. The dealer was notified of the failure and confirmed that the VIN was not included in a recall. The vehicle was not repaired. The contact refenced the NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline. The manufacture was not notified of the failure. The failure mileage was approximately 126,337.
NHTSA complaint #11544544 — an unverified report by a vehicle owner.
at 252,000 milesLa Rue, OH
ELECTRICAL SYSTEM
The contact owns a 2005 Dodge Durango. The contact stated upon starting the vehicle, the instrument cluster was not operating properly. The speedometer displayed 50 MPH while the vehicle was parked and the odometer turned blank, and the vehicle was stuck in FWD. The contact stated that the interior lights failed to turn off upon depressing the light switch. Additionally, the contact stated while driving at an undisclosed speed, there was an abnormally strong electrical wiring burning odor inside the vehicle. The contact veered to the side of the road. The contact stated that the burning odor was coming through the A/C vents on both sides of the instrument panel. The vehicle was taken to a nearby independent mechanic, where it was diagnosed that the failure was related to NHTSA Campaign Number: 07V092000 (Electrical system). The dealer was notified of the failure and informed the contact that the recall repair was previously completed on the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 252,000.
NHTSA complaint #11532720 — an unverified report by a vehicle owner.
at 152,000 milesStockbridge, GA
AIR BAGS
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the fuel tank spilled gasoline to the vehicle. The fuel also leaked onto the driveway while the vehicle was parked. Additionally, the vehicle lost motive power while driving with the air bag warning light illuminated. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the vehicle had previously been repaired under NHTSA Campaign Numbers: 09V003000 (Fuel System, Gasoline), 15V313000 (Air Bags), and 16V352000 (Air Bags). The failure mileage was approximately 152,000.
NHTSA complaint #11532008 — an unverified report by a vehicle owner.
at 152,000 milesStockbridge, GA
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Dodge Durango. The contact stated that while refueling the vehicle, the fuel tank spilled gasoline to the vehicle. The fuel also leaked onto the driveway while the vehicle was parked. Additionally, the vehicle lost motive power while driving with the air bag warning light illuminated. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the vehicle had previously been repaired under NHTSA Campaign Numbers: 09V003000 (Fuel System, Gasoline), 15V313000 (Air Bags), and 16V352000 (Air Bags). The failure mileage was approximately 152,000.
NHTSA complaint #11532008 — an unverified report by a vehicle owner.
Colorado Springs, CO
POWER TRAIN
This vehicle will slip in and out 4 wheel drive on its own. This can occur when driving and I’m concerned it will create a dangerous situation, especially if driving at high speeds. When this issue is occurring, making tight turns (parking, neighborhood driving) becomes very dangerous as the wheels become locked and you have to press the accelerator down creating a lot of power and the vehicle becomes dangerously uncontrollable. This is very common while parking, when often pedestrians are present and the vehicle becomes unpredictable due to this issue. This will also occur at a 2 way stop when turning right in front of on-coming traffic. The vehicle will again be unpredictable and can’t turn smoothly impairing traffic coming from behind.
NHTSA complaint #11520531 — an unverified report by a vehicle owner.
Paragould, AR1 injured
POWER TRAIN
Was on a delivery order with Doordash suddenly the truck started bucking back and forth it had felt as if someone was slaming into the back of truck anyway I was on the highway in traffic when this had started leaving me 1st and 2nd gear than final with no gears cause the transmission was burning hot to the touch causing burns on my hand when I tried to check out I was told my truck went into some kind of limp mode cause of transmission control module and shifted solenoid A on the transmission someone needs to hold Dodge responsible for its failures
NHTSA complaint #11511381 — an unverified report by a vehicle owner.
at 120,000 milesMonument, CO
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Dodge Durango. The contact stated that fuel spilled out of the filler neck at the end of refueling. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was previously repaired under NHTSA Campaign Number: 05V034000 (Fuel System, Gasoline). However, the contact related the failure to NHTSA Campaign Number: 09V003000 (Fuel System, Gasoline) but the VIN was not included in the recall. The failure mileage was approximately 120,000.
NHTSA complaint #11511074 — an unverified report by a vehicle owner.
Spokane, WA
POWER TRAIN
My 2005 Durango all of a sudden has decided to stall while driving . I've bought this vehicle almost 2 years ago, and this is by far the scariest experience I've had in it. The first time it happened was as I was slowing down to stop at a red light on January 17th. Since then it has been stalling one at least 3 to 5 times a week . Something isn't right. I did receive a code from my Milewise ins OBD reader today, that said P1794 URGENCY UNKNOWN - contact your mechanic . That's one of 3 I got . The other two are p 0700 Transmission control system ( MIL request ) Urgent - have checked ASAP AND - P0430 CATALYST system efficiency below threshold. Urgent - have checked ASAP This tells me something is seriously wrong and it's going to cost me a fortune. Which for me is impossible to even try to contemplate. I am disabled and my income is not enough. I can not afford to fix this, nor can I afford to buy something else. This is a real problem that I can't afford and it should have been fixed before when it was brought to your attention back in 2005.
NHTSA complaint #11506353 — an unverified report by a vehicle owner.
White Haven, PA
FUEL/PROPULSION SYSTEM
I have own my Durango for about 4 years and I recently had the air bag recall repaired that it had. My vehicle also had a previous recall for the fuel tank filler tube inlet check valve. It causes gas to splash out at a large amount which splashes out at you, all over the truck and the ground. It does this every time I fill my tank. I looked it up online and mine was never replaced but “checked” before I owned it. I don’t know why it was replaced because my vehicles is obviously affected by this recall and the dealer will not fix it because it was previously checked. I’m scared of the danger this issues has. I’m a single dad and this is my only vehicle. It happens regularly every time I refuel.
NHTSA complaint #11502996 — an unverified report by a vehicle owner.
at 215,000 milesMcallen, TX
AIR BAGS
The contact owns a 2005 Dodge Durango. The contact stated that the vehicle was previously repaired under NHTSA Campaign Numbers: 16V352000 (Air Bags) and 05V034000 (Fuel System, Gasoline) however, the failure occurred after the recall repairs were performed. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The contact stated that the dashboard was damaged, and the passenger's side air bag compartment was opened. Additionally, fuel was spilling out of the filler tube while refueling the vehicle. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 215,000.
NHTSA complaint #11501626 — an unverified report by a vehicle owner.
at 215,000 milesMcallen, TX
FUEL SYSTEM, GASOLINE
The contact owns a 2005 Dodge Durango. The contact stated that the vehicle was previously repaired under NHTSA Campaign Numbers: 16V352000 (Air Bags) and 05V034000 (Fuel System, Gasoline) however, the failure occurred after the recall repairs were performed. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The contact stated that the dashboard was damaged, and the passenger's side air bag compartment was opened. Additionally, fuel was spilling out of the filler tube while refueling the vehicle. The dealer was made aware of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 215,000.
NHTSA complaint #11501626 — an unverified report by a vehicle owner.
at 180,000 milesAurora, CO
POWER TRAIN
The contact owns a 2005 Dodge Durango. The contact stated while driving at various speeds, the gears inadvertently shifted from AWD to 4WD-Low. The contact also stated that while attempting to unlock the front driver’s side door, she heard the gears shifting inadvertently. The contact then stated that the driveshaft made a loud grinding sound. No warning lights were illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The mechanic retrieved DTC code: P0700 (Transfer Case motor and possibly snap ring) failure. The vehicle was not repaired. Neither the dealer nor the manufacturer was not notified of the failure. The failure mileage was approximately 180,000.
NHTSA complaint #11492165 — an unverified report by a vehicle owner.
Saint Augustine, FL
POWER TRAIN
The vehicle is shifting itself into 4WD HI, and sometimes even LO, while being driven - even at highway speed, which causes a sudden and dramatic drop in speed. It also makes turning the vehicle very difficult. This is dangerous and occurs regularly. There are many online forums discussing this exact issue with 2044/2005 Durango's, but no one seems to have a solution. For instance - https://www.cargurus.com/Cars/Discussion-t4148_ds482593
NHTSA complaint #11488600 — an unverified report by a vehicle owner.
Gulfport, MSFire
STRUCTURE:BODY
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
NHTSA complaint #11483550 — an unverified report by a vehicle owner.
Gulfport, MSFire
ENGINE
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
NHTSA complaint #11483550 — an unverified report by a vehicle owner.
Gulfport, MSFire
FUEL/PROPULSION SYSTEM
I almost died, I escaped my car moments before it completely exploded into flames. I was driving down the interstate and it said it was overheating for a couple seconds and then the car went completely dead going 70 miles per hour. My steering wheel locked up so I fought to pull it off the road and stop it, I had a bad feeling so I checked the front of the car but it was inflamed once I got out and my seat was consumed in fire
NHTSA complaint #11483550 — an unverified report by a vehicle owner.
Colorado Springs, CO
FUEL/PROPULSION SYSTEM
VIN: [XXX], 2005 Dodge Durang0 SLT, 4.7L. Vehicle purchased party on 07/20/2022. Register and insured 07/21/2022. SAFETY FCA Recall #: H45. NHTSA Recall #: 09v-003; The fuel tank inlet check valve sticks in the open position, causing fuel to spill out of the filler tube when the vehicle is being refueled. Fuel in the presence of an ignition source can result in a fire. Repair Description: The fuel inlet check valve must be tested for proper operation. A vehicle with a sticking check valve must have the fuel tank replaced. On 08/08/2022 during the second attempt of refueling as the current owner. There was fuel spillback during refueling. On 08/08/2022, I contacted Daimler Chrysler at [XXX], case number [XXX] explaining the incident. However, customer service ([XXX]) stated that the safety recall had been completed but in fact per recall status according to FCA, only an INSPECTION was performed. This is not only a serious safety concern to myself and my family but also to the community at large. Especially during refueling, with the possibility of an explosion and fire caused by fuel spilling and igniting in the process. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11478153 — an unverified report by a vehicle owner.
Filer, ID
AIR BAGS
My passenger side airbag will not activate. It shows a passenger side airbag off
NHTSA complaint #11471083 — an unverified report by a vehicle owner.
Douglas City, CA
FUEL/PROPULSION SYSTEM
When filling up my gas tank occasionally fuel will spit out of my gas tank and all over my car and ground
NHTSA complaint #11470480 — an unverified report by a vehicle owner.
Douglas City, CA
ELECTRICAL SYSTEM
I have had my durango for about 2 years, one day I went to start it and it clicked as if battery had died. When I jumped it, it started right up. I noticed that my dash had a tire sensor light and a light saying Overhead lamp on. I turned my overhead switch and all my lights in the car turned on and then off when i turned switch.( normal) so I knew something was up. After doing some research I read about the recall. I Made an appointment on the 15th of June to get a recall for my instrument panel fixed. I dropped my car off at 7 am my appointment was at 8am. I called around 11:30 to get an ETA since I was on a time limit for work and live an hour away. The dealership called to tell me that he needed to take out cluster and test it and if it was cluster he would have to order it and it could be a few days. If it was fine it was a circuit Issue and he would need to fix it. Thank god my mother was in the same area visiting and was able to give me a ride home. He then called that evening and asked if I owned another Key/FOB. I told them I didn't and my fob has never worked since i purchased the vehicle. He stated that he got the recall all finished and fixed but now all the lights on my dash were flashing, my headlights the horn, flashers and something" went wonky" there. He then tried to tell me they needed to order a new fob to program it to my car and it was going to cost me almost $400. I told them I was not going to pay that amount and that it seems like they messed something up when they put it together. I picked up my car Friday the 17th and my tire pressure light was still on. After getting home and checking tires they were all fine. The next day I went to start my car and the Headlight lamp light came back onto my dash. I already had to take 2 days off work and now have to miss more to have this recall done right. I looked up my vin today the 20th and it says my recall is incomplete! To top it off they never gave me any paperwork or have me sign anything.
NHTSA complaint #11470138 — an unverified report by a vehicle owner.
