Ford F-350 electrical problems

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact called on behalf of his client, who purchased a 2011 Ford F-350. The contact stated that while the client was in the process of selling the vehicle to a dealer, the dealer retrieved the Carfax report and informed the client that the odometer had been rolled back and that the vehicle could not be sold. The vehicle was a private sale. At the time of the purchase, the mileage was 128,530, and a dealer later informed the client that the mileage on the Carfax report was 345,000. The current mileage displayed on the odometer was 147,000. No other agency was contacted.

NHTSA complaint #11700270 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2004 Ford F-350. The contact stated that while driving approximately 76 MPH with his wife in the front passenger seat, the vehicle shuddered uncontrollably and stalled. The contact and his wife were concerned for their safety. There was no warning light illuminated. The contact was able to regain control of the vehicle and pulled over to the side of the road. The vehicle failed to restart and was towed to the residence. The contact stated that as an independent mechanic, he used a code reader to retrieve diagnostic trouble codes for the fuel control module wiring harness failure. The contact related to the failure to NHTSA Campaign Number: 05V270000 (Electrical System). The contact stated that the fuel control module wiring harness failure had caused warning lights to fail to illuminate as needed. The dealer was notified of the failure and informed the contact that the vehicle had previously been repaired under the recall. The manufacturer was notified of the failure and informed the contact that an elbow vacuum tubing connector was previously replaced under the recall; however, the contact advised the manufacturer that the recall involved replacing the entire fuel control module wiring harness. The manufacturer informed the contact that the recall was already marked completed and no further repairs could be covered. The contact stated that the dealer and the manufacturer had failed to honor the recall repair. The vehicle was not repaired. The failure mileage was 190,019.

NHTSA complaint #11655439 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Since my vehicle has been in warranty I've had intermittent issues where my vehicle loses track of what gear its in and forces downshift to 1st gear. For the most part this only happened when I was going slower speeds. I told my Ford dealer about it but they said there were no recalls for it. On Wednesday while driving at highway speeds my dash lights indicating the transmission position began to flicker then my vehicle downshifted to first gear locking up the tires and screeching me to a near halt.

NHTSA complaint #11654666 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.

NHTSA complaint #11594346 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving 60 mph, in heavy rain, flat roadway the vehicle down shifted from 6th gear to 4th and from 6th gear to 3rd several times. The shift to 3rd from 6th was hard and accompanied by a temporary loss of forward momentum. No check engine light came on. All temperature gauges remained within normal range. The tachometer jumped and fell wildly during each of the events. I pulled off the highway at the next exit, turned off the ignition, and waited a few minutes. I restarted the truck and proceeded without additional problems.

NHTSA complaint #11568184 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The vehicle just stated honking the horn , no key was in the ignition and no one was driving truck

NHTSA complaint #11563021 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:HORN

The contact owns a 2014 Ford F-350. The contact stated while driving 35 MPH, another vehicle pulled in front, and he was not able to honk the horn. Additionally, the cruise control deactivated independently. No warning light was illuminated. The vehicle was diagnosed by the dealer who determined a failure with the clock spring. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.

NHTSA complaint #11539209 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Bcm body control module is faulty so far my brights no longer work my fog lights no longer work and my left rear turn signal no longer works it is slowly getting worse taking out more and more components on the truck part is backorder with over 2070 of them requested threw ford with no update on when the part will be available

NHTSA complaint #11533755 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Truck died and never started again. Metal shavings from fuel pump

NHTSA complaint #11530986 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

there has been intense rust and corrosion in the roof seams and welds. This has led to water leaks and damage to the interior of the vehicle. The integrity of the roof has been compromised, and I am concerned about the possibility of roof crush should there be an accident. Not to mention the mold, rot and damage to the interior and electrical systems I have already suffered due to the defect. On February 3, 2023, I contacted the Ford Motors helpline and spoke to [XXX] (direct phone # [XXX] ext [XXX]) to discuss the issue.[XXX] created a request for a buyback and assigned a case number of [XXX]. She also requested that I send photos to [XXX] and visit the local Ford dealership so they could assess the vehicle and share the information with her. I was able to make an apt for Feb 6,2023 @ 10:50 with [XXX] @ Envision ford of Oxnard. When I arrived for the assessment, [XXX] did one walk around the vehicle (he did not inspect the roof at all) and then said he couldn’t help me as he this was a Ford issue, and they were a franchise. I contacted [XXX] with follow up from that meeting, as well as photos of the vehicle. About two weeks after this apt. [XXX] said the case was closed. I am extremely disappointed with how this case was handled, especially considering the significant investment I made in purchasing and maintaining it my vehicle. When I made the original investment I was told that the engine would last up to a million miles…but never imagined the body would be worthless at the 300,00 mark. There is so much damage to the roof that I currently keep my vehicle parked instead of using it. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA complaint #11512975 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2013 Ford F-350. The contact stated that while the vehicle was idling smoke appeared between the driver's side front and rear door panels. The contact stated that prior to the failure the electrical door and window switch functioned intermittently. The contact stated that an unknown warning light was illuminated. The vehicle was taken to the dealer who diagnosed the failure as a defective door wiring harness due to brittle wires from constantly opening and closing the doors. The contact was informed that the wiring harness needed to be replaced. Additionally, the contact stated that the wires were melted. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 80,794.

NHTSA complaint #11464050 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

NHTSA complaint #11462783 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The wires for the camshaft position sensor are failing just like they have in others models of the f series and cause the truck to suddenly die while driving. There was already a recall in place but it doesn't cover this vin and so I would like to request the recall be extended to this trucks vin

NHTSA complaint #11433730 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Emissions warning for my DEF system's Reductant heater code and possible connected wiring.

NHTSA complaint #11418952 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

THE INTERIOR WIRING HARNESS SHORTED VIA THE SEATBELT AND MELTED THE ENTIRE WIRING HARNESS. THE CAR WAS IN MOTION AND A CITY STREET AND STARTED SMOKING FROM THE DRIVER SEATBELT HOUSING. NO FUSES BLEW FROM THE SHORT WHICH CAUSED THE HARNESS TO MELT.

NHTSA complaint #11376702 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

SINCE I BOUGHT THIS 2007 FORD F 350 I'VE HAD NOTHING BUT PROBLEMS FUEL PUMP INJECTORS EGR COOLER FUEL FILTERS BRAKES THE TRUCK HAS BEEN IN TH E SHOP THREE TIMES SINCE I'VE HAD IT NOW I'M PRAYING DONT ANYTHING ELSE GO WRONG WHAT A WASTE.;

NHTSA complaint #11365421 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

WINDOWS ,WIPERS AND RADIO COME ON ABOUT A MINUTE LATTER AFTER STARTING THE TRUCK.

NHTSA complaint #11349099 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2011 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO ELDER FORD OF ROMEO LOCATED AT 633000 VAN DYKE, WASHINGTON, MI 48095, (586)838-1250, ON SEVERAL OCCASIONS IN THE PAST FOUR MONTHS IN REGARD TO AN ELECTRICAL SYSTEM FAILURE. THE CONTACT STATED THAT THE BCM (BODY CONTROL MODULE) WAS REPLACED ON THREE OCCASIONS HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 87,000

NHTSA complaint #11307215 — an unverified report by a vehicle owner.