43 of the
1,412 complaints filed about the Ford Maverick Hybrid
are about the fuel system —
3% of everything owners reported.
The worst model year for it is 2022.
Receiving daily Battery Saver Mode notices telling me some remote features including lock/unlock may temporarily be unavailable. Not to use my AC and go for longer rides, which I have done with no change. My interior lights are not coming on. My radio powers off and on while driving. Constant clicking and noises come from the vehicle when turned off. Difficulties starting the vehicle at times. Feel power losses when driving and accelerating, feel like I could be rear ended when this happens. In doing some online research, I am clearly not alone in this issue, when I contacted Ford and the dealership they both acted as if this is not a current issue and I would have to it inspected by a Ford dealership with no guarantee that the inspection would be covered. I found a recall 24S24 that sounds like my exact issue, yet they say it's not been authorized for my vehicle.
NHTSA complaint #11741803 — an unverified report by a vehicle owner.
Just picked up vehicle after having a new battery installed. Was getting pop up on dashboard every few seconds that electrical saving mode was active. Then all of a sudden the truck shut off while driving about 45 mph on a busy road. Dash said switch to neutral to start vehicle which i tried but nothing happened. Truck coasted to a stop and would not start or even shift into neutral to push it off of the road. The dashboard was flashing pretty much every warning possible including stop safety, shift system failure, parking brake , battery saver active etc. The truck continued to not start or shift. Tow truck was called and it was towed home.
NHTSA complaint #11723267 — an unverified report by a vehicle owner.
Fuel tank failure at 18,000 miles and less than 3 years of ownership. I noticed that the vehicle had a strong gasoline smell when I was around it. When looking under the truck, I could see that there was a fuel leak coming from the fill pipe inlet into the fuel tank itself. Took the vehicle under warranty to the ford dealer, and was told that the hose clamp was loose connecting the fill pipe into the fuel tank itself. Was sent on my way with the vehicle, and noticed a smell of gasoline and fuel not even two months later. Took it back to the dealer and was told that they were unable to replicate it. Once the weather got cold again, took the vehicle back after noticing a much larger leak and smelling fuel, and am now being told by ford that the fuel tank does in fact need to be replaced as the tank is leaking from the fill pipe inlet. I am no longer under warranty and was quoted $1100 for this repair. Not only do I find this to be a safety concern as leaking gasoline is extremely dangerous and flammable (plus there are vapors in the air in my garage) but felt that my dealership did not do their due diligence to resolve this issue properly, and now I am on the hook for an $1100 repair that should’ve been taken care of when the vehicle was under warranty. No warning lamps were lit alerting me to this problem, I noticed it by smelling gasoline in my garage near the vehicle.
NHTSA complaint #11706879 — an unverified report by a vehicle owner.
On November 9th, the vehicle became undrivable with the following alerts: "Stop safely now", "Pre-collision assist not available", "Check Brake System", "Front Camera Temporarily not available", "service vehicle soon", "service advance trac", "hill start assist not available" The accelerator was non-functional; however, when releasing the brake pedal the vehicle starts to accelerate, without pressing the accelerator. Dealer said they are unable to reproduce the event. This is the second time this has occurred with this vehicle, previously submitted complaint on this same VIN.
NHTSA complaint #11699914 — an unverified report by a vehicle owner.
While driving on onramp to the interstate the engine shut down and warning came on pull over now. All power was lost. The APP showed power train fuel control module could not connect. I tried to restart but had no power. On 6/16/2025 I took the vehicle in for repair (could not get appointment). It was returned (could not duplicate problem). On my way home it happened again engine lost power while driving. The vehicle was brought back to Ford. This time it was returned 6/25/2025.
NHTSA complaint #11674048 — an unverified report by a vehicle owner.
1)After sitting for 2 days the battery was drained or dead. The truck would not start. I jumped the truck and it started up. Every time I park the truck i get a warning that the battery is low and I should drive it to recharge the battery. I drive the truck but it will not recharge. 2) The check engine light comes on. I went to the auto parts and scanned for diagnostics. The scan came back as a fuel tank pressure sensor failure. 3) When I drive the truck it smells as if something is burning. 4) The fuel gage is not showing accurate reading. 5)The fuel door wont open unless I have the truck turned on and then it takes several minutes. 6) After driving on the freeway I came to a stop on the off rap before entering a main street and the truck died.
NHTSA complaint #11667821 — an unverified report by a vehicle owner.
Dealer states that they found a crack at the seam where filler neck connects to fuel tank. Fuel leak traces coming from where the hose assembly attaches to the gas tank. Visible fuel seaping and strong gasoline smell in garage.
NHTSA complaint #11656510 — an unverified report by a vehicle owner.
Started Vehicle, pulled out of a parking spot and I slowly approached an intersection, the engine accelerated at a high rpm/rate without touching the gas pedal, I immediately firmly applied brakes, the card was jerking and shaking hard working against brakes, I immediately turned car off. It could have easily ran into a car or person, being that I was on a city street with pedestrians crossing and car traffic. When I restarted, it did not want to move at all. I then restarted it a second time and it drove normal. No lights or warnings appeared. It was at Ford dealer getting all recalls repaired about 2 weeks ago and were completed to my knowledge. This just happened today [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11641224 — an unverified report by a vehicle owner.
Vehicle was parked in attached garage. Smelled gasoline smell inside the house. Investigated the source of the smell and found the vehicle to be leaking fuel where the filler neck attaches to the fuel tank.
NHTSA complaint #11632389 — an unverified report by a vehicle owner.
Just recently I've noticed that when the engine is running and I'm stopped or parked the truck will "lurch". Almost as if I'm trying to hit the gas while parked or holding the brakes. Since this has started, I've also noticed that from 25mph to 60/65mph there is a violent vibration ONLY under acceleration (20-25% on the power meter) while the engine is running. Issue worsens depending on the mode the truck is in (worse under sport, better under ECO/Slippery). Whole truck will shake, body, steering wheel and all. Not sure if these two issues are related? I'm not sure if these are considered to be powertrain or if it's the engine. Not sure if I could have it inspected upon request because I can't pin point any mechanical abnormalities visually. I feel my safety and others may be a concern because the unknown of the issue. I'm not sure if the vehicle is breaking down, will break down, lose power or whatever the case may be. The vehicle has been reported to Ford for these issues with no resolve. No warning lamps or messages. The issue appeared to come out of no where. Wasn't doing it one day, began doing it the next.
NHTSA complaint #11631117 — an unverified report by a vehicle owner.
The fuel tank is leaking where the fill tube enters the tank on the drivers side. It was at the dealership for this issue once. A hose clamp was found to be loose. It was tightened and considered fixed. Just tonight while.the truck had a full.tank I decided to inspect the repair. I found it to be leaking still. I have read of 22MY trucks having an issue with the interface between the fuel tank and the tank inlet hose barb fitting. (The white part in the attached picture.) I only noticed the gas smell originally whith a full tank and while parked in the garage. The fumes where overwhelming.
NHTSA complaint #11630764 — an unverified report by a vehicle owner.
My vehicle completely shutdown while we were driving on interstate 15 doing 77 mph. When everything shut off we had no brakes and no way to put the hazards on. It’s literally died while we were driving 77 mph.
NHTSA complaint #11612165 — an unverified report by a vehicle owner.
Driving at approximately 65 miles per hour. Vehicle suddenly went into neutral I was forced to pull over on a busy highway. The dashboard was illuminated with several warning lights and messages. After one key cycle, I was only able to drive in a limited limp mode. After a second key cycle and waiting a few minutes, I was able to drive like normal but an engine light stayed illuminated.
NHTSA complaint #11603646 — an unverified report by a vehicle owner.
I have a 2023 For Maverick hybrid pickup. While driving on the highway at about 70-75 miles an hour, the engine abruptly shut off. I had to carefully make my way to the shoulder while cars zipped by. Scary and very unsafe. My wife was hysterical and does not want to ride in the truck anymore. Once stopped at shoulder, I turned the ignition to the off and on positions several times. The gas engine would not crank. Three or four messages scrolled on the screen: "Service engine immediately," "Pre-collision assist not available," and others I don't exactly remember. When I would turn the ignition to on, the electric engine would start but when I accelerated in Park, the gas engine did not accelerate, not did it work in Reverse, Neutral or Drive. I was able to limp off the highway about 30 miles and hour under what I presume was electric battery power with my hazard flashers on and park at a gas station. I had to have the truck towed to the dealer on a Saturday night at a cost of $400.00 and leave it for repairs. The Service Department told me the truck was not giving any error codes and they were trying to get further guidance from Ford. They required extensive driving and time to input and test Ford updates. The final result was that they were not able to verify any issues after performing additional PCM updates. I was advised they are all done and will deliver the truck tomorrow Wednesday. However, they still don't know what caused the power failure. I have seen numerous similar incidents being posted about on the Internet.
NHTSA complaint #11600644 — an unverified report by a vehicle owner.
5th INCIDENT: On 06/09/2024, at approximately 5:25pm, I was pulling up to a stop sign after just leaving my home. Traveling about 10mph I began applying the brakes and vehicle suddenly lurched to a complete stop and shifted itself into park. Various warning prompts, chimes and cluster lights came on (see attached photos). Vehicle then accelerated all on its own without any pressure on the gas pedal. This is the 3rd such incident in nine (9) days. 1st time: 04/16/24, Complaint #11583215 2nd time: 05/26/24, Complaint #11590922 3rd time: 06/01/24, Complaint #11592069 4th time: 06/07/24, Complaint #11593195 5th time: 06/09/24, Current complaint.
NHTSA complaint #11593341 — an unverified report by a vehicle owner.
While driving in traffic and allowing the advanced cruise control to operate, while coming to a stop, the vehicle stopped recognizing stopped traffic and begun accelerating. I intervened and hit the brakes before a collision occurred. This was verbally reported to the dealership and was to be inspected at time of recall service.
NHTSA complaint #11592073 — an unverified report by a vehicle owner.
SECOND REPORT SAME PROBLEM: See NHTSA tracking Number 11583215, 04/16/2024. Took to dealer (Autonation Ford, Frisco, Texas) and they kept vehicle four (4) days. Upon return they told me diagnostics showed no alerts on vehicle, thus no problems. So, nothing was done. 05/26/2024 approx. 8:05pm, traveling 50-mph had sudden loss of power and speed. Warning lights and prompts appeared on cluster. Vehicle slowed immediately to 35-40mph and would not accelerate any faster. Sudden slowdown caused vehicle behind (who was following to close) to suddenly brake, almost hitting me. Would slow when brakes applied. When brakes released vehicle would accelerate to 35-40 mph on its own without applying gas pedal. This vehicle has had four (4) recalls, and now two separate incidents as described above. I believe it is a hazard and the issue complained of herein, and previously, are of such magnitude that they pose a significant risk of accident potentially causing injury or death to others or myself.
NHTSA complaint #11590922 — an unverified report by a vehicle owner.