28 of the
1,412 complaints filed about the Ford Maverick Hybrid
are about the suspension —
2% of everything owners reported.
The worst model year for it is 2022.
The contact called on behalf of her son who owned a 2025 Ford Maverick. The contact stated while her son was driving at an undisclosed speed, the vehicle became difficult to maneuver and her son loss control of the vehicle causing the front passenger side corner of the vehicle to crash into another vehicle; No further information was available. It was unknown if any warning lights were illuminated. The vehicle was pronounced totaled at the scene. The contact stated her son was pronounced dead at the scene and the driver of the other vehicle was in critical condition however, the injuries were unknown. A police report was filed. The contact did research and was made aware of NHTSA Campaign Number: 26V340000 (Suspension) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 11,460.
NHTSA complaint #11742701 — an unverified report by a vehicle owner.
The car has extreme vibration almost like speed wobbles when accelerating. Difficult to steer particularly if accelerating to change lanes. Appears the cv axles / have gone bad. Shocked there is not an active recall for the 2023 model year given the amount of reports of similar issue I have found online.
NHTSA complaint #11742730 — an unverified report by a vehicle owner.
SENCE PURCHACED the truck has a tie rod rattle, I have spoken to dealership and was informed no issue found. But as of late Vehicle wobbles very harshly when execrating or pulling away from stop signs passing another vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue with the tie rod ends. Now a recall on some of the mavericks suspension AKA tie rod installed wrong/ defective with a DO NOT DRIVE WARNING?
NHTSA complaint #11742520 — an unverified report by a vehicle owner.
Front end of vehicle suddenly started to shake violently when accelerating. Issue was reproduced any time when accelerating. No warning was indicated by the vehicle. Car was undrivable above 50 mph. Vehicle had 25K miles. Dealer reproduced issue. Diagnosed it as a catastrophic failure of both CV joints and front bearing(s). Dealer would not release vehicle as it was undrivable due to extreme safety issue. Parts arrived after a week and both CV joints & front bearing(s) were replaced. Online reporting for this vehicle shows this is a repeated issue which the manufacturer has a customer satisfaction bulletin but no recall.
NHTSA complaint #11739604 — an unverified report by a vehicle owner.
Vehicle wobbles very harshly after around 45k miles put on the vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue
NHTSA complaint #11737548 — an unverified report by a vehicle owner.
CV axle is going bad and the car would shake really bad when on the highway and felt unsafe to drive going 65 MPH was scary with a rattle and car could nat stay in lane
NHTSA complaint #11696685 — an unverified report by a vehicle owner.
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 50-70 MPH, the vehicle shook violently while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer and the front CV axles were replaced under warranty. However, three months after the CV axle repair, the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the CV axles were on backorder. The manufacturer was later notified of the failure and the contact was informed that parts were available; however, the part was no longer covered under warranty. The contact was provided an estimate to cover half the cost of the repair. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 38,000.
NHTSA complaint #11680652 — an unverified report by a vehicle owner.
At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.
NHTSA complaint #11680293 — an unverified report by a vehicle owner.
I have a 2022 ford maverick pickup truck and have a vibration in steeling wheel at acceleration so I took it to a very reapable tire ,brake and suspension dealer who checked the brakes, tires, balance, steering joints etc and found nothing wrong and said he had no clue what it could be and no Ford Recall issued but web sites show other customers with same problem and dealers are not wanting to completely check out because of no Recall please help us!!!
NHTSA complaint #11664704 — an unverified report by a vehicle owner.
My truck shakes like a bad washing machine with an uneven load at 50mph+ only while accelerating. While turning it squeals. I have a hybrid and have not done any off-roading. All my miles are from highway or city driving.
NHTSA complaint #11662718 — an unverified report by a vehicle owner.
On acceleration from a stand still or in motion, the vehicle will start to shake/wobble pretty violently. It will go away when letting go of the gas. Seems to be coming from the front end wheels. Going under the car and checking all connecting points, the CV axle has a lot of play. You can move it around.
NHTSA complaint #11659842 — an unverified report by a vehicle owner.
I was feeling a shaking throughout while driving. I took it into the dealership to have it looked at as it is a fairly new vehicle with less than 25k miles on it. They informed me that both of the CV Axles had gone out and were replaced. I was so shocked as those are supposed to last a fairly long time on a vehicle. I researched and it appears several Maverick owners have experienced the same thing, with some stating they be gone out twice before 34k miles and some as early as 10k miles. When I asked if it was a good thing I brought it in, the advisor told me absolutely it was as it is a huge safety issue if left unfixed. There were no warning lights for it nor any recall for it. I most certainly believe there needs to be something done about this.
NHTSA complaint #11658694 — an unverified report by a vehicle owner.
Vehicle shakes and vibrates at speeds 55 to 65 or under rapid acceleration. Took it into Ford dealership and charged with a wheel alignment. Didn’t change the situation. Noticed on Facebook Maverick group about cv axles wearing. Told this was the issue. Ford does not have replacements and still waiting since October 2024 for repairs to be made. Still not repaired and not sure if what to do if I’m still driving the vehicle.
NHTSA complaint #11635170 — an unverified report by a vehicle owner.
Started to develop a rumble/stumble upon acceleration. It seems to be getting worse. Finally took it in the dealer. The dealer confirmed that it is the CV axles. They need replacing. Dealer said no parts in stock and not sure when they will arrive. WTH. I asked about driving and they said keep on motoring. What. How can this be good for all the other connected parts! It shutters so bad I am not confident it will not cause me to have an accident. This is a major issue with the drive-line components. Ford needs to issue a recall and redesign this part or I will be replacing these again at my cost. I only have 39k milage
NHTSA complaint #11628223 — an unverified report by a vehicle owner.