279 of the
1,423 complaints filed about the Ford Maverick Hybrid
are about the transmission —
100% of everything owners reported.
The worst model year for it is 2022.
279
Complaints
100%
Share of all complaints
0
Crashes
0
Fires
Transmission & Drivetrain complaints by model year
My 2022 Ford Maverick Hybrid has twice suddenly entered limp mode and experienced a substantial loss of power. The first incident occurred on or about XXX. After leaving my subdivision, I turned onto [XXX], which has a posted speed limit of 55 mph. The vehicle immediately lost power and entered limp mode, and the engine and wrench warning lights appeared. The weather was clear and sunny. I was able to drive several miles at substantially reduced power and return home. On XXX, at 83,600 miles, Louisburg Ford retrieved DTC P1061, determined that Ford TSB 25-2454 applied, and reprogrammed the required modules. The second incident occurred on 9/13/2026. My husband and I were returning home after traveling through [XXX], [XXX], and [XXX]. We were driving northbound on I-35 near mile marker 182 at the [XXX] exit, just south of [XXX]. It was completely dark and storming, with rain and lightning, when the vehicle again entered limp mode and lost power in highway traffic. We were fortunate to have cellular service and a gas station nearby. Otherwise, we could have been stranded in dangerous conditions. On XXX, at 106,338 miles, the same dealer retrieved the same P1061 code and again applied TSB 25-2454 by reprogramming the PCM. The same loss-of-power condition, code, and Ford-prescribed repair recurred within approximately 11 months and 22,738 miles. The dealer advised that there is no guarantee it will not happen again. I am concerned that this sudden loss of acceleration or motive power could recur at highway speed and cause a crash. I request that NHTSA investigate this recurring condition and whether TSB [XXX] provides an adequate remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11764238 — an unverified report by a vehicle owner.
What component or system failed, and is it available for inspection? The right frame engine mount, differential/rear mount, and upper engine mount were all torn or broken. Both front CV axle shafts also needed replacement. Repaired 8/17/2026 by Miami County Auto, Louisburg, KS (invoice #13092). No, I don't have the parts anymore. How was your safety or the safety of others put at risk? The vehicle developed a wobble/vibration under acceleration that was reported as "getting worse" — pronounced enough to visibly shake objects in the cabin. The shop noted the engine mounts were torn/broken, allowing excess engine movement, which increases risk of further mount or drivetrain component failure and loss of vehicle control, especially at highway speeds or during hard acceleration. Has the problem been reproduced or confirmed by a dealer or independent shop? Yes — confirmed and repaired by an independent shop (Miami County Auto) on 8/17/2026 at 104,205–104,211 miles. Not taken to a Ford dealer. Has the vehicle been inspected by the manufacturer, police, insurance, or others? No — only inspected and repaired by the independent repair shop noted above. Were there warning symptoms before failure, and when did they first appear? Yes — a wobble/vibration under acceleration that subsided when off the throttle, and progressively worsened over time before the repair. Originally I thought it was a recently repaired tire that was unbalanced. Took it to Ford dealership to rebalance. They said there was no wobble (there was) and took it the independent shop.
NHTSA complaint #11760577 — an unverified report by a vehicle owner.
Truck started to shake when accelerating past 50 mph. The shaking would stop once the speed limit was reached and you let off the accelerator. Web search results showed 2022, 2023 & 2024 Ford Maverick hybrids are known for CV axle failures with those symptoms. Vehicle was around 48,000 miles. Dealership replaced both CV axles under the 5 year/60,000 mile warranty.
NHTSA complaint #11759113 — an unverified report by a vehicle owner.
At around 27K miles the two front CV axles began to fail. I brought it to the Ford dealership and they confirmed that both needed to be replaced. It was a $1600 repair. There have been a lot of complaints from Ford Maverick owners who have had CV axle failures at very low miles on their vehicles. These parts typically last 100K to 150K miles and it's not unusual for them to last the lifetime of the vehicle. There is no reason both front CV axles should be failing with 27K miles on a vehicle. This should be covered by a recall.
NHTSA complaint #11756480 — an unverified report by a vehicle owner.
Significant disruptive vibration upon acceleration at high speeds due to premature failure of front CV Axles. Confirmed failure of both axles by manufacturer at approximately 61,000 miles.
NHTSA complaint #11753274 — an unverified report by a vehicle owner.
12 volt electrical system no power. Dealer changed battery cable wiring harness. Received vehicle back. One week later vehicle exhibited no 12 volt power. Informed that it could be the Thinkware dash cam. Which was purchased from Ford and Ford dealer installed. Now informed that it could be the dash cam itself. The dash cam was installed via the OBD port which is always powered. This will drain the 12 volt battery unless vehicle is driven for extended periods. Ford is aware of the issue but no remedy for over 3 weeks. I have told the Ford dealer to have the dash cam installed so that when the ignition is on the dash cam is also powered on and off when the ignition switch is turned off. Using this method negates the parking mode on the dash cam. Another issue is when the drivers side door is opened the interior lights do not activate. Ford notified. Problem not resolved. Low 12 volt battery issue?
NHTSA complaint #11745446 — an unverified report by a vehicle owner.
While driving at highway speed on I-275with cruise control engaged on afternoon of June 11 the truck suddenly began slowing down. I couldn't get it to accelerate. I ultimately had to get over two lanes and still had enough momentum to get off an exit ramp. At the end of the ramp, I noticed I was unable to get the truck to accelerate from a stopped position either. Only then did I notice the dial transmission had moved to N from D. I did not initiate this move while I was on the highway, nor was I aware of it, nor do I believe I bumped the dial. This is the second time this has happened. Previously it occurred some time in late 2025 in a store parking lot. At highway speeds, this is extremely dangerous.
NHTSA complaint #11744383 — an unverified report by a vehicle owner.
The car has extreme vibration almost like speed wobbles when accelerating. Difficult to steer particularly if accelerating to change lanes. Appears the cv axles / have gone bad. Shocked there is not an active recall for the 2023 model year given the amount of reports of similar issue I have found online.
NHTSA complaint #11742730 — an unverified report by a vehicle owner.
SENCE PURCHACED the truck has a tie rod rattle, I have spoken to dealership and was informed no issue found. But as of late Vehicle wobbles very harshly when execrating or pulling away from stop signs passing another vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue with the tie rod ends. Now a recall on some of the mavericks suspension AKA tie rod installed wrong/ defective with a DO NOT DRIVE WARNING?
NHTSA complaint #11742520 — an unverified report by a vehicle owner.
My 2024 Ford Maverick (VIN [XXX] ) has had three sudden losses of drive power while driving. Each time the accelerator stopped delivering power with NO warning lights, no error messages, and no dashboard indicators before, during, or after. Each time I pulled over, shut off the vehicle, and restarting fully restored normal function. Incident 1 — Aug 2024, two-lane highway, New Mexico. Clear, ~80°F, light traffic, ~60 mph. Accelerator suddenly lost power, no indicators. Pulled to shoulder; restart restored function. Incident 2 — XXX, ~6:10 PM, XXX northbound on-ramp from [XXX] . While accelerating up the ramp to merge, power cut out — same behavior, no warnings. Pulled over; restart restored function. Incident 3 —XXX, ~8:05 AM, [XXX] . Slowed for a turn; no power when I accelerated out. Same signature. These symptoms are identical to NHTSA Recall 24V-267 (Ford 24S24) — loss of motive power from the BCM/PCM failing to detect 12V battery degradation — and the follow-on battery recall 25V-158 (Ford 25S26). My vehicle is a 2024 Maverick and is NOT included in 24V-267, which Ford limited to 2022-2023 Mavericks built Feb 2021–Oct 2022. I am reporting because my 2024 shows the identical failure mode, including the total absence of warning before power loss, matching the owner reports that prompted Recall Query RQ24014 into the adequacy of the 24V-267 remedy. I request NHTSA consider whether the affected population should include model year 2024 Mavericks. These events are recurring and have occurred at highway speed and while merging, creating a serious crash risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11741536 — an unverified report by a vehicle owner.
Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.
NHTSA complaint #11741298 — an unverified report by a vehicle owner.
While driving the vehicle at low speed (roughy 25mph) a loud sqeek was heard. This occured a few more times so I stopped to inspect. I countinued my trip after not finding the source of the noise. When it occured again, I pulled into a parts store and had them run codes. After finding none I purchased a code scanner so that I could monitor while under way. Once on the highway the sound became more frequent, after just a few miles warning lights appeared on my dash and the vehicle had a complete loss of power. I was able to coast to the side of the road. At that time the vehicle did have code P1061. Dealer diagnosted the truck with a failed transmission. I removed the trasmission and disassembled it. The main shaft had been stripped of it's splines on the gear that connects to the engine. I have a video of the gears and shaft here: [XXX] I saved the parts and will be happy to provide them for investigation if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11738381 — an unverified report by a vehicle owner.
Truck has stalled out multiple times, has been left in middle or road due to electrical drainage of battery. Person needed to get jumper cables to move truck.
NHTSA complaint #11738075 — an unverified report by a vehicle owner.
Both front CV axles on my 2023 Ford Maverick Hybrid are failing at approximately 60,000 miles. The vehicle experiences violent shaking and vibration during acceleration, most noticeably at speeds above 30 mph and on inclines. The shaking is severe enough to affect steering control and reduce driver confidence, particularly during highway merging and uphill acceleration. The problem was diagnosed and confirmed by San Leandro Ford dealership, which identified both front CV axles as defective and in need of replacement. No warning lamps or message appeared prior to or during the issue. The vehicle is available for inspection upon request. This appears to be a widespread manufacturing defect. Numerous owners of 2022-2023 Ford Mavericks have reported identical premature CV axle failures at mileages ranging from 10,000 to 60,000 miles, as documented in online forums and prior NHTSA complaints. Some owners have had axles replaced multiple times. The defective CV axles pose a safety risk as the severe vibration compromises vehicle control during normal driving conditions.
NHTSA complaint #11732289 — an unverified report by a vehicle owner.
Over the past 1-1/2 years I have experienced my transmission going into neutral and loss of power 4 times. The first time it happened I thought my hand hit the shifter and moved it into neutral. After a few more incidents and seeing the recall, I realized this was the cause of the issue. I noticed the NHTSA website has recall number 25V881000. Today I contacted Ford Motor Company regarding this recall and they do not show it against my 2024 Ford Maverick Hybrid. I have experienced the problem as indicated below and have not received a recall letter on this. Was my VIN left out of this recall? Dates were between November 2024- February 2026 Incidents occurred between 40-75 mph Mileages between 4000-12000 Very scary losing power on the expressway with lots of traffic Recall date 2025-12-17 Recall no. 25V881000 Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick Hybrid and 2020 Escape Hybrid vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power. Hide details Recall consequence A loss of drive power increases the risk of a crash. Recall action Dealers will update the HPCM software, free of charge. Owner notification letters were mailed February 12, 2026. Owners may contact Ford customer service at [XXX] . Ford's number for this recall is 24S33. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on [XXX] beginning January 15, 2026. This is an expansion of Recalls 24V330 (24S33) and 25V133 (25S16). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11731938 — an unverified report by a vehicle owner.
The contact owns a 2023 Ford Maverick. The contact stated that while driving 5 MPH and making a right turn, the vehicle lost power, and the transmission slipped into neutral(N). While driving 25 - 30 MPH and approaching a red light, the transmission slipped into neutral. The contact associated the failure with NHTSA Campaign Number: 24V330000 (Power Train) and 25V133000 (Power Train). The local dealer was contacted and confirmed that the VIN was included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 17,000.
NHTSA complaint #11725852 — an unverified report by a vehicle owner.
My 2022 ford Maverick is constantly sometimes several times a day and sometimes several times a week , but since 6 weeks after purchase I have been getting powertrain fault , engine fault and hybrid battery fault alerts from my ford pass my check engine light comes on my s service wrench light comes on also and my vehicle has reduced power. As well as my battery is constantly needing to be jumped. The dealership says my Battery is fine although I’ve already replaced it twice at my exspence. I’ve had to pay for diagnostics and pcm updates supposedly to fix these problems but no resolve. My vehicle goes into reduced power while driving 75 mph up the interstate and will not excellerate causeing the vehicle to coast to a stop. After sitting a while it can be started and driven. Today I received all three faults at 10:20 am so I went to my ford.com and done a health check and it says my vehicle is healthy with no engine or power train faults. But my ford pass alerts , my dashboard warning lights , and the performance of my vehicle says otherwise. I have been put in many situations on high speed roads and my vehicle will not accelerate. Often times it is necessary to jump my battery for I can move my vehicle. These issues are a constant safety hazard to all the drivers on the road when a vehicle suddenly loses power at high speeds. After 4 years of fighting with ford for a resolve I need help. I have seen numerous recalls issued addressing these very issues but they are not issued for my vin although the data on the recall states the recall pertains to vehicles made at the hermacillo Mexico plant . Which mine was on Dec 2021. I feel like my vin somehow is being overlooked and I’m not recieving the recall for the repairs. I also believe that due to the electrical issue my truck can not retain the obd codes. I have taken my vehicle to several dealerships all telling me different resolve which I pay for and no resolve. Please help
NHTSA complaint #11723301 — an unverified report by a vehicle owner.
The contact owns a 2024 Ford Maverick. The contact stated that on several occasions, while driving at an undisclosed speed, the vehicle unexpectedly shifted into neutral(N). There was no warning light illuminated. The contact stopped the vehicle and shifted the vehicle back into drive. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,000.
NHTSA complaint #11723033 — an unverified report by a vehicle owner.
Experienced excessive wobbling/shaking during acceleration. Ford replaced both axles at 38K miles. 30K miles later I am experiencing same issue. Replacing axles this frequent is abnormal and is an indicator that parts being used are not meeting the requirements needed for this vehicle.
NHTSA complaint #11717927 — an unverified report by a vehicle owner.
While driving highway speeds the vehicle suddenly lost power. Had to immediately pull to the shoulder of the highway with heavy traffic that got very close to my rear bumper due to the sudden decrease in speed. There was no advance warning of power loss. Upon stopping on the shoulder the vehicle was put in park and the key turned to the off position. After a short wait the ignition key was turned to the on position and was able to resume trip at highway speeds. Notified Ford close to my location and it was checked for fault codes and road tested with no defect found., Now concerned that the vehicle might fail again day or night leaving us stranded or causing a vehicle accident due to the sudden reduction in speed.
NHTSA complaint #11717948 — an unverified report by a vehicle owner.