1,258 of the 22,259 complaints filed about the Hyundai Sonata are about the braking system — 6% of everything owners reported. The worst model year for it is 2011.
1,258
Complaints
6%
Share of all complaints
128
Crashes
40
Fires
SERVICE BRAKES
Brake lights not working properly.
NHTSA complaint #11757315 — an unverified report by a vehicle owner.
SERVICE BRAKES
My 2013 Hyundai Sonata (VIN [XXX]) suffered a driver's airbag clock spring failure, completely disabling the primary restraint safety system. ABS light was on, the horn and all other electronics on the steering wheel were not functioning. All symptoms indicated in the recall This vehicle is explicitly covered under Hyundai Extended Warranty Campaign TXXA/TXXJ for 15 years/unlimited miles. However, Hyundai's validation systems are actively rejecting my VIN and blocking my federal right to a cost-free safety remedy or repair reimbursement. I replaced clock-spring and mechanic suggested i check into the recall. I attached receipt for repairs INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755968 — an unverified report by a vehicle owner.
SERVICE BRAKES
I was heading to work when suddenly smoke started pouring from the air conditioning vents, and the ABS and traction control warning lights came on. I hit the brakes to pull over, only to realize I had lost braking power. I managed to steer to the side of the road as carefully as possible and bring the car to a stop—despite having no brakes and a fire burning under the hood. I tried downshifting to slow the vehicle, but the transmission didn't respond, and the cabin began filling with smoke. Once I stopped, there was nothing I could do to extinguish the fire, as the car was completely consumed within seconds. It was a fire in the engine bay; I lost the brakes, and the ABS and traction control lights lit up. I assume it was a critical failure in the braking system, most likely involving the ABS module.
NHTSA complaint #11751236 — an unverified report by a vehicle owner.
SERVICE BRAKES
The contact owns a 2021 Hyundai Sonata. The contact stated that while driving 10 MPH and attempting to make a right turn, the brakes independently activated. Neither the dealer nor an independent mechanic was contacted. The check engine warning light was illuminated. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the dealer and an independent mechanic to be diagnosed. The manufacturer was not notified of the failure. The approximate failure mileage was 42,000.
NHTSA complaint #11747445 — an unverified report by a vehicle owner.
SERVICE BRAKES
Vehicle brakes sound and feel rough when pressing them. And when backing up the vehicle spotted another car turning in and hit brakes automatically. Car jerked hard as if I hit something. Very rough. Made a scrubbing sound. Does the same when pressing the parking button. It perks and makes the scrubbing sound. Just purchased Vehicle 2weeks ago. No inspection on it yet. A warning light about the approaching car but didn't know it was going to hit on brakes by itself so forcefully. Car wasn't near the vehicle just in the scenery of the camera.
NHTSA complaint #11743052 — an unverified report by a vehicle owner.
SERVICE BRAKES
To Whom It May Concern: I am submitting this complaint to report ongoing safety concerns involving my 2013 Hyundai Sonata. I purchased this vehicle in 2022 through financing and paid it off in 2025. Since acquiring the vehicle, I have experienced persistent mechanical issues that I believe may pose a safety risk to myself, my child, and others on the road. The most concerning issue involves the braking system. I have had the brakes replaced and serviced multiple times, yet the brakes begin grinding again within a very short period, including an instance where the grinding returned approximately one month after replacement. Despite spending money on repairs, the problem continues to reoccur. I am concerned that there may be an underlying defect affecting the braking system that is not being properly identified or corrected through normal maintenance. In addition, the vehicle consumes an excessive amount of oil, requiring frequent monitoring and replacement between oil changes. I am concerned that this issue could potentially lead to engine failure or other dangerous mechanical problems while the vehicle is being operated. As a single mother, I rely on this vehicle daily for transportation to and from work and for caring for my family. I have experienced significant financial hardship attempting to keep the vehicle operational and safe. Despite my efforts to maintain the vehicle, these issues continue to occur. I respectfully request that the National Highway Traffic Safety Administration review this complaint and determine whether these issues may be related to known defects, recalls, investigations, or patterns reported by other owners of 2013 Hyundai Sonata vehicles. I am willing to provide maintenance records, repair invoices, mileage information, and any additional documentation that may assist in evaluating this matter. Thank you for your attention to this complaint and for your commitment to vehicle safety.
NHTSA complaint #11742339 — an unverified report by a vehicle owner.
SERVICE BRAKES
Hyundai Sonata SEL - 2022 Both Leg break and hand break didnt work while driving. its a very severe issue in this model.
NHTSA complaint #11741184 — an unverified report by a vehicle owner.
SERVICE BRAKES
We were backing up and leaving a parking space when the emergency braking system overrode our driving and forced a stop. This has happened many times, once while turning at a red light (which we had the right-of-way) and our car stopped on the middle of the intersection. Another time was during a turn in a non-traffic light turn lane where timing is important. Our car was again completely stopped in the middle of the road in oncoming traffic.
NHTSA complaint #11739988 — an unverified report by a vehicle owner.
SERVICE BRAKES
the car has two issues. brake issue (gas pedal is soft and sinks) and engine power ( gas pedal is soft and not responsive) Brakes are soft and spongy some times and sometimes hard. even you push the brake pedal twice or three time it takes long distance to stop. some times the brake looks good but for short period of time. the brakes inconsistent. I took to the dealer where I bought it hey refuse to repair it. then i took it to another dealer. first time they said no issue with car then second time they they replace the vacuum pump and they found out one of the piston is not firing. they replace the ignition coil. the car still has issue and not fixed. I filed case with the manufacturer but the manufacturer closed the case. After that I file lemon law case.
NHTSA complaint #11738622 — an unverified report by a vehicle owner.
SERVICE BRAKES
I have the 2015 Hyundai sonata with the 2.5 GDI engine that eventually will seize due to internal damaged caused by manufacture design flaws. My Hyundai threw a P0010 code which causes my car to idle high and causing low vacuum affecting my brakes. I had a diagnostic test done at a Hyundai dealership that told me it was a cvvt cam sprocket issue and that it was the beginning of the end of the engine, They quoted me 3700.00 but the engine was to far gone and this repair would only accelerate the engine to seize. They said since the engine isn't seize Hyundai will not cover the cost to repair or exchange the engine, I contacted the Hyundai customer service who stated since the repair that is needed wasn't the root cause of the problems associated with the engine swap warranty they were not going to help me even though I explained to them that the cars high accelerating and the braking system been jeopardized and been told the engine is beyond repairs I feel Hyundai should reconsider their decision and help a loyal customer. I have purchased 12 Brand New Hyundaj since 2001. The customer Representative was Extremely un Professional even suggesting I scrap my car, Also I contacted My Hyundai service Technician who said Hyundai customer service never contacted them about my car, When they said they spoke with the technician. Also I received an Extended warranty on the 2.4 GDI engine from Hyundai who many Hyundai customers are or have dealt with.I also purchased an Extended warranty Which I believe should have been extended as well Thank You
NHTSA complaint #11735056 — an unverified report by a vehicle owner.
SERVICE BRAKES
Automatic Emergency Braking Blind Spot Warning/Blind Spot Detection Forward Collision Warning Antilock Brake System/ABS Lane Departure Warning Lane keeping Assistance I bought this vehicle last month from a dealer and two days later all the warning lights start popping up on the dashboard so I contacted the dealer and told them what was going on with the car they told me to bring it in so that the technician can check to see what’s wrong with it they told me that there’s nothing wrong with the vehicle so I went back home and the same day all the warning lights came back on so now I’m concerned about my daughter’s safety because she use the vehicle to drive to and from school and you never know when the brakes might fail, again I just bought this vehicle a month ago just one month not even a year and it’s having all this problem even though it’s a pre-owned vehicle I shouldn’t have to take it to the shop after one month please help… thank you
NHTSA complaint #11734528 — an unverified report by a vehicle owner.
SERVICE BRAKES
We think there’s an issue with the abs module and wheel speed sensor because we started having a problem where the brakes wouldn’t work or would stutter. The car would shake real bad it would make an awful grinding sound but normally only when trying to stop at higher speeds or long braking. The only thing that made it stop was to unplug the abs but then other parts of the car stopped working like the speedometer and the sensors around the car. So we got the abs replaced but the new one started doing the same thing. We did some research and it sounds like the same issue Hyundai is having with the palisade. The incident that made us get it replaced to begin with was were driving down the road and we got to a traffic light but when we tried to brake they just didn’t work so we drove through the red light luckily the one person who was supposed to be going saw us and didn’t pull out in front of us so we didn’t get hit. We haven’t taken it to the dealership yet but my sister who teaches automotive repair at the community college is the one who diagnosed it so she said we should report it here so maybe it won’t happen to anyone else. Before we had the brake issue we were having problems with basically everything on the dash not working randomly. We’d be driving down the road and the speedometer and the outside sensors and the gas gauge and the traction control all would go out at the same time it’s the same stuff that went out when we had the abs unplugged so it seems that might be related.
NHTSA complaint #11732415 — an unverified report by a vehicle owner.
SERVICE BRAKES
ABS module/brakes system goes into limp mode randomly, which causes brake malfunction, throwing codes c1233, c1234 and c1236. There was a recall repair performed by Hyundai about two years ago, however there was two options on NHTSA recall 23V651000/campaign 251. One was to replace a safety plug fuse issue, TSB 23-01-054H . That is the recall they performed. The other recall repair which they did not perform is to replace the ABS module. The Hyundai dealer says I must pay a $225 diagnostic fee for them established they need to do this recall repair . Does that sound correct to you?
NHTSA complaint #11730062 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC
The contact owns a 2011 Hyundai Sonata. While driving at an undisclosed speed, the vehicle lost power, an alarm sounded for the braking system, and the vehicle went into LIMP Mode and the vehicle failed to exceed 15 MPH. After originally paying out-of-pocket for an ABS module at the dealer and was informed that the engine needed to be repaired and the brakes needed to be replaced. The vehicle was towed to the residence where an independent mechanic repaired the vehicle. There was a recall for the ABS module and the contact returned to the dealer, and the dealer confirmed that the independent mechanic had correctly installed the part. The dealer performed the official recall repair and refused to reimburse the contact for the previous expenses. Three months later, the braking system failed again. The contact stated that the vehicle temporarily returned to normal after a restart, but the failure worsened and required a return trip to the dealer for another repair. In January 2026, the failure recurred for a third time with a loud squealing sound. The dealer was not notified of the third failure. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.
NHTSA complaint #11727065 — an unverified report by a vehicle owner.
SERVICE BRAKES
I am the original owner of a 2025 Hyundai Sonata purchased new in 2025. The vehicle currently has fewer than 4,000 miles on the odometer. Since early in my ownership, I have experienced a persistent and recurring squealing noise that occurs specifically when releasing the brake pedal after a short stop, and when transitioning from braking to acceleration. This is not an intermittent or weather/humidity-related issue. The noise has been consistent and ongoing throughout my ownership and has not resolved on its own--I was thinking it might since new cars take some time to adjust. At under 4,000 miles, brake components on this vehicle should be essentially new. Brake pads are engineered to last between 30,000 and 70,000 miles under normal driving conditions. A persistent brake noise at this mileage cannot reasonably be attributed to normal wear and tear and is indicative of a manufacturing defect, defective OEM brake pad compound, or a sticking/dragging brake caliper that fails to fully release after braking. I note that NHTSA has previously investigated Hyundai Sonata brake behavior, including a technical bulletin concerning rear brake pads remaining in contact with rotors after a diagnostic self-check cycle, causing a dragging condition in the next drive cycle. My symptoms are consistent with this type of brake drag behavior. Multiple Hyundai Sonata owners have documented the same persistent squeal-on-release pattern on Hyundai owner forums, with some reporting the issue beginning within the first year of new vehicle ownership and dealers being unable to diagnose or resolve it. I have formally reported this issue to Hyundai Motor America Consumer Affairs prior to filing this complaint and have requested warranty coverage. I am filing this complaint to create an official federal record of this defect and to contribute to any pattern investigation NHTSA may conduct on 2025 Hyundai Sonata brake systems.
NHTSA complaint #11726347 — an unverified report by a vehicle owner.
SERVICE BRAKES
I was driving in the evening on 2/7/26. The red brake light came on in the dash and seconds later the car went into limp mode. An alarm went off indicating that the hybrid system was not functioning. The braking performance decreased significantly. The car slowed down immediately and could not exceed 15 mph. My safety was extremely compromised. Luckily i was not on a high speed road or interstate and was able to pull off onto a side road. If i had been on a busier road, I believe that i would have been in an accident. This could have seriously injured myself or others. The vehicle was towed to a repair shop. The braking pump was replaced and that rectified the problem so far. The old part has been disposed of. The problem was reproduced by the repair facility.
NHTSA complaint #11726063 — an unverified report by a vehicle owner.
SERVICE BRAKES
I contact the Hyundai dealer about my 2016 Hyundai sonata. for all I know those vehicles have recalls with engine failure/stalling due to premature rod bearing wear, fire risks from malfunctioning electric oil pumps. My car is having those exact problems with the abs lights being on and is also have problems with the VVT sprocket. And the oil I called Hyundai and they said my vehicle only has a recall with the JUNCTION BOX. But my car is unable to go over 60. And is unsafe to drive and the recalls with that type of model car is the same recalls I am having and soon as I've bought the car and had it for some time i am starting to have those problems so I would like to know what’s going on because it is unsafe and I can’t even drive my vehicle I also have a blinking check engine light. I’ve wanted to report this now incase risk of a fire because I’ve did my research and realize these cars that have these type of problems are known for catching on fire.
NHTSA complaint #11725141 — an unverified report by a vehicle owner.
SERVICE BRAKES
The contact owned a 2013 Hyundai Sonata. The contact stated that while the contact's son was driving at an undisclosed speed, the brake pedal was depressed, the vehicle failed to stop as intended. The contact's son noticed an unusual sound coming from the hood compartment. The contact stated that the sound was as if something was coming through the hood. The contact's son lost control of the vehicle. The contact's vehicle rolled four times before rolling into a ditch. The contact's vehicle caught on fire. The contact's son was still inside the vehicle. The contact's son exited the vehicle. The fire department arrived and extinguished the fire. The vehicle was towed to a local tow yard. The contact's son was transported by a medical helicopter to a local medical facility. The contact's son sustained a punctured left lung, seven broken ribs, a fractured right hip, and additional bruises, minor burns, and bumps. The contact was advised by the insurance company to report the failure to the NHTSA Hotline. In addition, the contact was informed of an unrepaired recall associated with the VIN, NHTSA Campaign Number: 22V312000 (Fuel System, Gasoline), which the contact was not aware of the unrepaired recall. The contact was unsure if the vehicle had been inspected by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 170,000.
NHTSA complaint #11724176 — an unverified report by a vehicle owner.
SERVICE BRAKES
I was turning into a parking spot and the car accelerated unexpectedly. I slammed into a snow bank and my front bumper was damaged.
NHTSA complaint #11720509 — an unverified report by a vehicle owner.
SERVICE BRAKES
My engine light come on. Air flow notification come on. I had a brake cleaner notification come on.
NHTSA complaint #11717157 — an unverified report by a vehicle owner.