2,008 of the
22,302 complaints filed about the Hyundai Sonata
are about the electrical system —
100% of everything owners reported.
The worst model year for it is 2011.
A/C blower motor fan would stop working. Happened twice within less than a year apart. Upon further inspection, multi fuse wiring overheated and melted, ruining fuse and making A/C stop working during 100+ temperatures outside. Apparently this is a well known issue with this make and model Sonata. Electrical failure.
NHTSA complaint #11762639 — an unverified report by a vehicle owner.
I was driving down the road going the speed limit and all of a sudden it felt like I hit a brick wall my car staked out and I was stuck in the middle of the road for about 20 minutes and finally I got it to start and drove home it did it again 2 months later
NHTSA complaint #11762026 — an unverified report by a vehicle owner.
I am submitting a safety complaint regarding a recurring, unresolved electrical defect in my 2020 Hyundai Sonata SEL. The vehicle fails to recognize when the ignition is switched off, leaving core vehicle systems active and causing severe parasitic battery drain that leaves the car immobilized. Description of the Problem: False "On" Status: After parking, turning off the engine, and exiting the vehicle, the car continues to register as though the ignition is still active/on (accessories, cluster, or vehicle network remain awake). Severe Parasitic Draw: Because the vehicle fails to shut down its electrical circuits, the 12-volt battery repeatedly discharges overnight or while parked for short durations. Battery Replacement Did Not Resolve Issue: The 12-volt battery was replaced with a brand-new unit to eliminate typical wear, yet the drain and false "on" behavior persisted immediately. Frequency: The vehicle frequently fails to start, requiring constant jump-starts or roadside assistance to operate. Safety Hazard: This defect creates a direct safety risk by repeatedly stranding the driver without warning in public locations, traffic stops, or remote areas. In addition, an electrical system that fails to enter a sleep state creates a potential hazard for component overheating, failure of electronic security and locking systems, or total electrical failure while attempting to restart or operate auxiliary safety equipment. Other Hyundai owners have reported identical issues where the body control modules or ignition logic fail to power down. Corrective Action Requested: I request that the NHTSA investigate this electrical shutdown defect across the 2020 Hyundai Sonata model year to identify whether a faulty Body Control Module (BCM), smart key receiver, or ignition switch relay requires a safety recall and software or hardware remediation. Battery replaced on 09/04/2026 Car inspected/diagnosed by Hyundai Dealership on 09/03/2026
NHTSA complaint #11761900 — an unverified report by a vehicle owner.
I had taken my Sonata to Mike Miller Hyndia in Peoria,I'll and they agreed to do the recall although they had my vehicle for two weeks. They did not service it and when I picked it up they said I had to drive it till the service engine light come on. I was driving it five days later and heard a loud noise and car started malfunctioning I was stuck in a middle of a intersection and I had to push vehicle off road. I broke my right hand in this process and I have also lost my job I am very concerned why they did not service it after they agreed too and sent me off in it in that condition ..The car is currently parked and unsure what to do with it ..
NHTSA complaint #11760651 — an unverified report by a vehicle owner.
Parking malfunction. Parked, running car moved itself to reverse and backed up a driveway crossing a dirt road and hitting a fence and post. This car could have hit and severely injured anyone who was in the path while it was reversing on its own. Car was in reverse and all parking sensors were blaring when the car was found minutes later.
NHTSA complaint #11759884 — an unverified report by a vehicle owner.
Blower motor malfunction at night. Smelled something burning. Extremely hot and humid outside. Windows fogged up inside which greatly reduced visibility. Checked the multifuse which controls the ABS, oil pump, cooling fan, & Blower. I discovered a burnt connection on one of the terminals for the blower. This is a huge safety and fire risk and needs to be addressed ASAP!!!! Upon my research, I’m finding several Hyundai Sonata vehicles having this same exact issue. Kia vehicles are being recalled for this same exact issue. Why isn’t the Hyundai Sonata??
NHTSA complaint #11758874 — an unverified report by a vehicle owner.
The AC/heating blower motor circuit on my 2020 Hyundai Sonata failed intermittently due to extreme electrical resistance overheating and melting the terminal pins inside the engine fuse box. I took it to the dealership and they inspected it said it was out of warranty but it needed part number 18980-09910-FFF and wiring kit 91300L1000-FF to repair at a cost of 780.00 including parts, tax, and labor. This matches the severe design defect acknowledged in Hyundai TSB #25-EE-002H or alternative TSB-24-EEOO-1H. I filed case number 43138757 with Hyundai corporate. For now this just affects my air conditioning. However, the root failure is a known design defect that presents a severe vehicle fire hazard and potential loss of windshield defrosting capability, lights, etc. if the whole electrical system should fail. As you should know the engine bay fuse box (which currently has melted parts) is the "brain" for the car's electrical distribution. It doesn't just power my AC fan; it holds the fuses and relays for the cars fuel pump, engine control module (ECM), headlights, and electronic power steering. If left unfixed and over time as the plastic melts, copper wires will cross and touch each other, causing a massive short circuit. My engine could suddenly cut out and stall while I am traveling at 70 mph on the highway, instantly killing my power steering and power brakes and putting me in extreme danger. Again not to mention the fire hazard this situation is likely to cause. This should be addressed via a mandatory safety recall, so that I don’t have to pay for a known engineering design defect and in case the TBS bulletin fails or further unknown damage has already occurred.
NHTSA complaint #11757743 — an unverified report by a vehicle owner.
On the freeway at night when headlights and back lights quit working. Got off freeway and were able to temporarily fix it. A few months later while parked in driveway and not in use for a couple of days, lights came on without our knowledge and drained our battery. Neighbor alerted us to the situation.
NHTSA complaint #11756748 — an unverified report by a vehicle owner.
The entire dash cluster including the radio display cuts off and back on while driving. The only way I can describe it, is that the car seems to act like it was turned off then back on again. Initial lights when you start the car come on, seatbelt lights, initial startup dash lights, headlight indicator, headlights, radio, drive setting, everything turns off and back on while driving. Lasts for anywhere from 5-15 seconds. this has been going on for over a year now and the dealership has been made aware and have attempted to recreate the incident without success. It doesn't happen with any one way of driving, it happens at random times and so quickly, no photo evidence is able to be obtained. This most recent incident I did have a dashcam installed and it powered off and back on as it does when the vehicle is turned on and off. A different situation that my car has been having that is unable to be recreated is that the windows will lock up and not go down as well as when this happens the doors either remain locked unable to be unlocked or don't lock at all. This has also been reported to the dealership and they held my vehicle for a week attempting to recreate it without success even though I have multiple video evidence of this occurrence. I do not have pictures, but do have videos and it will not let me upload videos.
NHTSA complaint #11756636 — an unverified report by a vehicle owner.
The Left blinker switch keeps going in and out, working about 50% of the time. Both the light and the blinker sound do not turn on. When getting it checked out at an auto repair shop, the maintenance tech said this was more and more common for 2021 sonatas and it was not due to anything I did. It was a multifunction switch problem.
NHTSA complaint #11755451 — an unverified report by a vehicle owner.
1.) Following Hyundai's 9C2 Campaign update for the ECU that was completed back on May 27th, 2026, my 2015 Sonata went into limp mode [solid check engine light present] while I was accelerating up an on-ramp on the 2nd drive cycle since the update was performed. I was already far away from the dealership so I was forced to limp it to my local shop that I regularly use to have it checked out. It was confirmed that the code on the vehicle was P200A for intake manifold runners. Since the update was for smog regulation, the code was cleared in order to see if it would come back. Since then, it has not, however the vehicle continues to have one persistent problem. The RPMs will dramatically dip and then surge back upwards while the car is coasting (no gas and no brake applied). 70% of the time, you can feel the car violently jerk as it appears to try and correct itself. 2.) I've brought this car to multiple dealerships, have a case open with corporate and have also found that this is a systemic issue with this specific update in these cars. All and all, nothing has been done. I'm repeatedly turned away over and over again because their techs are only permitted to look into it once they have hard evidence of a fault. In this case, that would be a dashboard light. I'm told that I may only return if the check engine light comes back, which as I mentioned previously, posed a HUGE safety risk to myself the first time it appeared. If I can only go 55mph down the highway, I am at risk of being rear-ended or struck in some way. 3.) The problem has not been reproduced by the dealer as they will not test drive it to see the dip and spike. However, the code was still pending for awhile in the vehicle before it cleared it on its own, so that was acknowledged by at least one place. 4.) Vehicle has not been inspected by anyone but a dealership and local mechanic. 5.) No other signs prior to the vehicle limping out on me other than some acceleration concerns on May 27th, 2026.
NHTSA complaint #11755317 — an unverified report by a vehicle owner.
I was driving and all of a sudden the traction lights turned on and the sterring wheel is hard to turn. Almost go in a car accident. The windows just stopped working and the brakes light constantly keep getting burned out.
NHTSA complaint #11752817 — an unverified report by a vehicle owner.
I am writing to report a direct violation of the Theta II Class Action Settlement terms by Hyundai Motor America. This morning , I emailed an Executive Case Manager explicitly explaining that my 2017 Sonata has an active P1326 code, has the 2019 KSDS update, and requires a mandatory diagnostic under NHTSA Recall 17V226 that cannot be denied due to a salvage title. Instead of replying to my facts, the Case Manager Kathy gave me a hard denial falsely framing my federal recall safety request as a "voluntary goodwill warranty" issue to justify her rejection. Please help me in getting authorization my car with Hyundai dealership in Plano Tx to run the bearing rod test and get it fixed.
NHTSA complaint #11751813 — an unverified report by a vehicle owner.
I was heading to work when suddenly smoke started pouring from the air conditioning vents, and the ABS and traction control warning lights came on. I hit the brakes to pull over, only to realize I had lost braking power. I managed to steer to the side of the road as carefully as possible and bring the car to a stop—despite having no brakes and a fire burning under the hood. I tried downshifting to slow the vehicle, but the transmission didn't respond, and the cabin began filling with smoke. Once I stopped, there was nothing I could do to extinguish the fire, as the car was completely consumed within seconds. It was a fire in the engine bay; I lost the brakes, and the ABS and traction control lights lit up. I assume it was a critical failure in the braking system, most likely involving the ABS module.
NHTSA complaint #11751236 — an unverified report by a vehicle owner.
This vehicle had a recall, 201, for the smart junction box. This was due to the blinkers not working properly. The software update was performed, however, the problem still exists. This was due to the smart junction box. Now, aside from the blinker issue, the ac stays on when the engine is turned off, lights come on by themselves, the media screen goes randomly into night mode, daylight running lights are constantly in night mode, smart junction box failure. I have not taken this to a mechanic as of yet, the dealership is aware, and I opened a case with Hyundai case #42940056, however, I have not received a call from my service advisor or Hyundai. They offered to do diagnostics, but, if these problems are not about the safety recall, I would have to pay $350 for diagnostics, unless I get the problem fixed by them. This car has 66k miles with a new engine installed at 59400 miles! At this point, I have the car parked, battery disconnected, and looking for the most efficient way to fix the problem, which must be performed by specialized equipment.
NHTSA complaint #11750940 — an unverified report by a vehicle owner.
May 23rd, 2026, vehicle dash and navigation screens went black while driving on freeway. May 26th, 2026, vehicle battery completely drained. Purchased new battery and the same thing happened. Took the vehcile 3x to Hyundai dealership, switched out battery for a brand new OEM one. June 10th, vehicle died again, battery was completely drained. Dealership said its not the alternator but only jumped the vehcile since they couldn't figure out the issue. July 11th, 2026, vehcile died for 4th time and had to jumped again. Tested battery by tow truck driver, battery was DRAINED but alternator fine.
NHTSA complaint #11749769 — an unverified report by a vehicle owner.
My vehicle while driving, it is jerking and shaking. When I come to a stop, the cars rpms go up and down while the car is shaking. When I pressed the gas pedal to accelerate the car will not accelerate as normal and the car jerks as I’m driving it. The RPMs rev up and down without any pressure placed on the gas pedal. The check engine light came on.The miles per hour only allows me to put one digit. I wanted to clarify that the problem is occurring anywhere between 0 mph to 65 mph when these the car jerks and shakes and the RPMs go up and down without me pressure on the gas pedal.
NHTSA complaint #11749650 — an unverified report by a vehicle owner.
The contact owns a 2013 Hyundai Sonata. The contact stated that while driving at 60 MPH, the airbag warning light illuminated, and the horn failed to engage as intended. Additionally, the vehicle failed to respond when the accelerator pedal was depressed. The vehicle was taken to the dealer where it was diagnosed that the brake vacuum pump was not operating correctly and needed to be replaced. The vehicle was repaired by replacing the clock spring. The contact related the failure to a clock spring warranty extension TSB; however, the VIN was excluded. The manufacturer was notified of the failure and offered no assistance. The failure mileage was 124,000.
NHTSA complaint #11749065 — an unverified report by a vehicle owner.
Intermittent issue. On startup, the hvac system cycles through the modes and gets stuck blowing on mixed mode (face and feet) regardless of what mode is selected. The problem is temporarily fixed by manually tapping the mode button until the desired mode is selected.
NHTSA complaint #11747323 — an unverified report by a vehicle owner.