1,087 of the
22,259 complaints filed about the Hyundai Sonata
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 2013.
Issue- fuel pump/supply line causing fuel to leak and fuel smell around the outside of the car. This can cause a major fire, explosion, death for myself and others around me. Problem has been confirmed by auto repair shop. No warning messages on car dash board, just strong smell of gas. Replaced gas cap and smell is still there.
NHTSA complaint #11757985 — an unverified report by a vehicle owner.
I took my vehicle in for the safety recall due to an expanding fuel tank on 08/03/2026. I received my vehicle back on 8/12/2026. Hyundai performed an improper repair on the vehicle that will not correct the fuel tank expansion. They replaced the same check valve that was replaced last time I brought the vehicle in for recall on 11/20/2024 repair order # 107221 at Jones Hyundai of Belair. This valve did not and will not correct the fuel tank expansion issue. The expansion issue is caused by fuel getting past the check valve and entering the purge control system. The correct repair is to replace the fuel tank and the purge control system, as the check valve has already allowed fuel to bypass it and enter the system causing the expansion issue. . Replacing the valve that failed & allowed fuel into the system & caused the tank to expand will not correct the issue caused by the failed valve. My fuel tank has not decompressed. I still have the same problem I brought the vehicle in for because the repair Hyundai advised NHTSA on was NOT performed.
NHTSA complaint #11757244 — an unverified report by a vehicle owner.
I own a 2023 Hyundai Sonata SEL. Over approximately three years, the vehicle experienced four separate incidents involving sudden loss of engine power and recurring fuel injector/powertrain problems. Three of these incidents occurred while the vehicle was being driven on interstate highways, creating serious safety concerns. The first incident occurred on XXX, on [XXX] [XXX]. My daughter was driving the vehicle at the time when it suddenly lost power while traveling on the interstate. She had to maneuver the vehicle to the shoulder under unsafe traffic conditions. The second incident occurred on XXX, on [XXX] near [XXX]. I was driving the vehicle when it again experienced sudden loss of power while traveling at highway speed. The third incident occurred on XXX, in [XXX]. The vehicle experienced another significant power-loss event and required roadside assistance. The fourth incident occurred on XXX, on [XXX]. The vehicle again experienced a sudden loss of engine power while I was driving on the highway. Despite multiple repair attempts, including repairs related to the fuel injectors, the same or substantially similar power-loss problem continued to recur. Because the vehicle has repeatedly lost engine power while being driven, including multiple incidents at interstate highway speeds, I believe this recurring condition presents a serious safety risk. I am reporting these incidents so NHTSA can evaluate whether this may represent a broader safety-related defect affecting this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755422 — an unverified report by a vehicle owner.
1.) Following Hyundai's 9C2 Campaign update for the ECU that was completed back on May 27th, 2026, my 2015 Sonata went into limp mode [solid check engine light present] while I was accelerating up an on-ramp on the 2nd drive cycle since the update was performed. I was already far away from the dealership so I was forced to limp it to my local shop that I regularly use to have it checked out. It was confirmed that the code on the vehicle was P200A for intake manifold runners. Since the update was for smog regulation, the code was cleared in order to see if it would come back. Since then, it has not, however the vehicle continues to have one persistent problem. The RPMs will dramatically dip and then surge back upwards while the car is coasting (no gas and no brake applied). 70% of the time, you can feel the car violently jerk as it appears to try and correct itself. 2.) I've brought this car to multiple dealerships, have a case open with corporate and have also found that this is a systemic issue with this specific update in these cars. All and all, nothing has been done. I'm repeatedly turned away over and over again because their techs are only permitted to look into it once they have hard evidence of a fault. In this case, that would be a dashboard light. I'm told that I may only return if the check engine light comes back, which as I mentioned previously, posed a HUGE safety risk to myself the first time it appeared. If I can only go 55mph down the highway, I am at risk of being rear-ended or struck in some way. 3.) The problem has not been reproduced by the dealer as they will not test drive it to see the dip and spike. However, the code was still pending for awhile in the vehicle before it cleared it on its own, so that was acknowledged by at least one place. 4.) Vehicle has not been inspected by anyone but a dealership and local mechanic. 5.) No other signs prior to the vehicle limping out on me other than some acceleration concerns on May 27th, 2026.
NHTSA complaint #11755317 — an unverified report by a vehicle owner.
My 2016 Hyundai Sonata (VIN: [XXX]) has a serious safety issue involving excessive engine oil consumption. The vehicle loses oil rapidly between changes and requires frequent top‑offs to avoid engine damage. This creates a risk of sudden engine failure while driving. The dealership, South Charlotte Hyundai (10518 Cadillac Street, Pineville, NC 28134), refused to perform Hyundai’s official oil‑consumption test. Instead, they told me to pay $750 for a combustion cleaning and stated it would not fix the underlying problem. They would not document the refusal or provide any testing. I contacted Hyundai Corporate multiple times: • May 21, 2026 – Executive Office complaint submitted • June 3, 2026 – Follow‑up sent • June 29, 2026 – Regional escalation sent My Hyundai case number is XXX. As of XXX Hyundai has not responded to any of my Executive Office or Regional escalations. Only Customer Care replied with a template denial and no investigation. I have been waiting over two months with no action from Hyundai Corporate. I am reporting this because the manufacturer has not addressed a safety‑related defect, the dealership refused required testing, and the vehicle continues to consume oil abnormally. I am requesting NHTSA’s assistance in documenting this defect and Hyundai’s lack of response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755304 — an unverified report by a vehicle owner.
The contact owns a 2021 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the fuel gauge indicated that the tank was half full. The contact stated that the gauge erroneously indicated that the tank was empty, and the check engine warning light was illuminated. The vehicle was driven to the gas station, and while attempting to refuel the vehicle, the fuel did not go into the tank. The vehicle was towed to the residence. The vehicle was later towed to the dealer, where it was diagnosed with a failed fuel system and a failed fuel tank. The contact was informed that the fuel system and fuel tank needed to be replaced. The vehicle was not repaired. The contact was informed that the failure was associated with the unrepaired recall. The contact was informed that the vehicle was a fire risk. In addition, the contact was informed that there was a hole in the fuel tank that caused the fuel to leak out of the fuel tank. The contact was informed that the parts were ordered to repair the vehicle. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline). The manufacturer was not made aware of the failure. The failure mileage was approximately 50,200.
NHTSA complaint #11754791 — an unverified report by a vehicle owner.
RECALL REMEDY FAILURE AND MANUFACTURER COERCION My Certified Pre-Owned 2022 Hyundai Sonata Limited has been held completely out of service at an authorized Hyundai facility since June 2, 2026, due to severe fuel tank expansion under active NHTSA Safety Recall 25V-796 (Hyundai Campaign 286).The dealership confirmed that the defective expanding plastic fuel tank ballooned with enough force to structurally warp and buckle the unibody center floor pan and frame rails. Rather than providing a safe, timely remedy under federal recall guidelines, Hyundai Corporate and the dealership are attempting to coerce me into an unfair, non-statutory "voluntary trade-in" that simply pays off my remaining loan balance ($22,000) while completely wiping out the $9,000 in cash equity ($3,000 down payment and $6,000 in monthly payments) I have invested into the car. Upon rejecting this predatory trade-in offer, the manufacturer immediately threatened an additional 6 to 8-week delay to attempt a massive structural frame and unibody pull, which would bring the total out-of-service time to over 90 to 110 cumulative days. Furthermore, the dealership is actively withholding the internal diagnostic write-ups and structural alignment prints from me. I am requesting that the NHTSA investigate this recall remedy failure. Hyundai is using extreme delays (90+ days) and structural frame threats to force consumers to abandon their financial equity rather than issuing lawful, purchase-price repurchases for vehicles deemed structurally unsafe due to a manufacturing defect. I can't provide any documents as they have refused being able to provide me with any. Was told I would be emailed a copy from the dealership several times and they never end up sending over any information.
NHTSA complaint #11754635 — an unverified report by a vehicle owner.
Car was taken to dealership for inspection. Upon inspection, it was determined that the fuel tank had expanded and pushed towards the heat shield, and expanded upward pushing up the back seats of vehicle. It was determined to not safe to drive. Manufacturer contacted me and offered a buyback. Upon their offer of a buyback, it was determined that I would owe the manufacturer approximately $2,000. I have requested that they fix it, and they have refused to give me the paperwork I requested about the car's condition and fixability. I am in the process of negotiating and am filing this complaint for the record.
NHTSA complaint #11753819 — an unverified report by a vehicle owner.
Diagnosed 07/20/2026 with catastrophic oil ring failure requiring engine replacement. Engine can stall due to oil degradation/absence of causing uncontrolled vehicle handling and fire. This would put myself and others at risk. It has been diagnosed at dealership. Complaint Narrative: The subject vehicle is experiencing its third total engine failure due to an inherent manufacturing and design defect, presenting a severe and repeating highway safety hazard. The original factory engine failed catastrophically in 2015 at 116,440 miles and was replaced under NHTSA Recall 15V-568. The second engine failed in 2021 at 244,710 miles and was replaced under NHTSA Recall 17V-226. The third engine (the second replacement) has now failed prematurely at 334,935 chassis miles, lasting a mere 90,225 miles. An authorized Hyundai dealership diagnosed a total failure of the oil control rings. This mechanical defect allows engine oil to bypass the pistons directly into the combustion chambers. This causes severe, rapid oil consumption, spark plug fouling, engine stalling, and total loss of motive power at highway speeds without prior dashboard warning illumination. The manufacturer is failing to provide safe, durable remedies for its federally mandated safety recalls (see warranty info Magnuson-Moss Warranty Act (15 U.S.C. § 2301 et seq./ Breach of Implied Warranty of Merchantability). Instead, they are installing subsequent replacement powerplants that suffer from the exact same structural vulnerabilities and component lifecycle failures. This creates a continuous risk of sudden engine seizure and traffic collisions for consumers.
NHTSA complaint #11753470 — an unverified report by a vehicle owner.
The contact owns a 2023 Hyundai Sonata. The contact stated that while driving approximately 15-40 MPH, the vehicle was sputtering and shaking abnormally. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); but the VIN was not under recall. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,500.
NHTSA complaint #11753540 — an unverified report by a vehicle owner.
The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The vehicle was taken to the local dealer, and the contact was informed that the fuel tank was swollen and needed to be replaced. The vehicle was not yet repaired. The failure mileage was 80,484.
NHTSA complaint #11753027 — an unverified report by a vehicle owner.
Engine revving at a complete stop. Surging engine while braking. I was forced to put into neutral when stopping. I had check engine prior that read P049D85. It went away. The Hyundai dealer said to be the EGR valve. Nick Hayes at D'Arcy Hyundai and Hyundai Motor America (HMA) agreeing to a 75% goodwill split of cost to repair.
NHTSA complaint #11753130 — an unverified report by a vehicle owner.
The contact owns a 2018 Hyundai Sonata. The contact stated that while operating the vehicle, there was an abnormal fuel odor inside the vehicle. The vehicle was taken to the local dealer and was diagnosed with an inoperable low-pressure fuel pump. The contact was informed that the low-pressure fuel pump needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact stated that the manufacturer had issued an extended warranty coverage for the failure. The failure mileage was 92,000.
NHTSA complaint #11752670 — an unverified report by a vehicle owner.
I purchased fgis car from a used car dealership, for over $6,000.00 , which is not a ton of money, but plenty enough to not have instant issues. Since my purchase in june 30, 2026, i have already had all of these issues occur. There is white smoke coming from the left tail pipe, it is sluggish when you push on the gas, there is black soot constantly on my rims that is extreamly hard to remove, the high pressure fuel pump jas failed, I can tell because the oil is higher then it was when o had the oil freshly changed, and it smells of gasoline.inside the oil. The exhaust has stron smell of gasoline. My steering wheel has a loud clinking noise everytime I go over a speed bump on pull into my driveway. Just so many items consistently needing repair or replacement, even though I just had the fuel system cleaned, the oil changed, and filters, and.oil filter too. I checked to see if any of my issues are covered by a recall warranty, because they all are recalled items for my car year, make, and model, but apparently Hyunfai is only covering these dangerous recall items for ul to 10 years. These items shkuld be covered longer, because my carfax states that at least one of these recalled items had already been changed in 2018, and is already broken again!! Hyundai should have covered these extreamly high wear out car parts for a longer period of time, or for the life of the vehicle, if every 5 years your replacing a $1000.00 part, not including labor, like the (HPFP) I was quoted by auto zone for over that price point!! "Ridiculous"! Another item is the air bag cover on the driver side windows area, of the body frame it is loose and keeps un-clipping, i am afraid that it is going to possibly just go off and kill me or something!! Very disappointed right now, that i cannot get any of these recalled items replaced by the manufacturer!!
NHTSA complaint #11751926 — an unverified report by a vehicle owner.
I am writing to report a direct violation of the Theta II Class Action Settlement terms by Hyundai Motor America. This morning , I emailed an Executive Case Manager explicitly explaining that my 2017 Sonata has an active P1326 code, has the 2019 KSDS update, and requires a mandatory diagnostic under NHTSA Recall 17V226 that cannot be denied due to a salvage title. Instead of replying to my facts, the Case Manager Kathy gave me a hard denial falsely framing my federal recall safety request as a "voluntary goodwill warranty" issue to justify her rejection. Please help me in getting authorization my car with Hyundai dealership in Plano Tx to run the bearing rod test and get it fixed.
NHTSA complaint #11751813 — an unverified report by a vehicle owner.
When my father was driving, the vehicle stalled out with no prior odd activity. He pulled over to the side of the road and attempted to start the vehicle. He saw smoke, opened the hood, saw flames and cleared the area of the vehicle. Due to the large Hyundai/Kia engine recall for his year of vehicle, the engine had been replaced 2-3 times and ONLY EVER been serviced by the dealership. We do not know if all recall repair work had been done, because there was also a fuel line recall which was "fixed" in 2020 and 2022.
NHTSA complaint #11751024 — an unverified report by a vehicle owner.
The contact owns a 2022 Hyundai Sonata. The contact received notification of NTHSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11746780 — an unverified report by a vehicle owner.