Owners have filed 140 complaints
about the 2023 Hyundai Sonata with NHTSA between 2022 and 2026.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 23 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 10
Against the median year of the Hyundai Sonata. 50 means typical for this
model; 100 means roughly double.
Severity — 44
8.6% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
67% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
433.3%
1,000 – 9,999 miles
18.3%
10,000 – 24,999 miles
216.7%
25,000 – 49,999 miles
18.3%
50,000 – 74,999 miles
216.7%
75,000 – 99,999 miles
216.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2022peak 11Aug 2026
Recalls on the 2023 Hyundai Sonata
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V796000
FUEL SYSTEM, GASOLINE
Hyundai Motor America (Hyundai) is recalling certain 2020-2023 Sonata vehicles. A damaged check valve can allow air to enter the fuel tank, causing it to expand and contact hot exhaust components, melting the tank.
Risk: A melted fuel tank can leak, increasing the risk of a fire.
23V526000
POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:PUMP
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.
Risk: An electric oil pump assembly that overheats increases the risk of a vehicle fire.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20256375,616 units in Canada
Fuel System
Issue: On certain vehicles, the check valve for the purge control system could wear and cause the fuel tank to expand. As a result, the fuel tank could contact hot components and fuel could leak. Note: This recall only affects certain vehicles equipped with a 1.6 L turbocharged engine. This safety recall replaces emissions recall no. ECR-H0003-24-005 (Hyundai recall no. C0566). Vehicles that were repaired under that recall also require this repair. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the check valve and update the electronic control unit (ECU) software. The dealer will also inspect the fuel tank and surrounding components and repair them, as necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
Oro Valley, AZCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
Reported this previously, but more information was gathered, thanks to collision mechanic who guessed immediately when he heard 2023 hybrid Sonata - he said "they're notorious for it." Was at a stand still in a parking space/lot I know well. Cautious driver, watch my speed, very aware of other drivers, quick reaction time. Incident mid day, no pedestrians, distractions, no moving traffic. Vehicle doors shut, seat belt on. Not on incline. Pulled into parking spot I use weekly, spot has parking curb. Was at a full stop. Realized I had not pulled into the spot quite far enough, and attempted to inch vehicle forward. (Do not recall any warning lights, but this car usually alerts at literally anything - even shadows.) Very lightly applied gas to inch forward, slowly. Felt slight "scrape" of undercarriage on the parking curb. Put car in reverse, lightly applied gas to inch back. Car did not rev, no screeching tires, it was at a standstill previously. Was in Eco mode. All seemed normal, until vehicle suddenly launched UP the parking curb, full force, and into a building pillar directly ahead. The car never moves with that much force, I'm not a pedal-to-the metal driver. Eco mode on. No airbag deployment, injuries, etc. Sheriff took report for the building, simple incident. I couldn't make sense of it. I know how overly cautious I am while parking, what I do, and don't do. Took responsibility, but was still analyzing a week later, and explained what I remembered to the mechanic. He guessed right away. Said Sonatas were notorious for it. He said they're known for randomly applying the ebrake unexpectedly - and also randomly releasing the ebrake - and aggressively (and silently) switching from electric to gas when met with resistance, aka the parking curb. Insurance totalled the car. 2.5 years old, 17k miles. This was my 3rd Hyundai in 20 years, others were great. Discovered 40,000 Elantra hybrids, same year as my Sonata, were recalled due to "unintended acceleration."
NHTSA complaint #11724237 — an unverified report by a vehicle owner.
Reported this previously, but more information was gathered, thanks to collision mechanic who guessed immediately when he heard 2023 hybrid Sonata - he said "they're notorious for it." Was at a stand still in a parking space/lot I know well. Cautious driver, watch my speed, very aware of other drivers, quick reaction time. Incident mid day, no pedestrians, distractions, no moving traffic. Vehicle doors shut, seat belt on. Not on incline. Pulled into parking spot I use weekly, spot has parking curb. Was at a full stop. Realized I had not pulled into the spot quite far enough, and attempted to inch vehicle forward. (Do not recall any warning lights, but this car usually alerts at literally anything - even shadows.) Very lightly applied gas to inch forward, slowly. Felt slight "scrape" of undercarriage on the parking curb. Put car in reverse, lightly applied gas to inch back. Car did not rev, no screeching tires, it was at a standstill previously. Was in Eco mode. All seemed normal, until vehicle suddenly launched UP the parking curb, full force, and into a building pillar directly ahead. The car never moves with that much force, I'm not a pedal-to-the metal driver. Eco mode on. No airbag deployment, injuries, etc. Sheriff took report for the building, simple incident. I couldn't make sense of it. I know how overly cautious I am while parking, what I do, and don't do. Took responsibility, but was still analyzing a week later, and explained what I remembered to the mechanic. He guessed right away. Said Sonatas were notorious for it. He said they're known for randomly applying the ebrake unexpectedly - and also randomly releasing the ebrake - and aggressively (and silently) switching from electric to gas when met with resistance, aka the parking curb. Insurance totalled the car. 2.5 years old, 17k miles. This was my 3rd Hyundai in 20 years, others were great. Discovered 40,000 Elantra hybrids, same year as my Sonata, were recalled due to "unintended acceleration."
NHTSA complaint #11724237 — an unverified report by a vehicle owner.
Oro Valley, AZCrash
BACK OVER PREVENTION: WARNINGS
Reported this previously, but more information was gathered, thanks to collision mechanic who guessed immediately when he heard 2023 hybrid Sonata - he said "they're notorious for it." Was at a stand still in a parking space/lot I know well. Cautious driver, watch my speed, very aware of other drivers, quick reaction time. Incident mid day, no pedestrians, distractions, no moving traffic. Vehicle doors shut, seat belt on. Not on incline. Pulled into parking spot I use weekly, spot has parking curb. Was at a full stop. Realized I had not pulled into the spot quite far enough, and attempted to inch vehicle forward. (Do not recall any warning lights, but this car usually alerts at literally anything - even shadows.) Very lightly applied gas to inch forward, slowly. Felt slight "scrape" of undercarriage on the parking curb. Put car in reverse, lightly applied gas to inch back. Car did not rev, no screeching tires, it was at a standstill previously. Was in Eco mode. All seemed normal, until vehicle suddenly launched UP the parking curb, full force, and into a building pillar directly ahead. The car never moves with that much force, I'm not a pedal-to-the metal driver. Eco mode on. No airbag deployment, injuries, etc. Sheriff took report for the building, simple incident. I couldn't make sense of it. I know how overly cautious I am while parking, what I do, and don't do. Took responsibility, but was still analyzing a week later, and explained what I remembered to the mechanic. He guessed right away. Said Sonatas were notorious for it. He said they're known for randomly applying the ebrake unexpectedly - and also randomly releasing the ebrake - and aggressively (and silently) switching from electric to gas when met with resistance, aka the parking curb. Insurance totalled the car. 2.5 years old, 17k miles. This was my 3rd Hyundai in 20 years, others were great. Discovered 40,000 Elantra hybrids, same year as my Sonata, were recalled due to "unintended acceleration."
NHTSA complaint #11724237 — an unverified report by a vehicle owner.
Egg Harbor City, NJCrash
STRUCTURE:BODY
Recall 286 my vehicle suffered from this causing heat module failure misfire in cylinder 2 and high pressure in gas tank. Sports Hyundai had previously done a 180 day repair under recall 9b1 for an expanded gas tank after the repair the car suffered from the updated recall 286 . I brang to the dealership 4 times with check engine and misfires and limp mode between 57k and 68k they refused to fix the car under recall 286 and cleared all the codes and continued to make me leave in a unsafe car. On February 14th it sport Hyundais negligence was the direct cause of an auto accident were the car was unable to move out the way because of lack of power /limp mode. I begged them in the final days of me having the car to fix it and saying I didn’t feel safe and they wouldn’t without an extensive amount of money I could not provide . I’m currently filing a claim with Hyundai consumer affairs and the dca in Newark and also my senators office and I have a lawyer also who might help I wish to report this to the NHTSA.
NHTSA complaint #11722063 — an unverified report by a vehicle owner.
Egg Harbor City, NJCrash
ENGINE
Recall 286 my vehicle suffered from this causing heat module failure misfire in cylinder 2 and high pressure in gas tank. Sports Hyundai had previously done a 180 day repair under recall 9b1 for an expanded gas tank after the repair the car suffered from the updated recall 286 . I brang to the dealership 4 times with check engine and misfires and limp mode between 57k and 68k they refused to fix the car under recall 286 and cleared all the codes and continued to make me leave in a unsafe car. On February 14th it sport Hyundais negligence was the direct cause of an auto accident were the car was unable to move out the way because of lack of power /limp mode. I begged them in the final days of me having the car to fix it and saying I didn’t feel safe and they wouldn’t without an extensive amount of money I could not provide . I’m currently filing a claim with Hyundai consumer affairs and the dca in Newark and also my senators office and I have a lawyer also who might help I wish to report this to the NHTSA.
NHTSA complaint #11722063 — an unverified report by a vehicle owner.
Egg Harbor City, NJCrash
FUEL/PROPULSION SYSTEM
Recall 286 my vehicle suffered from this causing heat module failure misfire in cylinder 2 and high pressure in gas tank. Sports Hyundai had previously done a 180 day repair under recall 9b1 for an expanded gas tank after the repair the car suffered from the updated recall 286 . I brang to the dealership 4 times with check engine and misfires and limp mode between 57k and 68k they refused to fix the car under recall 286 and cleared all the codes and continued to make me leave in a unsafe car. On February 14th it sport Hyundais negligence was the direct cause of an auto accident were the car was unable to move out the way because of lack of power /limp mode. I begged them in the final days of me having the car to fix it and saying I didn’t feel safe and they wouldn’t without an extensive amount of money I could not provide . I’m currently filing a claim with Hyundai consumer affairs and the dca in Newark and also my senators office and I have a lawyer also who might help I wish to report this to the NHTSA.
NHTSA complaint #11722063 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Shawsville, VA
POWER TRAIN
I own a 2023 Hyundai Sonata SEL. Over approximately three years, the vehicle experienced four separate incidents involving sudden loss of engine power and recurring fuel injector/powertrain problems. Three of these incidents occurred while the vehicle was being driven on interstate highways, creating serious safety concerns. The first incident occurred on XXX, on [XXX] [XXX]. My daughter was driving the vehicle at the time when it suddenly lost power while traveling on the interstate. She had to maneuver the vehicle to the shoulder under unsafe traffic conditions. The second incident occurred on XXX, on [XXX] near [XXX]. I was driving the vehicle when it again experienced sudden loss of power while traveling at highway speed. The third incident occurred on XXX, in [XXX]. The vehicle experienced another significant power-loss event and required roadside assistance. The fourth incident occurred on XXX, on [XXX]. The vehicle again experienced a sudden loss of engine power while I was driving on the highway. Despite multiple repair attempts, including repairs related to the fuel injectors, the same or substantially similar power-loss problem continued to recur. Because the vehicle has repeatedly lost engine power while being driven, including multiple incidents at interstate highway speeds, I believe this recurring condition presents a serious safety risk. I am reporting these incidents so NHTSA can evaluate whether this may represent a broader safety-related defect affecting this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755422 — an unverified report by a vehicle owner.
Shawsville, VA
ENGINE
I own a 2023 Hyundai Sonata SEL. Over approximately three years, the vehicle experienced four separate incidents involving sudden loss of engine power and recurring fuel injector/powertrain problems. Three of these incidents occurred while the vehicle was being driven on interstate highways, creating serious safety concerns. The first incident occurred on XXX, on [XXX] [XXX]. My daughter was driving the vehicle at the time when it suddenly lost power while traveling on the interstate. She had to maneuver the vehicle to the shoulder under unsafe traffic conditions. The second incident occurred on XXX, on [XXX] near [XXX]. I was driving the vehicle when it again experienced sudden loss of power while traveling at highway speed. The third incident occurred on XXX, in [XXX]. The vehicle experienced another significant power-loss event and required roadside assistance. The fourth incident occurred on XXX, on [XXX]. The vehicle again experienced a sudden loss of engine power while I was driving on the highway. Despite multiple repair attempts, including repairs related to the fuel injectors, the same or substantially similar power-loss problem continued to recur. Because the vehicle has repeatedly lost engine power while being driven, including multiple incidents at interstate highway speeds, I believe this recurring condition presents a serious safety risk. I am reporting these incidents so NHTSA can evaluate whether this may represent a broader safety-related defect affecting this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755422 — an unverified report by a vehicle owner.
Shawsville, VA
FUEL/PROPULSION SYSTEM
I own a 2023 Hyundai Sonata SEL. Over approximately three years, the vehicle experienced four separate incidents involving sudden loss of engine power and recurring fuel injector/powertrain problems. Three of these incidents occurred while the vehicle was being driven on interstate highways, creating serious safety concerns. The first incident occurred on XXX, on [XXX] [XXX]. My daughter was driving the vehicle at the time when it suddenly lost power while traveling on the interstate. She had to maneuver the vehicle to the shoulder under unsafe traffic conditions. The second incident occurred on XXX, on [XXX] near [XXX]. I was driving the vehicle when it again experienced sudden loss of power while traveling at highway speed. The third incident occurred on XXX, in [XXX]. The vehicle experienced another significant power-loss event and required roadside assistance. The fourth incident occurred on XXX, on [XXX]. The vehicle again experienced a sudden loss of engine power while I was driving on the highway. Despite multiple repair attempts, including repairs related to the fuel injectors, the same or substantially similar power-loss problem continued to recur. Because the vehicle has repeatedly lost engine power while being driven, including multiple incidents at interstate highway speeds, I believe this recurring condition presents a serious safety risk. I am reporting these incidents so NHTSA can evaluate whether this may represent a broader safety-related defect affecting this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755422 — an unverified report by a vehicle owner.
at 86,500 milesCanton, GA
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Hyundai Sonata. The contact stated that while driving approximately 15-40 MPH, the vehicle was sputtering and shaking abnormally. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); but the VIN was not under recall. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,500.
NHTSA complaint #11753540 — an unverified report by a vehicle owner.
at 50 milesPort Jefferson, NY
POWER TRAIN
The contact owns a 2023 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the transmission shifted into neutral(N) and failed to shift into park or drive on three occasions. The vehicle was restarted. After restarting the vehicle, the vehicle was shifted into drive, and the contact continued driving. The message that the vehicle could not be shifted into other gears was displayed. The vehicle was originally purchased in another state. The vehicle was taken to the local dealer to be diagnosed. The dealer determined that the battery and fuel injector pump needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was not contacted regarding the failure. The failure mileage was approximately 50.
NHTSA complaint #11744098 — an unverified report by a vehicle owner.
Beaumont, TX
POWER TRAIN
This is an extremely common issue plaguing Hyundai & Kia vehicles with the Theta III 2.5L Turbo engine, Such as Kia K5 GT, Hyundai Sante Fe, Hyundai Santa Cruz, & Hyundai Sonata N-Line. Its a failing ITM (integrated thermal management) unit or otherwise known as an ITMS unit. There is a rod within the ITM that prevents proper control of the flow of cooling the oil and engine coolant of the engine. Results in Cooling issues, such as a cold lower radiator hose while the engine is hot, or 'limp mode' during acceleration, that causes a sudden loss of power while trying to merge on the expressway. There has been other Kia models and years that have had TSB's related to fixing this issue, but Hyundai has released nothing. I have uploaded an example of one of the TSB's that do not apply to my car. Technical symptoms often include: Fans running 100% full duty (high) while the lower radiator hose stays cool. Or Fuel dilution or a 'rich' running engine. Because the engine is overcooling that keeps the car's fueling rich and in a open loop mode affecting emissions and contaminating oil. Personal Details of exactly what happened when i noticed mine was failing. I ran home on my lunch break, and while accelerating on a ramp to get up on a highway, my car started beeping and flashing "Engine Overheated" and i immediately let off the gas with preparation to pull over. The second i left off the gas, the coolant temp within 1-2 seconds went from a little over 3/4 the way up the gauge back to normal a little below half temp. I resumed driving a 3 mile drive back to work, with it showing normal temps the rest of the way. I popped the hood when i got to work to see if coolant was low, and it was completely normal, a little over halfway between the min/max lines. The car continues to run hot, often with the cooling fans running at 100%.
NHTSA complaint #11737860 — an unverified report by a vehicle owner.
Beaumont, TX
ENGINE
This is an extremely common issue plaguing Hyundai & Kia vehicles with the Theta III 2.5L Turbo engine, Such as Kia K5 GT, Hyundai Sante Fe, Hyundai Santa Cruz, & Hyundai Sonata N-Line. Its a failing ITM (integrated thermal management) unit or otherwise known as an ITMS unit. There is a rod within the ITM that prevents proper control of the flow of cooling the oil and engine coolant of the engine. Results in Cooling issues, such as a cold lower radiator hose while the engine is hot, or 'limp mode' during acceleration, that causes a sudden loss of power while trying to merge on the expressway. There has been other Kia models and years that have had TSB's related to fixing this issue, but Hyundai has released nothing. I have uploaded an example of one of the TSB's that do not apply to my car. Technical symptoms often include: Fans running 100% full duty (high) while the lower radiator hose stays cool. Or Fuel dilution or a 'rich' running engine. Because the engine is overcooling that keeps the car's fueling rich and in a open loop mode affecting emissions and contaminating oil. Personal Details of exactly what happened when i noticed mine was failing. I ran home on my lunch break, and while accelerating on a ramp to get up on a highway, my car started beeping and flashing "Engine Overheated" and i immediately let off the gas with preparation to pull over. The second i left off the gas, the coolant temp within 1-2 seconds went from a little over 3/4 the way up the gauge back to normal a little below half temp. I resumed driving a 3 mile drive back to work, with it showing normal temps the rest of the way. I popped the hood when i got to work to see if coolant was low, and it was completely normal, a little over halfway between the min/max lines. The car continues to run hot, often with the cooling fans running at 100%.
NHTSA complaint #11737860 — an unverified report by a vehicle owner.
at 18,500 milesNorth Ridgeville, OH
ENGINE AND ENGINE COOLING
The contact owns a 2023 Hyundai Sonata. The contact stated that while his wife was driving at an undisclosed speed, the message "Engine Overheated" displayed. The contact checked the Hyundai app, but it showed no failure. The contact's wife drove to their son's residence, who inspected and discovered that there was no coolant in the engine. The contact's son added coolant to the engine. The vehicle was taken to the dealer, who replaced the coolant valve, exhaust muffler assembly center, clamp assembly exhaust pipe, two gasket exhaust pipes, and added coolant. The contact related the failure to Technical Service Bulletin: 23-EM-009H (EHRS Coolant Leak Repair); however, the vehicle was not covered under the TSB. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 18,500.
NHTSA complaint #11737251 — an unverified report by a vehicle owner.
Zachary, LA
FUEL/PROPULSION SYSTEM
Was driving and stopped at a stoplight. When I went to drive it started sputtering and if I wouldn’t have driven into a gas station, it would’ve given out in the middle of the road. It wouldn’t let me switch to drive or reverse , only neutral or park. It threw a code P0301, cylinder 1 misfire. Had to get it towed. Now I have to get my spark plugs and fuel injectors replaced.
NHTSA complaint #11737351 — an unverified report by a vehicle owner.
Phoenix, AZ
ENGINE AND ENGINE COOLING
See attached document for complaint.
NHTSA complaint #11728741 — an unverified report by a vehicle owner.
St Augustine, FL
ELECTRICAL SYSTEM
Battery Management System completely exhausting the 12V battery resulting in the car acting as if it has no power. When this happens, you can't unlock the door or open the trunk. On two separate occasions, I have encountered a complete loss of power in my Sonata Hybrid, preventing me from unlocking the trunk or doors upon returning from extended trips. The first incident occurred after a ten-day absence last Fall, and the most recent was on Saturday, March 14, 2025. During the latest incident, I returned from a seven-day trip and found my vehicle parked at Orlando International Airport. Upon approaching the car, I anticipated being able to unlock the trunk, load my luggage, enter the vehicle, and drive home. However, once again, the vehicle was unresponsive. Accessing the car required removing the cap from the door handle and manually inserting the key, a process that took approximately ten minutes, which was particularly inconvenient and concerning in an airport parking lot. This situation was even more challenging considering I am a [XXX] woman of smaller stature attempting to resolve this issue alone at night. I believe this poses a serious safety concern for all owners under similar circumstances. Following the incident last Fall, I brought my Sonata Hybrid to Key Hyundai in Jacksonville. I was informed that this is a known issue for which there is a recall; however, my vehicle model year is not included in the affected range. It was suggested that I would need to manage this problem independently. I believe this recurring issue represents a known vulnerability that could potentially expose Hyundai and its dealerships to liability should an owner suffer harm while addressing this malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11724724 — an unverified report by a vehicle owner.
St Augustine, FL
ENGINE
Battery Management System completely exhausting the 12V battery resulting in the car acting as if it has no power. When this happens, you can't unlock the door or open the trunk. On two separate occasions, I have encountered a complete loss of power in my Sonata Hybrid, preventing me from unlocking the trunk or doors upon returning from extended trips. The first incident occurred after a ten-day absence last Fall, and the most recent was on Saturday, March 14, 2025. During the latest incident, I returned from a seven-day trip and found my vehicle parked at Orlando International Airport. Upon approaching the car, I anticipated being able to unlock the trunk, load my luggage, enter the vehicle, and drive home. However, once again, the vehicle was unresponsive. Accessing the car required removing the cap from the door handle and manually inserting the key, a process that took approximately ten minutes, which was particularly inconvenient and concerning in an airport parking lot. This situation was even more challenging considering I am a [XXX] woman of smaller stature attempting to resolve this issue alone at night. I believe this poses a serious safety concern for all owners under similar circumstances. Following the incident last Fall, I brought my Sonata Hybrid to Key Hyundai in Jacksonville. I was informed that this is a known issue for which there is a recall; however, my vehicle model year is not included in the affected range. It was suggested that I would need to manage this problem independently. I believe this recurring issue represents a known vulnerability that could potentially expose Hyundai and its dealerships to liability should an owner suffer harm while addressing this malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11724724 — an unverified report by a vehicle owner.
Oro Valley, AZCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
Reported this previously, but more information was gathered, thanks to collision mechanic who guessed immediately when he heard 2023 hybrid Sonata - he said "they're notorious for it." Was at a stand still in a parking space/lot I know well. Cautious driver, watch my speed, very aware of other drivers, quick reaction time. Incident mid day, no pedestrians, distractions, no moving traffic. Vehicle doors shut, seat belt on. Not on incline. Pulled into parking spot I use weekly, spot has parking curb. Was at a full stop. Realized I had not pulled into the spot quite far enough, and attempted to inch vehicle forward. (Do not recall any warning lights, but this car usually alerts at literally anything - even shadows.) Very lightly applied gas to inch forward, slowly. Felt slight "scrape" of undercarriage on the parking curb. Put car in reverse, lightly applied gas to inch back. Car did not rev, no screeching tires, it was at a standstill previously. Was in Eco mode. All seemed normal, until vehicle suddenly launched UP the parking curb, full force, and into a building pillar directly ahead. The car never moves with that much force, I'm not a pedal-to-the metal driver. Eco mode on. No airbag deployment, injuries, etc. Sheriff took report for the building, simple incident. I couldn't make sense of it. I know how overly cautious I am while parking, what I do, and don't do. Took responsibility, but was still analyzing a week later, and explained what I remembered to the mechanic. He guessed right away. Said Sonatas were notorious for it. He said they're known for randomly applying the ebrake unexpectedly - and also randomly releasing the ebrake - and aggressively (and silently) switching from electric to gas when met with resistance, aka the parking curb. Insurance totalled the car. 2.5 years old, 17k miles. This was my 3rd Hyundai in 20 years, others were great. Discovered 40,000 Elantra hybrids, same year as my Sonata, were recalled due to "unintended acceleration."
NHTSA complaint #11724237 — an unverified report by a vehicle owner.
Reported this previously, but more information was gathered, thanks to collision mechanic who guessed immediately when he heard 2023 hybrid Sonata - he said "they're notorious for it." Was at a stand still in a parking space/lot I know well. Cautious driver, watch my speed, very aware of other drivers, quick reaction time. Incident mid day, no pedestrians, distractions, no moving traffic. Vehicle doors shut, seat belt on. Not on incline. Pulled into parking spot I use weekly, spot has parking curb. Was at a full stop. Realized I had not pulled into the spot quite far enough, and attempted to inch vehicle forward. (Do not recall any warning lights, but this car usually alerts at literally anything - even shadows.) Very lightly applied gas to inch forward, slowly. Felt slight "scrape" of undercarriage on the parking curb. Put car in reverse, lightly applied gas to inch back. Car did not rev, no screeching tires, it was at a standstill previously. Was in Eco mode. All seemed normal, until vehicle suddenly launched UP the parking curb, full force, and into a building pillar directly ahead. The car never moves with that much force, I'm not a pedal-to-the metal driver. Eco mode on. No airbag deployment, injuries, etc. Sheriff took report for the building, simple incident. I couldn't make sense of it. I know how overly cautious I am while parking, what I do, and don't do. Took responsibility, but was still analyzing a week later, and explained what I remembered to the mechanic. He guessed right away. Said Sonatas were notorious for it. He said they're known for randomly applying the ebrake unexpectedly - and also randomly releasing the ebrake - and aggressively (and silently) switching from electric to gas when met with resistance, aka the parking curb. Insurance totalled the car. 2.5 years old, 17k miles. This was my 3rd Hyundai in 20 years, others were great. Discovered 40,000 Elantra hybrids, same year as my Sonata, were recalled due to "unintended acceleration."
NHTSA complaint #11724237 — an unverified report by a vehicle owner.
Oro Valley, AZCrash
BACK OVER PREVENTION: WARNINGS
Reported this previously, but more information was gathered, thanks to collision mechanic who guessed immediately when he heard 2023 hybrid Sonata - he said "they're notorious for it." Was at a stand still in a parking space/lot I know well. Cautious driver, watch my speed, very aware of other drivers, quick reaction time. Incident mid day, no pedestrians, distractions, no moving traffic. Vehicle doors shut, seat belt on. Not on incline. Pulled into parking spot I use weekly, spot has parking curb. Was at a full stop. Realized I had not pulled into the spot quite far enough, and attempted to inch vehicle forward. (Do not recall any warning lights, but this car usually alerts at literally anything - even shadows.) Very lightly applied gas to inch forward, slowly. Felt slight "scrape" of undercarriage on the parking curb. Put car in reverse, lightly applied gas to inch back. Car did not rev, no screeching tires, it was at a standstill previously. Was in Eco mode. All seemed normal, until vehicle suddenly launched UP the parking curb, full force, and into a building pillar directly ahead. The car never moves with that much force, I'm not a pedal-to-the metal driver. Eco mode on. No airbag deployment, injuries, etc. Sheriff took report for the building, simple incident. I couldn't make sense of it. I know how overly cautious I am while parking, what I do, and don't do. Took responsibility, but was still analyzing a week later, and explained what I remembered to the mechanic. He guessed right away. Said Sonatas were notorious for it. He said they're known for randomly applying the ebrake unexpectedly - and also randomly releasing the ebrake - and aggressively (and silently) switching from electric to gas when met with resistance, aka the parking curb. Insurance totalled the car. 2.5 years old, 17k miles. This was my 3rd Hyundai in 20 years, others were great. Discovered 40,000 Elantra hybrids, same year as my Sonata, were recalled due to "unintended acceleration."
NHTSA complaint #11724237 — an unverified report by a vehicle owner.
Egg Harbor City, NJCrash
STRUCTURE:BODY
Recall 286 my vehicle suffered from this causing heat module failure misfire in cylinder 2 and high pressure in gas tank. Sports Hyundai had previously done a 180 day repair under recall 9b1 for an expanded gas tank after the repair the car suffered from the updated recall 286 . I brang to the dealership 4 times with check engine and misfires and limp mode between 57k and 68k they refused to fix the car under recall 286 and cleared all the codes and continued to make me leave in a unsafe car. On February 14th it sport Hyundais negligence was the direct cause of an auto accident were the car was unable to move out the way because of lack of power /limp mode. I begged them in the final days of me having the car to fix it and saying I didn’t feel safe and they wouldn’t without an extensive amount of money I could not provide . I’m currently filing a claim with Hyundai consumer affairs and the dca in Newark and also my senators office and I have a lawyer also who might help I wish to report this to the NHTSA.
NHTSA complaint #11722063 — an unverified report by a vehicle owner.
Egg Harbor City, NJCrash
ENGINE
Recall 286 my vehicle suffered from this causing heat module failure misfire in cylinder 2 and high pressure in gas tank. Sports Hyundai had previously done a 180 day repair under recall 9b1 for an expanded gas tank after the repair the car suffered from the updated recall 286 . I brang to the dealership 4 times with check engine and misfires and limp mode between 57k and 68k they refused to fix the car under recall 286 and cleared all the codes and continued to make me leave in a unsafe car. On February 14th it sport Hyundais negligence was the direct cause of an auto accident were the car was unable to move out the way because of lack of power /limp mode. I begged them in the final days of me having the car to fix it and saying I didn’t feel safe and they wouldn’t without an extensive amount of money I could not provide . I’m currently filing a claim with Hyundai consumer affairs and the dca in Newark and also my senators office and I have a lawyer also who might help I wish to report this to the NHTSA.
NHTSA complaint #11722063 — an unverified report by a vehicle owner.
Egg Harbor City, NJCrash
FUEL/PROPULSION SYSTEM
Recall 286 my vehicle suffered from this causing heat module failure misfire in cylinder 2 and high pressure in gas tank. Sports Hyundai had previously done a 180 day repair under recall 9b1 for an expanded gas tank after the repair the car suffered from the updated recall 286 . I brang to the dealership 4 times with check engine and misfires and limp mode between 57k and 68k they refused to fix the car under recall 286 and cleared all the codes and continued to make me leave in a unsafe car. On February 14th it sport Hyundais negligence was the direct cause of an auto accident were the car was unable to move out the way because of lack of power /limp mode. I begged them in the final days of me having the car to fix it and saying I didn’t feel safe and they wouldn’t without an extensive amount of money I could not provide . I’m currently filing a claim with Hyundai consumer affairs and the dca in Newark and also my senators office and I have a lawyer also who might help I wish to report this to the NHTSA.
NHTSA complaint #11722063 — an unverified report by a vehicle owner.
Little Elm, TX
POWER TRAIN
Vehicle WITHOUT WARNING will start to jerk then go into “limp” mode. Pressing on gas pedal makes the revving noise but with not physical movement made. This has happened on MULTIPLE occasions (13 times in 4 months) including in the snow and on the interstate while driving at 70mph where no shoulder is available to pull over. Car was taken to dealership 3 different times with no actual diagnosis, tests were ran all 3 times with nothing. Eventually the 3rd time at the dealership I was told the transmission was being replaced although they were not sure what actually caused the issue (this is written in the service report by the rep/mechanic). CAR REMAINS UNSAFE AND UNRELIABLE. Livelihood of myself, family and other drivers is at risk EVERYTIME I put the car in drive due to this mechanical issue. NO WARNINGS NO POWER NO FIX.
NHTSA complaint #11721841 — an unverified report by a vehicle owner.
Little Elm, TX
UNKNOWN OR OTHER
Vehicle WITHOUT WARNING will start to jerk then go into “limp” mode. Pressing on gas pedal makes the revving noise but with not physical movement made. This has happened on MULTIPLE occasions (13 times in 4 months) including in the snow and on the interstate while driving at 70mph where no shoulder is available to pull over. Car was taken to dealership 3 different times with no actual diagnosis, tests were ran all 3 times with nothing. Eventually the 3rd time at the dealership I was told the transmission was being replaced although they were not sure what actually caused the issue (this is written in the service report by the rep/mechanic). CAR REMAINS UNSAFE AND UNRELIABLE. Livelihood of myself, family and other drivers is at risk EVERYTIME I put the car in drive due to this mechanical issue. NO WARNINGS NO POWER NO FIX.
NHTSA complaint #11721841 — an unverified report by a vehicle owner.
Little Elm, TX
ENGINE
Vehicle WITHOUT WARNING will start to jerk then go into “limp” mode. Pressing on gas pedal makes the revving noise but with not physical movement made. This has happened on MULTIPLE occasions (13 times in 4 months) including in the snow and on the interstate while driving at 70mph where no shoulder is available to pull over. Car was taken to dealership 3 different times with no actual diagnosis, tests were ran all 3 times with nothing. Eventually the 3rd time at the dealership I was told the transmission was being replaced although they were not sure what actually caused the issue (this is written in the service report by the rep/mechanic). CAR REMAINS UNSAFE AND UNRELIABLE. Livelihood of myself, family and other drivers is at risk EVERYTIME I put the car in drive due to this mechanical issue. NO WARNINGS NO POWER NO FIX.
NHTSA complaint #11721841 — an unverified report by a vehicle owner.
Kissimmee, FL
FUEL/PROPULSION SYSTEM
I am filing this complaint regarding Recall 25V-796 (Hyundai Recall 286). On November 27th, while driving, my vehicle made a loud popping noise twice and then began sounding muffled. About a week later, while on a long-distance drive, I attempted to refuel and the gas would not go into the tank. At another gas station I was able to fuel it, but afterward the vehicle began rapidly leaking fuel while I was driving. The fuel gauge was also malfunctioning. It showed 53 miles remaining and then suddenly jumped to 200 miles. It was not accurately reflecting the fuel level. When I stopped again for gas, the same muffled noise occurred and the fuel level rapidly dropped again. Due to safety concerns, I took the vehicle directly to the dealership.I dropped the vehicle off on December 6th and it has remained at the dealership ever since. The vehicle is currently sitting in their lot with no remedy available. I am still making monthly payments on a vehicle I cannot use. Although Hyundai provided a rental vehicle, it has now been over three months of inconvenience, including having to exchange rental vehicles for service. This has caused disruption to my daily life and financial strain. Hyundai has offered to pay off my loan and provide 8% toward the purchase of another vehicle. However, I am a single mother who is currently rebuilding financially after losing my job in prior years, and my credit score has been affected. I do not believe I should be pressured into purchasing another vehicle due to an unresolved manufacturer safety defect. I also attempted to seek guidance regarding Florida Lemon Law, but was informed that I may not qualify because the vehicle was purchased in April 2023 and the issue occurred after the two-year period. However, this is a manufacturer recall involving the fuel system, and I believe it is unfair that I am left financially responsible for a vehicle with a serious safety defect and no available remedy. I am requesting investigation
NHTSA complaint #11721116 — an unverified report by a vehicle owner.
at 56,000 milesNorth Lauderdale, FL
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Hyundai Sonata. The contact stated that after depressing the START/STOP button, the vehicle failed to start immediately. Additionally, there was smoke coming from the exhaust pipe. There was no warning light illuminated; however, an undisclosed message was displayed. The vehicle was towed to the dealer, who replaced the fuel injector; however, the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000.
NHTSA complaint #11720359 — an unverified report by a vehicle owner.
oro Valley, AZCrash
POWER TRAIN
Car was parked, full stop, doors shut, seatbelt on. Foot on brake. Car then seemed to lurch forward by itself forward hitting parking cement block. Put in reverse to back away and car stayed still...then I tapped the gas again to back up and insted vehicle plowed forward.instead.of reverse ...went over the parking block and hit concrete beam in front, when the car should have backed up in reverse. I'm a person who drives speeed limits, and ulta careful when i drive, and parked at this place/spot for years. This has never happened not sure why it did. No injuries or other people involved thank god, but scared the heck out of me. Wracking my brain, my recalls and software and service appts are up ro date.Nothing out of ordinary that day. I'm confused and shaken, why the first lurch forward and why did going in reverse move it forward? ugh. It drove home fine. Commute to work daily for years, no issues. All I can guess is gear didn't click to reverse and was somehow in drive? Ive been going over the possibilities in my head for human error but they dont make sense - again I've been driving for 40 years. If it happens to other models, would love to know! Car will go to repair tomorrow as "my fault" via insurance, hoping they can see more if any error codes, to at least say if Reverse didn't engage or something else happened. May have been human error but it's so out of the ordinary for me. Thanks!
NHTSA complaint #11718993 — an unverified report by a vehicle owner.
oro Valley, AZCrash
VEHICLE SPEED CONTROL
Car was parked, full stop, doors shut, seatbelt on. Foot on brake. Car then seemed to lurch forward by itself forward hitting parking cement block. Put in reverse to back away and car stayed still...then I tapped the gas again to back up and insted vehicle plowed forward.instead.of reverse ...went over the parking block and hit concrete beam in front, when the car should have backed up in reverse. I'm a person who drives speeed limits, and ulta careful when i drive, and parked at this place/spot for years. This has never happened not sure why it did. No injuries or other people involved thank god, but scared the heck out of me. Wracking my brain, my recalls and software and service appts are up ro date.Nothing out of ordinary that day. I'm confused and shaken, why the first lurch forward and why did going in reverse move it forward? ugh. It drove home fine. Commute to work daily for years, no issues. All I can guess is gear didn't click to reverse and was somehow in drive? Ive been going over the possibilities in my head for human error but they dont make sense - again I've been driving for 40 years. If it happens to other models, would love to know! Car will go to repair tomorrow as "my fault" via insurance, hoping they can see more if any error codes, to at least say if Reverse didn't engage or something else happened. May have been human error but it's so out of the ordinary for me. Thanks!
NHTSA complaint #11718993 — an unverified report by a vehicle owner.