Owners have filed 226 complaints
about the 2004 KIA Sedona with NHTSA between 2004 and 2021.
The largest single group is the brakes.
Across this model's run it ranks 5 of 19 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 63
Against the median year of the KIA Sedona. 50 means typical for this
model; 100 means roughly double.
Severity — 80
15.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 82
48% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
74.3%
1,000 – 9,999 miles
3018.6%
10,000 – 24,999 miles
2918.0%
25,000 – 49,999 miles
1911.8%
50,000 – 74,999 miles
2414.9%
75,000 – 99,999 miles
2414.9%
100,000 – 149,999 miles
1811.2%
150,000+ miles
106.2%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2004 Kia Sedona Van
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2004peak 17Oct 2021
NHTSA investigations into the 2004 KIA Sedona
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA08017Opened 28 Aug 2008Closed 1 Jul 2009STEERING
STEERING INTERMEDIATE SHAFT BINDING
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WI...
PE08033Opened 28 Apr 2008Closed 28 Aug 2008STEERING
STEERING BINDING
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NOR...
PE04067Opened 24 Sep 2004Closed 27 Jan 2005VEHICLE SPEED CONTROL:CABLES
THROTTLE CABLE BINDING
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004...
Recalls on the 2004 KIA Sedona
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20053169,220 units in Canada
Electrical
On certain vehicles, the wiring under the front seats of vehicles equipped with power seats could be misrouted, allowing the wire to be pinched by metal seat components. As a result, electrical resistance will trip a circuit breaker diode in the fuse junction box. After the diode cools down, it will reset and recycle through this process repeatedly. It may be possible for the diode to continue to build up heat instead of cooling down, which may result in a fire in another component in the junction box area. Correction: Dealers will inspect to confirm the integrity of the power seat wiring. In addition, the dealer will install corrugated tubing around the underseat wires to eliminate the possibility of wire pinching.
Recall 20052289,488 units in Canada
Engine
On certain vehicles, water may enter between a protective rubber sleeve and the throttle cable towards the rear portion of the cable. If the ambient temperature drops below zero degrees Celsius, the water could freeze, causing the throttle to stick and the vehicle to accelerate unexpectedly. Correction: Dealers will modify the throttle cable rubber sleeve.
Recall 20051653,406 units in Canada
Other
On certain vehicles equipped with alloy wheels, moisture can enter the rear hub and cause damage to the wheel bearing. In certain conditions, this can result in wheel bearing failure which could lead to a loss of vehicle control. Correction: Dealers will inspect and, if necessary, replace the hub assemblies.
Reports where the owner recorded a crash, a fire, an injury or a death.
Hartford City, INFire
UNKNOWN OR OTHER
Everything appears normal driving down road bout 45 to 50 mph. Slowed down for car n front was turning when I noticed smoke coming from under hood around headlights both sides. Then we pulled into a storage unit place. When even more smoke . I got out popped hood it was all on fire. I turned off van and a friend and I got a couple cups and dipped in water puddle and put fire out , while we were watching to make sure it restarted 2 more times. After half hour goes by and no more smoke . Closed van up found a ride home after contacting insurance company.
NHTSA complaint #11436117 — an unverified report by a vehicle owner.
at 100,100 milesHomestead, FLFire
ENGINE
TL* THE CONTACT OWNED A 2004 KIA SEDONA. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW YARD. THE CONTACT MENTIONED THAT THE CAUSE OF THE FIRE WAS UNKNOWN. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 100,100.
NHTSA complaint #11193363 — an unverified report by a vehicle owner.
at 25,000 milesJonesboro, GAFire
ENGINE
MY 2004 KIA SEDONA WAS SITTING STATIONARY IN MY DRIVEWAY ENGINE WAS OFF. WHEN SOMETHING IN THE ENGINE COMPARTMENT CAUGHT FIRE CAUSING EXTENSIVE DAMAGE TO ENGINE PARTS ON THE TOP SIDE OF THE ENGINE. SUCH BE AS FLUID RESERVOIRS WIRING, FUSE BOX, AND MORE.
NHTSA complaint #11141627 — an unverified report by a vehicle owner.
at 214,000 milesCumming, GAFire
UNKNOWN OR OTHER
ON SATURDAY, DECEMBER 16, AT APPROXIMATELY 11:30 AM, MY WIFE'S 2004 KIA SEDONA SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY OF OUR HOME. I HAD DRIVEN IT THAT MORNING TO RUN A QUICK ERRAND, ACTUAL DRIVE TIME LESS THAN HALF AN HOUR WITHOUT ANYTHING OUT OF THE ORDINARY. I RETURNED HOME, PARKED IN OUR DRIVEWAY BEHIND MY FORD WINDSTAR. BOTH MY WIFE AND MYSELF WERE IN OUR HOUSE WHEN WE HEARD A LOUD BOOM FOLLOWED SHORTLY BY A SECOND BOOM. THAT IS WHEN WE SAW THAT FIRE WAS COMING FROM THE ENGINE COMPARTMENT OF HER VAN AND THE REAR OF MY WINDSTAR WAS ON FIRE. WE IMMEDIATELY CALLED 911 AND SHORTLY THEREAFTER OUR LOCAL FIRE COMPANY ARRIVED AND BEGAN FIGHTING THE BLAZE. BY THAT TIME BOTH VEHICLES WERE ENGULFED IN FLAMES. THE FIRE APPEARS TO HAVE STARTED IN THE ENGINE COMPARTMENT OF THE KIA. BOTH VEHICLES ARE A TOTAL LOSS. UNTIL THIS INCIDENT, NOTWITHSTANDING BASIC MAINTENANCE AND REPAIRS, THE KIA SEDONA WAS A VERY RELIABLE VEHICLE. AS WITH THE WINDSTAR, MAINTENANCE AND REPAIRS WERE DONE ON A REGULAR AND AS NEEDED BASIS BY THE SAME SHOP THAT HAS WORKED ON ALL OUR VEHICLES FOR OVER 10 YEARS. I AM SURE I CAN PRODUCE MAINTENANCE AND REPAIR RECORDS IF NEEDED. THE LAST TIME THE KIA WAS SERVICED WAS LATE OCTOBER OF THIS YEAR TO REPLACE AN ALTERNATOR.
NHTSA complaint #11080722 — an unverified report by a vehicle owner.
at 158,000 milesEmmett, IDCrash
AIR BAGS
"TAKATA RECALL" ON TUESDAY MAY 9, 2017 WE WERE INVOLVED IN AN AUTOMOBILE ACCIDENT. TO OUR AMAZEMENT AND HORROR, NOT ONE AIRBAG DEPLOYED . 'WE WERE HIT ON THE PASSENGER SIDE OF THE VAN . THE FRONT PASSENGER DOOR REQUIRED ASSISTANCE FROM THE POLICE/FIRE FIGHTERS ASSISTANCE TO EXIT THE VAN HOWEVER THE SLIDING DOOR COULD NOT BE OPENED REQUIRING REMOVING THE BABY THROUGH THE DRIVER'S SIDE. THE LIGHT TURNED GREEN AND WE BEGAN TO MOVE FORWARD WHEN OUR VAN WAS STRUCK BY THE OTHER CAR EXITING A PARKING LOT. NEITHER ONE OF US SAW THE ADVANCE NOR IMPACT OF THE OTHER CAR. AFTER REALIZING WHAT HAPPENED WE CALL EMERGENCY VEHICLES FOR ASSISTANCE. WE WERE INSTRUCTED TO MOVE OUR VAN TO A SAFE LOCATION AND WAIT FOR H
NHTSA complaint #10992708 — an unverified report by a vehicle owner.
at 158,000 milesEmmett, IDCrash
STRUCTURE:BODY
"TAKATA RECALL" ON TUESDAY MAY 9, 2017 WE WERE INVOLVED IN AN AUTOMOBILE ACCIDENT. TO OUR AMAZEMENT AND HORROR, NOT ONE AIRBAG DEPLOYED . 'WE WERE HIT ON THE PASSENGER SIDE OF THE VAN . THE FRONT PASSENGER DOOR REQUIRED ASSISTANCE FROM THE POLICE/FIRE FIGHTERS ASSISTANCE TO EXIT THE VAN HOWEVER THE SLIDING DOOR COULD NOT BE OPENED REQUIRING REMOVING THE BABY THROUGH THE DRIVER'S SIDE. THE LIGHT TURNED GREEN AND WE BEGAN TO MOVE FORWARD WHEN OUR VAN WAS STRUCK BY THE OTHER CAR EXITING A PARKING LOT. NEITHER ONE OF US SAW THE ADVANCE NOR IMPACT OF THE OTHER CAR. AFTER REALIZING WHAT HAPPENED WE CALL EMERGENCY VEHICLES FOR ASSISTANCE. WE WERE INSTRUCTED TO MOVE OUR VAN TO A SAFE LOCATION AND WAIT FOR H
NHTSA complaint #10992708 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Hartford City, INFire
UNKNOWN OR OTHER
Everything appears normal driving down road bout 45 to 50 mph. Slowed down for car n front was turning when I noticed smoke coming from under hood around headlights both sides. Then we pulled into a storage unit place. When even more smoke . I got out popped hood it was all on fire. I turned off van and a friend and I got a couple cups and dipped in water puddle and put fire out , while we were watching to make sure it restarted 2 more times. After half hour goes by and no more smoke . Closed van up found a ride home after contacting insurance company.
NHTSA complaint #11436117 — an unverified report by a vehicle owner.
at 18,000 milesGlendale, AZ
WHEELS
I HAVE A 2004 KIA SENDONA LX VAN AND THE WHEEL BARRINGS ARE BAD I FIXED IT ONCE ALREADY A MONTH AGO AND IT IS ALREADY BROKEN AGAIN BOTH TIMES IT COMPLETELY FELL APART IN TO LITTLE PEICES WHEN I TOOK THE WHEEL OFF.
NHTSA complaint #11319611 — an unverified report by a vehicle owner.
at 100,100 milesHomestead, FLFire
ENGINE
TL* THE CONTACT OWNED A 2004 KIA SEDONA. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW YARD. THE CONTACT MENTIONED THAT THE CAUSE OF THE FIRE WAS UNKNOWN. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 100,100.
NHTSA complaint #11193363 — an unverified report by a vehicle owner.
at 25,000 milesJonesboro, GAFire
ENGINE
MY 2004 KIA SEDONA WAS SITTING STATIONARY IN MY DRIVEWAY ENGINE WAS OFF. WHEN SOMETHING IN THE ENGINE COMPARTMENT CAUGHT FIRE CAUSING EXTENSIVE DAMAGE TO ENGINE PARTS ON THE TOP SIDE OF THE ENGINE. SUCH BE AS FLUID RESERVOIRS WIRING, FUSE BOX, AND MORE.
NHTSA complaint #11141627 — an unverified report by a vehicle owner.
at 214,000 milesCumming, GAFire
UNKNOWN OR OTHER
ON SATURDAY, DECEMBER 16, AT APPROXIMATELY 11:30 AM, MY WIFE'S 2004 KIA SEDONA SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY OF OUR HOME. I HAD DRIVEN IT THAT MORNING TO RUN A QUICK ERRAND, ACTUAL DRIVE TIME LESS THAN HALF AN HOUR WITHOUT ANYTHING OUT OF THE ORDINARY. I RETURNED HOME, PARKED IN OUR DRIVEWAY BEHIND MY FORD WINDSTAR. BOTH MY WIFE AND MYSELF WERE IN OUR HOUSE WHEN WE HEARD A LOUD BOOM FOLLOWED SHORTLY BY A SECOND BOOM. THAT IS WHEN WE SAW THAT FIRE WAS COMING FROM THE ENGINE COMPARTMENT OF HER VAN AND THE REAR OF MY WINDSTAR WAS ON FIRE. WE IMMEDIATELY CALLED 911 AND SHORTLY THEREAFTER OUR LOCAL FIRE COMPANY ARRIVED AND BEGAN FIGHTING THE BLAZE. BY THAT TIME BOTH VEHICLES WERE ENGULFED IN FLAMES. THE FIRE APPEARS TO HAVE STARTED IN THE ENGINE COMPARTMENT OF THE KIA. BOTH VEHICLES ARE A TOTAL LOSS. UNTIL THIS INCIDENT, NOTWITHSTANDING BASIC MAINTENANCE AND REPAIRS, THE KIA SEDONA WAS A VERY RELIABLE VEHICLE. AS WITH THE WINDSTAR, MAINTENANCE AND REPAIRS WERE DONE ON A REGULAR AND AS NEEDED BASIS BY THE SAME SHOP THAT HAS WORKED ON ALL OUR VEHICLES FOR OVER 10 YEARS. I AM SURE I CAN PRODUCE MAINTENANCE AND REPAIR RECORDS IF NEEDED. THE LAST TIME THE KIA WAS SERVICED WAS LATE OCTOBER OF THIS YEAR TO REPLACE AN ALTERNATOR.
NHTSA complaint #11080722 — an unverified report by a vehicle owner.
at 101,294 milesPeabody, MA
UNKNOWN OR OTHER
WHEN I WENT TO START MY CAR IT IMMEDIATELY SHUT OFF, AS IT OCCASIONALLY DOES. THE RPM'S DROPPED AND THE ENGINE CUT OUT. USUALLY THE PROBLEM IS RESOLVED BY ME REVVING THE ENGINE FOR A MINUTE OR TWO, BUT THE PROBLEM PERSISTED LONGER THAN USUAL. IT EVENTUALLY STAYED ON AND I TRIED TO DRIVE AWAY. AS I CHANGED INTO GEAR EVERYTHING SEEMED OKAY, I REVERSED FROM WHERE I WAS PARKED THEN I PUT IT INTO DRIVE AND WHILE IN THE MIDDLE OF THE ROAD THE ENGINE CUT OUT AND I WAS STUCK THERE FOR ONLY A FEW SECONDS LUCKILY. I DROVE BACK TO WHERE I WAS PARKED AND AS I STOPPED THE ENGINE CUT OUT ON ME. THIS TYPICALLY HAS HAPPENED TO ME WHEN THE GAS TANK WAS BELOW HALF. I MANAGED TO GET TO A GAS STATION AND FILL UP AND THAT STOPPED THE PROBLEM.
NHTSA complaint #10993222 — an unverified report by a vehicle owner.
at 158,000 milesEmmett, IDCrash
AIR BAGS
"TAKATA RECALL" ON TUESDAY MAY 9, 2017 WE WERE INVOLVED IN AN AUTOMOBILE ACCIDENT. TO OUR AMAZEMENT AND HORROR, NOT ONE AIRBAG DEPLOYED . 'WE WERE HIT ON THE PASSENGER SIDE OF THE VAN . THE FRONT PASSENGER DOOR REQUIRED ASSISTANCE FROM THE POLICE/FIRE FIGHTERS ASSISTANCE TO EXIT THE VAN HOWEVER THE SLIDING DOOR COULD NOT BE OPENED REQUIRING REMOVING THE BABY THROUGH THE DRIVER'S SIDE. THE LIGHT TURNED GREEN AND WE BEGAN TO MOVE FORWARD WHEN OUR VAN WAS STRUCK BY THE OTHER CAR EXITING A PARKING LOT. NEITHER ONE OF US SAW THE ADVANCE NOR IMPACT OF THE OTHER CAR. AFTER REALIZING WHAT HAPPENED WE CALL EMERGENCY VEHICLES FOR ASSISTANCE. WE WERE INSTRUCTED TO MOVE OUR VAN TO A SAFE LOCATION AND WAIT FOR H
NHTSA complaint #10992708 — an unverified report by a vehicle owner.
at 158,000 milesEmmett, IDCrash
STRUCTURE:BODY
"TAKATA RECALL" ON TUESDAY MAY 9, 2017 WE WERE INVOLVED IN AN AUTOMOBILE ACCIDENT. TO OUR AMAZEMENT AND HORROR, NOT ONE AIRBAG DEPLOYED . 'WE WERE HIT ON THE PASSENGER SIDE OF THE VAN . THE FRONT PASSENGER DOOR REQUIRED ASSISTANCE FROM THE POLICE/FIRE FIGHTERS ASSISTANCE TO EXIT THE VAN HOWEVER THE SLIDING DOOR COULD NOT BE OPENED REQUIRING REMOVING THE BABY THROUGH THE DRIVER'S SIDE. THE LIGHT TURNED GREEN AND WE BEGAN TO MOVE FORWARD WHEN OUR VAN WAS STRUCK BY THE OTHER CAR EXITING A PARKING LOT. NEITHER ONE OF US SAW THE ADVANCE NOR IMPACT OF THE OTHER CAR. AFTER REALIZING WHAT HAPPENED WE CALL EMERGENCY VEHICLES FOR ASSISTANCE. WE WERE INSTRUCTED TO MOVE OUR VAN TO A SAFE LOCATION AND WAIT FOR H
NHTSA complaint #10992708 — an unverified report by a vehicle owner.
at 110,000 milesSunrise, FLFire
ENGINE
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE STATIONARY, THE FRONT END OF THE VEHICLE ERUPTED INTO FLAMES. THE CONTACT STATED THAT THE FIRE ORIGINATED FROM THE ENGINE COMPARTMENT. A POLICE REPORT WAS NOT FILED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE WERE NO INJURIES SUSTAINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FIRE. THE FAILURE MILEAGE WAS 110,000.
NHTSA complaint #10985783 — an unverified report by a vehicle owner.
at 100,000 milesSwansea, SC
UNKNOWN OR OTHER
TAKATA RECALL..MY VAN STALLS OUT NO MATTER WHERE..STOPPED AT IDLE IT RANDOMLY SHUTS OFF..DRIVING AVERAGE SPEED IN TOWN 45MPH IT RANDOMLY SHUTS OFF..ON THE HWY. SPEEDS AVERAGE FROM 55 TO 70 MPH IT RANDOMLY SHUTS OFF ..IN HEAVY TRAFFIC THIS IS VERY DANGEROUS..I HAVE REPLACED THE FOLLOWING.. FUEL PUMP FUEL FILTER FUEL PUMP RELAYS THROTTLE POSITION SENSOR MASS AIR FLOW SENSOR CRANK SHAFT POSITION SENSOR OXYGEN SENSOR FUEL COIL PACKS SPARK PLUGS INTAKE GASKETS INJECTORS AIR FILTER JUST LIKE THE HUNDREDS OF PEOPLE ON THE FORUMEBAY ABOUT KIA SEDONA..I'VE PUT $1000'S IN THE VAN WITH NO SOLUTION TO THE DANGEROUS ISSUES..THE ONLY THING LEFT TO CHANGE IS THE INTERNAL WIRING..THIS PROBLEM IS WAY TO COMMON FOR KIA NOT TO HAVE A RECALL ON IT..ITS A HUGE SAFETY HAZARD AND NEEDS TO HAVE SOMETHING DONE ABOUT IT..NOT JUST FOR ME BUT FOR EVERYONE THAT HAS A KIA SEDONA..ITS OBVIOUSLY A SHORT IN THE WIRING AND IS A MANUFACTURER FLAW FOR SO MANY PEOPLE TO HAVE THE SAME ISSUE..BTW MY VAN ONLY HAS 100.000 MILES ON IT I'VE SEEN SOME AS LOW AS 30.000 WITH THIS SAME ISSUE..NO EXCUSES FOR THIS..ANY KIND OF ELECTRONIC SHORT OUT HAS POTENTIAL FOR FIRE NOT TO MENTION THE HAZARDS OF THE VAN RANDOMLY STOPPING IN TOWN AT INTERSECTION ON THE INTERSTATE .
NHTSA complaint #10969516 — an unverified report by a vehicle owner.
at 100,000 milesSwansea, SC
ELECTRICAL SYSTEM
TAKATA RECALL..MY VAN STALLS OUT NO MATTER WHERE..STOPPED AT IDLE IT RANDOMLY SHUTS OFF..DRIVING AVERAGE SPEED IN TOWN 45MPH IT RANDOMLY SHUTS OFF..ON THE HWY. SPEEDS AVERAGE FROM 55 TO 70 MPH IT RANDOMLY SHUTS OFF ..IN HEAVY TRAFFIC THIS IS VERY DANGEROUS..I HAVE REPLACED THE FOLLOWING.. FUEL PUMP FUEL FILTER FUEL PUMP RELAYS THROTTLE POSITION SENSOR MASS AIR FLOW SENSOR CRANK SHAFT POSITION SENSOR OXYGEN SENSOR FUEL COIL PACKS SPARK PLUGS INTAKE GASKETS INJECTORS AIR FILTER JUST LIKE THE HUNDREDS OF PEOPLE ON THE FORUMEBAY ABOUT KIA SEDONA..I'VE PUT $1000'S IN THE VAN WITH NO SOLUTION TO THE DANGEROUS ISSUES..THE ONLY THING LEFT TO CHANGE IS THE INTERNAL WIRING..THIS PROBLEM IS WAY TO COMMON FOR KIA NOT TO HAVE A RECALL ON IT..ITS A HUGE SAFETY HAZARD AND NEEDS TO HAVE SOMETHING DONE ABOUT IT..NOT JUST FOR ME BUT FOR EVERYONE THAT HAS A KIA SEDONA..ITS OBVIOUSLY A SHORT IN THE WIRING AND IS A MANUFACTURER FLAW FOR SO MANY PEOPLE TO HAVE THE SAME ISSUE..BTW MY VAN ONLY HAS 100.000 MILES ON IT I'VE SEEN SOME AS LOW AS 30.000 WITH THIS SAME ISSUE..NO EXCUSES FOR THIS..ANY KIND OF ELECTRONIC SHORT OUT HAS POTENTIAL FOR FIRE NOT TO MENTION THE HAZARDS OF THE VAN RANDOMLY STOPPING IN TOWN AT INTERSECTION ON THE INTERSTATE .
NHTSA complaint #10969516 — an unverified report by a vehicle owner.
at 120,500 milesMadeira Beach, FL
STEERING
MY STEERING IN MY 2004 KIA SEDONA LX IS TENDING TO BIND AND NEARLY LOCK UP AROUND TURNS. THIS PROBLEM COMES AND GOES.
NHTSA complaint #10788466 — an unverified report by a vehicle owner.
at 130,000 milesAlhambra, CAFire
ELECTRICAL SYSTEM
UPON RETURNING HOME AND PARKING MY VAN AFTER RUNNING AN ERRAND OF ABOUT 5 MILES, I SAW SMOKE COMING FROM THE ENGINE COMPARTMENT, RAN TO GET A FIRE EXTINGUISHER, THE FIRE WAS PUT OUT WITHIN 60 (SIXTY) SECONDS AFTER SEEING THE SMOKE. REMOVING THE AIR CLEANER AND OTHER COMPONENTS, -- THE WIRE HARNESS ON THE PASSENGER SIDE OF THE ENGINE COMPARTMENT WAS FOUND CHARRED BY THE FIRE. NO IMMEDIATE REASON WAS FOUND FOR THIS INCIDENT TO OCCUR.
NHTSA complaint #10716372 — an unverified report by a vehicle owner.
at 172,000 milesPort Saint Lucie, FLFire
ELECTRICAL SYSTEM
CAUGHT ON FIRE WHILE PARKED AFTER DRIVING ENGINE WAS OFF . HISTORY OF OIL LEAKS. #15003607 VAN TOTALED AND SENT TO SALVAGE YARD.
NHTSA complaint #10695433 — an unverified report by a vehicle owner.
at 297,400 milesJefferson, OH
STEERING
MY VAN WONT STEER. IT IS TIGHT AND WONT LET ME GO LEFT OR RIGHT.
NHTSA complaint #10681668 — an unverified report by a vehicle owner.
at 150,000 milesMissoury City, TX
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE OPENING THE FRONT DRIVER SIDE EXTERIOR DOOR HANDLE, ALL FOUR DOORS ON THE VEHICLE LOCKED INDEPENDENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDATED 6/11/15*CN UPDATED 06/16/15
NHTSA complaint #10669086 — an unverified report by a vehicle owner.
at 60,000 milesWoodburn, OR
STEERING
WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGEROUS TO LOSE POWER OF STEERING ESPECIALLY IN WET CONDITIONS.
NHTSA complaint #10668374 — an unverified report by a vehicle owner.
at 60,000 milesWoodburn, OR
ELECTRICAL SYSTEM
WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGEROUS TO LOSE POWER OF STEERING ESPECIALLY IN WET CONDITIONS.
NHTSA complaint #10668374 — an unverified report by a vehicle owner.
at 96,000 milesSyracuse, NY
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 40 MPH, THE SPEEDOMETER FLUCTUATED AND SEIZED INTERMITTENTLY. IN ADDITION, THE VEHICLE WOULD ACCELERATE INDEPENDENTLY. IN ORDER TO PREVENT THE FAILURE, THE CONTACT HAD TO DRIVE AT A SLOWER SPEED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V329000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
NHTSA complaint #10638653 — an unverified report by a vehicle owner.
at 129,994 milesNEW Port Richey, FL
STEERING
WHILE MAKING RIGHT AND LEFT TURNS THE STEERING BECOMES VERY TIGHT. THE POWER STEERING FLUID WAS FINE. NO OTHER WARNINGS. THIS MADE ME VERY SCARED TO MAKE TURNS. I DID MY BEST TO AVOID TURNS ONLY IF ABSOLUTELY NECESSARY FOR TWO DAYS. IN MY 32 YEARS OF DRIVING I HAVE NEVER HAD THIS HAPPEN TO ME. WHEN I TOOK IT TO TIRE CHOICE AND TOTAL CAR CARE THEY SAID IT WAS MY INTERMEDIATE STEERING SHAFT NEED TO BE REPLACED. I HAD IT REPLACED THAT DAY 9/20/14.
NHTSA complaint #10638133 — an unverified report by a vehicle owner.
at 139,685 milesVenice, FLFire
ELECTRICAL SYSTEM
WIRING UNDER SEAT SHORTED CAUSING SMALL FIRE INSIDE..EXTINGUISHED WIRING UNDER CAR IN SAME AREA MELTED SHORTING EVERY THING OUT.
NHTSA complaint #10622317 — an unverified report by a vehicle owner.
West Plains, MO
STEERING
STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE REFERENCE BULLETIN TSB-019 THIS IS RIDICULOUS THAT THERE HASN'T BEEN A RECALL! ARE WE JUST WAITING FOR A WRECK THAT ACTUALLY KILLS SOME ONE? WE WERE TURNING ONTO THE HIGHWAY AND THE STEERING WHEEL LOCKED AND HAD TO BE TURNED BACK TO STRAIGHT OR ELSE IT WOULD HAVE JUST KEPT TURNING US INTO ONCOMING TRAFFIC.
NHTSA complaint #10584969 — an unverified report by a vehicle owner.
at 152,500 milesGetteysburg, PACrash
AIR BAGS
TL* THE CONTACT OWNS A 2004 KIA SEDONA .THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE CONTACT CRASHED INTO A DEER BUT THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 152,500. THE VIN WAS UNAVAILABLE.
NHTSA complaint #10559674 — an unverified report by a vehicle owner.
Hackleburg, AL
TIRES
THIS IS THE SECOND SET OF DOUGLAS TIRES I HAVE HAD TO PAY FOR EVEN THOUGH WALMART SAYS IT IS A MANUFACTURE DEFECT THEY GET HOLES IN THE SIDE OF THE TIRES THIS TIME THE WHOLE INSIDE OF MY TIRE IS GONE LOOKS LIKE ROPE HANGING OUT ME AND MY DAUGHTER COULD OF BEEN SERIOUSLY HURT OR KILLED SO I THINK THAT DOUGLAS SHOULD HAVE TO REPLACE MY TIRES ON MY KIA MINI VAN I AM SICK AND TIRED OF WALMART AND THE DOUGLAS TIRES I CANNOT AFFORD MORE TIRES HERE IS THE DOT NUMBER ON THE TIRES AND THE SIZETHEY R EXTRA TRAC [[ MTS 215/70R15 MD34 O1R 17/11 SOMETHING NEEDS TO BE DONE.
NHTSA complaint #10536846 — an unverified report by a vehicle owner.
at 135,000 milesDecatur, GAFire
ENGINE
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE FROM UNDER THE HOOD WHILE DRIVING AN UNKNOWN SPEED. THE CONTACT WAS ABLE TO MOVE OFF THE ROADWAY AND CALLED THE FIRE DEPARTMENT, WHO EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS DEEMED AS DESTROYED BY THE CONTACT'S INSURANCE AGENCY. THE FAILURE AND CURRENT MILEAGES WERE 135,000.
NHTSA complaint #10532292 — an unverified report by a vehicle owner.
