2020 KIA Sedona problems

STRUCTURE:BODY

Paint delaminating due to latent defects.

NHTSA complaint #11736775 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

The contact owns a 2020 Kia Sedona. While driving approximately 30 MPH on a main road, the steering wheel started shaking abnormally and became difficult to control. The vehicle was driven to a tire shop and then to an independent mechanic. Additionally, the sliding doors failed to open as needed, the steering wheel occasionally seized, there was tread separation in the tires, and the wheels were bent. The mechanic inspected the tires and steering system, performed a safety inspection, and determined that the vehicle was unsafe to drive. The tires were replaced, and the wheels were repaired; however, the sliding doors were not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 65,245.

NHTSA complaint #11711006 — an unverified report by a vehicle owner.

WHEELS:RIM

The contact owns a 2020 Kia Sedona. While driving approximately 30 MPH on a main road, the steering wheel started shaking abnormally and became difficult to control. The vehicle was driven to a tire shop and then to an independent mechanic. Additionally, the sliding doors failed to open as needed, the steering wheel occasionally seized, there was tread separation in the tires, and the wheels were bent. The mechanic inspected the tires and steering system, performed a safety inspection, and determined that the vehicle was unsafe to drive. The tires were replaced, and the wheels were repaired; however, the sliding doors were not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 65,245.

NHTSA complaint #11711006 — an unverified report by a vehicle owner.

POWER TRAIN

March 2024 just before hitting 100,000 miles I started having oil consumption issues. Current milage is 137,300 About 10,000 miles ago my check engine light came on. I took it to an auto parts store and it was reading bank 1 O2 sensor. I took it for an oil change and never scheduled for the sensor replacement due to life events. I took it in for another service About 5,000 miles ago. At around 2,000 miles after the service the motor started stalling and sounded horrible. I took it to the dealership and it was 4.5 quarts low on oil. Took it back at 1,200 miles after top off and it was 2.5 quarts low. Started the new motor process which wasn't covered on the extended warranty due to manufactur defect. It cost me 500.00. Before the new motor was in my van started getting me stranded places. Motor wouldn't turn over at all. Got it started went to auto parts store and it was reading 4 bad sensors in bank 1 and 2 (O2 and air intake on the motor). Finally got it to KIA for the new motor told them about they sensors they were supposed to check/replace them when they put the new crate motor in. Picked my van up 3 days ago. I asked when they called if the engine light was off. They called me back several hours later and said yes. Picked it up at 5 pm 3 days ago. By 8am the next morning the engine light was back on. It's scheduled for 9am Monday. The van has now gotten me stranded 2 times in 3 days. Auto parts store ran the computer and the same 4 sensors are still showing bad. Sensors are in bank 1 and 2. The report on the old motor showed cylinder 1 and 2 oil fouling on the spark plugs (replaced at 100,000 miles by dealer) and excessive oil leakage in cylinder 1 and 2 into the crank case due to carbon stuck piston rings. I was told before the motor replacement that the KIA cares warranty may not cover these sensors. Even though the sensors are going out because they are gunked up with 7 quarts of oil their motor used and they didn't go out until the issue started.

NHTSA complaint #11708408 — an unverified report by a vehicle owner.

ENGINE

March 2024 just before hitting 100,000 miles I started having oil consumption issues. Current milage is 137,300 About 10,000 miles ago my check engine light came on. I took it to an auto parts store and it was reading bank 1 O2 sensor. I took it for an oil change and never scheduled for the sensor replacement due to life events. I took it in for another service About 5,000 miles ago. At around 2,000 miles after the service the motor started stalling and sounded horrible. I took it to the dealership and it was 4.5 quarts low on oil. Took it back at 1,200 miles after top off and it was 2.5 quarts low. Started the new motor process which wasn't covered on the extended warranty due to manufactur defect. It cost me 500.00. Before the new motor was in my van started getting me stranded places. Motor wouldn't turn over at all. Got it started went to auto parts store and it was reading 4 bad sensors in bank 1 and 2 (O2 and air intake on the motor). Finally got it to KIA for the new motor told them about they sensors they were supposed to check/replace them when they put the new crate motor in. Picked my van up 3 days ago. I asked when they called if the engine light was off. They called me back several hours later and said yes. Picked it up at 5 pm 3 days ago. By 8am the next morning the engine light was back on. It's scheduled for 9am Monday. The van has now gotten me stranded 2 times in 3 days. Auto parts store ran the computer and the same 4 sensors are still showing bad. Sensors are in bank 1 and 2. The report on the old motor showed cylinder 1 and 2 oil fouling on the spark plugs (replaced at 100,000 miles by dealer) and excessive oil leakage in cylinder 1 and 2 into the crank case due to carbon stuck piston rings. I was told before the motor replacement that the KIA cares warranty may not cover these sensors. Even though the sensors are going out because they are gunked up with 7 quarts of oil their motor used and they didn't go out until the issue started.

NHTSA complaint #11708408 — an unverified report by a vehicle owner.

ENGINE

Check engine light came on all of a sudden. Smell of exhaust/gas coming from car. Took car to the dealership to get the cause of the check engine light coming on. Dealership said it came back 02 sensor bank 2 and exhaust gasket to header.

NHTSA complaint #11701347 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Check engine light came on all of a sudden. Smell of exhaust/gas coming from car. Took car to the dealership to get the cause of the check engine light coming on. Dealership said it came back 02 sensor bank 2 and exhaust gasket to header.

NHTSA complaint #11701347 — an unverified report by a vehicle owner.

ENGINE

Problem: The Vehicle Slows down all of a sudden on the middle of the road from around 70 miles to 10 miles, then slowly drives at 15 or 20 miles speed. Safety Concern: On the Interstate Hwy, this has happened many time. Fortunately without any accidents. Very recently also this happened and I do not drive the vehicle out now, since it does not accelerate. Reason: The failure of the accelerator Pedal. Symptoms: The "Check Engine" light comes one and the Engine abruptly slows down. First time it occurred: I a year after the Vehicle was bought -- 15000 miles -- Company did a Warranty replacement after almost a month (Multiple Visits). Second time it occurred: After 4 years-- 50000 miles -- company did a Warranty Replacement after a month (Multiple visits). Third time it is occurring: After 5 years -- 63000 miles -- Company claims it is no longer a warranty issue and also it is a different problem that is causing the same issue and charging me $5000 for repairs. Present Situation: The Vehicle is unusable and since it is the 3rd time this is happening, there is a serious issue with the Vehicle and I am worried about my/my families Safety. A replacement of the Vehicle with the fully tested one (With no such safety issues)and with guarantee that the Company/Its dealers will service the vehicle without delay will be helpful. Available details: All the correspondence from the first time this issue happened (complete correspondence with the company of my safety and replacement of the vehicle) is available. Also my Service records with the Dealerships and the warranty issues are also available. The False charges by the dealers is also available. The recent visit to another authorized Car shop and their report that this issue is the same old Accelerator pedal issue is also available.

NHTSA complaint #11685963 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 Kia Sedona. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with several unknown warning lights illuminated. The vehicle was towed to the dealer, where the vehicle was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was not repaired; however, the failure recurred when the dealer attempted to test-drive the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 77,000. The VIN was not available.

NHTSA complaint #11676231 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The last week of February I took my 2020 Kia Sedona at 67,500 miles into Kia Ferguson in Tulsa, OK to have them replace my High Pressure Fuel Pump which was covered under an extended warranty. When I received my van back, the battery was dead and the AC wasn't working nor the control knob.(it was stuck) I had to replace my battery, and that Friday Kia said they would take a look at it. When I went to pick up my van, they told me it was going to cost $1500 to fix, and that I was responsible. I called Kia consumer Affairs, and discussed this with them as well. To no avail, I am being held responsible. I took my van somewhere else however was quoted higher. I asked if after they fix it was there a possibility it still might not work and that it could be something else, and the gentleman said yes. I don't want to put all of this money to fix a problem, Kia may have inadvertently disconnected something that really just needed to be reconnected. This is a safety issue for me and my children, as I get weak when I am overheated, and it gets entirely too hot in Oklahoma during the summers. I didn't have any prior issues with my AC prior to them replacing my high pressure fuel pump.

NHTSA complaint #11663173 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Sliding door malfunction. Door will not hold its weight and full force closes or opens if operating at an inclined position.

NHTSA complaint #11662099 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Sliding door trys to continue to open when already open all the way, it try’s to open too far, jams and clicks, then beeps.

NHTSA complaint #11662106 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I have multiple spots of the pearl white paint peeling/flaking/bubbling off the vehicle in multiple places. 1st spot noticed was on the roof just behind the sunroof and the 2nd spot is the edge of the liftgate.

NHTSA complaint #11603479 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I received a letter from Kia America, Inc. extending the warranty on the high pressure fuel pump on my 2020 Kia Sedona. They claim that the fuel control valve plunger may wear unevenly and over time become stuck in the open position. They state different things can happen including stalling. My research found that it can cause stalling at high speeds or in heavy traffic and it may cause a loss of control over the vehicle. ARE THEY TRYING TO AVOID A RECALL. I am [XXX] and this sounds real dangerous. Does a serious accident have to happen before a recall is ordered? i have attached a copy of the letter below. [XXX] cell [XXX] email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11592280 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I felt it was necessary to follow up on the open recall I have on my vehicle. I have owned the vehicle since Nov. 2019 and not once have we been contacted either by mail, verbal communication, by the NHTSA or the dealership of which the vehicle was purchased. Here we are in April 2024 and just a random click on “check recalls” button located on our vehicle insurance company website, made me aware of the open bulletin. I guess my question is, why are the insurance companies not offering the owner information on this? Or even the company who has been placed as lien holder? Why are we solely dependent on the USPS to deliver correspondence in hopes of making it to the correct address and owner? What happens if the owner has moved and the notification of recall did not forward to the new address? Too many “what if’s” in this scenario to allow unnecessary delay of repair. I’d like to see insurance companies begin notifying the owner as well. Makes sense to me. Or again, even the lien holder could attach notification to that months bill.

NHTSA complaint #11581467 — an unverified report by a vehicle owner.

POWER TRAIN

Oil consumption test failed. Told by dealer the first part of the repair is not covered under the power train warranty because my vehicle is not listed on the list of affected vehicles even though it has the GDI motor that is listed. It's a V6 and not a 4 cylinder and the V6 is not on the list. Dealership in knoxville has done the oil consumption test. Vehicle was bought new in November of 2019 and services have been preformed according to manufacturers recommendation. Van has 104,500 miles on it. Has a 200,000 power train warranty. Kia customer service said it is not covered on the manufacturer warranty because it ends at 100,000 miles. Dealership says its not covered on 200,000 mile power train warranty and Dealership ship isn't responsible because my vehicle and motor are not on the list. I wasn't even aware this was an issue until my van started acting up between oil changes and the oil pressure light came on and the van started stalling. At that time I put 4.5 quarts of oil in it and scheduled the Dealership visit just before 100,000 miles but was told to bring it back if the oil level dropped again. Now it's past 100,000 miles and they didn't register the complaint I made before 100,000 miles. 2nd part of oil consumption test was done today.

NHTSA complaint #11580142 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2020 Kia Sedona. The contact stated while driving 40–45 MPH, the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the headlights and taillights became inoperable. The contact also stated that the oil level was low after checking the dipstick. The driver's side window was stuck in the down position. The contact depressed the window button, but the window failed to roll up. The vehicle was taken to an independent mechanic, and the contact was informed that there was a leak in the trans axle boot, and the 02 sensor and trans axle boot were replaced. The vehicle was taken to the local dealer, where it was diagnosed that the headlights and taillights needed to be replaced. The dealer performed an oil pressure test, which indicated that the oil level was a 1/2 quart low. The vehicle was repaired, but the failure recurred. The contact stated that there was water inside the headlight housing. The vehicle was taken back to the same local dealer, and the contact was informed that there was no warranty coverage on the vehicle. The manufacturer was contacted, but there was no additional assistance provided. The failure mileage was approximately 79,000.

NHTSA complaint #11570716 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 Kia Sedona. The contact stated while driving 40–45 MPH, the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the headlights and taillights became inoperable. The contact also stated that the oil level was low after checking the dipstick. The driver's side window was stuck in the down position. The contact depressed the window button, but the window failed to roll up. The vehicle was taken to an independent mechanic, and the contact was informed that there was a leak in the trans axle boot, and the 02 sensor and trans axle boot were replaced. The vehicle was taken to the local dealer, where it was diagnosed that the headlights and taillights needed to be replaced. The dealer performed an oil pressure test, which indicated that the oil level was a 1/2 quart low. The vehicle was repaired, but the failure recurred. The contact stated that there was water inside the headlight housing. The vehicle was taken back to the same local dealer, and the contact was informed that there was no warranty coverage on the vehicle. The manufacturer was contacted, but there was no additional assistance provided. The failure mileage was approximately 79,000.

NHTSA complaint #11570716 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2020 Kia Sedona. The contact stated while driving 40–45 MPH, the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the headlights and taillights became inoperable. The contact also stated that the oil level was low after checking the dipstick. The driver's side window was stuck in the down position. The contact depressed the window button, but the window failed to roll up. The vehicle was taken to an independent mechanic, and the contact was informed that there was a leak in the trans axle boot, and the 02 sensor and trans axle boot were replaced. The vehicle was taken to the local dealer, where it was diagnosed that the headlights and taillights needed to be replaced. The dealer performed an oil pressure test, which indicated that the oil level was a 1/2 quart low. The vehicle was repaired, but the failure recurred. The contact stated that there was water inside the headlight housing. The vehicle was taken back to the same local dealer, and the contact was informed that there was no warranty coverage on the vehicle. The manufacturer was contacted, but there was no additional assistance provided. The failure mileage was approximately 79,000.

NHTSA complaint #11570716 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:BRAKE LIGHTS

The contact owns a 2020 Kia Sedona. The contact was notified by the local Police that the rear brake lights were not illuminating as needed. The vehicle was later taken to the local mechanic who was unable to determine the cause of the failure. Later while driving approximately 20 MPH and depressing the brake pedal, the brake pedal extended to the floorboard. The vehicle was immediately towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 41,000.

NHTSA complaint #11539097 — an unverified report by a vehicle owner.

SERVICE BRAKES

The contact owns a 2020 Kia Sedona. The contact was notified by the local Police that the rear brake lights were not illuminating as needed. The vehicle was later taken to the local mechanic who was unable to determine the cause of the failure. Later while driving approximately 20 MPH and depressing the brake pedal, the brake pedal extended to the floorboard. The vehicle was immediately towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 41,000.

NHTSA complaint #11539097 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2020 Kia Sedona. The contact stated while attempting to start the vehicle in hot temperatures, the vehicle failed to start immediately. After several attempts, the vehicle was able to be started and seemed to return to normal functionality. The contact stated that the failure had become a regular occurrence during the summer months. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 22,000.

NHTSA complaint #11536475 — an unverified report by a vehicle owner.

TIRES

my new kumo ho7 235-60-r18, tire fell apart on road trip from fl. to wi. had service done in Clarksville tenn. kia dealership on july 12th 2021. tire had to be replaced. odometer read 5,711 now another tire failed replaced jan. 22nd odometer read 11,765

NHTSA complaint #11448844 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Driving down the interstate at 70mph and the vehicle suddenly began to brake and the forward collision warning light illuminated along with the check engine light. The car stopped on the interstate and this happened at 1:15 am and it was in a rural area and it was pitch black outside. Luckily no one plowed into the back of the car. Was able to restart the car and was barely able to get it to the side of the road before it shut down again. 6 miles to the nearest exit attempted to get the car off the highway. After several attempts and turning off every electric accessory and sensor was able to get the car to the exit. KIA toed the car to the nearest dealership the next day. They discovered that the wiring harness was chewed up in several places and caused numerous shorts circuits and malfunction codes. I own several vehicles that are parked in the same area and this is the only one that has chewed up the wiring. My daughter and 2 of the grandchildren were in the car when this happened and they could have been killed if someone had plowed into the back of them at 70+ mph. This is a 2020 Kia Sedona and I'm being told that this is not covered under warranty. There is something wrong here seeing how this only happened to this car and not my other cars nor my boat. The car is in the shop and will not be ready for a week or two and this happened more than 350 miles from my house. I have lost the use of this car and Kia refused a rental because they said it was not a warranty issue. I know Kia is having this same issue with many of their vehicles. Does it take people to die for this to be addressed? I hope not. My family could have easily been killed because of this. Luck is probably the only thing that prevented a tragedy here. The car has not been repaired yet so I don't have any documents to upload yet.

NHTSA complaint #11430054 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

What component or system failed or malfunctioned, and is it available for inspection upon request? It looks like the ECU communication to my key fob failed and the engine was shutdown while I was driving the car on the highway. Then the anti-theft system called Immobilizer kicked in and prevented me to start the car again. It looks like the memory of my key fob id was erased or something as my car seemed to complain that the fob was not present when it in fact it was right next to me in the center console. How was your safety or the safety of others put at risk? I was driving with my three young kids and wife and we and to shoulder the car in the highway. I was forced to shoulder the car because the engine shutdown in the middle of driving. This was highly unexpected behavior and my immediate thought was to pull to the side of the highway and take a look a the issue in a safer spot but parking at the side of a highway while other cars are driving past at 75MPH is not the safest idea. Has the problem been reproduced or confirmed by a dealer or independent service center? The car was towed to a nearby KIA dealership and they have yet to take a look at it. It has been four days since the incident. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? I filed a complaint with KIA on Sunday and called today, they said they are escalating the issue but we have not heard any changes. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warnings prior to the incident, the dashboard lights turned off and an indicator light showed the immobilizer mode was on.

NHTSA complaint #11429457 — an unverified report by a vehicle owner.