Owners have filed 183 complaints
about the 2017 KIA Sedona with NHTSA between 2016 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 10 of 19 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 51
Against the median year of the KIA Sedona. 50 means typical for this
model; 100 means roughly double.
Severity — 45
8.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 84
49% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
35.7%
1,000 – 9,999 miles
35.7%
10,000 – 24,999 miles
1018.9%
25,000 – 49,999 miles
1120.8%
50,000 – 74,999 miles
1528.3%
75,000 – 99,999 miles
611.3%
100,000 – 149,999 miles
59.4%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2016peak 8Aug 2026
Recalls on the 2017 KIA Sedona
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
22V031000
AIR BAGS
Kia Motors America (Kia) is recalling certain 2017-2019 Sedona, Soul, Soul EV, 2017-2018 Forte, and 2017 Forte Koup vehicles. The Air Bag Control Unit (ACU) cover may contact a memory chip on the printed circuit board and damage the electrical circuit. Circuit damage may result in deactivated air bags that will not deploy in a crash.
Risk: Air bags that do not deploy as intended can increase the risk of injury in a crash.
21V725000
EXTERIOR LIGHTING:TURN SIGNAL
Kia Motors America (Kia) is recalling certain 2015-2017 Sedona vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.
Risk: A turn signal activating in the opposite direction of what was intended by the driver increases the risk of a crash.
19V109000
ELECTRICAL SYSTEM:WIRING
Kia Motors America (Kia) is recalling certain 2015-2018 Sedona vehicles equipped with manually-adjusted front passenger seats. Over time, the Occupant Detection System (ODS) wiring harness located underneath the front passenger seat may break from the seat being occupied.
Risk: If a child is in a child seat in the front seat, a broken ODS wiring harness will not prevent the front passenger air bag from deploying in the event of a crash, increasing the risk of injury to the child.
18V338000
STRUCTURE:BODY:DOOR
Kia Motors America (Kia) is recalling certain 2015-2018 Kia Sedona vehicles equipped with a power sliding door (PSD). The PSD may not auto-reverse when its closing is obstructed.
Risk: If the door closes on an occupant, there is an increased risk of an injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024549647,384 units in Canada
Label
Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. Kia has corrected the compliance label for all new vehicles.
Recall 202202358,054 units in Canada
Airbag
Issue: On certain vehicles, a defect in the airbag control unit could cause the airbag warning light to turn on. If this happens, the airbag system may not work properly, and the airbags may not inflate in a crash. Safety Risk: An airbag system that does not work properly could create an increased risk of injury in a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to update the airbag control unit software. If the airbag warning light is on because of diagnostic trouble code B1620, the dealer will replace the airbag control unit.
Recall 20216809,612 units in Canada
Electrical
Issue: Certain vehicles may be equipped with an accessory trailer wiring harness that could fail. Over time, water could leak into the control module and cause a short circuit. If this happens, there could be loss of the trailer lights. Note: This recall affects trailer wiring harness kits that may have been ordered at the time of a vehicle purchase, or purchased separately from a dealer as an aftermarket accessory. Safety Risk: A loss of trailer lights could make the trailer less visible. In addition, other drivers may not recognize that the vehicle ahead is braking or intends to turn. This could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the trailer wiring harness. If the harness is from the lot (batch) affected by this problem, the dealer will replace it. Kia recommends that you should always check to ensure that trailer lights work properly before towing.
Recall 20215745,851 units in Canada
Lights And Instruments
Issue: On certain vehicles, an intermittent problem could cause the turn signals to activate in the opposite direction from what a driver intends. For example, when the driver uses the right turn signal, the left signal could turn on. Safety Risk: Turn signals that do not work properly may cause confusion and could increase the risk of a crash. Corrective Action: Kia will notify owners by mail and instruct you to bring your vehicle to a dealer to update the Smart Junction Box software.
Recall 20191035,314 units in Canada
Seats And Restraints
Issue: On certain vehicles, the wiring for the Occupant Detection System (ODS) could break. This would cause the airbag system to not turn off the airbag when an infant or child is seated in the front passenger seat. This problem only affects vehicles with a manual front-passenger seat. Safety Risk: In a crash, an airbag that deploys in front of an infant or child increases the risk of injury. Corrective Actions: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to remove a wiring harness clip. This will prevent the wire from breaking. If the wiring is found damaged, the dealer will replace the front passenger seat cushion. Note: If the wiring breaks, the SRS airbag warning light will come on and the "Passenger Airbag Off" indicator will not turn on.
Recall 20182909,578 units in Canada
Structure
On certain vehicles, the power sliding door control module may not be calibrated correctly. As a result, a closing door may not stop and reverse direction if blocked by an object, increasing the risk of injury to vehicle occupants. Correction: Dealers will reprogram the power sliding door control module software.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 146,658 milesProspect, ILFire
ENGINE
The contact owns a 2017 Kia Sedona. The contact stated that while driving at 55 MPH, the contact the oil light illuminated, and the vehicle decelerated independently. The contact mention he pulled over to the right side of the road, exited the vehicle and when he lifted the hood of the vehicle, he noticed flames coming from the engine. No injuries were sustained. No medical attention. There was no police report filed. The fire department did not show at the scene to extinguish the fire. The vehicle was not destroyed. The vehicle is currently still at the scene. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 146,658.
NHTSA complaint #11736979 — an unverified report by a vehicle owner.
at 106,000 milesRaytown, MOFire
ENGINE
The contact owned a 2017 Kia Sedona. The contact stated that after parking in his driveway, there was white smoke coming from the front of the vehicle. The contact is handicapped and was assisted by his wife to exit the vehicle safely. The vehicle later caught on fire, and flames were visible in the front passenger side that spread to the rear of the vehicle. No warning lights illuminated before or after the failure. The contact stated that the front of the house was damaged, as well as the garage siding, along with an older truck parked in the driveway. The fire was extinguished by the fire department with water, and a police officer was on scene and tried to extinguish the rear with an extinguisher, but was unsuccessful. There was a fire report filed. The vehicle was towed a week after the fire to the insurance tow lot. The vehicle was deemed destroyed by the insurance company. No injuries were sustained. The manufacturer was notified of the failure. The failure mileage was 106,000.
NHTSA complaint #11707879 — an unverified report by a vehicle owner.
APO, NYFire4 injured
ENGINE
While driving on the highway, the engine stopped working; smoke, metal fragments and oil came out of the front of the car leading to zero visibility. We were extremely lucky that we were able to quickly navigate out of traffic, stop the car on the side of the highway and get all kids out safely. The police and fire department came immediately to help. We had the vehicle towed and examined. The car had an internal engine break down. The connecting rod and the engine block were torn off and the oil pan was heavily damaged. It is deformed to the outside. The vehicle needs a new engine.
NHTSA complaint #11556486 — an unverified report by a vehicle owner.
Kansas City, MO1 injured
STRUCTURE:BODY
Power Door (passenger side) closed on me when other door was opened. As I was putting a child into the passenger side middle row seat the passenger side sliding door closed on its own. (The door on the other side of van was opened at the same time the one began to close.) It did not stop when it it my body and kept closing. I tried pushing on the door to stop it from continuing to close but it didn’t stop. My husband reached to push the button to open it back up. I had bruise on my arm and cut on my thigh from the door attempting to close on me.
NHTSA complaint #11507588 — an unverified report by a vehicle owner.
Keene, NH1 injured
EQUIPMENT
The contact owns a 2017 Kia Sedona. The contact stated while using the original jack that came with the vehicle when one side of the jack bent and caused the vehicle to collapse. The contact stated he pulled his back and did seek medical attention at a walk-in clinic. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure.
NHTSA complaint #11438182 — an unverified report by a vehicle owner.
Chillicothe, OH1 injured
UNKNOWN OR OTHER
This event occurred on June 3, 2021. The passenger sliding door sunshade (in use) began to rip from the top edge due to a 3.4 year old child pulling on it from their front facing carseat on a long drive. Unknown to the driver, the sunshade fabric had ripped about 5 inches away, leaving a portion of the rod exposed. When the damage was noticed, the driver disconnected the shade and recessed it for the next duration of travel in an attempt to keep the child safe and to ensure no further damage to the shade. While continuing the drive child, the child reached over and had begun mouthing the end of the rod while recessed. The van later stopped. Driver opened automatic sliding door from outside unknowingly while rod was in toddler's mouth. As the door retracted to the rear, the exposed rod end was thrust down the toddler's throat. The child shrieked in pain and fear. Driver reached around and attempted to pull the rod forward from the toddler's throat unsuccessfully (because the door was still in backwards movement. The toddler's head was pinned. The child finally turned their head towards the door and the road sprung out from pressure. Child had bruising and slight bleeding from the back of throat and a scrape along the inside of the cheek where the rod drug on its way out of the mouth. Child was removed from carseat and checked for severe injuries. There was no significant bleeding, the airway was unaffected, and photographs could not be taken due to the location of the injury and the age of the child. The child was held and consoled. The child and parents were extremely traumatized and it took nearly an hour to continue the drive to the destination. Child had instantly become fearful of the carseat. The sunshade was manually removed entirely from the rod and the fabric recessed itself into the opening. The rod is intact and in possession. We will not be repairing it due to fear of a repeated injury. This event could easily occur again.
NHTSA complaint #11421963 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Phoenix, AZ
ELECTRICAL SYSTEM
The transmission doesnt know what gear it it in. Code p0705
NHTSA complaint #11758955 — an unverified report by a vehicle owner.
Poughkeepsie, NY
UNKNOWN OR OTHER
on 8/6/26 my wife was driving home when the Sedona Van began emitting white smoke and started making a whining noise. Little did we know the head bolts had pulled out of the engine causing the head gasket to blow and coolant to leak and total engine failure. Safety risk was engine could have seized in the middle of my wife driving home which could have caused a sudden crash. Vehicle was taken to dealership which confirmed total engine failure due to the well-documented engine failures of the 3.3L V6 Lamda - II engines. Dealership stated my VIN # was NOT included in the extended warranty that the NHTSA mandated KIA provide due to this well-documented problem. I was told the extended warranty covered vehicles through 2016 model years, my Sedona is a 2017. Therefore, there was NOTHING they could do. However, this is the SAME issue that has been documented over and over with this engine. But because mine is a 2017 I am being told it is not covered for the total engine replacement by KIA. I was told to call the KIA customer care line which I did. They confirmed my vehicle is NOT covered, but agreed it is the same engine issue that has been seen in the 2013-2016. I was told that I could file a Goodwill case that will be escalated to KIA corporate to see if there is anything they can do to help me. I am now waiting for them to get back to me. I was quoted $13,206 for the engine replacement and likely may need radiator replaced too so probably closer to $15,000 when all done. I am told this is purely mechanical failure and a manufacturer defect. I am waiting for KIA's response but want to file this complaint to see what help is available if they come back and deny covering my engine replacement. simply because it is a 2017. This vehicle has been great so far, has 157,000 well cared for miles until this issue erupted without warning. Dealership said have not seen this on a 2017 Sedona, but it happened, my van is currently dead and will there be more 2017's w/ this issu
NHTSA complaint #11757573 — an unverified report by a vehicle owner.
Poughkeepsie, NY
ENGINE
on 8/6/26 my wife was driving home when the Sedona Van began emitting white smoke and started making a whining noise. Little did we know the head bolts had pulled out of the engine causing the head gasket to blow and coolant to leak and total engine failure. Safety risk was engine could have seized in the middle of my wife driving home which could have caused a sudden crash. Vehicle was taken to dealership which confirmed total engine failure due to the well-documented engine failures of the 3.3L V6 Lamda - II engines. Dealership stated my VIN # was NOT included in the extended warranty that the NHTSA mandated KIA provide due to this well-documented problem. I was told the extended warranty covered vehicles through 2016 model years, my Sedona is a 2017. Therefore, there was NOTHING they could do. However, this is the SAME issue that has been documented over and over with this engine. But because mine is a 2017 I am being told it is not covered for the total engine replacement by KIA. I was told to call the KIA customer care line which I did. They confirmed my vehicle is NOT covered, but agreed it is the same engine issue that has been seen in the 2013-2016. I was told that I could file a Goodwill case that will be escalated to KIA corporate to see if there is anything they can do to help me. I am now waiting for them to get back to me. I was quoted $13,206 for the engine replacement and likely may need radiator replaced too so probably closer to $15,000 when all done. I am told this is purely mechanical failure and a manufacturer defect. I am waiting for KIA's response but want to file this complaint to see what help is available if they come back and deny covering my engine replacement. simply because it is a 2017. This vehicle has been great so far, has 157,000 well cared for miles until this issue erupted without warning. Dealership said have not seen this on a 2017 Sedona, but it happened, my van is currently dead and will there be more 2017's w/ this issu
NHTSA complaint #11757573 — an unverified report by a vehicle owner.
Honolulu, HI
STRUCTURE:BODY
White Pearl paint is flaking/peeling of for no apparent reason.
NHTSA complaint #11743793 — an unverified report by a vehicle owner.
at 146,658 milesProspect, ILFire
ENGINE
The contact owns a 2017 Kia Sedona. The contact stated that while driving at 55 MPH, the contact the oil light illuminated, and the vehicle decelerated independently. The contact mention he pulled over to the right side of the road, exited the vehicle and when he lifted the hood of the vehicle, he noticed flames coming from the engine. No injuries were sustained. No medical attention. There was no police report filed. The fire department did not show at the scene to extinguish the fire. The vehicle was not destroyed. The vehicle is currently still at the scene. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 146,658.
NHTSA complaint #11736979 — an unverified report by a vehicle owner.
Roseville, CA
ENGINE
Same defect on NHTSA (Investigation PE23-019) my vehicle is 1 month outside of the manufacturing date listed, having the same issues, but they will not cover it-even though the same engine is in it. KIA bulletin WTY039 Vehicle is overheating, coolant is bubbling
NHTSA complaint #11731432 — an unverified report by a vehicle owner.
Justin, TX
ELECTRICAL SYSTEM
The sliding door located on the driver's side / left side behind the driver's seat will not close completely which causes an alert/warning to be displayed that the door is still open. The door slides on the track but will not close completely. You must apply pressure as it closes to turn of the warning light.
NHTSA complaint #11731053 — an unverified report by a vehicle owner.
Justin, TX
ENGINE
There was an unusual amount of oil "slug" created by the engine which caused the engine to be inoperable. Therefore, we had to replace the engine.
NHTSA complaint #11731057 — an unverified report by a vehicle owner.
Fountain, CO
ENGINE
My vehicle would not start, after jumping and idling for a few moments, all dash lights started flashing and vehicle wouldnt go into gear. I shut it off as it started making a hum and smelled like something wasnt right. A mobile mechanic who came to my rescue after breaking down did a diagnostic of my engine. I was told I had low to no oil. I asked how was this possible as I had only driven around 2,000 miles since my recent oil change at the KIA dealer ( Wesley Chapel, FL). He said the tech may not have put recommended oil amount or the engine is consuming the oil. I told him I would contact the dealer regarding this matter. Long story, short I broke down to needing a new battery and alternator. I don't know if this was the exact cause of the latter 2 needing to be repaired. However, since speaking to others this is common with some models. I even had 1 individual state there were recalls and engines were being replaced as the engine could potentially lock up or fail. I am not finding a recall. Is this an issue that has been reported and I am missing something. Also, there was a recall on the sliding doors at 1 point. I am still having issues with the drivers side yet tge dealerships want to charge me a diagnostic fee. How do I go about seeing if this is an ongoing issue.
NHTSA complaint #11730765 — an unverified report by a vehicle owner.
Chippewa Falls, WI
ENGINE
137,000 Miles, regular oil changes every 4,000 miles,even adding 2 quarts during the 4,000 miles it would still come up short by 1 quart. Started throwing p0018 timing code,high pressure fuel pump on front blew off the valve cover,Im assuming due to jumping out of timing,as the high pressure pump sits ontop of one of the Camshaft rollers. Engine started knocking and is now useless.
NHTSA complaint #11729795 — an unverified report by a vehicle owner.
Chippewa Falls, WI
FUEL/PROPULSION SYSTEM
137,000 Miles, regular oil changes every 4,000 miles,even adding 2 quarts during the 4,000 miles it would still come up short by 1 quart. Started throwing p0018 timing code,high pressure fuel pump on front blew off the valve cover,Im assuming due to jumping out of timing,as the high pressure pump sits ontop of one of the Camshaft rollers. Engine started knocking and is now useless.
NHTSA complaint #11729795 — an unverified report by a vehicle owner.
Atlanta, GA
ENGINE
Vehicle Information: 2017 Kia Sedona VIN: [XXX] Engine: 3.3L GDI Mileage at failure: 186,000 miles Complaint: I am filing this complaint regarding sudden engine failure in my 2017 Kia Sedona equipped with the 3.3L GDI engine. The vehicle had approximately 186,000 miles at the time of failure and had just undergone a routine oil change prior to the incident. While driving on the highway, a warning light illuminated on the dashboard. Shortly after the warning light appeared, the engine began making a loud knocking sound. The knocking rapidly worsened, indicating internal engine damage. The failure occurred while the vehicle was in motion at highway speed, creating a serious safety risk due to potential loss of power and reduced ability to accelerate or maneuver safely. The vehicle was diagnosed as requiring a full engine replacement. The estimated cost provided was $5,758.05 for the engine, plus an additional $1,800 core charge, not including labor costs. This represents a substantial financial burden. It is my understanding that Kia has prior knowledge of widespread issues involving GDI engines, including premature internal bearing failure and engine seizure in multiple models. Despite this knowledge, the 2017 Kia Sedona with the 3.3L GDI engine has not been adequately addressed. Sudden engine failure at highway speeds poses a significant safety hazard and increases the risk of collision. I am requesting that NHTSA investigate the 3.3L GDI engine used in the 2017 Kia Sedona for potential manufacturing defects related to premature engine failure and internal component damage. Thanks, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11721656 — an unverified report by a vehicle owner.
San Antonio, TX
ENGINE
My husband and I originally bought our White 2017 Kia Sedona LX on 9/12/18 from Hertz automotive sales. Since that time we had had no engine issues. We maintained our brakes, and standard upkeeps on the car. Eight years in and still our car had given us no issues. Our most recent oil change was on 9/13/25 and it was inspected during that oil change and no issues were noted. The car had since that time been driven as expected to school for kids and work for myself and activities on the weekend for family time. There was no weird smells, discolored smoke from the tail piper or anything. The car was running fine. At no time were any warning signals on, flashing or intermittently coming on and off. Then on Thursday, 1/22/26 evening I stopped by the gas station to get gas before turning into my neighborhood for home. Upon leaving the gas station, I noticed and felt the engine seemed off and vibrating with soft tremor like shaking and as I pressed on the gas for power it was soft power, and at that moment only did I see the check engine light on solid (not flashing). I called my husband and a few mins later we made it home, he came out to check the car, and saw now that the engine light was flashing over and over. We read up on what this meant and new we had a problem. We dropped the car off on Saturday to the mechanic and on Monday, 1/26/26 a diagnostic was made and was given the bad news that the engine had complete failure. $18,000 bill to fix all the issues. But here is a short synopsis: Multiple codes found in ECM Metal found in oil, oil is also 1 or more quarts low P0300 (Random misfire), P0302 (CYL #2 misfire), p0304, (CYL#4 misfire) p0306. (CYL#6 misfire) p0175, (bank 2 rich) p0018 (crank - cam correlation) Engine has internal failure, failing piston rings allowing oil in combustion chamber, causing misfire, rich condition and engine shaking This was a shock and we had to sell it for nothing to a salvage company.
NHTSA complaint #11716567 — an unverified report by a vehicle owner.
Middlebury, VT
POWER TRAIN
My 2017 Kia Sedona has has regular oil changes about every 3000 miles. I was not due for an oil change quite yet and a ticking noise coming from the engine started to occur. I made an appointment at the Kia dealership right away. Just a few days before my appointment there was no warning light for the oil or engine until the engine failed, went limp and I lost power steering control, the brakes went stiff and all of the lights came on at once. It was very scary for me and my two children to lose that control of the vehicle. It can be inspected at Berlin City Kia where it currently sits and is in need of a replacement engine. After much research I have seen that this is a known issue for Kia engines and for some reason the 2017 Sedona is not included in any extended warranty's. Please investigate this. I did ask Kia for help in covering the replacement engine but was denied by the woman who I spoke to on the phone. I still put in a claim online anyway. It has been inspected by Berlin City Kia and they said there was "significant rod knocking". They are quoting me $9880 to replace the engine. After regular oil changes for the time that I have owned this vehicle and especially after I has the oil pressure sensor leak addressed as well over the last few years, it should not have died prematurely as it did. I am worried that the oil leaking so badly at that time may have pooled in the back of the engine which could have led to the rods wearing which in turn led to them knocking in the future. What else could cause this to happen? And so many other customers have complained about this exact issue. Please investigate this.
NHTSA complaint #11713242 — an unverified report by a vehicle owner.
Waukesha, WI
ENGINE
Engine with around 107K miles has had regular maintenance done to it. Went out one morning to start my van and there was a knocking noise coming from under the hood. We then had it towed to an engine/transmission repair shop to have it looked at and was told that we needed a new/used engine and the price was thru the roof. this is a very trusted shop so took there advice. To have the engine replaced is going to cost more than what the vehicle is worth. This is a known issue with some kia engines as they with no signs of failure prior to the noise. We had not one warning light on the dash, it just went poof.
NHTSA complaint #11710621 — an unverified report by a vehicle owner.
at 106,000 milesRaytown, MOFire
ENGINE
The contact owned a 2017 Kia Sedona. The contact stated that after parking in his driveway, there was white smoke coming from the front of the vehicle. The contact is handicapped and was assisted by his wife to exit the vehicle safely. The vehicle later caught on fire, and flames were visible in the front passenger side that spread to the rear of the vehicle. No warning lights illuminated before or after the failure. The contact stated that the front of the house was damaged, as well as the garage siding, along with an older truck parked in the driveway. The fire was extinguished by the fire department with water, and a police officer was on scene and tried to extinguish the rear with an extinguisher, but was unsuccessful. There was a fire report filed. The vehicle was towed a week after the fire to the insurance tow lot. The vehicle was deemed destroyed by the insurance company. No injuries were sustained. The manufacturer was notified of the failure. The failure mileage was 106,000.
NHTSA complaint #11707879 — an unverified report by a vehicle owner.
Forked River, NJ
ENGINE
Excessive oil consumption
NHTSA complaint #11705212 — an unverified report by a vehicle owner.
Richmond, TX
ENGINE
Oil Control valve failed and oil leaking
NHTSA complaint #11694305 — an unverified report by a vehicle owner.
Flowery Branch, GA
ENGINE
Burning through oil faster than it should, needing to feel up oil every week, has been confirmed by an auto repair shop.⁸
NHTSA complaint #11687085 — an unverified report by a vehicle owner.
Albemarle, NC
SEATS
seats break easily and dont lock in place as well as control modulae harness from door to rear tail lights burn up
NHTSA complaint #11686395 — an unverified report by a vehicle owner.
Albemarle, NC
ELECTRICAL SYSTEM
seats break easily and dont lock in place as well as control modulae harness from door to rear tail lights burn up
NHTSA complaint #11686395 — an unverified report by a vehicle owner.
Fort Worth, TX
ENGINE
On [XXX], while driving my 2017 Kia Sedona on a road trip through Killeen, Texas, the engine suddenly began making a loud knocking noise without any prior warning, leading to catastrophic engine failure and complete loss of motive power. The vehicle became inoperable and was towed to University Kia in Waco, Texas. The day prior, on [XXX], the vehicle underwent a thorough pre-trip inspection and full synthetic oil change at Sun Auto Tire & Service (5117 Golden Triangle Blvd., Keller, TX 76244), confirming it was roadworthy with no issues detected initially, though oil was found leaking afterward (maintenance records attached). University Kia confirmed the catastrophic engine failure, likely related to the 3.3L Lambda engine's known oil pressure switch (OPS) defects, as the OPS had been previously replaced under warranty. Kia Motors America (Case [XXX]) denied liability unless I pay $3,000 for a teardown inspection to prove the failure was due to the OPS, despite the vehicle's eligibility under the WTY026 extended warranty (15 years/150,000 miles). This failure aligns with similar complaints and NHTSA investigations into 3.3L Lambda engine issues, such as oil starvation and sudden seizures. Due to the failure, we missed a prepaid hotel stay in San Antonio, incurred additional hotel stay charges as our trip had to be extended, and incurred costs for a rental vehicle to complete the trip. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11685326 — an unverified report by a vehicle owner.
Lake Stevens, WA
ENGINE
I was driving and my engine seized and my car is now undrivable. I immediately looked up recalls and see that there were several recalls and recalls surrounding the engine as well. I am told I now need a brand new engine and was referred to file a report as the issue experienced should not have been happening.
NHTSA complaint #11678952 — an unverified report by a vehicle owner.
Snellville, GA
ENGINE
Engine stared clattering at the end of a 2 hour drive home. Engine died entering a round about 1-1/2 miles from home. It restarted and limped to my home. Arranged to have it towed to mechanic shop. They informed me there is issues with rod bearings and that Kia has a class action suite but Kia is telling me that my vin is not involved.
NHTSA complaint #11678706 — an unverified report by a vehicle owner.
Yauco, PR
UNKNOWN OR OTHER
The Sedona is showing paint damage on the rear trunk door. The unit is white. It is starting to flake where the glass ends.
NHTSA complaint #11676139 — an unverified report by a vehicle owner.