FaultScore report
Owners have filed 15 complaints about the 1994 Toyota 4RUNNER with NHTSA between 2006 and 2021. The largest single group is the engine & cooling. Across this model's run it ranks 30 of 34 worst.
FaultScore 32/100
Higher is worse. Measured against the other years of the Toyota 4RUNNER.
How this is worked out15
Complaints
4
Crashes reported
1
Fires reported
3
Injuries reported
155,000 mi
Median mileage at failure
Half of reported failures happened before this
0%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
1 crashes, 1 fires · median 108,500 mi
2 crashes, 0 fires · median 83,000 mi
1 crashes, 0 fires · median 157,500 mi
Median failure at 291,000 miles
Median failure at 155,000 miles
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.
REAR SEAT BELT ROUTING
CORRODED BRAKE LINES
TOYOTA IS CONDUCTING A SAFETY RECALL IN CANADA 98-253. CORRODED BRAKE LINES COULD FAIL RESULTING IN A PARTIAL BRAK SYSTEM LOSS AND INCREASED STOPPING DISTANCES
A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.
Canada runs its own recall programme, and its campaigns do not always mirror the American ones.
Steering
On certain vehicles, if the steering wheel is repeatedly turned under conditions where high steering effort and power assist are required, for instance, when fully turning the wheel while the vehicle is stopped, a fatigue crack may develop in the steering relay rod. Correction: Dealers will replace the steering relay rod.
Structure
Owners of affected vehicles operated in severe/high road salt use areas of Ontario, Quebec and the Atlantic provinces will receive a Toyota advisory letter. This letter will include a free-of-charge vehicle undercarriage wash and inspection. Subsequently, owners will be advised of any services, if applicable.
Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.
Reports where the owner recorded a crash, a fire, an injury or a death.
UNKNOWN OR OTHER
MY VEHICLE WAS IN A ACCIDENT ON THE PASSENGER QUARTER PANEL THE DAMAGE CAUSED A ELECTRICAL OUTAGE TO ALL THE BLINKERS ON THE PASSENGER SIDE AND BOTH MY PASSENGER SIDE DOOR LOCK ACTUATORS THEY LOCKED UP AND STOPPED WORKING AFTER THE ACCIDENT. WITH THE DOOR LOCK ACTUATORS NOT WORKING MADE MY VEHICLE UNSAFE ON THE PASSENGER SIDE.
NHTSA complaint #11414343 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1994 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HEARD A POPPING SOUND FROM UNDER THE VEHICLE AND NOTICED AN ABNORMAL ODOR OF OIL. THE CONTACT STOPPED THE VEHICLE AND UPON EXITING, NOTICED A FLAME UNDER THE FRONT DRIVER SIDE. THE FIRE DEPARTMENT WAS CALLED AND REPORTED TO THE SCENE. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #10452644 — an unverified report by a vehicle owner.
STEERING:LINKAGES:ROD:RELAY:CONNECTING
MY WIFE WAS DRIVING HOME FROM WORK AT ABOUT 8:00 AM AND THE SUV SLID TO THE LEFT ON ICE, SHE THEN TURNED TO THE RIGHT AND THE STEERING WOULDN'T STRAIGHTEN UP AND AS A RESULT SHE WENT DOWN AN INBANKMENT AND THE SUV ROLLED ALL THE WAY OVER AND BACK ON ITS WHEELS. THE VEHICLE SINCE HAS BEEN TOTALED AND PARTED OUT BUT I'M THINKING THIS RECALL MAY HAVE CAUSED THE ACCIDENT.
NHTSA complaint #10172146 — an unverified report by a vehicle owner.
STEERING
1994 4 RUNNER 4 WD STEERING CONTROL LOCKED UP WHILE DRIVING. VEHICLE LOST ALL POWER. *TS ***NAR*** THE CONSUMERS WIFE LOST CONTROL OF THE VEHICLE AND SUBSEQUENTLY THE VEHICLE ROLLED OVER AN EMBANKMENT INTO A STREAM. THE VEHICLE WAS DEEMED TOTALED.
NHTSA complaint #10171200 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
1994 4 RUNNER 4 WD STEERING CONTROL LOCKED UP WHILE DRIVING. VEHICLE LOST ALL POWER. *TS ***NAR*** THE CONSUMERS WIFE LOST CONTROL OF THE VEHICLE AND SUBSEQUENTLY THE VEHICLE ROLLED OVER AN EMBANKMENT INTO A STREAM. THE VEHICLE WAS DEEMED TOTALED.
NHTSA complaint #10171200 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
UNKNOWN OR OTHER
MY VEHICLE WAS IN A ACCIDENT ON THE PASSENGER QUARTER PANEL THE DAMAGE CAUSED A ELECTRICAL OUTAGE TO ALL THE BLINKERS ON THE PASSENGER SIDE AND BOTH MY PASSENGER SIDE DOOR LOCK ACTUATORS THEY LOCKED UP AND STOPPED WORKING AFTER THE ACCIDENT. WITH THE DOOR LOCK ACTUATORS NOT WORKING MADE MY VEHICLE UNSAFE ON THE PASSENGER SIDE.
NHTSA complaint #11414343 — an unverified report by a vehicle owner.
POWER TRAIN
A COUPLE OF YEARS AFTER PURCHASING THIS TOYOTA 4-RUNNER THERE WAS A RECALL DUE TO FAULTY HEAD GASKETS. THEY LEAKED. A RECALL WAS (SUPPOSEDLY) DONE. 100,000 MILES LATER THE SAME PROBLEM HAD TO BE FIXED AGAIN. I CONTACTED TOYOTA AND WAS INFORMED THAT THEY WERE ONLY RESPONSIBLE FOR ONE FIX. THAT WOULD BE NICE IF THEY HAD ACTUALLY FIXED IT. A (FIX) IMPLIES THAT IT HAS BEEN REALLY FIXED. HEAD GASKETS ARE NOT SUPPOSED TO LEAK . . . EVER! SO I AM WONDERING OF THEY REALLY ACCOMPLISHED A FIX THE FIRST TIME. OBVIOUSLY NOT SINCE IT COST ME $2000 TO GET IT FIXED AGAIN FOR THE EXACT SAME PROBLEM. IF THEY DID ATTEMPT A FIX THEY CERTAINLY MUST HAVE USED INFERIOR OF DEFECTIVE PARTS SINCE THE SAME PROBLEM NEEDED TO BE FIXED AGAIN. I THINK THERE OUGHT TO BE A LAW THAT IF A RECALL (FIX) FAILS AND NEED TO BE DONE OVER THE MANUFACTURER SHOULD BE LIABLE FOR THE REDO. THANK YOU
NHTSA complaint #10507426 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
A COUPLE OF YEARS AFTER PURCHASING THIS TOYOTA 4-RUNNER THERE WAS A RECALL DUE TO FAULTY HEAD GASKETS. THEY LEAKED. A RECALL WAS (SUPPOSEDLY) DONE. 100,000 MILES LATER THE SAME PROBLEM HAD TO BE FIXED AGAIN. I CONTACTED TOYOTA AND WAS INFORMED THAT THEY WERE ONLY RESPONSIBLE FOR ONE FIX. THAT WOULD BE NICE IF THEY HAD ACTUALLY FIXED IT. A (FIX) IMPLIES THAT IT HAS BEEN REALLY FIXED. HEAD GASKETS ARE NOT SUPPOSED TO LEAK . . . EVER! SO I AM WONDERING OF THEY REALLY ACCOMPLISHED A FIX THE FIRST TIME. OBVIOUSLY NOT SINCE IT COST ME $2000 TO GET IT FIXED AGAIN FOR THE EXACT SAME PROBLEM. IF THEY DID ATTEMPT A FIX THEY CERTAINLY MUST HAVE USED INFERIOR OF DEFECTIVE PARTS SINCE THE SAME PROBLEM NEEDED TO BE FIXED AGAIN. I THINK THERE OUGHT TO BE A LAW THAT IF A RECALL (FIX) FAILS AND NEED TO BE DONE OVER THE MANUFACTURER SHOULD BE LIABLE FOR THE REDO. THANK YOU
NHTSA complaint #10507426 — an unverified report by a vehicle owner.
ENGINE
A COUPLE OF YEARS AFTER PURCHASING THIS TOYOTA 4-RUNNER THERE WAS A RECALL DUE TO FAULTY HEAD GASKETS. THEY LEAKED. A RECALL WAS (SUPPOSEDLY) DONE. 100,000 MILES LATER THE SAME PROBLEM HAD TO BE FIXED AGAIN. I CONTACTED TOYOTA AND WAS INFORMED THAT THEY WERE ONLY RESPONSIBLE FOR ONE FIX. THAT WOULD BE NICE IF THEY HAD ACTUALLY FIXED IT. A (FIX) IMPLIES THAT IT HAS BEEN REALLY FIXED. HEAD GASKETS ARE NOT SUPPOSED TO LEAK . . . EVER! SO I AM WONDERING OF THEY REALLY ACCOMPLISHED A FIX THE FIRST TIME. OBVIOUSLY NOT SINCE IT COST ME $2000 TO GET IT FIXED AGAIN FOR THE EXACT SAME PROBLEM. IF THEY DID ATTEMPT A FIX THEY CERTAINLY MUST HAVE USED INFERIOR OF DEFECTIVE PARTS SINCE THE SAME PROBLEM NEEDED TO BE FIXED AGAIN. I THINK THERE OUGHT TO BE A LAW THAT IF A RECALL (FIX) FAILS AND NEED TO BE DONE OVER THE MANUFACTURER SHOULD BE LIABLE FOR THE REDO. THANK YOU
NHTSA complaint #10507426 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1994 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HEARD A POPPING SOUND FROM UNDER THE VEHICLE AND NOTICED AN ABNORMAL ODOR OF OIL. THE CONTACT STOPPED THE VEHICLE AND UPON EXITING, NOTICED A FLAME UNDER THE FRONT DRIVER SIDE. THE FIRE DEPARTMENT WAS CALLED AND REPORTED TO THE SCENE. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA complaint #10452644 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS
TL*THE CONTACT OWNS A 1994 TOYOTA 4RUNNER . THE CONTACT NOTICED THAT THE FRAME WAS RUSTED, WHICH HAS CAUSED THE CONTROL ARM TO FALL OFF. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED AND THE VEHICLE WAS NOT REPAIRED OR INSPECTED. THE CURRENT AND FAILURE MILEAGES WERE 291,000.
NHTSA complaint #10381001 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
THIS IS A FAILURE THAT HAS NO EVENTS LEADING UP TO IT . I OWN A 1994 TOYOTA 4 RUNNER WITH 4 WHEEL DRIVE. THE HARMONIC BALANCER HAS BROKEN MORE THAN 3 TIMES ON THIS VEHICLE. IT SEEMS THAT THE KEY THAT FITS INTO THE SLOT ON THE CRANK SHAFT IS TOO SHORT. THE KEY THAT FITS INTO THE SLOT ALSO KEEPS THE HARMONIC BALANCER IN PLACE AS IT ALSO HAS A SLOT FOR THE KEY TO FIT INTO. WHEN THIS HAPPENS IT IS SUDDEN AND GIVES YOU LITTLE OR NO TIME TO REACT. ALL OF THE INSTRUMENT LIGHTS COME ON AT ONCE AND THE STEERING AND BRAKES FAIL CAUSING LOSS OF CONTROL. I HAVE SPOKEN WITH DOZENS OF MECHANICS AND TOYOTA OWNERS AND THEY ALL SAY THIS IS A COMMON PROBLEM WITH THIS VEHICLE. THIS IS NOT ONLY A SAFETY HAZARD BUT ALSO A COSTLY REPAIR. THIS HAPPENED TO MY CAR AGAIN FOR THE FOURTH TIME RECENTLY.
NHTSA complaint #10324604 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
ENGINE BLOWN HEAD GASKET CAUSED WATER TO LEAK INTO ENGINE CAUSING ENGINE FAILURE. TOYOTA REPAIRED UNDER RECALL SEVERAL YEARS AGO. NOW THE SAME PROBLEM OCCURRED AND NOW IT WILL COST ME $1,900.00 TO REPAIR THEIR POOR QUALITY, OR CRAFTSMANSHIP. WHY CAN'T WE GET TOYOTA TO WARRANTY THIS PROBLEM FOR THE LIFE OF THE CAR. I HAVE READ HUNDREDS OF POSTS REGARDING THIS MATTER, AND WE CANNOT GET FAIR RESULTS FROM ANYONE. MY FRIEND HAD TOYOTA OFFER HIM $500.00 TOWARDS THE PURCHASE OF A NEW TOYOTA, PRETTY FUNNY OFFER.
NHTSA complaint #10318293 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
BLOWN HEAD GASKET ON 1994 TOYATA 4RUNNER. 98K ON ENGINE.
NHTSA complaint #10268929 — an unverified report by a vehicle owner.
WHEELS
I BOUGHT 1994 TOYOTA 4RUNNER USED. THE OUTFIT NEEDED NEW TIRES WHEN I TRIED TO REMOVER THE WHEELS I COULD NOT GET THEM OFF THE VEHICLE AFTER ALOT OF WORK THEY FINALLY CAME OFF. WHEN I REINSTALLED THEM I USED ANTI-SEIZE AND HOPE TO NEVER HAVE THIS PROBLEM AGAIN.
NHTSA complaint #10242738 — an unverified report by a vehicle owner.
STEERING:COLUMN
TL* - THE CONTACT OWNS A 1994 TOYOTA FORERUNNER. THE CONTACT STATED THAT WHEN HE TRIED TO MAKE A TURN OR STEER THE VEHICLE IT WOULD NOT WORK. THE CONTACT HAD THE STEERING COLUMN FIXED. THE STEERING COLUMN PROBLEM WAS CONSISTENT AND KEPT GETTING WORSE. THE CURRENT AND FAILURE MILEAGE WERE BOTH 83000.
NHTSA complaint #10183174 — an unverified report by a vehicle owner.
STEERING:LINKAGES:ROD:RELAY:CONNECTING
MY WIFE WAS DRIVING HOME FROM WORK AT ABOUT 8:00 AM AND THE SUV SLID TO THE LEFT ON ICE, SHE THEN TURNED TO THE RIGHT AND THE STEERING WOULDN'T STRAIGHTEN UP AND AS A RESULT SHE WENT DOWN AN INBANKMENT AND THE SUV ROLLED ALL THE WAY OVER AND BACK ON ITS WHEELS. THE VEHICLE SINCE HAS BEEN TOTALED AND PARTED OUT BUT I'M THINKING THIS RECALL MAY HAVE CAUSED THE ACCIDENT.
NHTSA complaint #10172146 — an unverified report by a vehicle owner.
STEERING
1994 4 RUNNER 4 WD STEERING CONTROL LOCKED UP WHILE DRIVING. VEHICLE LOST ALL POWER. *TS ***NAR*** THE CONSUMERS WIFE LOST CONTROL OF THE VEHICLE AND SUBSEQUENTLY THE VEHICLE ROLLED OVER AN EMBANKMENT INTO A STREAM. THE VEHICLE WAS DEEMED TOTALED.
NHTSA complaint #10171200 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
1994 4 RUNNER 4 WD STEERING CONTROL LOCKED UP WHILE DRIVING. VEHICLE LOST ALL POWER. *TS ***NAR*** THE CONSUMERS WIFE LOST CONTROL OF THE VEHICLE AND SUBSEQUENTLY THE VEHICLE ROLLED OVER AN EMBANKMENT INTO A STREAM. THE VEHICLE WAS DEEMED TOTALED.
NHTSA complaint #10171200 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
I OWN A 94 TOYOTA 4RUNNER AND A 94 TOYOTA SR5 PICKUP TRUCK. BACK IN '98 I RECEIVED A RECALL NOTICE I BROUGHT BOTH MY VEHICLES TO FRED ANDERSON TOYOTA IN RESPONSE TO THE RECALL. THEY REPLACED THE HEAD GASKETS ON BOTH VEHICLES. RECALL NOTICE: A 3VZ-E HEAD GASKET REPLACEMENT JUNE 26, 1998 VEHICLE: TOYOTA TRUCK 4X4MILEAGE: 46,623 JULY 17, 1998 VEHICLE: TOYOTA 4RUNNERMILEAGE: 38,037 THE BEGINNING OF FEBRUARY 2006 OF THIS YEAR, MY TOYOTA PICKUP TRUCK BLEW A HEAD GASKET WHEN I CRANKED IT UP ONE AFTERNOON. DENSE SMOKE AND RADIATOR FLUID FLOWED FROM THE TAILPIPE AND THE ENGINE WAS VIBRATING.LESS THAN 12 HOURS AFTER THE HEAD GASKET BLEW IN MY PICKUP TRUCK, THE VERY NEXT MORNING I STARTED MY WIFE'S 4RUNNER TO MAKE A TRIP INTO TOWN. IMMEDIATELY WHEN I STARTED IT, DENSE SMOKE AND RADIATOR FLUID FLOWED FROM THE TAILPIPE AND THE ENGINE WAS VIBRATING EVEN WORST THAN BEFORE. I IMMEDIATELY TURN THE TRUCK OFF. TOYOTA OPENED A CASE# 200602060829. I WAS TOLD THEY WOULD CALL CHAN COLEMAN AT SANFORD TOYOTA AND TRY TO GET A SPECIAL PRICE. I CALLED CHAN AND WAS TOLD I WOULD NEED TO SPEAK WITH SOMEONE IN HIS SERVICE DEPARTMENT. HE TRANSFERRED ME TO SERVICE AND WAS QUOTED A PRICE OF $1,600 PER VEHICLE TO REPAIR. I HAD BOTH VEHICLES TOWED AND REPAIRED BY A LOCAL REPAIR SHOP. BELOW ARE THE DATES AND MILEAGE FOR THE REPAIRS. FEBRUARY 16, 2006 VEHICLE: TOYOTA TRUCK 4X4 MILEAGE: 120,000 FEBRUARY 4, 2006 VEHICLE: TOYOTA 4RUNNER MILEAGE: 102,000 I WAS TOLD BY THE MECHANIC AT THE LOCAL REPAIR SHOP THAT THE REASON THE HEAD GASKETS WERE BLOWING WAS BECAUSE OF A CASTING DESIGN FLAW WITH THE ENGINE HEADS AND NOT THE HEAD GASKETS. THE HEADS HAD DIMPLES WHICH OVER TIME WOULD CAUSE THE HEAD GASKET TO BLOW. THE HEADS ON BOTH MY VEHICLES HAD TO BE RESURFACED TO REMOVE THE DIMPLES. I CALLED TOYOTA WITH THIS INFORMATION BUT WAS TOLD THEY SHOW BOTH MY VEHICLES WERE FIXED IN ACCORDANCE TO THE RECALL AND IT IS A ONE TIME FIX ONLY AND THE OWNER NEEDS TO TAKE RESPONSIBILITY AT SOME POINT.
NHTSA complaint #10157000 — an unverified report by a vehicle owner.