2009 Toyota 4RUNNER problems

STRUCTURE:FRAME AND MEMBERS

The contact owns a 2009 Toyota 4Runner. The contact stated while pulling out of a driveway, the contact observed a grinding noise coming from the front end of the vehicle and the steering wheel violently yanked to the right. Additionally, the contact stated that when the brake pedal was depressed, the vehicle pulled to the left inadvertently. The vehicle was stopped and inspected. The contact observed that the front passenger’s side tire was dangling by the rocker arm and the subframe. The vehicle was taken to the residence. The vehicle was then towed to an independent mechanic where it was diagnosed that the front passenger’s side subframe and the rocker arms needed to be replaced due to extreme corrosion. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 114,000.

NHTSA complaint #11594145 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

On 4/8/22, the rear window of our 2009 Toyota 4runner just shattered and fell apart for no reason. We took it to get replaced at Safelite on 4/13/22 and one of their techs asked if we knew what caused the glass to break and we told him we had no idea. We told him it just broke out of nowhere from some strange reason, and he told us that it looks like the window breaking was caused by the overheating of the rear defroster and that it was a common issue with 2009 4runners. We were in shock to find this out and are grateful that our son or dog was not in the back seat when this happened. I found out online that Toyota issued a recall for this issue (Warranty Program ZG7) and I spoke with a Toyota customer service rep to see if we could be reimbursed the $100 we paid out of pocket for this manufacturer's defect and they said the warranty program ended in 2018 so they couldn't help us. We were very disappointed to be told this because this is obviously still happening with these 4runners and it's a major safety issue as well.

NHTSA complaint #11461419 — an unverified report by a vehicle owner.

STEERING

STEERING WAS VERY HARD TO DO AND REALLY JERKY.TOOK IT TO DEALERSHIP AND WAS TOLD THAT THE RACK AND PIN NEEDED TO BE COMPLETELY CORRODED AND NEEDED TO BE REPLACED. YET ANOTHER PART I HAVE TO EAT THE COST DUE TO CORROSION. I HAVE READ MULTIPLE COMPLAINTS ABOUT THE SAME PROBLEMS. WHY IS NOTHING BEING DONE?

NHTSA complaint #11153258 — an unverified report by a vehicle owner.

POWER TRAIN

EXCESSIVE RUST ON FRAME WITH JEOPARDIZED INTEGRITY AT JOINS CONNECTING BRAKES, FUEL LINES AND SUSPENSIONS SYSTEM.

NHTSA complaint #10985534 — an unverified report by a vehicle owner.

SUSPENSION

EXCESSIVE RUST ON FRAME WITH JEOPARDIZED INTEGRITY AT JOINS CONNECTING BRAKES, FUEL LINES AND SUSPENSIONS SYSTEM.

NHTSA complaint #10985534 — an unverified report by a vehicle owner.

STRUCTURE:BODY

EXCESSIVE RUST ON FRAME WITH JEOPARDIZED INTEGRITY AT JOINS CONNECTING BRAKES, FUEL LINES AND SUSPENSIONS SYSTEM.

NHTSA complaint #10985534 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

UPON ACCELERATION, THE VEHICLE HESITATES FOR 2-3 SECONDS. THIS HAPPENS ON STARTING OFF, DRIVING DOWN THE ROAD, PULLING INTO TRAFFIC. I HAVE HAD IT TO THE DEALER 15-20 TIMES AND THEY CAN'T FIND THE CAUSE. THEY SAID IT HAD TO FAIL FOR AT LEAST 5 SECONDS FOR IT TO REGISTER ON THE COMPUTER MODULE. IT NEVER LASTS MORE THAN 2-3 SECONDS AND, I CONSIDER IT 'VERY DANGEROUS'. DATES ABOVE ARE APPX. IT DOES IT EVERY DAY.

NHTSA complaint #10631983 — an unverified report by a vehicle owner.

ENGINE

UPON ACCELERATION, THE VEHICLE HESITATES FOR 2-3 SECONDS. THIS HAPPENS ON STARTING OFF, DRIVING DOWN THE ROAD, PULLING INTO TRAFFIC. I HAVE HAD IT TO THE DEALER 15-20 TIMES AND THEY CAN'T FIND THE CAUSE. THEY SAID IT HAD TO FAIL FOR AT LEAST 5 SECONDS FOR IT TO REGISTER ON THE COMPUTER MODULE. IT NEVER LASTS MORE THAN 2-3 SECONDS AND, I CONSIDER IT 'VERY DANGEROUS'. DATES ABOVE ARE APPX. IT DOES IT EVERY DAY.

NHTSA complaint #10631983 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

DRIVING ALONG A TWO LANE U.S. HIGHWAY AT THE POSTED SPEED, I NOTICED THAT MY FUEL GAUGE WAS SHOWING FULLY EMPTY, AND THE WARNING LIGHT WAS FLASHING. PUSHING THE ODOMETER TRIP BUTTON, I NOTICED THAT I HAD NOT YET REACHED THE MILEAGE FOR A "NORMAL" FILL UP, WHERE I ROUTINELY GET 20-21 MPG. AT THE END OF THAT TRIP,WHEN I TURNED THE VEHICLE OFF AND RESTARTED IT, THE FUEL GAUGE SHOWED HALF FULL. USING THE TRIP ODOMETER, I DROVE AN ADDITIONAL ESTIMATED 30 MILES TO HOME. THE FUEL GAUGE CONTINUED TO DISPLAY HALF FULL. THE NEXT MORNING, I DROVE APPROXIMATELY 3 MILES TO THE GAS STATION, AND WAS SURPRISED WHEN IT TOOK ALMOST 15 GALLONS TO FILL THE TANK. THE NEEDLE ON THE GAUGE THEN WENT TO FULL. SINCE THEN IT HAS ONLY COME DOWN TO ONE HALF, YET MY MILEAGE NOW IS AT THE POINT (261-270) WHERE I NORMALLY FILL UP WHEN THE NEEDLE NEAR THE EMPTY LINE. I BELIEVE THIS PROBLEM IS NO DOUBT WIDESPREAD.

NHTSA complaint #10594345 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

TL* THE CONTACT OWNS A 2009 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS AND TURNING, THE VEHICLE LOST ACCELERATING POWER. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 24,000. UPDATED 03/21/13*LJ THE CONSUMER STATED THE TRANSMISSION SLIPPED (REVVED TO HIGH RPMS) WHILE ATTEMPTING TO ACCELERATE AFTER SLOWING DOWN BELOW 15 MPH (WHILE MAKING TURNS OR SLOWING FOR TRAFFIC). THIS HAS CAUSED DANGEROUS SITUATIONS WHERE SIGNIFICANT LAG TIME BETWEEN DEPRESSING THE GAS PEDAL AND WHEN THE TRANSMISSION ENGAGED WHILE MAKING A LEFT TURN ACROSS ONCOMING TRAFFIC OR WHEN A QUICK ACCELERATION WAS NEEDED AFTER SLOWING DOWN. THE POTENTIAL FOR AN ACCIDENT IS HIGH. TOYOTA SHOULD ADDRESS THE SITUATION BEFORE SOMEONE GETS INTO A SERIOUS ACCIDENT AS SEVERAL OTHER REPORTS OF THIS CONDITION HAVE BEEN REPORTED. THERE ARE A NUMBER OF COMPLAINTS ON THE INTERNET WITH THE SAME PROBLEM.

NHTSA complaint #10500520 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

2009 4RUNNER TRANSMISSION SLIPS (REVS TO HIGH RPMS) WHILE ATTEMPTING TO ACCELERATE AFTER SLOWING BELOW 15 MPH (WHILE MAKING TURNS OR SLOWING FOR TRAFFIC). THIS HAS CAUSED DANGEROUS SITUATIONS WHERE A SIGNIFICANT LAG TIME BETWEEN DEPRESSING THE GAS PEDAL AND WHEN THE TRANSMISSION ENGAGES WHILE MAKING A LEFT HAND TURN ACROSS ON COMING TRAFFIC OR WHEN A QUICK ACCELERATION IS NEEDED AFTER SLOWING. THE POTENTIAL FOR AN ACCIDENT IS HIGH. TOYOTA SHOULD ADDRESS THIS SITUATION BEFORE SOMEONE GETS INTO A SERIOUS ACCIDENT AS SEVERAL OTHER REPORTS OF THIS CONDITION HAVE BEEN REPORTED.

NHTSA complaint #10383941 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

I PURCHASED MY 2009 4RUNNER NEW LAST YEAR. FROM THE MINUTE I DROVE IT OFF THE LOT I NOTICED A PROBLEM WITH THE TRANSMISSION. ANY TIME THE VEHICLE SLOWS BELOW 15MPH AND THEN THE ACCELERATOR IS DEPRESSED, THE ENGINE REVS TO A HIGH RPM AS IF SEARCHING FOR A GEAR AND DOES NOT ACCELERATE AS COMMANDED. THIS IS VERY PREVALENT IN SLOW TRAFFIC, SLOWING FOR A YIELD SIGN OR TURNING CORNERS. THE BIGGEST SAFETY CONCERN IS IN SLIPPERY ROAD CONDITIONS. WHEN THE VEHICLE FINALLY DOES FIND A GEAR TO SHIFT INTO, IT LURCHES FORWARD. THE SHIFTING INTO GEAR FROM A HIGH RPM ON SLICK SURFACES COULD CAUSE THE WHEELS TO SPIN OUT. I ALMOST EXPERIENCED A LOSS OF CONTROL OF THE VEHICLE BECAUSE OF THIS. I'VE BROUGHT IT IN TO GET REPAIRED AT THE DEALERSHIP TWICE. ALL THEY DO IS FLASH THE ECM AND THE PROBLEM PERSISTS. MOST IMPORTANTLY, TOYOTA HAS ACKNOWLEDGED THIS EXACT SAME PROBLEM ON THE 2010 MODEL BY ISSUING A TSB. (TSB-0166-10) FROM READING SEVERAL TOYOTA 4RUNNER FORUMS, THIS TSB FIXES THE PROBLEM. PLEASE PUT PRESSURE ON TOYOTA TO ISSUE A FIX FOR THE 2009 MODEL BEFORE SOMEONE GETS INJURED OR KILLED.

NHTSA complaint #10373627 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

I PURCHASED MY 2009 4RUNNER NEW LAST YEAR. FROM THE MINUTE I DROVE IT OFF THE LOT I NOTICED A PROBLEM WITH THE TRANSMISSION. ANY TIME THE VEHICLE SLOWS BELOW 15MPH AND THEN THE ACCELERATOR IS DEPRESSED, THE ENGINE REVS TO A HIGH RPM AS IF SEARCHING FOR A GEAR AND DOES NOT ACCELERATE AS COMMANDED. THIS IS VERY PREVALENT IN SLOW TRAFFIC, SLOWING FOR A YIELD SIGN OR TURNING CORNERS. THE BIGGEST SAFETY CONCERN IS IN SLIPPERY ROAD CONDITIONS. WHEN THE VEHICLE FINALLY DOES FIND A GEAR TO SHIFT INTO, IT LURCHES FORWARD. THE SHIFTING INTO GEAR FROM A HIGH RPM ON SLICK SURFACES COULD CAUSE THE WHEELS TO SPIN OUT. I ALMOST EXPERIENCED A LOSS OF CONTROL OF THE VEHICLE BECAUSE OF THIS. I'VE BROUGHT IT IN TO GET REPAIRED AT THE DEALERSHIP TWICE. ALL THEY DO IS FLASH THE ECM AND THE PROBLEM PERSISTS. MOST IMPORTANTLY, TOYOTA HAS ACKNOWLEDGED THIS EXACT SAME PROBLEM ON THE 2010 MODEL BY ISSUING A TSB. (TSB-0166-10) FROM READING SEVERAL TOYOTA 4RUNNER FORUMS, THIS TSB FIXES THE PROBLEM. PLEASE PUT PRESSURE ON TOYOTA TO ISSUE A FIX FOR THE 2009 MODEL BEFORE SOMEONE GETS INJURED OR KILLED.

NHTSA complaint #10373627 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I PURCHASED MY 2009 4RUNNER NEW LAST YEAR. FROM THE MINUTE I DROVE IT OFF THE LOT I NOTICED A PROBLEM WITH THE TRANSMISSION. ANY TIME THE VEHICLE SLOWS BELOW 15MPH AND THEN THE ACCELERATOR IS DEPRESSED, THE ENGINE REVS TO A HIGH RPM AS IF SEARCHING FOR A GEAR AND DOES NOT ACCELERATE AS COMMANDED. THIS IS VERY PREVALENT IN SLOW TRAFFIC, SLOWING FOR A YIELD SIGN OR TURNING CORNERS. THE BIGGEST SAFETY CONCERN IS IN SLIPPERY ROAD CONDITIONS. WHEN THE VEHICLE FINALLY DOES FIND A GEAR TO SHIFT INTO, IT LURCHES FORWARD. THE SHIFTING INTO GEAR FROM A HIGH RPM ON SLICK SURFACES COULD CAUSE THE WHEELS TO SPIN OUT. I ALMOST EXPERIENCED A LOSS OF CONTROL OF THE VEHICLE BECAUSE OF THIS. I'VE BROUGHT IT IN TO GET REPAIRED AT THE DEALERSHIP TWICE. ALL THEY DO IS FLASH THE ECM AND THE PROBLEM PERSISTS. MOST IMPORTANTLY, TOYOTA HAS ACKNOWLEDGED THIS EXACT SAME PROBLEM ON THE 2010 MODEL BY ISSUING A TSB. (TSB-0166-10) FROM READING SEVERAL TOYOTA 4RUNNER FORUMS, THIS TSB FIXES THE PROBLEM. PLEASE PUT PRESSURE ON TOYOTA TO ISSUE A FIX FOR THE 2009 MODEL BEFORE SOMEONE GETS INJURED OR KILLED.

NHTSA complaint #10373627 — an unverified report by a vehicle owner.

POWER TRAIN

I AM FILING THIS, MY SECOND, COMPLAINT ABOUT MY 2009 TOYOTA 4RUNNER. MY FIRST COMPLAINT WAS FILED IN FEBRUARY 2010. I COMPLAINED TO MY DEALERSHIP ABOUT THE PROBLEM SINCE RIGHT AFTER PURCHASING THE 4RUNNER WHICH WE BOUGHT BRAND NEW IN MAY 2009. THE PROBLEM OCCURRED WHEN SLOWING DOWN TO TURN CORNERS TO ABOUT 15 MPH, AND THEN STEPPING ON THE ACCELERATOR TO SPEED UP, THE CAR REVS, SOMETIMES 2500-3000 RPMS BEFORE THE TRANSMISSION ENGAGES AND WE LURCH FORWARD. NOW, 17 MONTHS LATER AND MANY TRIPS AND E-MAILS TO MY DEALERSHIP, WHO CAN'T GET A RESPONSE FROM TOYOTA THAT MAKES SENSE, AND MY 4RUNNER STILL EXHIBITS THE SAME PROBLEM. MY HUSBAND HAD A KIDNEY TRANSPLANT IN AUGUST 2009, WHICH REQUIRES TRAVEL TO A BIG CITY ABOUT 90 MILES FROM HOME SEVERAL TIMES A MONTH, THAT HAS HEAVY TRAFFIC FLOW. LAST WEEK, I HAD TO MAKE A QUICK ACCELERATION TO MERGE INTO ONCOMING TRAFFIC, AND FOR THE FIRST TIME, THE 4RUNNER ACTUALLY DID THE SAME THINK IT DOES ON TURNS. WHEN I STEPPED ON THE GAS TO MERGE INTO ONCOMING TRAFFIC, THE 4RUNNER JUST REVVED FOR A FEW SECONDS AND THEN LURCHED FORWARD INTO TRAFFIC. LUCKILY NO ACCIDENT RESULTED, BUT WE WERE VERY SCARED. I PARTICIPATE IN FORUMS ON DIFFERENT CAR SITES AND THERE ARE MANY, MANY OF US HAVING THE EXACT PROBLEMS AND YET TOYOTA HAS NO ANSWER OR PUTS US OFF WITH SOME LAME EXPLANATIONS OR WORSE, TELLS US THAT IS JUST THE WAS THE 4RUNNER IS BECAUSE OF THE COMPUTER. MY DEALERSHIP HAS RESET THE COMPUTER AND DID NOT REMEDY THE PROBLEM. I AM REPORTING THIS NEWEST INCIDENT FOR DOCUMENTATION IN CASE THIS PROBLEM ACTUALLY CAUSES AN ACCIDENT, MY COMPLAINT WILL BE ON FILE. THANK YOU

NHTSA complaint #10356674 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I AM FILING THIS, MY SECOND, COMPLAINT ABOUT MY 2009 TOYOTA 4RUNNER. MY FIRST COMPLAINT WAS FILED IN FEBRUARY 2010. I COMPLAINED TO MY DEALERSHIP ABOUT THE PROBLEM SINCE RIGHT AFTER PURCHASING THE 4RUNNER WHICH WE BOUGHT BRAND NEW IN MAY 2009. THE PROBLEM OCCURRED WHEN SLOWING DOWN TO TURN CORNERS TO ABOUT 15 MPH, AND THEN STEPPING ON THE ACCELERATOR TO SPEED UP, THE CAR REVS, SOMETIMES 2500-3000 RPMS BEFORE THE TRANSMISSION ENGAGES AND WE LURCH FORWARD. NOW, 17 MONTHS LATER AND MANY TRIPS AND E-MAILS TO MY DEALERSHIP, WHO CAN'T GET A RESPONSE FROM TOYOTA THAT MAKES SENSE, AND MY 4RUNNER STILL EXHIBITS THE SAME PROBLEM. MY HUSBAND HAD A KIDNEY TRANSPLANT IN AUGUST 2009, WHICH REQUIRES TRAVEL TO A BIG CITY ABOUT 90 MILES FROM HOME SEVERAL TIMES A MONTH, THAT HAS HEAVY TRAFFIC FLOW. LAST WEEK, I HAD TO MAKE A QUICK ACCELERATION TO MERGE INTO ONCOMING TRAFFIC, AND FOR THE FIRST TIME, THE 4RUNNER ACTUALLY DID THE SAME THINK IT DOES ON TURNS. WHEN I STEPPED ON THE GAS TO MERGE INTO ONCOMING TRAFFIC, THE 4RUNNER JUST REVVED FOR A FEW SECONDS AND THEN LURCHED FORWARD INTO TRAFFIC. LUCKILY NO ACCIDENT RESULTED, BUT WE WERE VERY SCARED. I PARTICIPATE IN FORUMS ON DIFFERENT CAR SITES AND THERE ARE MANY, MANY OF US HAVING THE EXACT PROBLEMS AND YET TOYOTA HAS NO ANSWER OR PUTS US OFF WITH SOME LAME EXPLANATIONS OR WORSE, TELLS US THAT IS JUST THE WAS THE 4RUNNER IS BECAUSE OF THE COMPUTER. MY DEALERSHIP HAS RESET THE COMPUTER AND DID NOT REMEDY THE PROBLEM. I AM REPORTING THIS NEWEST INCIDENT FOR DOCUMENTATION IN CASE THIS PROBLEM ACTUALLY CAUSES AN ACCIDENT, MY COMPLAINT WILL BE ON FILE. THANK YOU

NHTSA complaint #10356674 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

I AM FILING MY SECOND COMPLAINT ABOUT MY 2009 TOYOTA 4RUNNER. MY FIRST COMPLAINT WAS FILED IN FEBRUARY 2010. I COMPLAINED TO MY DEALERSHIP ABOUT THE PROBLEM SINCE RIGHT AFTER PURCHASING THE 4RUNNER WHICH WE BOUGHT BRAND NEW IN MAY 2009. THE PROBLEM OCCURRED WHEN SLOWING DOWN TO TURN CORNERS TO ABOUT 15 MPH, AND THEN STEPPING ON THE ACCELERATOR TO SPEED UP, THE CAR REVS, SOMETIMES 2500-3000 RPMS BEFORE THE TRANSMISSION ENGAGES AND WE LURCH FORWARD. NOW, 17 MONTHS LATER AND MANY TRIPS AND E-MAILS TO MY DEALERSHIP, WHO CAN'T GET A RESPONSE FROM TOYOTA THAT MAKES SENSE, AND MY 4RUNNER STILL EXHIBITS THE SAME PROBLEM. MY HUSBAND HAD A KIDNEY TRANSPLANT IN AUGUST 2009, WHICH REQUIRES TRAVEL TO A BIG CITY ABOUT 90 MILES FROM HOME SEVERAL TIMES A MONTH, THAT HAS HEAVY TRAFFIC FLOW. LAST WEEK, I HAD TO MAKE A QUICK ACCELERATION TO MERGE INTO ONCOMING TRAFFIC, AND FOR THE FIRST TIME, THE 4RUNNER ACTUALLY DID THE SAME THING IT DOES ON TURNS. WHEN I STEPPED ON THE GAS TO MERGE INTO ONCOMING TRAFFIC, THE 4RUNNER JUST REVVED FOR A FEW SECONDS AND THEN LURCHED FORWARD INTO TRAFFIC. LUCKILY, NO ACCIDENT RESULTED, BUT WE WERE VERY SCARED. I PARTICIPATE IN FORUMS ON DIFFERENT CAR SITES AND THERE ARE MANY OF US HAVING THE EXACT PROBLEMS AND YET TOYOTA HAS NO ANSWER OR PUTS US OFF WITH SOME LAME EXPLANATIONS OR WORSE, TELLS US THAT IS JUST THE WAS THE 4RUNNER IS BECAUSE OF THE COMPUTER. MY DEALERSHIP HAS RESET THE COMPUTER AND DID NOT REMEDY THE PROBLEM. I AM REPORTING THIS NEWEST INCIDENT FOR DOCUMENTATION IN CASE THIS PROBLEM ACTUALLY CAUSES AN ACCIDENT, MY COMPLAINT WILL BE ON FILE. THANK YOU UPDATED 09/28/10 *BF UPDATED IVOQ 09/29/10

NHTSA complaint #10356677 — an unverified report by a vehicle owner.