Toyota Tundra wheel problems

WHEELS

The truck has had three alignments and it still pulls to the right.

NHTSA complaint #11744904 — an unverified report by a vehicle owner.

WHEELS

Excessive outer tire wear at 15,000 miles. Dealer advised that alignment was out of spec due to “Michigan roads” but I noticed this at 10,000 miles too and it’s still occurring.

NHTSA complaint #11738746 — an unverified report by a vehicle owner.

WHEELS

2024 Toyota Tundra 4X4 SR5 CrewMax 6.5, VIN: [XXX] , 28,500 miles. Three distinct, worsening vibration issues affecting separate systems: 1 — Powertrain/Driveline: Significant vibration on initial acceleration, under tow load, and on inclines. Suspected driveshaft carrier bearing, U-joint, or engine main bearing failure. Recall 25V-767 (V35A engine bearing debris, 2022–2024 Tundra) — VIN recall status to be confirmed at [XXX] . Component available for inspection. 2 — Highway vibration 40–70 mph: Constant speed-dependent vibration in steering wheel, seat, and floor. Worsening and expanding in speed range over time. Impairs steering feedback — direct safety hazard at highway speed. Suspected wheel bearing or hub failure. No warning lamps present at any time. 3 — Braking: Violent vibration during heavy deceleration, downhill braking, and rapid stops. Severely impairs controlled stopping and risks loss of vehicle control. Consistent with rotor degradation per Toyota TSB (Nov. 2025, 2022–2026 Tundra). Repair history: OEM tires replaced at 20,000 miles — abnormal camber-induced outside shoulder wear. Toyota issued a Limited Service Campaign for this identical defect on 2022–2023 models but explicitly excluded 2024. All 4 tires replaced twice. Multiple alignments, balancings, and rotations performed at L&S Toyota, Beckley, WV (3+ dealer visits) and an independent tire chain (3+ visits). No resolution. Defect is mechanical, not tire-related. No DTCs or warning lights at any visit. Safety risk: Braking vibration risks loss of control on downgrades and emergency stops. Highway vibration impairs steering feedback over extended driving. Towing vibration creates trailer instability on public roads. Requesting NHTSA investigate and include 2024 Tundra in the existing Limited Service Campaign covering this known defect on prior model years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11732760 — an unverified report by a vehicle owner.

WHEELS

My vehicle sustained a flat tire after driving. I was able to make it home safely. Vehicle was taken to dealer who found no evidence of a nail. This is the second incident. The first incident occurred while I was driving but thankfully I Was able to pull into a gas station. After research I found out that the tires on the new Toyota tundra have had weak side wall issues causing the tires the explode or wear out prematurely. I have tire warranty through Toyota. I believe Toyota offered this warranty due to their knowledge of the tires being defective. Other issues have been the wheel alignment and premature thread wear which is also a known problem with these vehicles.

NHTSA complaint #11732137 — an unverified report by a vehicle owner.

WHEELS

There is an unresolved body corrosion recall that has not been addressed in over a year, despite receiving an invoice from the dealership. I will attach the invoice that lists all the parts ordered for the remedy of this recall.

NHTSA complaint #11721644 — an unverified report by a vehicle owner.

WHEELS

Bad factory alignment caused OEM tires (Falken Wildpeak A/T, 265/60 R20) to wear prematurely. Tread depth reduced to 3/32 on all 4 tires at 10,500 miles. Clearly a safety risk as no reasonable person would expect new tires to last only 10,000 miles and; therefore, likely not check tread depth presenting significant safety risk in any inclement weather.

NHTSA complaint #11720239 — an unverified report by a vehicle owner.

WHEELS

All four tires are wearing unevenly. The outside of the tires are worn down much more than the middle and inside edge of tires. I noticed this six months ago, have called Toyota and brought the truck to the dealership and they stated there is no issue. I had the exact same Make/Model/Trim (3rd Generation Tundra TRD Pro) from 2022, and the tires wore out in the exact same manner. A safety recall was issued for this and all four tires were replaced and the alignment was adjusted to a "new standard" because it was determined that on this trim level, the original factory alignment was incorrect. This issue still hasn't been resolved as it is happening the exact same on the 2025 as it did on previous model years of the same trim. Toyota and dealership both refuse to even consider that this may be the same issue requiring a recall and replacement of tires and proper alignment. An internet search and an NHTSA search on this issue shows multiple instances of this complaint and nothing has been done to rectify.

NHTSA complaint #11718330 — an unverified report by a vehicle owner.

WHEELS

The outer edges of front tires wearing excessively. They replaced 2 around 20k milage and there are many reports of the same issue from factory alignment and camber. The tire appears to be splitting prematurely.

NHTSA complaint #11714263 — an unverified report by a vehicle owner.

WHEELS

Alignment issues from the factory that Toyota refuses to rectify.

NHTSA complaint #11712765 — an unverified report by a vehicle owner.

WHEELS

All four tires on my 2025 Toyota Tundra experienced severe and abnormal outside edge wear at approximately 13,000 miles. The vehicle was purchased new and maintained according to manufacturer recommendations, including tire rotations every 5,000 miles at authorized Toyota dealerships. An authorized Toyota dealership inspected the vehicle, documented the abnormal tire wear, and performed alignment measurements. The dealership issued a written recommendation stating that a four-wheel alignment was needed to extend tire life and/or correct drivability concerns. Alignment measurements showed values outside specification. The tire manufacturer reviewed photos and documentation and confirmed the wear pattern is caused by vehicle alignment and not a tire manufacturing defect. The condition affected all four tires and required premature replacement, creating a potential safety concern due to reduced tread depth and handling stability. The issue appears to be related to steering or suspension geometry rather than normal tire wear.

NHTSA complaint #11710661 — an unverified report by a vehicle owner.

WHEELS

Tires have 15,000 miles on them and are the stock OEM tires/wheels. They have excessive outer tire wear and need replaced from this. Inner tire wear is on par with the center tire wear. Alignment is confirmed to Toyota OEM specs.

NHTSA complaint #11705613 — an unverified report by a vehicle owner.

WHEELS

Both front tires have premature wear to the outer edge. Additionally, all four tires have warned to 3/32" with less than 30,000 miles on them. Vehicle has been serviced by Toyota every 5,000 miles. All components have been inspected and per Toyota the vehicle alignment is within spec per manufacture. That being the case, the tires shouldn't wear unless there is a manufacture defect. Toyota nor Falken wants to honor the warranty or take responsibility for the defect of the OEM equipment. Toyota has a TSB for the Tundra alignment with 18" tires but refuse to add trucks with the 20" tires. They keep pointing the finger at each other leaving the customer with zero resolution. Others have replaced the tires but having the same issue reoccur. This is a safety concern as premature wear can contribute to poor cornering in curves, turns, and handling in wet or icy conditions.

NHTSA complaint #11701510 — an unverified report by a vehicle owner.

WHEELS

According to Toyota, the 2022-2026 Tundra is compatible with 35x11.5 tires. These tires were installed by the dealer before my purchase. However, during turns, the tires heavily rub against the sway bar. This issue may be specific to the TRD upgrade package, which includes an upgraded, thicker sway bar. After driving for just 500 miles, noticeable rub marks have developed on both sides of the sway bar and visible marks on the inside of the tire. Tire rubbing can lead to faster tire wear and may even cause the tire to break during operation if the damage continues over time. I have reported this to Toyota Customer service and all they say they do is file a report.

NHTSA complaint #11701540 — an unverified report by a vehicle owner.

WHEELS

On September 4, 2025, I brought my 2001 Toyota Tundra to Midas at 5325 Olde Wadsworth Blvd, Arvada, CO 80002 for an oil change and inspection. Midas advertises a “Closer Look Vehicle Check,” which includes checking steering, suspension, and wheels. Their inspection report marked the steering system as “OK” and only noted mild shock wear. Less than a month later, while exiting the highway, the lower ball joint failed completely, causing the front suspension and wheel to detach. I immediately lost steering control. Fortunately, this occurred at low speed; had it happened moments earlier on the highway, it could have caused a major collision or fatalities. The failed component (lower ball joint and related suspension parts) is still available for inspection. An independent mechanic later confirmed that the joint was severely worn and the failure appeared to be due to long-term deterioration that should have been detected during Midas’s inspection. No warning lights or indicators appeared before the failure. The incident endangered my life, my passengers’ safety, and other drivers on the road. The business has refused to take responsibility or cover repair costs, which currently total over $2,400, despite their advertised inspection and guarantee. This raises serious concerns that Midas and potentially other service locations may be failing to properly inspect critical suspension components, which poses a major public safety hazard.

NHTSA complaint #11691486 — an unverified report by a vehicle owner.

WHEELS

Gulf States Toyota issued a recall (GST002) for the Enkei 18” wheels installed on my 2007 tundra. Toyota Vandergriff in Arlington has attempted to contact Gulf States Toyota multiple times since 8/21/25 but no reply has been provided. Currently, the wheels need to be replaced under the recall but Gulf States Toyota has made no effort to rectify the situation.

NHTSA complaint #11688148 — an unverified report by a vehicle owner.

WHEELS

I am the original owner of a brand new 2024 Toyota Tundra TRD Pro, and this issue began within the first 15,000 miles of regular dealer-maintained use. At approximately 14,800 miles, I noticed unusual and rapid outer shoulder wear on all four OEM Falken Wildpeak A/T3W 285/65R18 tires. A professional alignment inspection performed by Toyota Carlsbad dealership confirmed that the factory-set front toe angle was significantly out of Toyota’s specification (left front toe: +0.30°, right front: +0.10°, total front toe: +0.39°). This incorrect alignment was present from the factory and caused tire damage before any corrections were made. These settings match exactly what is described in Toyota Limited Service Campaign 24TD01, which applies to 2022–2023 Tundra models. However, my 2024 vehicle is not included, even though the defect and symptoms are identical. The alignment defect was confirmed and corrected by the dealership, but Toyota refused to replace the damaged tires, stating it is not a warrantable condition. However, this wear was directly caused by the misalignment on a new, factory-spec vehicle, maintained per Toyota guidelines. This condition presents a clear safety risk, as premature outer tire wear significantly reduces traction, affects handling, and increases stopping distance—especially in wet or emergency conditions. There were no warning lights or messages, making the condition undetectable until visible tire damage occurred. I filed a formal complaint with Toyota USA, but they declined further assistance. I respectfully request that NHTSA investigate whether Toyota should expand Campaign 24TD01 to include 2024 models with the same alignment-related defect. The tires are available for inspection. I have supporting documentation including alignment reports, photos of tire wear, and communications with Toyota regarding this case #.

NHTSA complaint #11679314 — an unverified report by a vehicle owner.

WHEELS

Complaint Against: Toyota Motor North America Category: Vehicle Warranty Obligations Toyota USA Case Number: [XXX] Dealer: Toyota Carlsbad Service Advisor: Ken McDonald Date Warranty Claim Submitted: [XXX] Date of Denial: [XXX] I am filing a complaint regarding Toyota’s denial of warranty coverage for premature tire wear on all four factory-installed Falken Wildpeak A/T3W 285/65R18 tires on my 2024 Toyota Tundra TRD Pro. By 15,000 miles, I observed outer edge wear — a typical symptom of incorrect factory alignment. Following the dealer’s recommendation, I performed an alignment, and all scheduled maintenance, including tire rotations, has been completed at authorized Toyota dealerships. On [XXX], I submitted a warranty claim at Toyota Carlsbad. Ken McDonald inspected the tires and took photos, but no diagnostic work was performed — no alignment check, no suspension inspection. A month later, Toyota USA denied the claim based solely on Ken McDonald’s verbal opinion that “the problem is with the tires,” without any technical evaluation or factual basis. This is unacceptable. My issue clearly matches Toyota Service Campaign 24TD01, which confirms that certain 2022–2024 Tundra models may experience premature outer edge tire wear due to factory misalignment. My vehicle fits this description exactly. Requested Resolution: Replacement of the damaged tires under warranty or fair compensation for the financial loss. Toyota’s response represents a failure to uphold warranty obligations, raises serious safety concerns, and violates consumer rights. I respectfully request that the Better Business Bureau help ensure this case is reviewed fairly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11676542 — an unverified report by a vehicle owner.

WHEELS

My Tundra 2014 have vibration during light to hard braking. The vibration can felt in any combination, Steering wheel, seat, and entire vehicle. To can fell over a large or short rang of speed. The truck have a new rotors and New break pads (I change twice in 2 years helps a little bit but not fix the problem). I purchased the truck on 2023 and come with this issue, i tried to many shops and no one can find the problem until i see some complaints for the same problem, this maybe to late, i hope some cam help me please.

NHTSA complaint #11671854 — an unverified report by a vehicle owner.

WHEELS

Engine is misfiring, truck vibrates when breaking when accelerating the engine cuts out dealership confirmed at service on 2/4/2025 that sensor needs to be replaced, need breaks, four tire rotation No No

NHTSA complaint #11670285 — an unverified report by a vehicle owner.

WHEELS

My factory stock Toyota painted steel wheels rotted and I had a 6 inch long area rusted through inside the rim losing air. I was advised by my tire center ,that i took it to ,that was not safe to drive on. I called my local Toyota dealer service manager and was told it was road corrosion and was not under any warranty. What would of happened if I had been on the highway and had a rapid deflation of the tire or what if the wheel broke and came apart. The truck has no rust. I replaced all 4 wheels the very next day. These wheels should be recalled and inspected and replaced if needed before someone gets hurt.

NHTSA complaint #11655306 — an unverified report by a vehicle owner.