576 of the
9,446 complaints filed about the Toyota Tundra
are about the fuel system —
6% of everything owners reported.
The worst model year for it is 2022.
Ive been waiting for years for the previous recalls I have been informed about to get fixed. Feul system,brake lights.Was told by Toyota that someone would call me to come to get them taken care of. In the meantime, constantly checking that my brake lights are working before departing on any excursions in truck & patiently waiting for toyota to reach out when they were gonna fix the first 2 recalls that I was notified about. I can't recall the date exactly, but I was driving on the highway w/ my still backward carseat, facing 2y.o. baby safely strapped in,ThankGod.As accelerating into my lane, heard huge BOOM like an IED. Immediately, the check engine light among others came on.Truck immediately lost power & was violently shaking.Felt it in the steering wheel, but largely in engine compartment.@this time,I tried to get over to shoulder to a safe place.I turned the car off.Let it rest checked on my infant in back made sure he was ok. After letting car rest, turn back on to my surprise All lights were off.I was w/in few miles of home so went directly back, never getting to my intended destination. Shortly before driveway, all lights came back on & multiple service messages.Since then the truck has not been driveable,As we have specifically looked up recalls,thusly Nov.recall matched lights on the dash for the specific make,year, model of truck. From my understanding, it says that there is no remedy for such recall. But that is untrue. The remedy is an entirely new engine. They just haven't rolled out the recall info to everyone applicable. I am unable to work. My home is without a vehicle and this is unacceptable.Along w/ safety risk to me and infant. I'm sure Toyota doesn't want to admit or remedy Because that is very costly. But this was a mistake made by the company. And it should be remedied, because our family is suffering in various ways. Lost revenue. Inability to respond if emergency etc.I need a new engine.& in the interim,I need a car supplied while fixed.
NHTSA complaint #11758505 — an unverified report by a vehicle owner.
Unknown Truck stuck in Branchport NY Started truck. Drove for ~20miles then died Has ~1/4 tank of gas Started truck again let it idle then died again Started truck again, gave it gas, ran fine, then died Started truck again, reversed it to turn around and died again in middle of intersection
NHTSA complaint #11755724 — an unverified report by a vehicle owner.
November 2025 notice there was issue with engine February 24 2026 serviced for engine April 13 2026 serviced for engine May 05 2026 serviced for engine June 15,2026 serviced for engine NO remedy Problem still presist
NHTSA complaint #11754267 — an unverified report by a vehicle owner.
We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had been recalled for this issue. They said my VIN was not recalled. That does not make sense. It was the same problem, same year, just at a different plant. Now we are having other fuel issues and the dealer says it all stems from the replacement of the pump, which we had to pay out of pocket. If we had not just exited the interstate it could have caused a major accident.
NHTSA complaint #11753016 — an unverified report by a vehicle owner.
2016 flex fuel toyota tundra with 118,00 miles was towed to toyota dealer in Las cruces with a no fuel issue. After the analysis it was determined the fuel pump over heated burning out conector and wiring ,but the pump was still working. According to toyota TSB 0166-19 this is a problem the can arise if the alcohol fuel density ID is not updated. I told the dealer to due repairs on vehicle even though a fuel pump was installed and reflashed at 114,000 miles. Viva toyota of las cruses advicate stated that a reflash is all the vehiles needs and does not desire to change the alchol fuel density to updated ID as per TSB-0166-19, so I am worried I will be operating a vehicle with a fuel pump that will over heat and burn out connectors again. I called Toyota complaints and they told me they cannot make a dealer do any repairs.
NHTSA complaint #11752420 — an unverified report by a vehicle owner.
I bought the vehicle new in November 2025. 2026 Toyota Tubdra TRD SR5. In the first week I noticed a lot of jerking and shaking. I brought it to the dealer and was told it was a break in period and it should go away. I’ve had the truck in the shop 5-6 times since and the jerking and shaking hasn’t gone away. I’m at 6300 miles now. The dealer won’t even respond to me anymore. The only way to make the jerking go away is to step on the gas pedal harder but this has become extremely dangerous because it’s forcing me to go faster than I would like, especially in school zones. The dealers say that it’s the truck running very low RPM’s to maximize fuel efficiency and also because there are 10 gears but is that’s the case than why isn’t everyone experiencing it. It’s worse on cold mornings (40 or below) but it’s almost like the truck needs an hour or two to warm up. Even then it’s still jerking. My guess is that the truck doesn’t know what gear it’s supposed to be in but 4th or 5th gear are the worst where the truck hesitates and jerks. I’ve been told to run it in Sport mode but that doesn’t help. I’m finding more and more complaints about this online with the Toyota Tundra SR5’s and I’m part of numerous groups. Someone needs to step in because no one should have to go through this and it’s very unsafe to have to push the gas pedal down harder to make the jerking go away.Thank you for your time.
NHTSA complaint #11752024 — an unverified report by a vehicle owner.
This is a reoccuring issue and happens daily. When the vehicle is cold and sitting all day or all night, on the first 5 minutes of driving or so, when you push the accelerator pedal from a dead stop or rolling stop, there is no throttle/engine response for at least 1.5-2 seconds. This is a HIGHLY unsafe condition and can lead to a traffic collision. I have reached out to Toyota Corporate about this and they said to bring it into my local dealer, Dick Hannah Toyota in Kelso, WA to perform the rolling stop TSB that is out on these Tundra Trucks. I received information from Dick Hannah that when they went to perform the procedures to take care of this TSB, that it had already been done and that there was nothing they could do further. They asked me to document the conditions to try and get Toyota Corporate to do something about it. I asked if there wasn't a recalibration they could do or anything else to make this condition improve, and they said no there is not. I expressed my concerns saying that there is nothing to document, that this happens everyday and is a daily occurence whenever the vehicle has been sitting for a long period of time. I have reached out to other vehicle owners on vehicle forums on the internet that are experiencing the same exact problems with no remediation from Toyota Dealers or Toyota Corporate. I was even offered to get into a split to hire a lawyer to get this unsafe condition remedied. This is a big deal and should not be overlooked and written off by ANYBODY.
NHTSA complaint #11751956 — an unverified report by a vehicle owner.
Driving on the interstate and the truck surged very hard. The truck began to surge very hard and went into decreased speed mode. We were told by the dealer there is a TSB for the PCM. This decreased power caused the truck to not be able to travel over 25 MPH in a 70 MPH zone. This caused an unsafe situation.
NHTSA complaint #11750077 — an unverified report by a vehicle owner.
The dealership and Toyota Engagement Center refused to service the 2 recalls that was critical for the truck since October 2025. It was supposed to be including frame replacement and other parts but Toyota Engagement decided to active buy back option and took advantage of low offer to solve the matter which I don't accept.
NHTSA complaint #11749814 — an unverified report by a vehicle owner.
Have owned the 2025 Toyota Tundra for about 18 months. Multiple instances of delayed acceleration when stopped or almost stopped, sometimes as much as 3 or 4 seconds. Last time was in early June, 2026. This is very dangerous because when I pull out into an intersection it will start to go but then lose all power for a few seconds with traffic coming behind me. This is something Toyota needs to look into.
NHTSA complaint #11744569 — an unverified report by a vehicle owner.
I have experienced a severe hesitation or delay in acceleration when accelerating from a stop or near-stop condition. While the issue has only occurred a few times over the past several months, on multiple occasions it happened while merging into traffic and nearly resulted in an accident. Toyota has issued Technical Service Bulletin (TSB-0032-26) addressing this condition. However, when I brought my vehicle to the dealership, Toyota documented that they were unable to reproduce or confirm the hesitation, and no repair was performed. This defect presents a significant safety risk. Unexpected loss of acceleration during traffic merges, intersections, or other situations requiring immediate power can place drivers and passengers in danger and could lead to serious injury or death. Given the safety implications and the fact that the remedy appears to be a software update requiring less than an hour to perform, I believe this issue warrants a formal safety recall rather than a voluntary Technical Service Bulletin. I urge NHTSA to investigate this matter and require Toyota to provide a recall remedy for all affected vehicles.
NHTSA complaint #11743105 — an unverified report by a vehicle owner.
Problem - throttle lag/hesitation/lurch. Truck won't go when throttle is pressed for a couple seconds cold or hot. Mentioned the problem on my 5000 mile service. Service tech said he could not reproduce the problem but happens with my drives 95% of the time. No warning lights have appeared.
NHTSA complaint #11742273 — an unverified report by a vehicle owner.
When coming to a rolling or quick stop and then attempting to maneuver across traffic, my truck hesitates for about a full second before accelerating. This delay can create a dangerous situation for myself, other drivers, and pedestrians. I believe this is a safety issue that Toyota needs to address promptly.
NHTSA complaint #11741206 — an unverified report by a vehicle owner.
After I put gas into the vehicle gas tank, the gas tank gauge indicated the tank was 75% full. The following day when I started the vehicle the gauge indicated the tank was 100% full and I did not add a drop of gas into the tank. Days later the tank appears to be stuck on 100% full. My fear is that I will not realize when the tank approaches empty at a very inopportune time.
NHTSA complaint #11740236 — an unverified report by a vehicle owner.
The fuel pump component or system failed or malfunctioned the engine tried cranking but would not start. The problem has been reproduced to an independent service center, where I was notified of a safety recall on Toyota Tundra. No other inspections have been performed. There are no warning lamps messages visible on the vehicle in question. The vehicle will not start until repeated starts are performed. Vehicle idles roughly before regaining normal idle. One other past similar incident of this type has occurred. No other
NHTSA complaint #11739464 — an unverified report by a vehicle owner.
2 issues to report: 1. Truck has a pull to the right since new. Found the front strut springs installed wrong. Attached photos show 2024 tundras on the dealer (pink dot on drivers side, yellow dot on passenger side) lot vs. mine (pink dot on passengers side, yellow dot on drivers side). Dealer corrected. Following repairs, pull is much better, but still present. Over 20 alignments completed; 3 by toyota and 3 by 3rd party. Problem continues. I believe it is a manufacturing defect in the safety equipment, suspension, or bent frame. 2. Toyota recalled V35A engines through my manufactured date. Because mine is a hybrid, it was excluded. Crankshaft main bearings seize due to a defect. I am forced to drive a vehicle on public roads while toyota recognizes the issue.
NHTSA complaint #11739152 — an unverified report by a vehicle owner.
I was crossing two lanes of a 4-lane highway from a stop. I floored the accelerator to cross traffic and the truck hesitated for approximately 1-2 seconds in the middle of the highway before finally accelerating. During this time I was completely exposed to oncoming traffic with no ability to move the vehicle. This is not the first time I have experienced throttle hesitation on this vehicle but this was by far the most dangerous instance. The truck has ~17,000 miles and is a 2025 model year
NHTSA complaint #11738459 — an unverified report by a vehicle owner.
The contact owns a 2008 Toyota Tundra. The contact stated that while driving at an undisclosed speed, the fuel tank strap frame mount fractured. The failure was caused by corrosion. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 79,000.
NHTSA complaint #11734362 — an unverified report by a vehicle owner.
Have replaced every part in the fuel system. Pumps, modules, etc. and it continues to have issues. Now a fuel smell issue. These cars have constant issues and need a full recall. Still has issues and have had multiple times it stopped running due to the fuel system issues. Attached is most recent receipt
NHTSA complaint #11732644 — an unverified report by a vehicle owner.
The contact owns a 2016 Toyota Tundra. The contact stated that while driving at slower speeds, the vehicle stalled while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was towed to a local dealer to be diagnosed. The contact was informed that the fuel pump and other fuel pump-related parts needed to be replaced. The vehicle was not repaired because the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 67,000.
NHTSA complaint #11732710 — an unverified report by a vehicle owner.